Particle rotation characteristics in impinging streams

doi:10.11949/j.issn.0438-1157.20151655

Abstract

Abstract:

An experimental device of gas-solid impinging streams was built up to study particle rotation characteristics. High-speed video camera system was used to observe particle motion in area of 0.15 m × 0.08 m. The influence factors of particle rotation were studied by using this experimental device with single injection or double injections. The particle rotation characteristics was obtained by analyzing those research data. The results showed that the particles always rotated when moving along the gas-solid impinging streams. The influence of gas on particle rotation was relatively small, and therefore it can be ignored. The average rotation speed of particles with smaller diameter was higher than that with greater diameter under same experimental conditions. Those particles with relatively higher velocity before collision were inclined to have a higher rotational speed after collision. The average difference between particle rotation speeds before and after collision can reach 280 r·s^-1 at gas velocity 25 m·s^-1 and diameter of alumina cement 0.003 m. The direction of particle motion has little influence on the particle rotation speed during collision.

Key words: impinging streams, particles, collision, rotation

摘要：

搭建了研究撞击流中颗粒旋转特性的气固两相撞击流实验台,使用高速摄像机拍摄一个截面为0.15 m×0.08 m的撞击区域内固体颗粒的运动。利用所搭建的实验台设置了单喷口和双喷口两种实验方式来研究颗粒旋转影响因素,得出撞击流内颗粒的旋转特性。结果表明:固体颗粒在气相中运动过程一直伴随着其自身的旋转;气相场对颗粒转速的影响较小,可忽略不计;相同实验条件下,颗粒直径越小其转速越大;颗粒以及气相速度越大,则固体颗粒在碰撞后的转速越大,当加速气相速度为25 m·s^-1,氧化铝陶瓷直径为0.003 m时,颗粒碰撞前后转速差平均值可达280 r·s^-1;颗粒间碰撞过程中,颗粒相对运动偏置角度对转速变化影响很小。

关键词: 撞击流, 颗粒, 碰撞, 旋转

CLC Number:

TK121

DU Min, CHEN Wei, WANG Zhuliang, GONG Jun, WANG Hongyu. Particle rotation characteristics in impinging streams[J]. CIESC Journal, 2016, 67(5): 1878-1883.

杜敏, 陈威, 王助良, 龚俊, 王宏宇. 撞击流中颗粒旋转特性[J]. 化工学报, 2016, 67(5): 1878-1883.

References 21

[1]	ELPERIN I T. Heat and mass transfer in opposing currents [J]. J. Engng. Physics., 1961, 6: 62-68.
[2]	伍沅. 撞击流性质及其应用 [J]. 化工进展, 2001, (11): 8-13. WU Y. Properties and application of impinging stream [J].Chemical Industry and Engineering Progress, 2001, (11): 8-13.
[3]	许建良, 代正华, 李巧红, 等. 气流床气化炉内颗粒停留时间分布[J].化工学报, 2008, 59(1): 53-57. XU J L, DAI Z H, LI Q H, et al. Particle residence time distribution inside a gasifier of a gas fluidized bed[J].Journal of Chemical Industry and Engineering(China), 2008, 59(1): 53-57.
[4]	朱文学, 段续. 对撞流中单一颗粒运动的理论分析[J]. 农业机械学报, 2002, 33(3): 50-52. ZHU W X, DUAN X. Theoretical analysis of a single particle movement in impinging stream [J]. Transaction of the Chinese Society for Agricultural Machinery, 2002, 33(3): 50-52.
[5]	伍沅. 撞击流——原理·性质·应用 [M]. 北京: 化学工业出版社, 2006: 3-12. WU Y. Impinging Stream — Principle, Nature, Applications [M].Beijing: Chemical Industry Press, 2006: 3-12.
[6]	张涛, 杜敏, 周宾, 等. 气固同轴撞击流干燥实验研究 [J]. 工程热物理学报, 2011, 32(11): 1910-1912. ZHANG T, DU M, ZHOU B, et al. Experimental of gas-solid coaxial impinging stream drying [J]. Journal of Engineering Thermophysics, 2011, 32(11): 1910-1912.
[7]	杜敏, 周宾. 气固两相撞击流内颗粒运动规律的实验研究 [J]. 热能动力工程, 2013, 28(6): 611-615. DU M, ZHOU B. Experimental of the movement of the particles within the flow of gas-solid impinging stream [J]. Thermal and Power Engineering, 2013, 28(6): 611-615.
[8]	杜敏, 郝英立, 刘向东. DSMC方法在大规模气固两相撞击流中的应用 [J]. 化工学报, 2009, 60(8): 1950-1958. DU M, HAO Y L, LIU X D. Applications of DSMC method in large-scale gas-solid impinging stream [J]. CIESC Journal, 2009, 60(8): 1950-1958.
[9]	DU M, ZHAO C, ZHOU B, et al. A modified DSMC method for simulating gas-particle two-phase impinging streams [J]. Chemical Engineering Science, 2011, 66(20): 4922-4931.
[10]	王勤辉, 杨秋灰, 吴学成, 等. 多相流中颗粒旋转特性的研究进展 [J]. 化工学报, 2011, 62(9): 2381-2390. WANG Q H, YANG Q H, WU X C, et al. Research progress of particle totation characteristics in multi-phase flow [J]. CIESC Journal, 2011, 62(9): 2381-2390.
[11]	王淑彦, 何玉荣, 陆慧林. 颗粒旋转对鼓泡流化床内气固两相流动特性影响的数值模拟 [J]. 化工学报, 2007, 58(11): 2738-2746. WANG S Y, HE Y R, LU H L. Numerical simulation of gas and particles flow behavior considering effect of particle rotations in bubbling fluidized beds [J]. Journal of Chemical Industry and Engineering(China), 2007, 58(11): 2738-2746.
[12]	袁竹林, 马明, 徐益谦.离散数值模拟颗粒自转对流化床内颗粒流态的影响 [J]. 燃烧科学与技术, 2001, 7(3): 238-241. YUAN Z L, MA M, XU Y Q. Study on effect of particle rotation on fluidizing behavior using discrete numerical simulation method [J]. Journal of Combustion Science and Technology, 2001, 7(3): 238-241.
[13]	袁竹林, 徐益谦.从软、硬球模型探讨颗粒自转对流态化的影响 [J]. 工程热物理学报, 2001, 22(3): 363-366. YUAN Z L, XU Y Q. Study on the effect of particle rotation on fluidizing behavior using numerical simulation method [J]. Journal of Engineering Technology, 2001, 22(3): 363-366.
[14]	SUN J. Hydrodynamic modeling of particle rotation for segregation in bubbling gas-fluidized beds [J]. Chemical Engineering Science, 2006, 61(5): 1470-1479.
[15]	刘红娟, 邹春, 田智威.撞击流中单颗粒运动行为的数值模拟 [J]. 华中科技大学学报(自然科学版), 2008, 36(5): 106-109. LIU H J, ZOU C, TIAN Z W. Motion of single particle in the impinging stream [J]. Journal of Huazhong University(Nature Science Edition), 2008, 36(5): 106-109.
[16]	骆仲泱, 吴学成, 王勤辉, 等. 循环流化床中颗粒旋转特性 [J]. 化工学报, 2005, 56(10): 1869-1874. LUO Z Y, WU X C, WANG Q H, et al. Particle rotation in CFB [J]. Journal of Chemical Industry and Engineering(China), 2005, 56(10): 1869-1874.
[17]	孙志刚, 李伟锋, 刘海峰, 等. 同轴对称撞击流中的颗粒运动行为 [J]. 化学反应工程与工艺, 2009, 25(2): 97-103. SUN Z G, LI W F, LIU H F, et al. Behavior of particles in coaxial impinging stream [J]. Chemical Reaction Engineering and Technology, 2009, 25(2): 97-103.
[18]	吴学成, 王勤辉, 骆仲泱, 等. 高速数字摄像应用于流化床内颗粒旋转特性的测试 [J]. 中国电机工程学报, 2005, 25(9): 72-77. WU X C, WANG Q H, LUO Z Y, et al. Measurement of particle rotation in CFB riser with high-speed digital video camera technique [J]. Proceeding of the CSEE, 2005, 25(9): 72-77.
[19]	朱志斌. 氧化铝陶瓷的发展与应用 [J]. 陶瓷, 2003, (1): 5-7. ZHU Z B. The development and application of alumina ceramics [J]. Ceramics, 2003, (1): 5-7.
[20]	李静海, 欧阳洁, 高士秋, 等. 颗粒流体复杂系统的多尺度模拟[M]. 北京: 科学出版社, 2005: 207-208. LI J H, OUYANG J, GAO S Q, et al. Multi-Scale Simulation of Particle-Fluent Complex Systems[M]. Beijing: Science Press, 2005: 207-208.
[21]	孔琥. 两相流体力学[M]. 北京: 高等教育出版社, 2004: 99-100. KONG H. Two-Phase Fluent Mechanics[M]. Beijing: Higher Education Press, 2004: 99-100.