利用LNG冷能与工业余热的有机朗肯循环复合系统优化分析

doi:10.3969/j.issn.0438-1157.2014.08.040

化工学报 ›› 2014, Vol. 65 ›› Issue (8): 3144-3151.DOI: 10.3969/j.issn.0438-1157.2014.08.040

利用LNG冷能与工业余热的有机朗肯循环复合系统优化分析

张墨耕, 赵良举, 刘朝, 饶文姬, 莫依璃, 蔡义林

重庆大学动力工程学院, 低品位能源利用技术及系统教育部重点实验室, 重庆 400030

收稿日期:2013-11-18 修回日期:2014-02-21 出版日期:2014-08-05 发布日期:2014-08-05
通讯作者: 赵良举
基金资助:
国家重点基础研究发展计划项目（2011CB710701）。

Optimization and analyses of organic Rankine cycle combined system utilizing cold energy of LNG and industrial waste heat

ZHANG Mogeng, ZHAO Liangju, LIU Chao, RAO Wenji, MO Yili, CAI Yilin

Key Laboratory of Low-Grade Energy Utilization Technologies and Systems, Ministry of Education, College of Power Engineering, Chongqing University, Chongqing 400030, China

Received:2013-11-18 Revised:2014-02-21 Online:2014-08-05 Published:2014-08-05
Supported by:
supported by the National Basic Research Program of China (2011CB710701).

摘要/Abstract

摘要： 对中低温余热（150℃）及LNG（-162℃）冷能联合利用，设计了一种复合式有机朗肯循环，对此复合循环系统进行了详细的热力分析及经济性分析，并与相对应的单独循环系统进行了比较。结果表明，该复合循环系统的净输出功比单独循环系统提高了41.55%，热效率和效率也分别提高了18.09%和19%，单位功率所需换热面积也仅为单独循环系统的61.03%。对该复合循环系统各部件进行了可用能损失分析，同时考虑了LNG余压的利用，进一步提出了优化方案。

关键词: 有机朗肯循环, 回收, 液化天然气, 热力学, 热经济性

Abstract: For the use of low-temperature waste heat (about 150℃) and cold energy of liquefied natural gas (LNG, about -162℃), this paper presents a combined system. The thermodynamic and thermo-economy properties of the system are analyzed in detail, with comparative analysis on the proposed combined system and a separated system composed of a conventional organic Rankine cycle (ORC) and a low temperature ORC. Propane and R601a are adopted as work fluids in three cycles of the system, different temperature in internal heat exchanger and that in evaporator are selected to examine the system performance and obtain the best working condition. The results show that, for the combined system, the net work output increases 41.55%. The thermal efficiency and exergy efficiency are increased by 18.09% and 19%, while the area power ratio is only 61.03% of the separated system. The exergy lost among different components of the combined system is analyzed with the pressure exergy of LNG taken into account, and an appropriate system is proposed.

Key words: organic Rankine cycle, recovery, exergy, liquefied natural gas, thermodynamics, thermo-economy

中图分类号:

TK123

张墨耕, 赵良举, 刘朝, 饶文姬, 莫依璃, 蔡义林. 利用LNG冷能与工业余热的有机朗肯循环复合系统优化分析[J]. 化工学报, 2014, 65(8): 3144-3151.

ZHANG Mogeng, ZHAO Liangju, LIU Chao, RAO Wenji, MO Yili, CAI Yilin. Optimization and analyses of organic Rankine cycle combined system utilizing cold energy of LNG and industrial waste heat[J]. CIESC Journal, 2014, 65(8): 3144-3151.

参考文献 26

[1]	Sternlicht B. Waste energy recovery: an excellent investment opportunity[J]. Energy Conversion and Management, 1982, 22: 361-373
[2]	Hung T C, Shai T Y, Wang S K. A review of organic Rankine cycles (ORCs) for the recovery of low-grade waste heat[J]. Energy, 1997, 22(7): 661-667
[3]	Hung T C. Waste heat recovery of organic Rankine cycle using dry fluids[J]. Energy Conversion and Management, 2001, 42(5):539-553
[4]	Liu B T, Chen K H, Wang C C. Effect of working fluids on organic Rankine cycle for waste heat recovery[J]. Energy, 2004, 29(8): 1207-1217
[5]	Wei D, Lu X, Lu Z, Gu J. Performance analysis and optimization of organic Rankine cycle (ORC) for waste heat recovery[J]. Energy Conversion and Management, 2007, 48(4): 1113-1119
[6]	Madhawa H, Mihajlo G, William M W, Yasuyuki I. Optimum design criteria for an organic Rankine cycle using low-temperature geothermal heat sources[J]. Energy, 2007, 32(9): 1698-1706
[7]	Hisazumi Y, Yamasaki Y, Sugiyama S. Proposal for a high efficiency LNG power generation system utilizing waste heat from the combined cycle[J]. Applied Energy, 1998, 60(3): 169-182
[8]	Wang Qiang(王强), Li Yanzhong(厉彦忠), Chen Xi(陈曦).A cryogenic power system for recovering LNG (liquefied natural gas) cooling energy based on a low-grade heat source[J]. Journal of Engineering for Thermal Energy and Power(热能动力工程), 2003, 18(3): 245-247
[9]	Wang Q, Li Y Z, Wang J. Analysis of power cycle based on cold energy of liquefied natural gas and low-grade heat source[J]. Applied Thermal Engineering, 2004, 24(4): 539-548
[10]	Shi X J, Che D F. A combined power cycle utilizing low-temperature waste heat and LNG cold energy[J]. Energy Conversion and Management, 2009, 50(3): 567-575
[11]	Miyazaki T, Kang Y T, Akisawa A, Kashiwagi T. A combined power cycle using refuse incineration and LNG cold energy[J]. Energy, 2000, 25(7): 639-655
[12]	Zhang N, Lior N. A novel near-zero CO2 emission thermal cycle with LNG cryogenic exergy utilization[J]. Energy, 2006, 31(10/11): 1666-1679
[13]	Zhang N, Lior N, Liu M, Han W. COOLCEP (cool clean efficient power): a novel CO2-capturing oxy-fuel power system with LNG (liquefied natural gas) coldness energy utilization[J]. Energy, 2010, 35: 1200-1210
[14]	Lin W S, Huang M B, He H M, Gu A Z. A transcritical CO2 Rankine cycle with LNG cold energy utilization and liquefaction of CO2 in gas turbine exhaust[J]. Journal of Energy Resources Technology Transactions of the ASME, 2009, 131(4): 042201-1-04220-5
[15]	Rao W J, Zhao L J, Liu C, Zhang M G. A combined cycle utilizing LNG and low-temperature solar energy[J]. Applied Thermal Engineering, 2013, 60: 51-60
[16]	Yang H C, Lu Y W, Ma C F, Wu Y T. Optimization study on the cascade utilization of LNG cold energy[J]. Renewable Energy Resources, 2011, 29(1): 71-80
[17]	Wang Zhiqi(王志奇), Zhou Naijun(周乃君), Luo Liang(罗亮). Comparison of thermodynamic performance for waste heat power generation system with different low temperature working fluids[J]. Journal of Central South University(中南大学学报), 2010, 41(6): 2424-2429
[18]	Nishith B D, Santanu B. Process integration of organic Rankine cycle[J]. Energy, 2009, 34: 1674-1686
[19]	Karellas S, Schuster A. Supercritical fluid parameters in organic rankine cycle applications[J]. International Journal of Thermodynamics, 2008, 11(3): 101-108
[20]	Cayer E, Galanis N, Nesreddine H. Parametric study and optimization of a transcritical power cycle using a low temperature source[J]. Applied Energy, 2010, 87: 1349-1357
[21]	Gawlik K. Advanced binary cycles: optimum working fluids// Proceedings of the 32nd Intersociety[C]. San Diego, 1998: 1809-1814
[22]	Liu Yuan(刘媛). Utilization of the waste heat boiler flue gas[J].Science & Technology Information(科技资讯), 2010, 18: 44
[23]	Uehara H, Ikegami Y. Optimization of a closed-cycle OTEC plant system [J]. Solar Eng., 1990, 112: 247-256
[24]	Incropera F P, Dewit D P. Fundamentals of Heat and Mass Transfer[M]. 5th ed. New York: John Wiley & Sons Inc., 2002: 587
[25]	Gungor K E, Winterton R H S. Simplified general correlation for saturated flow boiling and comparisons of correlations with data[J]. Chemical Engineering Research and Design, 1987, 65: 148-156
[26]	Shah M M. A general correlation for heat transfer during film condensation inside pipes[J]. International Journal of Heat and Mass Transfer, 1979, 22: 547-556

利用LNG冷能与工业余热的有机朗肯循环复合系统优化分析

Optimization and analyses of organic Rankine cycle combined system utilizing cold energy of LNG and industrial waste heat

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 26

相关文章 15

编辑推荐

Metrics

本文评价

[1]	杨欣, 王文, 徐凯, 马凡华. 高压氢气加注过程中温度特征仿真分析[J]. 化工学报, 2023, 74(S1): 280-286.
[2]	黄琮琪, 吴一梅, 陈建业, 邵双全. 碱性电解水制氢装置热管理系统仿真研究[J]. 化工学报, 2023, 74(S1): 320-328.
[3]	常明慧, 王林, 苑佳佳, 曹艺飞. 盐溶液蓄能型热泵循环特性研究[J]. 化工学报, 2023, 74(S1): 329-337.
[4]	张化福, 童莉葛, 张振涛, 杨俊玲, 王立, 张俊浩. 机械蒸汽压缩蒸发技术研究现状与发展趋势[J]. 化工学报, 2023, 74(S1): 8-24.
[5]	胡建波, 刘洪超, 胡齐, 黄美英, 宋先雨, 赵双良. 有机笼跨细胞膜易位行为的分子动力学模拟研究[J]. 化工学报, 2023, 74(9): 3756-3765.
[6]	张佳怡, 何佳莉, 谢江鹏, 王健, 赵鹬, 张栋强. 渗透汽化技术用于锂电池生产中N-甲基吡咯烷酮回收的研究进展[J]. 化工学报, 2023, 74(8): 3203-3215.
[7]	张瑞航, 曹潘, 杨锋, 李昆, 肖朋, 邓春, 刘蓓, 孙长宇, 陈光进. ZIF-8纳米流体天然气乙烷回收工艺的产品纯度关键影响因素分析[J]. 化工学报, 2023, 74(8): 3386-3393.
[8]	张曼铮, 肖猛, 闫沛伟, 苗政, 徐进良, 纪献兵. 危废焚烧处理耦合有机朗肯循环系统工质筛选与热力学优化[J]. 化工学报, 2023, 74(8): 3502-3512.
[9]	卫雪岩, 钱勇. 微米级铁粉燃料中低温氧化反应特性及其动力学研究[J]. 化工学报, 2023, 74(6): 2624-2638.
[10]	姚晓宇, 沈俊, 李健, 李振兴, 康慧芳, 唐博, 董学强, 公茂琼. 流体气液临界参数测量方法研究进展[J]. 化工学报, 2023, 74(5): 1847-1861.
[11]	陈科, 杜理, 曾英, 任思颖, 于旭东. 四元体系LiCl+MgCl₂+CaCl₂+H₂O 323.2 K相平衡研究及计算[J]. 化工学报, 2023, 74(5): 1896-1903.
[12]	党玉荣, 莫春兰, 史科锐, 方颖聪, 张子杨, 李作顺. 综合评价模型联合遗传算法的混合工质ORC系统性能研究[J]. 化工学报, 2023, 74(5): 1884-1895.
[13]	肖忠良, 尹碧露, 宋刘斌, 匡尹杰, 赵亭亭, 刘成, 袁荣耀. 废旧锂离子电池回收工艺研究进展及其安全风险分析[J]. 化工学报, 2023, 74(4): 1446-1456.
[14]	毛元敬, 杨智, 莫松平, 郭浩, 陈颖, 罗向龙, 陈健勇, 梁颖宗. C₆~C₁₀烷醇的SAFT-VR Mie状态方程参数回归及其热物性研究[J]. 化工学报, 2023, 74(3): 1033-1041.
[15]	陈瑞哲, 程磊磊, 顾菁, 袁浩然, 陈勇. 纤维增强树脂复合材料化学回收技术研究进展[J]. 化工学报, 2023, 74(3): 981-994.