Application of polyvinylidene fluoride/polydimethylsiloxane composite membrane in butanol recovery

doi:10.3969/j.issn.0438-1157.2014.09.026

CIESC Journal ›› 2014, Vol. 65 ›› Issue (9): 3499-3504.DOI: 10.3969/j.issn.0438-1157.2014.09.026

Previous Articles Next Articles

Application of polyvinylidene fluoride/polydimethylsiloxane composite membrane in butanol recovery

DU Guangqing, CHEN Lijie, XUE Chuang, BAI Fengwu

School of Life Sciences and Biotechnology, Dalian University of Technology, Dalian 116023, Liaoning, China

Received:2013-12-24 Revised:2014-03-07 Online:2014-09-05 Published:2014-09-05
Supported by:
supported by the National Natural Science Foundation of China (21306020, 21376044), the Specialized Research Fund for the Doctoral Program of Higher Education of China (20130041120027), the Scientific Research Fund of Liaoning Provincial Education Department (L2013022), China Postdoctoral Science Foundation (2013M530904, 2014T70257), Doctor Startup Fund of Liaoning Province (20141197), the Open Research Fund from Biofuels Key Laboratory of Chinese Academy of Sciences in Qingdao Institute of Bioenergy and Bioprocess Technology (CASKLB201303) and the Scientific Research Foundation for the Returned Overseas Chinese Scholars of State Education Ministry.

聚偏氟乙烯/聚二甲基硅氧烷渗透气化膜在丁醇分离中的应用

杜广庆, 陈丽杰, 薛闯, 白凤武

大连理工大学生命科学与技术学院, 辽宁大连 116023

通讯作者: 薛闯
基金资助:
国家自然科学基金项目（21306020，21376044）；教育部博士点基金（20130041120027）；辽宁省教育厅科学研究一般项目（L2013022）；中国博士后科学基金项目（2013M530904，2014T70257）；辽宁省博士科研启动基金（20141197）；中国科学院生物燃料重点实验室开放基金（CASKLB201303）；教育部留学回国人员科研启动基金。

Abstract

Abstract: A polyvinylidene fluoride (PVDF)/polydimethylsiloxane (PDMS) composite membrane for butanol recovery was fabricated by coating a dense PDMS separation layer on a PVDF porous support layer prepared by phase inversion. The total flux and separation factor of the PVDF/PDMS composite membrane could be 158.2 g·m^-2·h^-1 and 17.3, respectively, when feed solution was 15 g·L^-1 butanol at 37℃ with a flow rate 1.6 L·min^-1. To simulate the fermentation liquor, acetone and ethanol were added into the feed solution in a ratio 6(butanol):3:1, the total flux of PVDF/PDMS composite membrane increased to 189.5 g·m^-2·h^-1, but separation factor decreased to 14.8. Furthermore, fermentation broths with/without biomass as feed solution were investigated to evaluate pervaporation performance of the PVDF/PDMS composite membrane. The total flux and separation factor were 120.2 g·m^-2·h^-1 and 19.7 for without biomass case, 122.1 g·m^-2·h^-1 and 16.7 for with biomass case, respectively. Compared with PDMS membrane, the performance of PVDF/PDMS composite membrane had significant improvement for butanol recovery, indicating that it is of potential for industrial application of butanol recovery.

Key words: biofuel, bioseparation, PVDF/PDMS composite membrane, pervaporation, butanol

摘要： 通过相转化法制备PVDF多孔支撑膜，在其上涂覆致密的PDMS分离层制备得到PVDF/PDMS复合膜，用于丁醇的分离纯化。以丁醇水溶液为原料液，流速为1.6 L·min^-1，丁醇浓度为15 g·L^-1，温度为37℃时， PVDF/PDMS复合膜的总通量为158.2 g·m^-2·h^-1，分离因子为17.3。向丁醇水溶液中按丁醇：丙酮：乙醇比例为6：3：1添加丙酮和乙醇模拟发酵液，PVDF/PDMS复合膜的总通量升高到189.5 g·m^-2·h^-1，分离因子降低到14.8。进一步考察了以丙酮-丁醇-乙醇（ABE）发酵液为原料液的渗透气化膜分离性能，发酵液中不存在菌体时，PVDF/PDMS复合膜的总通量和分离因子分别为120.2 g·m^-2·h^-1和19.7，而菌体存在时，复合膜的总通量和分离因子分别为122.1 g·m^-2·h^-1和16.7。与PDMS均质膜相比，PVDF/PDMS复合膜在丁醇分离过程中的分离性能有了显著的提升，具有潜在的应用价值。

关键词: 生物燃料, 生物分离, PVDF/PDMS复合膜, 渗透气化, 丁醇

CLC Number:

Q939.9

DU Guangqing, CHEN Lijie, XUE Chuang, BAI Fengwu. Application of polyvinylidene fluoride/polydimethylsiloxane composite membrane in butanol recovery[J]. CIESC Journal, 2014, 65(9): 3499-3504.

杜广庆, 陈丽杰, 薛闯, 白凤武. 聚偏氟乙烯/聚二甲基硅氧烷渗透气化膜在丁醇分离中的应用[J]. 化工学报, 2014, 65(9): 3499-3504.

References 27

[1]	Nigam P S, Singh A. Production of liquid biofuels from renewable resources [J]. Prog. Energ. Combust., 2011, 37 (1): 52-68
[2]	Xue C, Zhao X Q, Liu C G, Chen L J, Bai F W. Prospective and development of butanol as an advanced biofuel [J]. Biotechnol. Adv., 2013, 31: 1575-1584
[3]	Dürre P. Biobutanol: an attractive biofuel [J]. Biotechnol. J., 2007, 2: 1525-1534
[4]	Xue C, Zhao J B, Liu F F, Lu C C, Yang S T, Bai F W. Two-stage in situ gas stripping for enhanced butanol fermentation and energy-saving product recovery [J]. Bioresour. Technol., 2013, 135: 396-402
[5]	Wu Y D, Xue C, Chen L J, Bai F W. Effect of zinc supplementation on acetone-butanol-ethanol fermentation by Clostridium acetobutylicum [J]. J. Biotechnol., 2013, 165: 18-21
[6]	Xue C, Zhao J B, Lu C C, Yang S T, Bai F W, Tang I. High-titer n-butanol production by Clostridium acetobutylicum JB200 in fed-batch fermentation with intermittent gas stripping [J]. Biotechnol. Bioeng., 2012, 109 (11): 2746-2756
[7]	Ezeji T C, Qureshi N, Blaschek H P. Butanol fermentation research: upstream and downstream manipulations [J]. Chem. Record., 2004, 4 (5): 305-314
[8]	Srinivasan K, Palanivelu K, Gopalakrishnan A N. Recovery of 1-butanol from a model pharmaceutical aqueous waste by pervaporation [J]. Chem. Eng. Sci., 2007, 62: 2905-2914
[9]	Wu H, Chen X P, Liu G P, Jiang M, Guo T, Jin W Q, Wei P, Zhu D W. Acetone-butanol-ethanol (ABE) fermentation using Clostridium acetobutylicum XY16 and in situ recovery by PDMS/ceramic composite membrane [J]. Bioproc. Biosyst. Eng., 2012, 35: 1057-1065
[10]	Aroujalian A, Raisi A. Pervaporation as a means of recovering ethanol from lignocellulosic bioconversions [J]. Desalination, 2009, 247 (1/2/3): 509-517
[11]	Sun D, Li B B, Xu Z L. Preparation and characterization of poly(dimethylsiloxane)-polytetrafluoroethylene (PDMS-PTFE) composite membrane for pervaporation of chloroform from aqueous solution [J]. Korean. J. Chem. Eng., 2013, 30 (11): 2059-2067
[12]	Sukitpaneenit P, Chung T S. Molecular design of the morphology and pore size of PVDF hollow fiber membranes for ethanol-water separation employing the modified pore-flow concept [J]. J. Membr. Sci., 2011, 374 (1/2): 67-82
[13]	Kim H J, Nah S S, Min B R. A new technique for preparation of PDMS pervaporation membrane for VOC removal [J]. Adv. Environ. Res., 2002, 6: 255-264
[14]	Volkov V V, Fadeev A G, Khotimsky V S, Litvinova E G, Selinskaya Y A, McMillan J D, Kelley S S. Effects of synthesis conditions on the pervaporation properties of poly[1-(trimethylsilyl)-1-propyne] useful for membrane bioreactors [J]. J. Appl. Polym. Sci., 2004, 91: 2271-2277
[15]	Claes S, Vandezande P, Mullens S, Sitter K D, Peeters R, Van Bael M K. Preparation and benchmarking of thin film supported PTMSP-silica pervaporation membranes [J]. J. Membr. Sci., 2012, 389: 265-271
[16]	Niemistö J, Kujawski W, Keiski R L. Pervaporation performance of composite poly(dimethyl siloxane) membrane for butanol recovery from model solutions [J]. J. Membr. Sci., 2013, 434: 55-64
[17]	Li L, Xiao Z Y, Tan S J, Pu L, Zhang Z B. Composite PDMS membrane with high flux for the separation of organics from water by pervaporation [J]. J. Membr. Sci., 2004, 243 (1/2): 177-187
[18]	Li S Y, Srivastava R, Parnas R S. Separation of 1-butanol by pervaporation using a novel tri-layer PDMS composite membrane [J]. J. Membr. Sci., 2010, 363 (1/2): 287-294
[19]	Zhao D, Shen Z, Yan X H, Wu D P, Ding K, Guan Y F. A porous membrane extraction and microtrap system for on-line monitoring of volatile organic compounds in water [J]. Chinese J. Anal. Chem., 2013, 41 (8): 1153-1158
[20]	Liu F F, Liu L, Feng X S. Separation of acetone-butanol-ethanol (ABE) from dilute aqueous solutions by pervaporation [J]. Sep. Purif. Technol., 2005, 42 (3): 273-282
[21]	Tang Y P, Li Z C, Li Y G. Salting effect in partially miscible systems of n-butanol-water and butanone-water (2): An extended Setschenow equation and its application [J]. Fluid Phase Equilibr., 1995, 105: 241-258
[22]	El-Zanati E, Abdel-Hakim E, El-Ardi O, Fahmy M. Modeling and simulation of butanol separation from aqueous solutions using pervaporation [J]. J. Membr. Sci., 2006, 280 (1/2): 278-283
[23]	Fouad E A, Feng X S. Use of pervaporation to separate butanol from dilute aqueous solutions: effects of operating conditions and concentration polarization [J]. J. Membr. Sci., 2008, 323: 428-435
[24]	Liu G P, Wei W, Wu H, Dong X L, Jiang M, Jin W Q. Pervaporation performance of PDMS/ceramic composite membrane in acetone butanol ethanol (ABE) fermentation-PV coupled process [J]. J. Membr. Sci., 2011, 373 (1/2): 121-129
[25]	Yen H W, Chen Z H, Yang I K. Use of the composite membrane of poly (ether-block-amide) and carbon nanotubes (CNTs) in a pervaporation system incorporated with fermentation for butanol production by Clostridium acetobutylicum [J]. Bioresour. Technol., 2012, 109: 105-109
[26]	Jeon E J, Kim A S, Lee Y T. Pervaporation of butanol/water mixtures using siloxane polymer/ceramic composite membranes [J]. Desalin. Water Treat., 2012, 48: 17-26
[27]	Niemistö J, Kujawski W, Keiski R L. Pervaporation performance of composite poly(dimethyl siloxane) membrane for butanol recovery from model solutions [J]. J. Membr. Sci., 2013, 434: 55-64

Application of polyvinylidene fluoride/polydimethylsiloxane composite membrane in butanol recovery

聚偏氟乙烯/聚二甲基硅氧烷渗透气化膜在丁醇分离中的应用

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References 27

Related Articles 15

Recommended Articles 0

Metrics

Comments

[1]	Jie CHEN, Yongsheng LIN, Kai XIAO, Chen YANG, Ting QIU. Study on catalytic synthesis of sec-butanol by tunable choline-based basic ionic liquids [J]. CIESC Journal, 2023, 74(9): 3716-3730.
[2]	Yaxin ZHAO, Xueqin ZHANG, Rongzhu WANG, Guo SUN, Shanjing YAO, Dongqiang LIN. Removal of monoclonal antibody aggregates with ion exchange chromatography by flow-through mode [J]. CIESC Journal, 2023, 74(9): 3879-3887.
[3]	Jiayi ZHANG, Jiali HE, Jiangpeng XIE, Jian WANG, Yu ZHAO, Dongqiang ZHANG. Research progress of pervaporation technology for N-methylpyrrolidone recovery in lithium battery production [J]. CIESC Journal, 2023, 74(8): 3203-3215.
[4]	Jun ZHANG, Sheng HU, Jing GU, Haoran YUAN, Yong CHEN. Catalytic hydrogenation of furfural over magnetic polymetallic materials derived from electroplating sludge in methanol [J]. CIESC Journal, 2022, 73(7): 2996-3006.
[5]	Xin LIU, Yang PAN, Gongping LIU, Jing FANG, Chunli LI, Hao LI. Study on the process of preliminary separation of Fischer-Tropsch synthetic water by coupling pervaporation and dividing wall column distillation [J]. CIESC Journal, 2022, 73(5): 2020-2030.
[6]	Heng MAO, Yue WANG, Sen WANG, Weimin LIU, Jing LYU, Fuxue CHEN, Zhiping ZHAO. APTES-modified ZIF-L/PEBA mixed matrix membranes for enhancing phenol perm-selective pervaporation [J]. CIESC Journal, 2022, 73(3): 1389-1402.
[7]	Wuyu WANG, Yuzhu SHI, Long YAN, Xinghua ZHANG, Longlong MA, Qi ZHANG. Synthesis of valerate biofuels on supported Co-based bifunctional catalysts [J]. CIESC Journal, 2022, 73(2): 689-698.
[8]	Junyi LUO, Shiliang WU, Rui XIAO. Study on combustion characteristics of cycloalkanes mixed with aviation kerosene [J]. CIESC Journal, 2022, 73(2): 847-856.
[9]	Wanyue DING, Xiaohua MA. Effects of synthesis times and Si-Al ratio of SAPO-34 zeolite membrane on ethanol dehydration performance [J]. CIESC Journal, 2021, 72(8): 4410-4417.
[10]	FANG Lijun, WANG Jingmei, LIN Qiaojing, CHEN Jianhua, YANG Qian. Enrichment of phenol in water by dibenzo-18-crown ether-6/polyether block amide membrane [J]. CIESC Journal, 2021, 72(7): 3716-3727.
[11]	NIU Xiaopo, XU Shuang, LI Xiaoxue, FENG Fuxiang, WANG Qingfa. Hollow Pt/ZSM-5 catalysts for highly selective hydrodeoxygenation of guaiacol to cycloalkanes [J]. CIESC Journal, 2021, 72(5): 2616-2625.
[12]	Ziyi LI,Enze PAN,Jiaxuan WANG,Jinming LU,Jianhua YANG. Preparation of ZSM-5 zeolite membrane and its application in desalination [J]. CIESC Journal, 2021, 72(10): 5247-5256.
[13]	Chunhui FAN,Zongye GAO,Shanjing YAO,Dongqiang LIN. Quantitative characterization of non-specific adsorption on affinity chromatography resins [J]. CIESC Journal, 2021, 72(10): 5218-5225.
[14]	PENG Li, WU Zhengqi, WANG Boxuan, WANG Xing, GU Xuehong. Preparation and stability study of TMCS modified MFI zeolite for ethanol/water separation [J]. CIESC Journal, 2021, 72(1): 569-577.
[15]	Chengye ZUO, Rui TU, Xiaobin DING, Weihong XING. Recovery of isobutanol from esterified wastewater by PDMS composite membrane [J]. CIESC Journal, 2020, 71(9): 4189-4199.