考虑内部热集成的乙二醇反应精馏系统设计与优化

doi:10.3969/j.issn.0438-1157.2013.12.054

化工学报 ›› 2013, Vol. 64 ›› Issue (12): 4634-4640.DOI: 10.3969/j.issn.0438-1157.2013.12.054

考虑内部热集成的乙二醇反应精馏系统设计与优化

安维中¹, 林子昕¹, 江月¹, 陈菲¹, 周立明², 朱建民²

1. 中国海洋大学化学化工学院, 山东青岛 266100;
2. 辽宁奥克化学集团, 辽宁辽阳 111003

收稿日期:2013-08-16 修回日期:2013-08-26 出版日期:2013-12-05 发布日期:2013-12-05
通讯作者: 安维中
作者简介:安维中（1968- ），男，博士，副教授。
基金资助:
国家自然科学基金项目（21306179）；化学工程联合国家重点实验室开放课题（SKL-ChE-12B03）。

Design and optimization of an internally heat integrated reactive distillation column for ethylene glycol production

AN Weizhong¹, LIN Zixin¹, JIANG Yue¹, CHEN Fei¹, ZHOU Liming², ZHU Jianmin²

1. Department of Chemical Engineering, Ocean University of China, Qingdao 266100, Shandong, China;
2. Liaoning Oxiranchem Group, Liaoyang 111003, Liaoning, China

Received:2013-08-16 Revised:2013-08-26 Online:2013-12-05 Published:2013-12-05
Supported by:
supported by the National Natural Science Foundation of China (21306179).

摘要/Abstract

摘要： 针对环氧乙烷水合制乙二醇反应精馏过程反应热的利用和系统能量更大集成问题，提出一种将反应段和提馏段分割、从反应段移出热量供提馏段加热的内部热集成反应精馏塔（R-HIDiC）的设计。利用Aspen Plus模拟软件，分析了内部热集成的可能性，优化了内部热交换量及其分布，给出了一种不需要再沸器的能量最大集成方案。研究表明，与传统的反应精馏塔相比，通过对内部热集成进行优化，乙二醇反应精馏塔可取消再沸器，系统需要的能量只由环氧乙烷水合反应热和外部压缩机提供，其操作费用将降低约47.2%，总费用将降低约39.1%，体现了其技术和经济优越性。

关键词: 反应精馏, 乙二醇, 反应热, 内部热集成

Abstract: The problem to seek further heat integration for the hydration of ethylene oxide by reactive distillation (RD) to produce ethylene glycol,which involves reactions with highly thermal effect,was investigated.An innovative process,internally heat-integrated RD column (R-HIDiC),was proposed to maximize energy efficiency of the system,in which the reactive section and stripping section was partitioned into two parts with different operating pressures so that the internal heat transfer between reactive section and stripping section was allowed.Steady-state simulations based on Aspen Plus software were performed to investigate the feasibility of internal heat integration,and an energy integration design without the need of reboiler was provided by optimizing the heat distribution in R-HIDiC.The results obtained demonstrated that,comparing with the conventional design,the proposed R-HIDiC design did not need a reboiler,thus,the total energy input can be supplied by the heat of reaction of the hydration of ethylene oxide and the electricity power of compressor,which leads to a reduction of the operating and total cost by 47.2% and 39.1%,respectively.

Key words: reactive distillation, ethylene glycol, reaction heat, internal heat integration

中图分类号:

安维中, 林子昕, 江月, 陈菲, 周立明, 朱建民. 考虑内部热集成的乙二醇反应精馏系统设计与优化[J]. 化工学报, 2013, 64(12): 4634-4640.

AN Weizhong, LIN Zixin, JIANG Yue, CHEN Fei, ZHOU Liming, ZHU Jianmin. Design and optimization of an internally heat integrated reactive distillation column for ethylene glycol production[J]. CIESC Journal, 2013, 64(12): 4634-4640.

参考文献 20

[1]	Malone M F, Doherty M F.Reactive distillation[J].Ind.Eng.Chem.Res., 2000, 39:3953-4404
[2]	Jan Harmsena G.Reactive distillation:the front-runner of industrial process intensification[J].Chemical Engineering and Processing, 2007, 46:774 -780
[3]	Ciric A R, Gu D.Synthesis of nonequilibrium processes by MINLP reactive distillation optimization[J].AIChE J., 1994, 40:1479-1487
[4]	Baur R, Higler A P, Taylor R, Krishna R.Comparison of equilibrium stage and non-equilibrium stage models for reactive distillation[J].Chemical Engineering Journal, 1999, 76:33-47
[5]	Okasinski M J, Doherty M F.Design method for kinetically controlled staged reactive distillation columns[J].Ind. Eng.Chem.Res., 1998, 37:2821-2834
[6]	Kumar A, Daoutidis P.Modeling, analysis and control of ethylene glycol reactive distillation column[J].AIChE J., 1999, 45:51-68
[7]	Ciric A R, Miao P.Steady state multiplicities in an ethylene glycol reactive distillation column[J].Ind. Eng. Chem. Res., 1994, 33:2738-2748
[8]	Scenna N J, Benz S.Start-up operation of reactive columns with multiple steady states:the ethylene glycol case[J].Ind.Eng.Chem.Res., 2003, 42:873-882
[9]	Lima R M, Salcedo R L, Barbosa D.SIMOP:efficient reactive distillation optimization using stochastic optimizers[J].Chemical Engineering Science, 2006, 61:1718-1739
[10]	Zhu Fanghong, Huang Kejin, et al.Towards further internal heat integration in design of reactive distillation columns (Ⅳ):Application to a high-purity ethylene glycol reactive distillation column[J].Chemical Engineering Science, 2009, 64:3498-3509
[11]	Jana A K, Mane A.Heat pump assisted reactive distillation:wide boiling mixture[J].AIChE J., 2011, 51:3233-3237
[12]	Huang Kejin, Lin Quanquan, et al.A fundamental principle and systematic procedures for process intensification in reactive distillation columns[J].Chemical Engineering and Processing, 2010, 49:294-311
[13]	Jiang Yue (江月).Energy integration and optimization of a reactive distillation system for ethylene glycol production[D].Qingdao:Ocean University of China, 2013
[14]	Freshwater D C.Thermal economy in distillation[J].Trans. Inst. Chem. Eng., 1951, 29:149-154
[15]	Zhao Xiong (赵雄), Luo Yiqing (罗祎青), Yan Binghai (闫兵海), Yuan Xigang (袁希钢).Simulation study of internally heat-integrated distillation column and its characteristics for energy saving[J].CIESC Journal (化工学报), 2009, 60 (1):142-150
[16]	Nakaiwa M, Huang K, Endo A, et al.Internally heat integrated distillation columns:a review[J].Trans. IchemE, Part A, Chem.Eng.Res.Des., 2003, 81 (1):162-177
[17]	Li Jun (李军), Sun Lanyi (孙兰义), Zhou Xiantian (周宪田).Study on the configuration of internal thermally coupled reactive distillation column[J].Chemical Industry and Engineering Progress (化工进展), 2012, 31 (5):997-1003
[18]	An Weizhong (安维中), Meng Xia (孟霞), Li Hongxi (李宏熙), Zhou Liming (周立明), Zhu Jianmin (朱建民).Energy internal integration and optimization within ethoxylation reactive distillation column with consideration of heat of reaction[J].CIESC Journal (化工学报), 2012, 63 (11):3602-3608
[19]	Gadalla M, Jimé nez L, Olujic Z, Jansens P J.A thermo-hydraulic approach to conceptual design of an internally heat-integrated distillation column (i-HIDiC)[J].Comput. Chem. Eng., 2007, 31:1346-1354
[20]	Anirudh A, Shenvi D, Michael Herron M, Agrawal R.Energy efficiency limitations of the conventional heat integrated distillation column (HIDiC) configuration for binary distillation[J].Ind.Eng.Chem.Res., 2011, 50:119-130

考虑内部热集成的乙二醇反应精馏系统设计与优化

Design and optimization of an internally heat integrated reactive distillation column for ethylene glycol production

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

本文评价

[1]	李振, 张博, 王丽伟. PEG-EG固-固相变材料的制备和性能研究[J]. 化工学报, 2023, 74(6): 2680-2688.
[2]	石晓青, 朱炜玄, 叶昊天, 韩志忠, 董宏光. 碳五隔壁反应精馏预处理工艺模拟及多目标优化[J]. 化工学报, 2022, 73(3): 1246-1255.
[3]	邬云飞, 栾小丽, 刘飞. 基于迁移学习的2，6-二甲酚纯度近红外光谱在线检测[J]. 化工学报, 2022, 73(2): 782-791.
[4]	高帅涛, 刘雪珂, 张丽, 刘芬, 余江, 商剑锋, 欧天雄, 周政, 陈平文. Aspen Plus模拟高浓度H₂S/CO₂酸性气的选择性分离[J]. 化工学报, 2021, 72(S1): 413-420.
[5]	宋振兴, 崔现宝, 张缨, 张雪梅, 何杰, 冯天扬, 王纪孝. 混合离子液体催化反应精馏合成乙酸正己酯[J]. 化工学报, 2021, 72(8): 4155-4165.
[6]	张矿生, 唐梅荣, 薛小佳, 李楷, 邵炎, 周健, 岳冲冲, 李壮壮, 潘鹏举. 聚乳酸/聚乙二醇共混物的结晶与降解行为[J]. 化工学报, 2021, 72(2): 1181-1190.
[7]	谭方园, 李康康, 于海, 蒋凯琦, 韩月衡, 王晓龙, 翟融融, 李玉龙, 陈健. 金属离子促进乙醇胺捕集二氧化碳研究[J]. 化工学报, 2021, 72(2): 1026-1035.
[8]	李富恒. 石墨烯纳米片-乙二醇纳米流体光热转化特性研究[J]. 化工学报, 2020, 71(S1): 479-485.
[9]	何莉, 邹雄, 叶昊天, 李香琴, 董宏光. 邻甲酚-间二甲苯-乙二醇液液平衡数据的测定与关联[J]. 化工学报, 2020, 71(7): 2993-2999.
[10]	杨庆, 许思敏, 张大伟, 杨庆春. 石油与煤路线制乙二醇过程的技术经济分析[J]. 化工学报, 2020, 71(5): 2164-2172.
[11]	刘丹, 安然, 安维中, 林子昕, 别海燕. 考虑不同产品选择性目标的乙醇胺反应精馏塔模拟与优化[J]. 化工学报, 2020, 71(3): 1202-1209.
[12]	杨小青,廖泉飞,易芸,杨春亮,赵天翔,胡兴邦,刘飞. 三乙二醇二甲醚吸收低浓度SO₂性能及机理研究[J]. 化工学报, 2020, 71(11): 5052-5058.
[13]	刘雪珂,张丽,刘芬,高帅涛,余江,商剑锋,欧天雄,周政,陈平文. NHD/MDEA/H₂O复合脱硫液催化水解羰基硫[J]. 化工学报, 2020, 71(11): 5286-5293.
[14]	王清莲, 王晓达, 王红星, 黄智贤, 叶长燊, 邱挺. 酶反应精馏耦合技术研究进展[J]. 化工学报, 2020, 71(1): 122-137.
[15]	杨杰, 祁江羽, 沙勇. 反应精馏隔壁塔制甲缩醛过程模拟与分析[J]. 化工学报, 2019, 70(3): 960-968.