纯Fe在酸性AlCl3-EMIC离子液体中的阳极行为

doi:10.11949/j.issn.0438-1157.20151753

化工学报 ›› 2016, Vol. 67 ›› Issue (S1): 341-346.DOI: 10.11949/j.issn.0438-1157.20151753

纯Fe在酸性AlCl₃-EMIC离子液体中的阳极行为

杨扬, 薛东朋, 凌国平

浙江大学材料科学与工程学院, 浙江杭州 310027

收稿日期:2015-11-23 修回日期:2015-12-07 出版日期:2016-08-31 发布日期:2016-08-31
通讯作者: 凌国平,linggp@zju.edu.cn
基金资助:
国家自然科学基金面上项目（51271166）。

Anodic behavior of Fe in acidic AlCl₃-EMIC ionic liquid

YANG Yang, XUE Dongpeng, LING Guoping

School of Materials Science and Engineering, Zhejiang University, Hangzhou 310027, Zhejiang, China

Received:2015-11-23 Revised:2015-12-07 Online:2016-08-31 Published:2016-08-31
Supported by:
supported by the National Natural Science Foundation of China (51271166).

摘要/Abstract

摘要：

重点研究了纯铁（Fe）在2∶1酸性AlCl₃-氯化1-甲基-3-乙基咪唑（AlCl₃-EMIC）中的阳极行为。通过三电极体系测定了Fe在AlCl₃-EMIC中的阳极极化和不同电位下的电流-时间曲线，利用恒电位溶解计算了Fe溶解的价态，最后通过扫描电子显微镜（SEM）观察了不同电流密度下Fe的溶解形貌。结果表明：Fe表面的氧化膜会阻碍Fe的溶解，在去除氧化膜后，当电位达到-0.35 V时，Fe开始发生活性溶解，产物为Fe（Ⅱ）。Fe的阳极电流密度随电位的增加而增加，达到峰值后显著下降。小电流密度下（如2 mA·cm^-2），Fe的溶解形貌随时间的延长，呈现先点状腐蚀再均匀腐蚀的特点；而大电流密度下（如15 mA·cm^-2），Fe电极表面会生成一层固态物质，同时可见清晰的划痕，即不发生明显的腐蚀。

关键词: Fe, AlCl₃-EMIC离子液体, 阳极行为

Abstract:

The anodic behavior of Fe in 2:1 acidic AlCl₃-1-ethyl-3-methyl-imidazolium chloride (AlCl₃-EMIC) ionic liquid was investigated in this paper. Anodic polarization and chronoamperometry was measured using three-electrode system. The valence state of dissolved Fe was calculated by potentiostatic process. The surface morphologies of Fe were characterized using a scanning electron microscopy (SEM). The results showed that the oxide film would restrain the dissolution of Fe. After the oxide film was removed, Fe began to dissolve at the potential of -0.35 V versus Pt. The anodic current density increased rapidly to a maximum with the positive shift of potential and than decreased abruptly. The product existed in the form of Fe(Ⅱ). After galvanostatic process at 2 mA·cm^-2, the surface of Fe showed a pitting morphology, which became homogeneous as time prolonged. With a larger anodic current applied (15 mA·cm^-2), no obvious corrosion occurred on the surface of Fe electrode with precipitate formed.

Key words: Fe, AlCl₃-EMIC ionic liquid, anodic behavior

中图分类号:

TQ153

杨扬, 薛东朋, 凌国平. 纯Fe在酸性AlCl₃-EMIC离子液体中的阳极行为[J]. 化工学报, 2016, 67(S1): 341-346.

YANG Yang, XUE Dongpeng, LING Guoping. Anodic behavior of Fe in acidic AlCl₃-EMIC ionic liquid[J]. CIESC Journal, 2016, 67(S1): 341-346.

参考文献 26

[1]	SEDDON K R. Ionic liquids for clean technology[J]. J. Chem. Technol. Biot., 1997, 68(4):351-356.
[2]	COMPTOM D L, LASZLO J A. Loss of cytochrome c Fe(Ⅲ)/Fe(Ⅱ) redox couple in ionic liquids[J]. J. Electroanal. Chem., 2003, 553:187-190.
[3]	MCFARLANE J, RIDENOUR W B, LUO H, et al. Room temperature ionic liquids for separating organics from produced water[J]. Sep. Sci. Technol., 2005, 40(6):1245-1265.
[4]	RAUT D G, SUNDMAN O, SU W, et al. A morpholinium ionic liquid for cellulose dissolution[J]. Carbohyd. Polym., 2015, 130:18-25.
[5]	TSENG C, CHANG J, CHEN J, et al. Corrosion behaviors of materials in aluminum chloride-1-ethyl-3-methylimidazolium chloride ionic liquid[J]. Electrochem. Commun., 2010, 12(8):1091-1094.
[6]	LIN P, SUN I, CHANG J, et al. Corrosion characteristics of nickel, copper, and stainless steel in a Lewis neutral chloroaluminate ionic liquid[J]. Corros. Sci., 2011, 53(12):4318-4323.
[7]	WANG Y, LEE T, LIN J, et al. Corrosion properties of metals in dicyanamide-based ionic liquids[J]. Corros. Sci., 2014, 78:81-88.
[8]	MOUSTAFA E M, MANN O, FUERBETH W, et al. Electrochemical behaviour of iron in a third-generation ionic liquid:cyclic voltammetry and micromachining investi-gations[J]. Chemphyschem., 2009, 10(17):3090-3096.
[9]	ABBOTT A P, CAPPER G, MCKENZIE K J, et al. Electropolishing of stainless steels in a choline chloride based ionic liquid:an electrochemical study with surface characterisation using SEM and atomic force microscopy[J]. Phys. Chem. Chem. Phys., 2006, 8(36):4214-4221.
[10]	LIU Q X, EL ABEDIN S Z, ENDRES F. Electroplating of mild steel by aluminium in a first generation ionic liquid:a green alternative to commercial Al-plating in organic solvents[J]. Surf. Coat. Tech., 2006, 201(3/4):1352-1356.
[11]	NANJUNDIAH C, SHIMIZU K, OSTERYOUNG R A. Electrochemical studies of Fe(Ⅱ) and Fe(Ⅲ) in an aluminum-chloride butylpyridinium chloride ionic liquid[J]. J. Electrochem. Soc., 1982, 129(11):2474-2480.
[12]	HUANG H, SU C, KAO C, et al. Electrochemical study of Pt and Fe and electrodeposition of PtFe alloys from air-and water-stable room temperature ionic liquids[J]. J. Electroanal. Chem., 2010, 650(1):1-9.
[13]	ZHU Y, KATAYAMA Y, MIURA T. Electrochemistry of Fe(Ⅱ)/Fe in a hydrophobic amide-type ionic liquid[J]. J. Electrochem. Soc., 2012, 159(12):D699-D704.
[14]	GEETHA S, TRIVEDI D C. Properties and applications of chloroaluminate as room temperature ionic liquid[J]. Bull. Electrochem., 2003, 19(1):37-48.
[15]	XU B, ZHANG M, LING G. Electrolytic etching of AZ91D Mg alloy in AlCl3-EMIC ionic liquid for the electrodeposition of adhesive Al coating[J]. Surf. Coat. Tech., 2014, 239:1-6.
[16]	CHEN J, XU B, LING G. Amorphous Al-Mn coating on NdFeB magnets:electrodeposition from AlCl3-EMIC-MnCl2 ionic liquid and its corrosion behavior[J]. Mater. Chem. Phys., 2012, 134(2/3):1067-1071.
[17]	DING J, XU B, LING G. Al-Mn coating electrodeposited from ionic liquid on NdFeB magnet with high hardness and corrosion resistance[J]. Appl. Surf. Sci., 2014, 305:309-313.
[18]	XU B, CHEN J, LING G. Viscous layer formed in the anodic electrolytic etching of reactive metals in ionic liquid[J]. Electrochem. Solid. ST., 2012, 15(1):D1-D3.
[19]	XU B, QU R, LING G. Anodic behavior of Mg in acidic AlCl3-1-ethyl-3-methyl-imidazolium chloride ionic liquid[J]. Electrochim. Acta, 2014, 149:300-305.
[20]	QU R, JIANG Y, XU B, et al. Anodic behavior of neodymium in acidic AlCl3-1-ethyl-3-methyl-imidazolium chloride ionic liquid[J]. J. Rare Earth, 2015, 33(7):776-782.
[21]	WILKES J S, LEVISKY J A, WILSON R A, et al. Dialkylimidazolium chloroaluminate melts-a new class of room-temperature ionic liquids for electrochemistry, spectroscopy, and synthesis[J]. Inorg. Chem., 1982, 21(3):1263-1264.
[22]	PILLING N B, BEDWORTH R E. The oxidation of metals at high temperatures[J]. J. Inst. Met., 1923, 29:529-582.
[23]	DENT A J, SEDDON K R, WELTON T. The structure of halogenometallate complexes dissolved in both basic and acidic room-temperature halogenoaluminate(Ⅲ) ionic liquids, as determined by EXAFS[J]. J. Chem. Soc., Chem. Commun., 1990(4):315-316.
[24]	MELTON T J, JOYCE J, MALOY J T, et al. Electrochemical studies of sodium-chloride as a Lewis buffer for room-temperature chloroaluminate molten-salts[J]. J. Electrochem. Soc., 1990, 137(12):3865-3869.
[25]	LAHER T M, HUSSEY C L. Electrochemical studies of chloro complex-formation in low-temperature chloroalu-minate melts(1):Iron(Ⅱ), iron(Ⅲ), and nickel(Ⅱ)[J]. Inorg. Chem., 1982, 21(11):4079-4083.
[26]	LIPSZTAJN M, OSTERYOUNG R A. Electrochemistry in neutral ambient-temperature ionic liquids (1):Studies of iron(Ⅲ), neodymium(Ⅲ), and lithium(I)[J]. Inorg. Chem., 1985, 24(5):716-719.

纯Fe在酸性AlCl₃-EMIC离子液体中的阳极行为

Anodic behavior of Fe in acidic AlCl₃-EMIC ionic liquid

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 26

相关文章 15

编辑推荐

Metrics

本文评价

[1]	陈爱强, 代艳奇, 刘悦, 刘斌, 吴翰铭. 基板温度对HFE7100液滴蒸发过程的影响研究[J]. 化工学报, 2023, 74(S1): 191-197.
[2]	曾如宾, 沈中杰, 梁钦锋, 许建良, 代正华, 刘海峰. 基于分子动力学模拟的Fe₂O₃纳米颗粒烧结机制研究[J]. 化工学报, 2023, 74(8): 3353-3365.
[3]	袁妮妮, 郭拓, 白红存, 何育荣, 袁永宁, 马晶晶, 郭庆杰. 化学链燃烧过程Fe₂O₃/Al₂O₃载氧体表面CH₄反应：ReaxFF-MD模拟[J]. 化工学报, 2022, 73(9): 4054-4061.
[4]	陈永安, 周安宁, 李云龙, 石智伟, 贺新福, 焦卫红. 磁性MgFe₂O₄及其核壳催化剂制备与煤热解性能研究[J]. 化工学报, 2022, 73(7): 3026-3037.
[5]	朱江伟, 马鹏飞, 杜晓, 杨言言, 郝晓刚, 罗善霞. 基于可变价NiFe-LDH/rGO对磷酸根离子的特异性电控分离[J]. 化工学报, 2022, 73(7): 3057-3067.
[6]	贾艳萍, 丁雪, 刚健, 佟泽为, 张海丰, 张兰河. Mn强化Fe/C微电解工艺条件优化及降解油墨废水机理[J]. 化工学报, 2022, 73(5): 2183-2193.
[7]	王保文, 张港, 刘同庆, 李炜光, 王梦家, 林德顺, 马晶晶. CeO₂/CuFe₂O₄氧载体CH₄化学链重整耦合CO₂热催化还原研究[J]. 化工学报, 2022, 73(12): 5414-5426.
[8]	石文举, 白进, 孔令学, 曹景沛, 李文. 不同气氛下Ca-Fe二元助剂改变高硅铝煤灰熔融温度的规律和机制[J]. 化工学报, 2022, 73(10): 4638-4647.
[9]	徐文华, 刘冬福, 何利华, 刘旭恒, 赵中伟. 电化学脱嵌法盐湖提锂电极反应动力学研究[J]. 化工学报, 2021, 72(6): 3105-3115.
[10]	黄艳, 陈功, 王睿猛, 邵珊, 张正生, 杨东晓, 卢真保, 黄佳, 赵祯霞, 赵钟兴. MIL-100（Fe）中乙醇对低挥发性香兰素的协同脱附研究[J]. 化工学报, 2021, 72(5): 2697-2705.
[11]	李海昌, 何燕, 孙洪冉, 徐常蒙, 李劢, 宋文明, 李慧芳, 王晓君, 刘治明. 具有优异锂存储性能的蛋黄蛋壳结构FeS₂@CFs薄膜电极[J]. 化工学报, 2021, 72(11): 5858-5866.
[12]	黄瑞涛, 春江, 张峥, 李启凡, 温荣福, 马学虎. 微纳复合表面HFE-7100/水的BRT现象及沸腾传热特性[J]. 化工学报, 2021, 72(11): 5510-5519.
[13]	吴悦溪, 曾薇, 刘宏, 李健敏, 彭永臻. Feammox系统内氮素转化途径的研究[J]. 化工学报, 2020, 71(5): 2265-2272.
[14]	杨鑫宇, 吴杰, 张建庭, 吴纯鑫, 赵德明. 功能化磁性纳米复合材料Fe₃O₄-mPD/SP吸附Cr(Ⅵ)研究[J]. 化工学报, 2020, 71(3): 1060-1071.
[15]	张霄玲, 于凤芹, 皇甫林, 王超, 李长明, 高士秋, 余剑. Fe-Zn基废脱硫剂制备铁碳材料及其对废水微电解性能[J]. 化工学报, 2020, 71(2): 788-798.