燃煤锅炉烟气中Na2SO4生成的化学动力学研究

doi:10.11949/j.issn.0438-1157.20180051

摘要/Abstract

摘要：

准东煤燃烧过程中Na₂SO₄的形成会造成锅炉受热面沾污、尾部SCR催化剂失活等问题。烟气中Na₂SO₄形成及转化规律的研究对于预测和控制燃煤烟气中Na₂SO₄的形成有重要意义。发展了烟气中Na/Cl/S/O/H化学动力学模型，研究了烟气中Na₂SO₄的生成过程及转化机理，考察了含氧量、温度、SO₂浓度、H₂O浓度等因素对Na₂SO₄生成的影响。动力学计算结果表明，模型预测结果与实验数据吻合较好，验证了模型的准确性。烟气中的高氧气含量有利于Na₂SO₄的生成。高温加快化学反应的同时，抑制了Na₂SO₄的生成。SO₂和H₂O的影响效果受温度影响较大。反应路径分析表明，Na₂SO₄的生成路径有两个：一是依赖于SO₂直接氧化（NaCl→NaSO₃Cl→NaHSO₄→Na₂SO₄），二是依赖于SO₂间接氧化（NaCl→NaO₂→NaSO₄→NaHSO₄→Na₂SO₄）。敏感性分析结果表明，Na₂SO₄的生成主要对系统中生成或消耗自由基的反应更为敏感。

关键词: 准东煤, 碱金属, Na₂SO₄生成, 化学动力学, 反应路径

Abstract:

The formation of gaseous sodium sulphate during Zhundong coal combustion leads to a series of problems such as the deposition and corrosion of heat exchange surface and the deactivation of tail SCR catalyst. Therefore, the kinetic study on the transformation of Na₂SO₄ is important for predicting and controlling the Na₂SO₄ formation in coal-fired flue gas. In this study, a more complicated chemical kinetic model of Na/Cl/S/O/H in flue gas was established and the formation mechanism of Na₂SO₄ was studied. The influence of oxygen content, temperature, SO₂and H₂O concentrations on Na₂SO₄ formation was also investigated. The model predictions were in good agreement with the experimental results. Oxygen promoted the formation of Na₂SO₄. Even though the chemical reactions were accelerated at high temperature, the Na₂SO₄ formation was inhibited. The effects of SO₂ and H₂O on Na₂SO₄ formation depended on reaction temperature. The path analysis indicated that there were two important paths to form Na₂SO₄:(1) the direct oxidation of SO₂ (NaCl→NaSO₃Cl→NaHSO₄→Na₂SO₄), and (2) the indirect oxidation of SO₂(NaCl→NaO₂→NaSO₄→NaHSO₄→Na₂SO₄). The result of sensitivity analysis showed that the Na₂SO₄ formation was sensitive to the reactions that generated or consumed radicals in the system.

Key words: Zhundong coal, alkali metal, Na₂SO₄ formation, chemical kinetics, reaction path

中图分类号:

TK16

张志潮, 刘晶, 杨应举, 张振. 燃煤锅炉烟气中Na₂SO₄生成的化学动力学研究[J]. 化工学报, 2018, 69(8): 3643-3650.

ZHANG Zhichao, LIU Jing, YANG Yingju, ZHANG Zhen. Study on chemical kinetics of Na₂SO₄ formation in coal fired flue gas[J]. CIESC Journal, 2018, 69(8): 3643-3650.

参考文献 30

[1]	张守玉, 陈川, 施大钟, 等. 高钠煤燃烧利用现状[J]. 中国电机工程学报, 2013, 33(5):1-12. ZHANG S Y, CHEN C, SHI D Z, et al. Situation of combustion utilization of high sodium coal[J]. Proceedings of the CSEE, 2013, 33(5):1-12.
[2]	金涌, 胡永琪, 胡山鹰, 等. 煤炭热力学高效和化学高价值利用新工艺[J]. 化工学报, 2014, 65(2):381-389. JIN Y, HU Y Q, HU S Y, et al. New technology for thermo-chemical comprehensive utilization of coal[J]. CIESC Journal, 2014, 65(2):381-389.
[3]	刘敬, 王智化, 项飞鹏, 等. 准东煤中碱金属的赋存形式及其在燃烧过程中的迁移规律实验研究[J]. 燃料化学学报, 2014, 42(3):316-322. LIU J, WANG Z H, XIANG F P. et al. Modes of occurrence and transformation of alkali metals in Zhundong coal during combustion[J]. Journal of Fuel Chemistry and Technology, 2014, 42(3):316-322.
[4]	陈川, 张守玉, 刘大海, 等. 新疆高钠煤中钠的赋存形态及其对燃烧过程的影响[J]. 燃料化学学报, 2013, 41(7):832-838. CHEN C, ZHANG S Y, LIU D H, et al. Existence form of sodium in high sodium coals from Xinjiang and its effect on combustion process[J]. Journal of Fuel Chemistry and Technology, 2013, 41(7):832-838.
[5]	刘大海, 张守玉, 陈川, 等. 新疆高钠煤脱钠提质过程中钠存在形式[J]. 煤炭学报, 2014, 39(12):2519-2524. LIU D H, ZHANG S Y, CHEN C, et al. Existence form of sodium in the high sodium coals from Xinjiang during its sodium removal process[J]. Journal of China Coal Society, 2014, 39(12):2519-2524.
[6]	刘大海, 张守玉, 涂圣康, 等. 五彩湾煤中钠在热解过程中的形态变迁[J]. 燃料化学学报, 2014, 42(10):1190-1196. LIU D H, ZHANG S Y, TU S K, et al. Transformation of sodium during Wucaiwan coal pyrolysis[J]. Journal of Fuel Chemistry and Technology, 2014, 42(10):1190-1196.
[7]	刘大海, 张守玉, 涂圣康, 等. 五彩湾煤中钠在燃烧过程中的迁移释放规律[J]. 化工进展, 2015, 34(3):705-709. LIU D H, ZHANG S Y, TU S K, et al. Transformation and release of sodium in Wucaiwan coal during combustion[J]. Chemical Industry and Engineering Progress, 2015, 34(3):705-709.
[8]	VAN EYK P J, ASHMAN P J, ALWAHABI Z T, et al. The release of water-bound and organic sodium from Loy Yang coal during the combustion of single particles in a flat flame[J]. Combustion and Flame, 2011, 158(6):1181-1192.
[9]	VAN EYK P J, ASHMAN P J, NATHAN G J. Mechanism and kinetics of sodium release from brown coal char particles during combustion[J]. Combustion and Flame, 2011, 158(12):2512-2523.
[10]	OLESCHKO H, SCHIMROSCZYK A, LIPPERT H, et al. Influence of coal composition on the release of Na-, K-, Cl-, and S-species during the combustion of brown coal[J]. Fuel, 2007, 86(15):2275-2282.
[11]	王学斌, 魏博, 张利孟, 等. 温度和SiO2添加物对准东煤中碱金属的赋存形态及迁徙特性的影响[J]. 热力发电, 2014, 43(8):84-88. WANG X B, WEI B, ZHANG L M, et al. Effect of temperature and silicon additives on occurrence and transformation characteristics of alkali metal in Zhundong coal[J]. Thermal Power Generation, 2014, 43(8):84-88.
[12]	WANG X, XU Z, WEI B, et al. The ash deposition mechanism in boilers burning Zhundong coal with high contents of sodium and calcium:a study from ash evaporating to condensing[J]. Applied Thermal Engineering, 2015, 80(5):150-159.
[13]	张翔, 乌晓江, 陈楠. 新疆高碱煤沾污结渣特性中试试验研究[J]. 锅炉技术, 2016, 47(4):44-47. ZHANG X, WU X J, CHEN N. Experimental study on Xinjiang high-alkali ash deposition and slagging behavior in a 3 MWth pilot-scale test facility[J]. Boiler Technology, 2016, 47(4):44-47.
[14]	CHRISTENSEN K A, LIVBJERG H. A plug flow model for chemical reactions and aerosol nucleation and growth in an alkali-containing flue gas[J]. Aerosol Science and Technology, 2000, 33(6):470-489.
[15]	KNUDSEN J N, JENSEN P A, DAMJOHANSEN K. Transformation and release to the gas phase of Cl, K, and S during combustion of annual biomass[J]. Energy & Fuels, 2004, 18(5):1385-1399.
[16]	STEINBERG M, SCHOFIELD K. The controlling chemistry of surface deposition from sodium and potassium seeded flames free of sulfur or chlorine impurities[J]. Combustion and Flame, 2002, 129(4):453-470.
[17]	CAPABLO J, BALLESTER J. Experimental study of the kinetics of sulfation of alkali chloride deposits[J]. Fuel Processing Technology, 2015, 140:215-221.
[18]	STEINBERG M, SCHOFIELD K. The controlling chemistry in flame generated surface deposition of Na2SO4 and the effects of chlorine[J]. Symposium on Combustion, 1996, 26(2):1835-1843.
[19]	JENSEN J R, NIELSEN L B, SCHULTZ M, et al. The nucleation of aerosols in flue gases with a high content of alkali-a laboratory study[J]. Aerosol Science & Technology, 2000, 33(6):490-509.
[20]	GLARBORG P, MARSHALL P. Mechanism and modeling of the formation of gaseous alkali sulfates[J]. Combustion and Flame, 2005, 141(1):22-39.
[21]	LI B, SUN Z, LI Z, et al. Post-flame gas-phase sulfation of potassium chloride[J]. Combustion & Flame, 2013, 160(5):959-969.
[22]	GLARBORG P, KUBEL D, DAM-JOHANSEN K, et al. Impact of SO2 and NO on CO oxidation under post-flame conditions[J]. International Journal of Chemical Kinetics, 1996, 28(10):773-790.
[23]	ALZUETA M U, BILBAO R, GLARBORG P. Inhibition and sensitization of fuel oxidation by SO2[J]. Combustion and Flame, 2001, 127(4):2234-2251.
[24]	DAGAUT P, LECOMTE F, MIERITZ J, et al. Experimental and kinetic modeling study of the effect of NO and SO2 on the oxidation of CO and H2 mixtures[J]. International Journal of Chemical Kinetics, 2003, 35(11):564-575.
[25]	GLARBORG P, ALZUETA M U, KJ RGAARD K, et al. Oxidation of formaldehyde and its interaction with nitric oxide in a flow reactor[J]. Combustion & Flame, 2003, 132(4):629-638.
[26]	BAULCH D, DUXBURY J, GRANT S, et al. Evaluated kinetic data for high temperature reactions.Vol.4:Homogeneous gas phase reactions of halogen and cyanide-containing species[J]. J. Phys. Chem. Ref. Data, 1981, 10(Suppl.):723.
[27]	STEARNS C A, MILLER R A, KOHL F J, et al. Investigation of the formation of gaseous sodium sulfate in a doped methane-oxygen flame[J]. Journal of Scientific & Industrial Research, 1977, 29(2):1-20.
[28]	STULL D R, PROPHET H. JANAF thermochemical tables[R]. National Standard Reference Data System, 1971.
[29]	赵斯楠, 方庆艳, 马仑, 等. 燃烧初期化学当量比对锅炉NOx生成与排放特性的影响[J]. 燃烧科学与技术, 2017, 23(3):236-241. ZHAO S N, FANG Q Y, MA L, et al. Influence of stoichiometric ratio at initial combustion stage on NOx formation and emission characteristics of a utility boiler[J]. Journal of Combustion Science and Technology, 2017, 23(3):236-241.
[30]	谭厚章, 魏博, 王学斌, 等. 高碱煤燃烧过程中屏式过热器分层结渣机理研究[J]. 中国电力, 2016, 49(8):167-171. TAN H Z, WEI B, WANG X B, et al. Study on layered slagging mechanism at platen superheater during high alkali coal[J]. Electric Power, 2016, 49(8):167-171.

燃煤锅炉烟气中Na₂SO₄生成的化学动力学研究

Study on chemical kinetics of Na₂SO₄ formation in coal fired flue gas

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 30

相关文章 15

编辑推荐

Metrics

本文评价

[1]	蔺彩虹, 王丽, 吴瑜, 刘鹏, 杨江峰, 李晋平. 沸石中碱金属阳离子对CO₂/N₂O吸附分离性能的影响[J]. 化工学报, 2023, 74(5): 2013-2021.
[2]	黄磊, 孔令学, 白进, 李怀柱, 郭振兴, 白宗庆, 李平, 李文. 油页岩添加对准东高钠煤灰熔融行为影响的研究[J]. 化工学报, 2023, 74(5): 2123-2135.
[3]	张永泉, 玄伟伟. 碱金属/（FeO+CaO+MgO）对硅酸盐灰熔渣结构和黏度的影响机理[J]. 化工学报, 2023, 74(4): 1764-1771.
[4]	禹进, 余彬彬, 蒋新生. 一种基于虚拟组分的燃烧调控化学作用量化及分析方法研究[J]. 化工学报, 2023, 74(3): 1303-1312.
[5]	梁天水, 王新科, 刘德智, 钟委. 全氟三乙胺热解机理的实验与理论研究[J]. 化工学报, 2022, 73(10): 4762-4768.
[6]	王晓蓉, 曾玺, 王芳, 张光义, 许德平, 许光文. 温度和气氛对高K高S糠醛渣灰分的烧结特性研究[J]. 化工学报, 2022, 73(1): 411-424.
[7]	宋江涛, 袁菲, 余艳, 郭亚飞, 邓天龙. 四元体系LiB₅O₈ + NaB₅O₈ + KB₅O₈ + H₂O在298.15 K实验与理论预测相平衡研究[J]. 化工学报, 2021, 72(6): 3179-3187.
[8]	余作伟, 刘倩, 钟文琪, 周骏. 烘焙生物质燃烧过程中钾的赋存形态及析出迁移特性[J]. 化工学报, 2021, 72(4): 2258-2266.
[9]	潘锋,刘家义,杜占,朱庆山. 超细碳化钨制备过程及机理研究进展[J]. 化工学报, 2021, 72(11): 5455-5467.
[10]	王晨,陈泽翔,王建强,沈美庆,王军. 基于NH₃-SCR反应铜基小孔分子筛催化剂Na中毒对比研究[J]. 化工学报, 2020, 71(12): 5551-5560.
[11]	刘洋洋, 孙超, Malhi Haripal Singh, 位重洋, 张振洲, 涂维峰. 载体对铁基催化剂结构及CO₂加氢制烯烃反应性能的影响特性[J]. 化工学报, 2020, 71(10): 4652-4662.
[12]	赵京, 张玉锋, 魏小林, 李腾, 宾峰. 高碱煤燃烧过程中亚微米颗粒物PM₁的生成特性[J]. 化工学报, 2019, 70(8): 3113-3120.
[13]	赵云, 刘春燕, 刘家旭, 贺宁, 郭洪臣. Zn/NaHZSM-5沸石在C₅～C₈链烷烃芳构化反应中的催化性能[J]. 化工学报, 2019, 70(6): 2182-2191.
[14]	李汉卿, 王长安, 朱晨钊, 赵磊, 韩涛, 车得福. O₂/CO₂气氛对准东煤灰熔融行为和微观理化特性的影响[J]. 化工学报, 2018, 69(6): 2632-2638.
[15]	张尊华, 徐力, 梁俊杰, 李敬瑞, 李格升. 甲烷/乙烷与甲烷/丙烷混合燃料着火特性[J]. 化工学报, 2018, 69(5): 2199-2207.