Heat transfer analysis and numerical calculation for full containment LNG tank

doi:10.11949/j.issn.0438-1157.20150862

CIESC Journal ›› 2015, Vol. 66 ›› Issue (S2): 132-137.DOI: 10.11949/j.issn.0438-1157.20150862

Previous Articles Next Articles

Heat transfer analysis and numerical calculation for full containment LNG tank

LI Zhaoci, GUO Baoling, WU Xin, ZHENG Mei

National Engineering Laboratory for Pipeline Safety/Beijing Key Laboratory of Urban Oil and Gas Distribution Technology, China University of Petroleum, Beijing 102200, China

Received:2015-06-09 Revised:2015-06-16 Online:2015-08-31 Published:2015-08-31
Supported by:
supported by the China University of Petroleum Young Teachers Special Training Foundation(KYJJ2012-04-01).

全容式LNG储罐传热分析与数值计算

李兆慈, 郭保玲, 吴鑫, 郑梅

中国石油大学(北京)油气管道输送安全国家工程实验室/城市油气输配技术北京市重点实验室, 北京 102200

通讯作者: 李兆慈
基金资助:
中国石油大学(北京)青年教师专项培养基金项目(KYJJ2012-04-01)。

Abstract

Abstract:

Due to the huge temperature difference between LNG and ambient temperature,the thermal insulation and structure of the full containment LNG tank are complex.The full containment LNG tank was selected as the example,and the heat transfer of each part of the tank were analyzed.The two-dimensional and three-dimensional steady temperature field numerical calculation models were built,and the temperature distribution of the bottom,the wall and the connecting parts of the tank were calculated.The research results has reference significance for LNG tank structure design.

Key words: natural gas, heat transfer, numerical analysis

摘要：

LNG储罐储存介质与环境温度存在较大温差,保冷和罐体结构复杂。以全容式LNG储罐为例分析储罐各部分的传热计算方法,建立了储罐罐体的二维和三维稳态温度场数值计算模型,计算得到罐壁、罐底及各连接部位的温度场分布图,并进行了分析。研究结果对LNG储罐的结构设计具有参考价值。

关键词: 天然气, 传热, 数值分析

CLC Number:

TE821

LI Zhaoci, GUO Baoling, WU Xin, ZHENG Mei. Heat transfer analysis and numerical calculation for full containment LNG tank[J]. CIESC Journal, 2015, 66(S2): 132-137.

李兆慈, 郭保玲, 吴鑫, 郑梅. 全容式LNG储罐传热分析与数值计算[J]. 化工学报, 2015, 66(S2): 132-137.

References 22

[1]	Huang Qun(黄群),Xia Fang(夏芳).Feasibility of LNG storage tanks localization[J].Technical Engineering(技术工程),2010,30(7):1-3.
[2]	Rama Subba Reddy Gorla.Probabilistic analysis of a lique-fied natural gas storage tank[J].Applied Thermal Engineering,2010,30(7):2763-2769.
[3]	Kim Hyeon Su,Chun Min Sung,Lee Jae Myung.A com-parative evaluation of fatigue and fracture characteristics of structural components of liquefied natural gas carrier insulation system[J].Journal of Pressure Vessel Technology,2013,135(2):1-9.
[4]	Lebel F,et al.Thermal ageing process at laboratory scale to evaluate the lifetime of liquefied natural gas storage and loading/unloading materials[J].Materials and Design,2013,44(7):283-290.
[5]	Kogbara R B,Iyengar S R,Grasley Z C,et al.A review of concrete properties at cryogenic temperatures:towards direct LNG containment[J].Construction and Building Materials,2013,47(12):760-770.
[6]	Zhang Yunfeng(张云峰),Liu Xiaoli(刘晓丽),Yu Yahui(余亚辉),Wang Weixun(王伟勋).Morphing analysis of outer wall of LNG storage tank influenced by ultra low temperature[J].Science Technology Engineering(科学技术与工程),2010,10(3):769-772.
[7]	Wang Chun(王春).Early temperature crack analysis on LNG tank outside concrete wall[J].Low Temperature Architecture Technology(低温建筑技术),2009,(11):119-120.
[8]	Liu Zhaoqiu (刘照球).Study on the convective heat transfer coefficient of the concrete surface[D].Shanghai:Tongji University,2006.
[9]	Liu Shan(柳山).Study on structure and performance of full containment LNG tank[D].Guangzhou:South China University of Technology,2009.
[10]	Cheng Xudong(程旭东),Zhu Xingji(朱兴吉).Thermal stress analysis on external wall of LNG storage tank and the design of pre-stressed reinforcement[J].Acta Petrolei Sinica(石油学报),2012,33(3):499-505.
[11]	Tian Xiaoxue(田晓雪).Stress analysis of LNG storage tank under impact loading[D].Daqing:Northeast Petroleum University,2011.
[12]	Zhang Yunfeng(张云峰),Zhang Zhao(张钊),Xue Jinghong(薛景宏),JI Jing(计静).Stress analysis of the outer wall of the storage tank under impact loading[J]. Journal of Daqing Petroleum Institute(大庆石油学院学报),2011,35(6):93-96.
[13]	Yu Rangang(俞然刚),Li Zhiming(李志明),Zhang Jian(张健),Zhou Jinshun(周金顺).Numerical simulation and optimization of pre-stressed tendon tensioning for large-scale LNG storage tank[J].Oil & Gas Storage and Transporation(油气储运),2013,32(3):291-294.
[14]	Zhang R F,Weng D G,Ni W B.Application of annular damper reaction wall in seismic isolated LNG tank//Proceedings of the ASME 2010 Pressure Vessels & Piping Division Conference[C].2010.
[15]	Lü Keke(吕克克).The analysis of temperature-stress field of full containment LNG tank[D].Tianjing:Tianjin University,2010.
[16]	Su Juan(苏娟),Zhou Meizhen(周美珍),Yu Jianxing(余建星).Low temperature analysis of LNG prestressed concrete tank for spill conditions[J].Cryogenics(低温工程),2010,(4):47-52.
[17]	Li Jianjun(李建军).Thermal-structural coupling finite element analysis of large-scale LNG tanks[D].Tianjin:Tianjin University,2012.
[18]	Sun Heng(孙恒),Yu Ting(余霆),Ma Wenhua(马文华),Li Zhaoci(李兆慈).FEM analysis of the temperature distribution of the TCP of a LNG tank[J].Cryogenics & Superconductivity(低温与超导),2010,38(4):15-16.
[19]	Zhu Hongmei(朱鸿梅),Sun Heng(孙恒),Liu Hongwei(刘宏伟).Temperature field on corner adiabatic structure of large-scale LNG storage tank[J].Oil & Gas Storage and Transporation(油气储运),2011,30(1):37-40.
[20]	Li Hairun(李海润),Xu Jiashuang(徐嘉爽),Li Zhaoci(李兆慈).Calculation and analysis on temperature field in full containment LNG tank[J].Natural Gas and Oil(天然气与石油),2012,30(4):15-19.
[21]	Li Hairun(李海润).Temperature distribution research of full containment LNG tank[D].Beijing:China University of Petroleum,2011.
[22]	Guo Baoling(郭保玲).Temperature field simulation of full containment LNG tank based on ANSYS[D].Beijing:China University of Petroleum,2013.

Heat transfer analysis and numerical calculation for full containment LNG tank

全容式LNG储罐传热分析与数值计算

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References 22

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Cheng CHENG, Zhongdi DUAN, Haoran SUN, Haitao HU, Hongxiang XUE. Lattice Boltzmann simulation of surface microstructure effect on crystallization fouling [J]. CIESC Journal, 2023, 74(S1): 74-86.
[2]	Shuangxing ZHANG, Fangchen LIU, Yifei ZHANG, Wenjing DU. Experimental study on phase change heat storage and release performance of R-134a pulsating heat pipe [J]. CIESC Journal, 2023, 74(S1): 165-171.
[3]	Yifei ZHANG, Fangchen LIU, Shuangxing ZHANG, Wenjing DU. Performance analysis of printed circuit heat exchanger for supercritical carbon dioxide [J]. CIESC Journal, 2023, 74(S1): 183-190.
[4]	Aiqiang CHEN, Yanqi DAI, Yue LIU, Bin LIU, Hanming WU. Influence of substrate temperature on HFE7100 droplet evaporation process [J]. CIESC Journal, 2023, 74(S1): 191-197.
[5]	Mingxi LIU, Yanpeng WU. Simulation analysis of effect of diameter and length of light pipes on heat transfer [J]. CIESC Journal, 2023, 74(S1): 206-212.
[6]	Zhiguo WANG, Meng XUE, Yushuang DONG, Tianzhen ZHANG, Xiaokai QIN, Qiang HAN. Numerical simulation and analysis of geothermal rock mass heat flow coupling based on fracture roughness characterization method [J]. CIESC Journal, 2023, 74(S1): 223-234.
[7]	Ke LI, Jian WEN, Biping XIN. Study on influence mechanism of vacuum multi-layer insulation coupled with vapor-cooled shield on self-pressurization process of liquid hydrogen storage tank [J]. CIESC Journal, 2023, 74(9): 3786-3796.
[8]	Yitong LI, Hang GUO, Hao CHEN, Fang YE. Study on operating conditions of proton exchange membrane fuel cells with non-uniform catalyst distributions [J]. CIESC Journal, 2023, 74(9): 3831-3840.
[9]	Yubing WANG, Jie LI, Hongbo ZHAN, Guangya ZHU, Dalin ZHANG. Experimental study on flow boiling heat transfer of R134a in mini channel with diamond pin fin array [J]. CIESC Journal, 2023, 74(9): 3797-3806.
[10]	Cong QI, Zi DING, Jie YU, Maoqing TANG, Lin LIANG. Study on solar thermoelectric power generation characteristics based on selective absorption nanofilm [J]. CIESC Journal, 2023, 74(9): 3921-3930.
[11]	Yue YANG, Dan ZHANG, Jugan ZHENG, Maoping TU, Qingzhong YANG. Experimental study on flash and mixing evaporation of aqueous NaCl solution [J]. CIESC Journal, 2023, 74(8): 3279-3291.
[12]	Ruihang ZHANG, Pan CAO, Feng YANG, Kun LI, Peng XIAO, Chun DENG, Bei LIU, Changyu SUN, Guangjin CHEN. Analysis of key parameters affecting product purity of natural gas ethane recovery process via ZIF-8 nanofluid [J]. CIESC Journal, 2023, 74(8): 3386-3393.
[13]	Rui HONG, Baoqiang YUAN, Wenjing DU. Analysis on mechanism of heat transfer deterioration of supercritical carbon dioxide in vertical upward tube [J]. CIESC Journal, 2023, 74(8): 3309-3319.
[14]	Tianhua CHEN, Zhaoxuan LIU, Qun HAN, Chengbin ZHANG, Wenming LI. Research progress and influencing factors of the heat transfer enhancement of spray cooling [J]. CIESC Journal, 2023, 74(8): 3149-3170.
[15]	Hai WANG, Hong LIN, Chen WANG, Haojie XU, Lei ZUO, Junfeng WANG. Investigation of enhanced boiling heat transfer on porous structural surfaces by high voltage electric field [J]. CIESC Journal, 2023, 74(7): 2869-2879.