Effect of feeding gas on hopper discharge of pulverized coal

doi:10.3969/j.issn.0438-1157.2014.09.010

CIESC Journal ›› 2014, Vol. 65 ›› Issue (9): 3383-3388.DOI: 10.3969/j.issn.0438-1157.2014.09.010

Previous Articles Next Articles

Effect of feeding gas on hopper discharge of pulverized coal

LU Haifeng, GUO Xiaolei, TAO Shunlong, GONG Xin, LU Jun

Shanghai Research Center of Gasification Technology, Key Laboratory of Coal Gasification and Energy Chemical Engineering of Ministry of Education, East China University of Science and Technology, Shanghai 200237, China

Received:2013-12-27 Revised:2014-01-22 Online:2014-09-05 Published:2014-09-05
Supported by:
supported by the National Natural Science Foundation of China (21206041), the China Postdoctoral Science Foundation Funded Project (2012M520847) and the Fundamental Research Funds for the Central Universities.

不同载气供料对煤粉料仓下料的影响

陆海峰, 郭晓镭, 陶顺龙, 龚欣, 鲁军

华东理工大学煤气化及能源化工教育部重点实验室, 上海市煤气化工程技术研究中心, 上海 200237

通讯作者: 龚欣
基金资助:
国家自然科学基金项目（21206041）；中国博士后科学基金项目（2012M520847）；中央高校基本科研业务费专项资金项目。

Abstract

Abstract: Hopper discharge is one of the most important components in the entrained-flow gasification technology of pulverized coal. Safe and stabilized hopper discharge is of great economic significance. The effect of feeding gas, including air and CO₂ on hopper discharge was studied in the loop feeding system of pulverized coal. Both gravity discharge and aerated discharge were examined and analyzed. The behavior and flowability of powders would be influenced by their previous bulk or fluidized state. For gravity discharge, the pulverized coal fed by CO₂ showed a higher void and thus corresponded to higher discharge rate. For aerated discharge, the pulverized coal fed by air was hard to be fluidized by CO₂, resulting in lower discharge rate.

Key words: powder, hopper discharge, pneumatic conveying, fluidization, adsorption

摘要： 煤粉料仓下料是气流床粉煤气化工艺中粉体供料单元的重要组成部分，其安全稳定运行具有重大的经济意义。在煤粉循环供料系统上，研究了以空气和CO₂为载气的气力输送供料对料仓内煤粉重力下料和通气下料的影响。研究表明，料仓内粉体的堆积或流化状态对后续粉体的流动行为影响明显。对于重力下料，CO₂供料后的重力下料过程中煤粉床层空隙率较高，下料流率较大；对于通气下料，空气供料后煤粉难以被CO₂气体流化，从而对应较低的下料流率。

关键词: 粉体, 料仓下料, 气力输送, 流态化, 吸附

CLC Number:

TQ536

LU Haifeng, GUO Xiaolei, TAO Shunlong, GONG Xin, LU Jun. Effect of feeding gas on hopper discharge of pulverized coal[J]. CIESC Journal, 2014, 65(9): 3383-3388.

陆海峰, 郭晓镭, 陶顺龙, 龚欣, 鲁军. 不同载气供料对煤粉料仓下料的影响[J]. 化工学报, 2014, 65(9): 3383-3388.

References 18

[1]	Liu S D, Zhou Z Y, Zou R P, Pinson D, Yu A B. Flow characteristics and discharge rate of ellipsoidal particles in a flat bottom hopper [J]. Powder Technology, 2014, 253: 70-79
[2]	Liang Qinfeng, Guo Xiaolei, Dai Zhenghua, Liu Haifeng, Gong Xin. An investigation on the heat transfer behavior and slag deposition of membrane wall in pilot-scale entrained-flow gasifier [J]. Fuel, 2012, 102: 491-498
[3]	Lu Haifeng, Guo Xiaolei, Gong Xin, Huang Wanjie, Ma Sheng, Wang Chuanhong. Study of the flowability of pulverized coals [J]. Energy & Fuels, 2009, 23: 5529-5535
[4]	Lu Haifeng, Guo Xiaolei, Gong Xin, Cong Xingliang, Dong Weibin. Study on the fluidization and discharge characteristics of cohesive coals from an aerated hopper [J]. Powder Technology, 2011, 207: 199-207
[5]	Crewdson B J, Ormond A L, Nedderman R M. Air-impeded discharge of fine particles from a hopper [J]. Powder Technology, 1977, 16: 197-207
[6]	Altiner H K. Flow of solids form aerated hopper: effect of aeration methods [J]. AIChE J., 1983, 222: 55-59
[7]	Massimilla L, Betta V, Della Rocca C. A study of streams of solids flowing from solid-gas fluidized beds [J]. AIChE J., 1961, 7: 502-508
[8]	Lu Haifeng, Guo Xiaolei, Gong Xin, Cong Xingliang, Dong Weibin, Huang Wanjie. Effect of gas type on the fluidization and discharge characteristics of the pulverized coal [J]. Powder Technology, 2012, 217: 347-355
[9]	Lu Haifeng (陆海峰)，Guo Xiaolei (郭晓镭), Tao Shunlong (陶顺龙), Gong Xin (龚欣). Application of electrical capacitance tomography in hopper discharge of pulverized coal [J]. CIESC Journal (化工学报), 2014, 65 (2): 422-429
[10]	Gong Xin (龚欣), Guo Xiaolei (郭晓镭), Dai Zhenghua (代正华), Feng Jinhua (封金花), Chen Jinfeng (陈金峰), Zheng Yaohui (郑耀辉), Chen Feng (陈锋), Xiong Lang (熊浪), Yu Zunhong (于遵宏). High solids loading pneumatic conveying of pulverized coal [J]. Journal of Chemical Industry and Engineering (China) (化工学报)，2006, 57: 640-644
[11]	Cong Xingliang, Guo Xiaolei, Lu Haifeng, Gong Xin, Liu Kai, Sun Xiaolin, Xie Kai. Flow patterns of pulverized coal pneumatic conveying and time-series analysis of pressure fluctuations [J]. Chemical Engineering Science, 2013, 101: 303-314
[12]	Lu Haifeng, Guo Xiaolei, Gong Xin, Cong Xingliang, Liu Kai, Qi Haifeng. Experimental study on aerated discharge of the pulverized coal [J]. Chemical Engineering Science, 2012, 71: 438-448
[13]	Nielsen Jorgen. Pressures from flowing granular solids in silos [J]. Phil. Trans. R. Soc. Lond. A, 1998, 356: 2667-2684
[14]	Freeman R E. Measuring the flow properties of consolidated, conditioned and aerated powders-a comparative study using a powder rheometer and a rotational shear cell [J]. Powder Technology, 2007, 174: 25-33
[15]	Cong Xingliang, Guo Xiaolei, Gong Xin, Lu Haifeng, Liu Kai, Qi Haifeng. Investigations of pulverized coal pneumatic conveying using CO2 and air [J]. Powder Technology, 2012, 219: 135-142
[16]	Xie H Y, Geldart D. Fluidization of FCC powders in the bubble-free regime: effect of types of gases and temperature [J]. Powder Technology, 1995, 82: 269-277
[17]	Barletta D, Donsi G, Ferrari G, Poletto M, Russo P. Solid flow rate prediction in silo discharge of aerated cohesive powders [J]. AIChE J., 2007, 53: 2240-2253
[18]	Xu C B, Zhu J X. Effects of gas type and temperature on fine particle fluidization [J]. China Particuology, 2006, 4: 114-121

Effect of feeding gas on hopper discharge of pulverized coal

不同载气供料对煤粉料仓下料的影响

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 18

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Lei WU, Jiao LIU, Changcong LI, Jun ZHOU, Gan YE, Tiantian LIU, Ruiyu ZHU, Qiuli ZHANG, Yonghui SONG. Catalytic microwave pyrolysis of low-rank pulverized coal for preparation of high value-added modified bluecoke powders containing carbon nanotubes [J]. CIESC Journal, 2023, 74(9): 3956-3967.
[2]	Zhenbao LI, Chao LI, Hu WANG, Shaorui WANG, Quan LI. The microscopic mechanism on MPP inhibiting explosion of Al-Mg alloy powder [J]. CIESC Journal, 2023, 74(8): 3608-3614.
[3]	Bingchun SHENG, Jianguo YU, Sen LIN. Study on lithium resource separation from underground brine with high concentration of sodium by aluminum-based lithium adsorbent [J]. CIESC Journal, 2023, 74(8): 3375-3385.
[4]	Ruihang ZHANG, Pan CAO, Feng YANG, Kun LI, Peng XIAO, Chun DENG, Bei LIU, Changyu SUN, Guangjin CHEN. Analysis of key parameters affecting product purity of natural gas ethane recovery process via ZIF-8 nanofluid [J]. CIESC Journal, 2023, 74(8): 3386-3393.
[5]	Yan GAO, Peng WU, Chao SHANG, Zejun HU, Xiaodong CHEN. Preparation of magnetic agarose microspheres based on a two-fluid nozzle and their protein adsorption properties [J]. CIESC Journal, 2023, 74(8): 3457-3471.
[6]	Ji CHEN, Ze HONG, Zhao LEI, Qiang LING, Zhigang ZHAO, Chenhui PENG, Ping CUI. Study on coke dissolution loss reaction and its mechanism based on molecular dynamics simulations [J]. CIESC Journal, 2023, 74(7): 2935-2946.
[7]	Jie WANG, Xiaolin QIU, Ye ZHAO, Xinyang LIU, Zhongqiang HAN, Yong XU, Wenhan JIANG. Preparation and properties of polyelectrolyte electrostatic deposition modified PHBV antioxidant films [J]. CIESC Journal, 2023, 74(7): 3068-3078.
[8]	Xueyan WEI, Yong QIAN. Experimental study on the low to medium temperature oxidation characteristics and kinetics of micro-size iron powder [J]. CIESC Journal, 2023, 74(6): 2624-2638.
[9]	Hanbing HE, Zhen LIU, Yong CHEN, Xiaofeng WANG, Jing ZENG. Synthesis and slurry control of manganese oxide powder for direct ink writing electrode [J]. CIESC Journal, 2023, 74(5): 2239-2247.
[10]	Shaoyun CHEN, Dong XU, Long CHEN, Yu ZHANG, Yuanfang ZHANG, Qingliang YOU, Chenglong HU, Jian CHEN. Preparation and adsorption properties of monolayer polyaniline microsphere arrays [J]. CIESC Journal, 2023, 74(5): 2228-2238.
[11]	Caihong LIN, Li WANG, Yu WU, Peng LIU, Jiangfeng YANG, Jinping LI. Effect of alkali cations in zeolites on adsorption and separation of CO₂/N₂O [J]. CIESC Journal, 2023, 74(5): 2013-2021.
[12]	Chenxin LI, Yanqiu PAN, Liu HE, Yabin NIU, Lu YU. Carbon membrane model based on carbon microcrystal structure and its gas separation simulation [J]. CIESC Journal, 2023, 74(5): 2057-2066.
[13]	Simin YI, Yali MA, Weiqiang LIU, Jinshuai ZHANG, Yan YUE, Qiang ZHENG, Songyan JIA, Xue LI. Study on ammonia evaporation and hydration kinetics of microcrystalline magnesite [J]. CIESC Journal, 2023, 74(4): 1578-1586.
[14]	Xuanjun WU, Chao WANG, Zijian CAO, Weiquan CAI. Deep learning model of fixed bed adsorption breakthrough curve hybrid-driven by data and physical information [J]. CIESC Journal, 2023, 74(3): 1145-1160.
[15]	Yu PAN, Zihang WANG, Jiayun WANG, Ruzhu WANG, Hua ZHANG. Heat and moisture performance study of Cur-LiCl coated heat exchanger [J]. CIESC Journal, 2023, 74(3): 1352-1359.