Analysis of pyrolysis kinetics of neighboring-port oil sludge

doi:10.11949/j.issn.0438-1157.20141553

Abstract

Abstract:

Based on composition analysis of extract oil and pyrolysis oil from oil sludge, the pyrolysis characteristics of oil sludge in the air were studied experimentally using thermal gravimetric analyzer. The thermogravimetry and differential thermal analysis curve were investigated under different heating rate. Based on Coats-Redfern integral method, the adjusted R- square coefficient of ln [g(a)/T²] versus 1/T for TG datum between 200 and 600℃ was analyzed using nine kinds of different kinetics mechanism functions. The activation energy of reaction and the pre-exponential factor were fitted. The results indicated that TG and DTA curve of oil sludge shifted to higher temperature with the increase of the heating rates. There are two temperature stages in the pyrolysis of oil sludge: 200—400℃ and 400—600℃. The kinetics reaction process of the sample complies with reaction mechanisms of the three dimensional diffusion in the first stage. Pyrolysis reaction of oil sludge of the second stage is in accordance with the rules of the first-order reaction.

Key words: oil sludge, pyrolysis, extract, kinetics, activation energy

摘要：

对含油污泥及其抽提油和热解油的组成进行分析。采用热重分析仪对含油污泥在空气氛下的热重特性进行实验研究, 考察不同升温速率下的热重(TG)和差热分析(DTA)曲线。采用Coats-Redfern积分法, 基于9种不同动力学机制模式函数分别对200～600℃之间的热重分析数据就ln[g (a)/T²]对1/T进行校正决定系数分析, 拟合反应动力学活化能和指前因子。实验结果表明:随着升温速率的增加, 油泥的TG和DTA曲线都向高温方向移动。含油污泥的热解阶段分为200～400℃和400～600℃两个阶段, 第一个阶段符合三维扩散反应动力学机制;第二个阶段含油污泥的热解反应符合一级反应规律。

关键词: 含油污泥, 热解, 抽提, 动力学, 活化能

CLC Number:

TQ028.8

YANG Shuqing, ZHENG Xianmin, WANG Beifu, DU Yan, WANG Luhui. Analysis of pyrolysis kinetics of neighboring-port oil sludge[J]. CIESC Journal, 2015, 66(S1): 319-325.

杨淑清, 郑贤敏, 王北福, 杜燕, 王路辉. 临港含油污泥的热解动力学分析[J]. 化工学报, 2015, 66(S1): 319-325.

References 26

[1]	Ramzi F Hejazi, Tahir Husain, Faisal I Khan. Landfarming operation of oily sludge in arid region-human health risk assessment [J]. Journal of Hazardous Materials, 2003, 99(3): 287-302.
[2]	Hu Guangji, Li Jianbing, Zeng Guangming . Recent development in the treatment of oily sludge from petroleum industry: a review [J]. Journal of Hazardous Materials, 2013, 261: 470-490.
[3]	Xu Ning, Wang Wenxiang, Han Pingfang, Lu Xiaoping . Effects of ultrasound on oily sludge deoiling [J]. Journal of Hazardous Materials, 2009, 171(1/2/3): 914-917.
[4]	Zhang Ju, Li Jianbing, Ronald W Thring, Hu Xuan, Song Xinyuan. Oil recovery from refinery oily sludge via ultrasound and freeze/thaw [J]. Journal of Hazardous Materials, 2012, 203/204: 195-203.
[5]	Yan Ping, Lu Mang, Yang Qin, Zhang Hailing, Zhang Zhongzhi, Chen Rong. Oil recovery from refinery oily sludge using a rhamnolipid biosurfactant-producing [J]. Bioresource Technology, 2012, 116: 24-28.
[6]	Zhou Lingsheng, Jiang Xiumin, Liu Jianguo. Characteristics of oily sludge combustion in circulating fluidized beds [J]. Journal of Hazardous Materials, 2009, 170 (1): 175-179.
[7]	Ragheb A Tahhan, Rouba Youssef Abu-Ateih. Biodegradation of petroleum industry oily-sludge using Jordanian oil refinery contaminated soil [J]. International Biodeterioration & Biodegradation, 2009, 63(8): 1054-1060.
[8]	Bassam Mrayyan, Mohammed N Battikhi. Biodegradation of total organic carbons (TOC) in Jordanian petroleum sludge [J]. Journal of Hazardous Materials, 2005, 120(1/2/3): 127-134.
[9]	Lai Nanjun(赖南君), Ye Zhongbin(叶仲斌), Fan Kaiyun(樊开赟), Shu Zheng(舒政). Hydrophobically associating polymer gelling fluid with oily sludge admixtured as profile modificator: a preliminary study [J]. Oilfield Chemistry(油田化学), 2010, 27(1): 66-68.
[10]	Saeed M Al-Zahrani, Meilana Dharma Putra. Used lubricating oil regeneration by various solvent extraction techniques [J]. Journal of Industrial and Engineering Chemistry, 2013, 19(2): 536-539.
[11]	Essam A H Zubaidy, Dana M Abouelnasr. Fuel recovery from waste oily sludge using solvent extraction [J]. Process Safety and Environmental Protection, 2010, 88: 318-326.
[12]	Wang Zhiqi, Guo Qingjie, Liu Xinmin, Cao Changqing. Low temperature pyrolysis characteristics of oil sludge under various heating conditions [J]. Energy & Fuels, 2007, 21(2): 957-962.
[13]	Je Lueng Shie, Ching Yuan Chang, Jyh Ping Lin, Duu-Jong Lee, Chao-Hsiung Wu. Use of inexpensive additives in pyrolysis of oil sludge [J]. Energy & Fuels, 2002, 16(1): 102-108.
[14]	Song Wei(宋薇), Liu Jianguo (刘建国), Nie Yongfeng(聂永丰). Pyrolysis properties of oil sludge [J]. Journal of Fuel Chemistry and Technology(燃料化学学报), 2008, 36(3): 286-290.
[15]	Quan Cui(全翠), Li Aimin(李爱民), Gao Ningbo(高宁博), Guo Dandan(郭眈丹). Oil recovery from oily-sludge by pyrolysis method [J]. Acta Petrolei Sinica: Petroleum Processing Section(石油学报: 石油加工), 2010, 26(5): 742-746.
[16]	Isabel Fonts, Gloria Gea, Manuel Azuara, Javier Ábrego, Jesús Arauzo. Sewage sludge pyrolysis for liquid production: a review [J]. Renewable and Sustainable Energy Reviews, 2012, 16(5): 2781-2805.
[17]	Zhang Suping, Yan Yongjie, Li Tingchen, Ren Zhengwei. Upgrading of liquid fuel from the pyrolysis of biomass [J]. Bioresource Technology, 2005, 96(5): 545-550.
[18]	Liu Jianguo, Jiang Xiumin, Han Xiangxin. Devolatilization of oil sludge in a lab-scale bubbling fluidized bed [J]. Journal of Hazardous Materials, 2011, 185: 1205-1213.
[19]	Hou Xianglin(侯祥麟). Chinese Refining Technology (中国炼油技术) [M]. 2nd ed. Beijing:China Petrochemical Press, 2000: 89-103.
[20]	Liang Wenjie(梁文杰). Petroleum Chemistry(石油化学) [M]. Dongying:University of Petroleum Press, 1995: 257-266.
[21]	Silva V S, Romeiro G A, Veloso M C C, Figueiredo M K K, Pinto P A, Ferreira A F, Gonalves M L A, Teixeira A M, Damasceno R N. Fractions composition study of the pyrolysis oil obtained from sewage sludge treatment plant [J]. Bioresource Technology, 2012, 103(1): 459-465.
[22]	Yang Fuqiang(阳富强), Wu Chao(吴超), Liu Hui(刘辉), Pan Wei(潘伟), Cui Yan(崔燕). Thermal analysis kinetics of sulfide ores for spontaneous combustion [J]. Journal of Central South University: Science and Technology(中南大学学报:自然科学版), 2011, 42(8): 2469-2474.
[23]	Yu Boling(于伯龄), Jiang Jiaodong (姜胶东). The Utility of Thermal Analysis(实用热分析)[M]. Beijing:China Textile & Apparel Press, 1990: 39-60.
[24]	Hu Rongzu(胡荣祖), Gao Shengli(高胜利), Zhao Fengqi(赵凤起). Kinetics of Thermal Analysis(热分析动力学)[M]. Beijing: Science Press, 2001: 5-20.
[25]	Liu Zhenhai(刘振海), Tian Shan Lizi(畠山立子). Handbook of Analytical Chemistry: Thermal Analysis (分析化学手册热分析)[M].2nd ed. Beijing: Chemical Industry Press, 2004: 42-56.
[26]	Popescu C. Integral method to analyze the kinetics of heterogeneous reactions under non-isothermal conditions: a variant on the Ozawa-Flynn-Wall method [J]. Thermochimica Acta, 1996, 285(2): 309-323.