不同来源污泥热解油中多环芳烃分布特征

doi:10.11949/j.issn.0438-1157.20151994

摘要/Abstract

摘要：

分析了4种不同来源污泥的热解油中16种EPA-PAHs生成分布，并探讨了污泥原样中自由赋存PAHs和污泥泥质特性（碳含量、H/C摩尔比、O/C摩尔比及挥发分含量等）的影响。结果表明，4种来源污泥热解油中均不同程度包含16种EPA-PAHs，∑EPA-PAHs含量分布次序为：工业印染污泥热解油（21.72 mg·kg^-1）>生活污泥热解油（14.10 mg·kg^-1）>造纸污泥热解油（13.72 mg·kg^-1）>食品污泥热解油（5.48 mg·kg^-1），且以低环（2R）和中环（3R和4R）PAHs为主，其总量占∑EPA-PAHs的95%以上。热解油中PAHs含量高低与污泥自身赋存的自由PAHs含量具有一定关联；泥质特性对热解油中EPA-PAHs含量分布也呈现了不同程度影响，随着污泥泥质特性变化，3R和4R-PAHs含量变化规律较相似，均在碳含量为30.96%、H/C摩尔比为1.1、O/C摩尔比为0.33和挥发分为35.5%时达到最高水平；2R-PAHs含量在碳含量为20.75%、H/C摩尔比为1.44、O/C摩尔比为0.6和挥发分为46.3%时达到最高水平。

关键词: 污泥, 热解油, 多环芳烃, 分布特征

Abstract:

Distribution of sixteen kind of EPA-PAHs in pyrolysis bio-oil from four sorts of different wastewater sewage sludge was investigated. The influences of free PAHs of raw sewage sludge and phi-chemical characteristics (carbon content, H/C molar ratio, O/C molar ratio and volatile content) of the sludge on PAHs distributions were discussed. The results showed that the bio-oil produced from pyrolysis of different sludge contained sixteen kinds of EPA-PAHs in different extent. A decreasing order of content of PAHs in the different bio-oil was as followed: Industrial wastewater sewage sludge in dying (21.72 mg·kg^-1) > household wastewater sewage sludge (14.10 mg·kg^-1) > paper manufacturing wastewater sewage sludge (13.72 mg·kg^-1) > food production wastewater sewage sludge (5.48 mg·kg^-1). The PAHs of bio-oil were majorly consisted of two, three and four rings of PAHs, and their amount was accounted for more than 95% of the total concentrated PAHs. The concentration distributions of different rings of PAHs were closely related with the concentrations of the free PAHs of raw sewage sludge. In addition, it was found that the distributions of PAHs in bio-oil was also dependent of the phi-chemical characteristics of raw sludge. Along with the phi-chemical properties of sludge varied, the PAHs concentrations of three and four rings presented a similar variation trend. Their maximum contents were obtained at 30.96% of carbon content, 1.1 of H/C molar ratio, 0.33 of O/C molar ratio and 35.5% of volatile contents. The maximum content of two rings of PAHs was obtained at 20.75% of carbon content, 1.44 of H/C molar ratio, 0.6 of O/C molar ratio and 46.30% of volatile contents.

Key words: sewage sludge, pyrolysis bio-oil, polycyclic aromatic hydrocarbon (PAHs), distribution characterization

中图分类号:

胡艳军, 马文超, 吴亚男, 陈江. 不同来源污泥热解油中多环芳烃分布特征[J]. 化工学报, 2016, 67(7): 3016-3022.

HU Yanjun, MA Wenchao, WU Yanan, CHEN Jiang. Characterization on PAHs distributions in pyrolysis bio-oil from different wastewater sewage sludge[J]. CIESC Journal, 2016, 67(7): 3016-3022.

参考文献 22

[1]	岳敏, 谷学新, 邹洪, 等. 多环芳烃的危害与防治[J].首都师范大学学报(自然科学版), 2003, 24(3): 40-44. DOI: 10.3969/j.issn. 1004-9398.2003.03.009. YUE M, GU X X, ZHOU H, et al. Harm and pollution control of PAHs [J]. Journal of Capital Normal University(Natural Science Edition), 2003, 24(3): 40-44. DOI: 10.3969/j.issn.1004-9398. 2003.03.009.
[2]	张曌. 污泥热解工艺机理与碳排放研究[D]. 哈尔滨: 哈尔滨工业大学, 2011. ZHANG Z. Mechanism and carbon emission of sewage sludge pyrolysis [D]. Harbin: Harbin Institute of Technology, 2011.
[3]	李培生, 胡益, 胡念苏, 等. 污泥和煤混烧过程中含氧官能团的变化规律[J]. 中国电机工程学报, 2009, 129(8): 40-44. DOI: 10.3321/j.issn:0258-8013.2009.08.007. LI P S, HU Y, HU N S, et al. Evolution of oxygen functionality during co-combustion of sewage sludge and coal [J]. Proceedings of the CSEE, 2009, 129(8): 40-44. DOI: 10.3321/j.issn:0258-8013. 2009.08.007.
[4]	朱学栋, 朱子彬, 韩崇家, 等. 煤的热解研究III.煤中官能团与热解生成物[J]. 华东理工大学学报, 2000, 26(1): 14-17. DOI: 10.3969/j.issn.1006-3080.2000.01.004. ZHU X D, ZHU Z B, HAN C J, et al. Research on coal pyrolysis (Ⅲ): Functional groups of coal and its pyrolysis products [J]. Journal of East China University of Science and Technology, 2000, 26(1): 14-17. DOI: 10.3969/j.issn.1006-3080.2000.01.004.
[5]	胡益, 李培生, 余亮英. 污泥与煤混烧中含碳官能团的演化过程[J]. 武汉大学学报, 2013, 46(5): 649-653. HU Y, LI P S, YU L Y. Evolution of carbon functionalities in sewage sludge and coal during their co-combustion [J]. Engineering Journal of Wuhan University, 2013, 46(5): 649-653.
[6]	TSAI W T, MI H H, CHANG J H, et al. Levels of polycyclic aromatic hydrocarbons in the bio-oils from induction-heating pyrolysis of food-processing sewage sludges [J]. Journal of Analytical and Applied Pyrolysis, 2009, 86(2): 364-368. DOI: 10.1016/j.jaap.2009.08.010.
[7]	DOMINGUEZ A, MENENDEZ J A, INGUANZO M, et al. Production of bio-fuels by high temperature pyrolysis of sewage sludge using conventional and microwave heating [J]. Bioresource Technology, 2006, 97(15): 1185-1193. DOI: 10.1016/j.biortech. 2005.05.011.
[8]	CHIANG H L, LIN K H, LAI N N, et al. Element and PAH constituents in the residues and liquid oil from biosludge pyrolysis in an electrical thermal furnace [J]. Science of the Total Environment, 2014, 481: 533-541. DOI: 10.1016/j.scitotenv.2014.02.083.
[9]	贾相如. 污水污泥热解制油及热解油特性试验研究[D]. 南京: 东南大学, 2009. DOI: 10.7666/d.y1580652. JIA X R. Experiments on sewage sludge pyrolysis to produce bio-oil and characteristics of the resulting bio-oil [D]. Nanjing: Southeast University, 2009. DOI: 10.7666/d.y1580652.
[10]	潘一廷, 何广湘, 焦玉海, 等. 污泥低温热解产物油成分的气相色谱[J]. 质谱学报, 2004, 25(z1): 109-110. DOI: 10.3969/j.issn.1004- 2997. 2004.z1.054. PAN Y T, HE G X, JIAO Y H, et al. Gas chromatographic-mass spectrometric study of the oil fractions produced by low temperature pyrolysis of sewage sludges [J]. Journal of Chinese Mass Spectrometry Society, 2004, 25(z1): 109-110. DOI: 10.3969/j.issn. 1004-2997.2004.z1.054.
[11]	DAI Q J, JIANG X G, JIANG Y F, et al. Formation of PAHs during the pyrolysis of dry sewage sludge [J]. Fuel, 2014, 130: 92-99. DOI: 10.1016/j.fuel.2014.04.017.
[12]	DAI Q J, JIANG X G, JIANG Y F, et al. Temperature influence and distribution in three phases of PAHS in wet sewage sludge pyrolysis using conventional and microwave heating [J]. Energy & Fuels, 2014, 28: 3317-3325. DOI: 10.1021/ef5003638.
[13]	煤的工业分析标准方法: GB/T 212-2008 [S], 2008. The national testing standard of proximate analysis of coal of China: GB/T 212-2008 [S], 2008.
[14]	胡艳军, 管志超, 郑小艳. 污水污泥裂解油中多环芳烃的分析[J]. 化工学报, 2013, 64(6): 2227-2231. DOI: 10.3969/j.issn.0438-1157. 2013.06.043. HU Y J, GUAN Z C, ZHENG X Y. Analysis of polycyclic aromatic hydrocarbons (PAHs) in pyrolysis oil from municipal wastewater sewage sludge [J]. CIESC Journal, 2013, 64(6): 2227-2231. DOI: 10.3969/j.issn.0438-1157.2013.06.043.
[15]	胡艳军, 管志超. 测定污泥热解油中多环芳烃的方法: ZL201210571580.0 [P]. 2014-6-11. HU Y J, GUAN Z C. A method of determining polycyclic aromatic hydrocarbons (PAHs) in pyrolysis oil from municipal wastewater sewage sludge: ZL201210571580.0 [P]. 2014-06-11.
[16]	DONG J, LI F, XIE K C. Study on the source of polycyclic aromatic hydrocarbons (PAHs) during coal pyrolysis by PY-GC-MS [J]. Journal of Hazardous Materials, 2012, 243: 80-85. DOI: 10.1016/j. jhazmat. 2012.09.073.
[17]	RICHTER H, HOWARD J B. Formation of polycyclic aromatic hydrocarbons (PAH) and their growth to soot - a review of chemical reaction pathways [J]. Progress in Energy and Combustion Science, 2000, 26(4/5/6): 565-608. DOI: 10.1016/S0360-1285(00)00009-5.
[18]	ZHOU H, WU C F, MENG A H, et al. Effect of interactions of biomass constituents on polycyclic aromatic hydrocarbons (PAH) formation during fast pyrolysis [J]. Journal of Analytical and Applied Pyrolysis, 2014, 110: 264-269. DOI: 10.1016/j.jaap.2014.09.007.
[19]	SHARMA H S. Compositional analysis of neutral detergent, acid detergent, lignin and humus fractions of mushroom compost [J]. Thermochimical Acta, 1996, 285(2): 221-220. DOI: 10.1016/0040- 6031(96)02954-1.
[20]	SANCHEZ N E, CALLEJAS A, MILLERA A, et al. Formation of PAH and soot during acetylene pyrolysis at different gas residence times and reaction temperatures [J]. Energy, 2012, 43: 30-36. DOI: 10.1016/j.energy.2011.12.009.
[21]	BAUSCHLICHAER C W, RICCA A. Mechanisms for polycyclic aromatic hydrocarbon (PAH) growth [J]. Chemical Physics, 2000, 326: 283-287. DOI: 10.1016/S0009-2614(00)00798-3.
[22]	ZHANG B P, XIONG S J, XIAO B, et al. Mechanism of wet sewage sludge pyrolysis in a tubular furnace [J]. International Journal of Hydrogen Energy, 2011, 36: 355-363. DOI: 10.1016/j.ijhydene. 2010.05.100.