水力停留时间对生物膜/颗粒污泥耦合工艺脱氮除磷的影响

doi:10.3969/j.issn.0438-1157.2014.06.046

化工学报 ›› 2014, Vol. 65 ›› Issue (6): 2294-2300.DOI: 10.3969/j.issn.0438-1157.2014.06.046

水力停留时间对生物膜/颗粒污泥耦合工艺脱氮除磷的影响

尹航¹, 何理¹, 卢健聪¹, 高辉¹, 高大文^1,2

1. 东北林业大学林学院, 黑龙江哈尔滨 150040;
2. 哈尔滨工业大学城市水资源与水环境国家重点实验室, 黑龙江哈尔滨 150090

收稿日期:2013-08-13 修回日期:2013-10-09 出版日期:2014-06-05 发布日期:2014-06-05
通讯作者: 高大文
作者简介:尹航（1983- ），男，博士研究生
基金资助:
国家自然科学基金项目（21177033）。

Effect of hydraulic retention time on nitrogen and phosphorus removal by biofilm and granular coupling process

YIN Hang¹, HE Li¹, LU Jiancong¹, GAO Hui¹, GAO Dawen^1,2

1. School of Forestry, Northeast Forestry University, Harbin 150040, Heilongjiang, China;
2. State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, Heilongjiang, China

Received:2013-08-13 Revised:2013-10-09 Online:2014-06-05 Published:2014-06-05
Supported by:
supported by the National Natural Science Foundation of China (21177033).

摘要/Abstract

摘要： 采用自主设计的悬浮载体生物膜/颗粒污泥耦合装置，利用硝化菌载体生物膜和反硝化聚磷菌颗粒污泥，研究水力停留时间对生物膜/颗粒污泥耦合工艺脱氮除磷的影响，得出最佳工艺参数。试验考查水力停留时间分别为6 h、7 h、8.5 h和10.5 h，结果表明，当水力停留时间为8.5 h时，系统的COD去除率为91.26%，氨氮和总氮的去除率分别为80.68%和70.58%，厌氧释磷速率也较稳定，为0.47 mg P·（g SS）^-1·h^-1，厌氧释磷速率最高，其碳源利用率最大，反硝化除磷效率最稳定，PO₄³^--P去除率为76.50%，反硝化除磷效率为1.04 mg P·（mg NO₃^--N）^-1，所以当水力停留时间为8.5 h时，系统具有较高的脱氮除磷效率。当水力停留时间过短时，氮磷的去除不完全，过长时，系统不稳定，系统的最优水力停留时间为8.5 h。

关键词: 水力停留时间, 生物膜, 颗粒污泥, 耦合

Abstract: In home-designed coupling unit consisting of suspended carrier biofilm and granular sludge, biofilm supported nitrifying bacteria and denitrifying phosphorus granular sludge were used for investigating the effect of the hydraulic retention time (HRT) on nitrogen and phosphorus removal to arrive at optimizing process parameters. In the experiment, HRT was set at 6 h, 7 h, 8.5 h and 10.5 h. The results showed that when HRT was 8.5 h, the removal rates of COD, ammonia nitrogen and total nitrogen were 91.26%, 80.68% and 70.58% respectively. The release rate of phosphorus was 0.47 mg P·(g SS)^-¹·h^-¹, anaerobic phosphorus release and carbon source utilization were both at the highest rate, PO₄³^--P removal rate 76.50%, denitrifying phosphorus removal efficiency 1.04 mg P·(mg NO₃^--N)^-¹. At the hydraulic retention time 8.5 h, the system had higher nitrogen and phosphorus removal efficiency. When the HRT was too short, nitrogen and phosphorus removal was incomplete, If too long, the system was unstable. Therefore, the system's optimal hydraulic retention time was 8.5 h.

Key words: hydraulic retention time, biofilm, granular sludge, coupling

中图分类号:

X703.1

尹航, 何理, 卢健聪, 高辉, 高大文. 水力停留时间对生物膜/颗粒污泥耦合工艺脱氮除磷的影响[J]. 化工学报, 2014, 65(6): 2294-2300.

YIN Hang, HE Li, LU Jiancong, GAO Hui, GAO Dawen. Effect of hydraulic retention time on nitrogen and phosphorus removal by biofilm and granular coupling process[J]. CIESC Journal, 2014, 65(6): 2294-2300.

参考文献 21

[1]	Li M, Wu Y J, Yu Z L, et al. Enhanced nitrogen and phosphorus removal from eutrophic lake water by Ipomoea aquatica with low-energy ion implantation [J]. Water Research, 2009, 43(5): 1247-1256
[2]	Conley D J, Paerl H W, Howarth R W, et al. Controlling eutrophication: nitrogen and phosphorus[J]. Science, 2009, 323(5917): 1014-1015
[3]	Gao H, Yin H, Dou Y, et al. Simultaneous nitrogen and phosphorus removal using sequencing batch biofilm reactor and granular sludge process [J]. China Water & Wastewater, 2012, 28(5): 12-15
[4]	Li Hongyan(李红岩), Zhang Xing(张星), Gao Feng(高峰), et al. Effects of hydraulic retention time (HRT) on nitrification performance and microbial community of conventional activated sludge (CAS) [J]. Environmental Science(环境科学), 2006, 27(9): 1862-1870
[5]	Nogueira R, Melo L F, Purkhold U, et al. Nitrifying and heterotrophic population dynamics in biofilm reactors: effects of hydraulic retention time and the presence of organic carbon [J]. Water Research, 2002, 36(2): 469-481
[6]	Wang Y, Peng Y, Stephenson T. Effect of influent nutrient ratios and hydraulic retention time (HRT) on simultaneous phosphorus and nitrogen removal in a two-sludge sequencing batch reactor process [J]. Bioresource Technology, 2009, 100(14): 3506-3512
[7]	Chinese NEPA. Water and Wastewater Monitoring Methods [M]. 4th ed. Beijing: Chinese Environmental Science Publishing House, 2002
[8]	Chen Sheng(陈胜), Sun Dezhi(孙德智), Chen Guixia(陈桂霞), et al. Kinetics of COD degradation in landfill leachate treatment using moving-bed bioreactor[J]. Journal of Chemical Industry and Engineering(China)(化工学报), 2007, 58(3): 733-740
[9]	Du J D, Wang Y L, Li J, et al. Impact of hydraulic retention time (HRT) in ABR on its operation performance and granular sludge characteristics when treating low-strength wastewater[J]. Environmental Science(环境科学), 2009, 30(7): 2022-2029
[10]	Han H, Zhang Y, Cui C, et al. Effect of COD level and HRT on microbial community in a yeast-predominant activated sludge system [J]. Bioresource Technology, 2010, 101(10): 3463-3465
[11]	Guan Y, Ning T, Zhang L. Effects of HRT and media on nitrogen and phosphorus removal in an integrated biofilm reactor [J]. Journal of Tsinghua University:Science and Technology, 2009(3): 11-12
[12]	Lee D S, Jeon C O, Park J M. Biological nitrogen removal with enhanced phosphate uptake in a sequencing batch reactor using single sludge system [J]. Water Research, 2001, 35(16): 3968-3976
[13]	Huang G, Yang Y, Zhang L. Effect of hydraulic retention time on the formation of soluble microbial products in aerobic completely stirred tank reactor [J]. Journal of East China University of Science and Technology: Natural Science Edition, 2009, 35(1): 66-70
[14]	Feng H, Hu L, Shan D, et al. Effects of operational factors on soluble microbial products in a carrier anaerobic baffled reactor treating dilute wastewater[J]. Journal of Environmental Sciences, 2008, 20(6): 690-695
[15]	Aquino S F, Stuckey D C. The effect of organic and hydraulic shock loads on the production of soluble microbial products in anaerobic digesters [J]. Water Environment Research, 2004, 76(7): 2628-2636
[16]	Moy B Y P, Tay J H, Toh S K, et al. High organic loading influences the physical characteristics of aerobic sludge granules [J]. Letters in Applied Microbiology, 2002, 34(6): 407-412
[17]	Tay J H, Liu Q S, Liu Y. Microscopic observation of aerobic granulation in sequential aerobic sludge blanket reactor [J]. Journal of Applied Microbiology, 2001, 91(1): 168-175
[18]	Seviour T, Pijuan M, Nicholson T, et al. Gel-forming exopolysaccharides explain basic differences between structures of aerobic sludge granules and floccular sludges [J]. Water Research, 2009, 43(18): 4469-4478
[19]	Zeng R J, Lemaire R, Yuan Z, et al. Simultaneous nitrification, denitrification, and phosphorus removal in a lab‐scale sequencing batch reactor [J]. Biotechnology and Bioengineering, 2003, 84(2): 170-178
[20]	Hu J Y, Ong S L, Ng W J, et al. A new method for characterizing denitrifying phosphorus removal bacteria by using three different types of electron acceptors [J]. Water Research, 2003, 37(14): 3463-3471
[21]	Grady Jr C P L, Daigger G T, Love N G, et al. Biological Wastewater Treatment[M]. IWA Publishing, 2011

相关文章 15

[1]	宋嘉豪, 王文. 斯特林发动机与高温热管耦合运行特性研究[J]. 化工学报, 2023, 74(S1): 287-294.
[2]	胡建波, 刘洪超, 胡齐, 黄美英, 宋先雨, 赵双良. 有机笼跨细胞膜易位行为的分子动力学模拟研究[J]. 化工学报, 2023, 74(9): 3756-3765.
[3]	王阳, 戴永强, 曾炜. 2，5-二羟基苯磺酸增强离子水凝胶材料热电性能的研究[J]. 化工学报, 2023, 74(9): 3946-3955.
[4]	毕恩哲, 李双喜, 沙廉翔, 刘登宇, 陈凯放. 高温动压涨圈密封结构参数多目标优化分析[J]. 化工学报, 2023, 74(6): 2565-2579.
[5]	张建华, 陈萌萌, 孙雅雯, 彭永臻. 部分短程硝化同步除磷耦合Anammox实现生活污水高效脱氮除磷[J]. 化工学报, 2023, 74(5): 2147-2156.
[6]	顾浩, 张福建, 刘珍, 周文轩, 张鹏, 张忠强. 力电耦合作用下多孔石墨烯膜时间维度的脱盐性能及机理研究[J]. 化工学报, 2023, 74(5): 2067-2074.
[7]	范坤阳, 杨景兴, 许海波, 连兴容, 何凤梅, 陈聪慧, 李增耀. 遮光剂掺杂SiO₂气凝胶传热的统一格子Boltzmann模型研究[J]. 化工学报, 2023, 74(5): 1974-1981.
[8]	肖川宝, 李林洋, 刘武锋, 钟年丙, 解泉华, 钟登杰, 常海星. 光催化与离子交换吸附耦合有效去除2，4，6-三氯苯酚[J]. 化工学报, 2023, 74(4): 1587-1597.
[9]	任金胜, 刘克润, 焦志伟, 刘家祥, 于源. 涡流空气分级机近导叶处团聚体解团机理研究[J]. 化工学报, 2023, 74(4): 1528-1538.
[10]	刘庆超, 贾辉, 许逸飞, 路娜, 尹延梅, 王捷. 基于FBG力学传感的曝气生物滤池中剪切力分布研究[J]. 化工学报, 2023, 74(4): 1755-1763.
[11]	李雨萧, 王青月, Ho Lim Khak, 李晓辉, Erlita Mastan, 彭博, 王文俊. 自由基聚合反应动力学常数测定技术[J]. 化工学报, 2023, 74(2): 559-570.
[12]	范怡平, 卢春喜. 离心力场-移动床耦合气固分离装备的研究进展[J]. 化工学报, 2023, 74(1): 157-169.
[13]	孙国鑫, 苟萌萱, 周诚, 常佩, 贺高红, 姜晓滨. 高浓度Na⁺//NO $3 -$ ， SO $4 2 -$ -H₂O溶液的膜蒸馏结晶耦合过程调控[J]. 化工学报, 2022, 73(7): 3078-3089.
[14]	钱宇, 陈耀熙, 史晓斐, 杨思宇. 太阳能波动特性大数据分析与风光互补耦合制氢系统集成[J]. 化工学报, 2022, 73(5): 2101-2110.
[15]	宋伟, 李万佳, 俞树荣, 马荣荣. 热力耦合下TC4合金微动磨损行为影响的研究[J]. 化工学报, 2022, 73(3): 1324-1334.

水力停留时间对生物膜/颗粒污泥耦合工艺脱氮除磷的影响

Effect of hydraulic retention time on nitrogen and phosphorus removal by biofilm and granular coupling process

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 21

相关文章 15

编辑推荐

Metrics

本文评价