超临界压力下CO2在螺旋管内的混合对流换热

doi:10.3969/j.issn.0438-1157.2013.11.006

CIESC Journal ›› 2013, Vol. 64 ›› Issue (11): 3917-3926.DOI: 10.3969/j.issn.0438-1157.2013.11.006

超临界压力下CO₂在螺旋管内的混合对流换热

王淑香¹, 张伟¹, 牛志愿¹, 徐进良^1,2

1. 华北电力大学低品位能源多相流与传热北京市重点实验室, 北京 102206;
2. 华北电力大学可再生能源学院, 北京 102206

收稿日期:2013-04-07 修回日期:2013-07-23 出版日期:2013-11-05 发布日期:2013-11-05
通讯作者: 徐进良
作者简介:王淑香(1985-),女,博士研究生。
基金资助:
国家自然科学基金项目(51006035);国家重点基础研究发展计划项目(2011CB710703);北京市自然科学基金项目(3132018);教育部留学回国科研启动基金项目。

Mixed convective heat transfer to supercritical carbon dioxide in helically coiled tube

WANG Shuxiang¹, ZHANG Wei¹, NIU Zhiyuan¹, XU Jinliang^1,2

1. Beijing Key Laboratory of Low Grade Energy Multiphase Flow and Heat Transfer, North China Electric Power University, Beijing 102206, China;
2. School of Renewable Energy, North China Electric Power University, Beijing 102206, China

Received:2013-04-07 Revised:2013-07-23 Online:2013-11-05 Published:2013-11-05
Supported by:
supported by the National Natural Science Foundation of China(51006035),the National Basic Research Program of China(2011CB710703)and the Natural Science Foundation of Beijing(3132018).

摘要/Abstract

摘要： 在恒热流条件下,对超临界压力CO₂在内径为9 mm,绕径为283 mm,节距为32 mm的螺旋管内垂直上升混合对流的传热特性进行了实验研究,实验参数范围为:进口压力8 MPa、质量流速0～650 kg·m^-2·s^-1、内壁热负荷0～50 kW·m^-2。研究发现:受热螺旋管内超临界压力CO₂的壁温及传热特性由变物性、浮升力及离心力的耦合作用共同支配,变物性及浮升力影响的相对大小可用Buoyancy数定性表征,当Bo>8×10^-7时,自然对流占主导作用,浮升力作用引起强烈的二次流效应,显著强化传热;在浮升力和离心力共同作用下,截面周向温度最低点出现在外下侧区域,且当浮升力作用占优时,底部区域的传热系数大于外侧,当离心力作用占优时,底部区域的传热系数小于外侧。基于本实验获取的2346个数据点,得出了计算Nu实验关联式,90%以上的实验值与拟合公式计算值偏差在±20%以内。

关键词: 超临界压力CO₂, 螺旋管, 混合对流, 准临界温度, 浮升力

Abstract: Under constant heat flux conditions,an experimental investigation was conducted on heat transfer to carbon dioxide flowing upward through a helically coiled tube with inner diameter 9 mm,coil diameter 283 mm and coil pitch 32 mm.The operating pressure was maintained at 8 MPa for all the tests. The mass flux and heat flux were in the range of 0-650 kg·m^-2·s^-1 and 0-50 kW·m^-2,respectively.It is found that the inner wall temperatures and heat transfer coefficients are determined by the combined effects of physical property variation,buoyancy force and centrifugal force.The Buoyancy number can qualitatively stand for the relative importance of physical property variation and buoyancy effect.When Bo>8×10^-7,the natural convection becomes predominant,and heat transfer rate is obviously enhanced because of the buoyancy induced secondary flow.Due to the combined effects of buoyancy force and centrifugal force,the site with the lowest inner wall temperature and the highest heat transfer coefficient is located in the region 90°<ø<180°.When the buoyancy force takes advantage over the centrifugal force,the heat transfer coefficient in the bottom region is larger than that in the outer region. When the centrifugal force becomes dominant,the heat transfer coefficient in the bottom region is smaller than that in the outer region.Based on the 2346 data obtained in the present experimental study,two correlations of Nusselt number suitable for different temperature regions is proposed.It is verified that at least ninety percent of experimental data fall within 20% deviation predicted by the proposed correlations.

Key words: supercritical CO₂, helically coiled tube, mixed convection, pseudo-critical temperature, buoyancy force

中图分类号:

TK124

王淑香, 张伟, 牛志愿, 徐进良. 超临界压力下CO₂在螺旋管内的混合对流换热[J]. CIESC Journal, 2013, 64(11): 3917-3926.

WANG Shuxiang, ZHANG Wei, NIU Zhiyuan, XU Jinliang. Mixed convective heat transfer to supercritical carbon dioxide in helically coiled tube[J]. , 2013, 64(11): 3917-3926.

参考文献 24

[1]	Chen Jianyu(陈建宇),Liu Ziwen(刘资文),Li Ping(李平),Yu Jianguo(于建国).Thermodynamic study of CO2 and N2 adsorption on modified activated carbon monolith[J].CIESC Journal(化工学报),2012,63(10):3017-3026
[2]	Huang Yanping(黄彦平),Wang Junfeng(王俊峰).Applications of supercritical carbon dioxide in nuclear reactor system[J].Nuclear Power Engineering(核动力工程),2012,33(3):21-27
[3]	Wang Dong(王栋),Li Meng(李蒙),Qi Lili(戚利利),Qian Fuping(钱付平).Design and experimental study of capillary tube in transcritical carbon dioxide refrigeration system[J].CIESC Journal(化工学报),2011,62(10):2753-2758
[4]	Zhang X R,Yamaguchia H,Fujima K,Enomotoc M,Sawadad N.Theoretical analysis of a thermodynamic cycle for power and heat production using supercritical carbon dioxide[J].Energy,2007,32:591-599
[5]	Liao S M,Zhao T S.An experimental investigation of convection heat transfer to supercritical carbon dioxide in miniature tubes[J].International Journal of Heat and Mass Transfer,2002,45:5025-5034
[6]	He S,Kim W S,Jackson J D.A computational study of convective heat transfer to carbon dioxide at a pressure just above the critical value[J].Applied Thermal Engineering,2008,28:1662-1675
[7]	Bae Y Y,Kim H Y.Convective heat transfer to CO2 at a supercritical pressure flowing vertically upward in tubes and an annular channel[J].Experimental Thermal and Fluid Science,2009,33(2):329-339
[8]	Jiang Peixue,Xu Yijun,Lv Jing,Shi Runfu,He S,Jackson J D.Experimental investigation of convection heat transfer of CO2 at super-critical pressures in vertical mini-tubes and in porous media[J].Applied Thermal Engineering,2004,24:1255-1270
[9]	Cao Yuhui(曹玉会),Zhang Xinrong(张信荣).Application of lattice Botlzmann method to simulate supercritical CO2 natural convection[J].Journal of Engineering Thermophysics(工程热物理学报),2011,32(12):2120-2123
[10]	Liu Dan(刘丹),Zhang Zhongguo(张忠国),Zhao Kehui(赵可卉),Luan Zhaokun(栾兆坤),Cheng Yanjun(程言君),Li Jiding(李继定),Rong Liming(荣立明),Song Yun(宋云).Mixing performance of helical secondary-flow mixer used in coagulation[J].CIESC Journal(化工学报),2011,62(10):2707-2712
[11]	Bi Qincheng(毕勤成),Chen Tingkuan(陈听宽),Tian Yongsheng(田永生),Chen Xuejun(陈学俊).Study on critical heat flux of steam-water two-phase flow in helical coil tubes[J].Journal of Xi'an Jiaotong University(西安交通大学学报),1996,30(5):30-35
[12]	Lee Jy-ber,Simon H A,Chow J C F.Buoyancy in developed laminar curved tube flows[J].Int.J.Heat Mass Transfer,1985,28:631-640
[13]	Guo Liejin(郭烈锦),Feng Ziping(冯自平).Oscillation heat transfer in the helically coiled tube with fully developed turbulent oscillation flow[J].Journal of Chemical Industry and Engineering(China)(化工学报),2000,51(2):159-164
[14]	Chen Qianqiao(陈迁乔),Zhong Qin(钟秦).Field synergy enhancement simulation of convective mass transfer in helical tube[J].CIESC Journal(化工学报),2012,63(12):3764-3770
[15]	Kang H J,Lin C X,Ebadian M A.Condensation of R134a flowing inside helicoidal pipe[J].Int.J.Heat Mass Transfer,2000,43:2553-2564
[16]	Ghorbani N,Taherian H,Gorji M,Mirgolbabaei H. Experimental study of mixed convection heat transfer in vertical helically coiled tube heat exchangers[J].Experimental Thermal and Fluid Science,2010,34:900-905
[17]	Moawed M.Experimental study of forced convection from helical coiled tubes with different parameters[J].Energy Conversion and Management,2011,52:1150-1156
[18]	Wang Shuxiang(王淑香),Zhang Wei(张伟),Xu Jinliang(徐进良),Niu Zhiyuan(牛志愿).Construction of experimental setup for heat transfer of carbon dioxide[J].Fluid Machinery(流体机械),2012,40(5):71-75
[19]	Taler J,Zima W.Solution of inverse heat conduction problems using control volume approach[J].International Journal of Heat and Mass Transfer,1999,42(6):1123-1140
[20]	Dang Chaobin,Hihara E J.In-tube cooling heat transfer of supercritical carbon dioxide(Part 1):Experimental measurement[J].International Journal of Refrigeration,2004,27:736-747
[21]	Jackson J D,Hall W B.Forced Convection Heat Transfer to Fluids at Supercritical Pressure[R].Turbulent Forced Convection in Channels and Bundles,1979
[22]	McEligot D M,Jackson J D."Deterioration"criteria for convective heat transfer in gas flow through non-circular ducts[J].Nuclear Engineering and Design,2004,232:327-333
[23]	Merkel F.Die Grundlagen der Warmeubertrgung[M].Berlin:Springer Publishing Company,1927
[24]	Huang Shanfang,Ma Taiyi,Gu Hanyang,Yang Yanhua,Yan Xiao.Heat transfer analysis in mixed convection//Proceedings of the 18th International Conference on Nuclear Engineering[C].Xi'an,2010

超临界压力下CO₂在螺旋管内的混合对流换热

Mixed convective heat transfer to supercritical carbon dioxide in helically coiled tube

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 24

相关文章 15

编辑推荐

Metrics

本文评价

[1]	洪瑞, 袁宝强, 杜文静. 垂直上升管内超临界二氧化碳传热恶化机理分析[J]. 化工学报, 2023, 74(8): 3309-3319.
[2]	刘晓洋, 喻健良, 侯玉洁, 闫兴清, 张振华, 吕先舒. 螺旋微通道对掺氢甲烷爆轰传播的影响[J]. 化工学报, 2023, 74(7): 3139-3148.
[3]	许婉婷, 许波, 王鑫, 陈振乾. 方形微通道内超临界CO₂流动换热特性研究[J]. 化工学报, 2022, 73(4): 1534-1545.
[4]	戴军涛, 刘莉, 刘帅, 顾汉洋, 王科. 基于丝网探针的螺旋管内气液两相流气泡行为研究[J]. 化工学报, 2022, 73(10): 4377-4388.
[5]	谢瑶, 李剑锐, 胡海涛. 印刷电路板式换热器内超临界甲烷流动换热特性模拟[J]. 化工学报, 2021, 72(S1): 203-209.
[6]	王彦红, 陆英楠, 李素芬, 东明. 周向非均匀加热水平圆管内超临界正癸烷换热特性[J]. 化工学报, 2021, 72(3): 1342-1353.
[7]	颜建国, 朱凤岭, 郭鹏程, 罗兴锜. 高热流低流速条件下超临界CO₂在小圆管内的对流传热特性[J]. 化工学报, 2019, 70(5): 1779-1787.
[8]	张海燕, 郭江峰, 淮秀兰, 崔欣莹. PCHE内轴向导热对局部换热性能的影响研究[J]. 化工学报, 2019, 70(12): 4590-4598.
[9]	万星晨, 林文胜. 螺旋管丙烷流动沸腾换热特性[J]. 化工学报, 2018, 69(S2): 135-140.
[10]	孔令健, 韩吉田, 陈常念, 刘志刚. 立式和卧式螺旋管内过冷沸腾起始点特性[J]. 化工学报, 2018, 69(5): 1956-1963.
[11]	刘新新, 叶建, 徐肖肖, 刘朝, 王开正, 李洪瑞, 白万金. 超临界CO₂在水平螺旋管内的冷却换热特性[J]. 化工学报, 2016, 67(S2): 120-127.
[12]	白万金, 徐肖肖, 吴杨杨. 低质量流速下超临界CO₂在管内冷却换热特性[J]. 化工学报, 2016, 67(4): 1244-1250.
[13]	梁栋, 张淑芬. 缩放螺旋混合器的实验评价与优化设计[J]. 化工学报, 2015, 66(8): 3036-3040.
[14]	刘尚华, 孙宝芝, 史建新, 韩文静, 张国磊, 干依燃. 螺旋直径对螺旋管热工水力不均匀性的影响[J]. 化工学报, 2014, 65(z2): 148-154.
[15]	崔文智, 尹飞. 非均匀热流边界条件下螺旋管内流动传热的场协同分析[J]. 化工学报, 2014, 65(S1): 229-234.