深度脱水污泥的热干化特性

doi:10.11949/j.issn.0438-1157.20170069

化工学报 ›› 2017, Vol. 68 ›› Issue (6): 2491-2500.DOI: 10.11949/j.issn.0438-1157.20170069

深度脱水污泥的热干化特性

汪家兴¹, 刘欢¹, 刘鹏¹, 张强¹, 卢更^1,2, 胡红云¹, 姚洪¹

1. 华中科技大学能源与动力工程学院煤燃烧国家重点实验室, 湖北武汉 430074;
2. 华中科技大学中欧清洁与可再生能源学院, 湖北武汉 430074

收稿日期:2017-01-16 修回日期:2017-02-17 出版日期:2017-06-05 发布日期:2017-06-05
通讯作者: 刘欢
基金资助:
国家自然科学基金项目（51506064，51661145010，51606075）

Drying characteristics of deep dewatered sludge

WANG Jiaxing¹, LIU Huan¹, LIU Peng¹, ZHANG Qiang¹, LU Geng^1,2, HU Hongyun¹, YAO Hong¹

1. State Key Laboratory of Coal Combustion, School of Energy and Power Engineering, Huazhong University of Science and Technology, Wuhan 430074, Hubei, China;
2. China-EU Institute for Clean and Renewable Energy, Huazhong University of Science and Technology, Wuhan 430074, Hubei, China

Received:2017-01-16 Revised:2017-02-17 Online:2017-06-05 Published:2017-06-05
Contact: 10.11949/j.issn.0438-1157.20170069
Supported by:
supported by the National Natural Science Foundation of China (51506064, 51661145010, 51606075)

摘要/Abstract

摘要：

深度脱水污泥中调理剂对其干化特性有着重要影响。实验采用4种典型复合调理剂对污泥进行预处理，制得脱水污泥，在N₂气氛、473 K条件下，探究调理剂对污泥干化过程中水分和污染物释放以及干化气、液、固产物特性的影响。结果表明，所用复合调理剂均可以有效降低脱水污泥含水率，加快干化阶段水分释放速率；调理过程中的酸碱及强氧化环境能破坏污泥中的有机结构，使污泥中的芳香族或噻吩S转化为更加稳定的磺酸或砜类S，且调理后的碱性环境让溶解的酸性含硫气体固定，从而使得干化时含硫气体释放量减少，但会加速氨气的释放。干化时复杂的气相产物溶解于冷凝液使其具有较高的pH以及COD并伴有恶臭，需进行进一步处理；污泥热干化后样品热值降低量在3.63%以内，不影响其能源化利用。

关键词: 污泥, 深度脱水, 干化, 污染性气体, 冷凝液, 热值

Abstract:

Composite conditioners in deep-dewatered sludge have an important influence on its drying characteristics. In order to obtain deep-dewatered sludge, the raw sludge was pretreated by four kinds of typical composite conditioners and then dewatered. At the N₂ atmosphere and 473 K, the effects of the composite conditioners on the emission characteristics of moisture and pollutants, as well as the drying products properties of gas, liquid and solid phase, were investigated. The results showed that the composite conditioner could effectively reduce the water content of dewatered sludge and accelerate the water release, shorting the drying time as well. Conditioning process in the acid, alkali and strong oxidizing environment destroyed the organic structure of sludge so that the aromatic-or thiophene-S in sludge could transfer into more stable sulfonic acid-or sulfone-S. Also, the alkaline environment allowed the dissolved acidic sulfur-containing gas to be fixed, thereby reducing the amount of sulfur-containing gas released during drying. But the releasing rate of ammonia was accelerated. Because of the high concentration of sulfur-containing gases, nitrogen-containing gases and volatile organic compounds in the drying exhaust gas, the condensate had a high pH and COD accompanied by malodor, and thus needed to be disposed before it can be discharged. The lower heating value of sludge can be 6.79—13.18 kJ·g^-1 of dry sludge and efficiently maintained under the drying temperature of 473 K so that the dried sludge can provide a kind of renewable energy.

Key words: sewage sludge, deep dewatering, drying, polluting gas, condensate, heating value

中图分类号:

汪家兴, 刘欢, 刘鹏, 张强, 卢更, 胡红云, 姚洪. 深度脱水污泥的热干化特性[J]. 化工学报, 2017, 68(6): 2491-2500.

WANG Jiaxing, LIU Huan, LIU Peng, ZHANG Qiang, LU Geng, HU Hongyun, YAO Hong. Drying characteristics of deep dewatered sludge[J]. CIESC Journal, 2017, 68(6): 2491-2500.

参考文献 34

[1]	NOVAK J T. Dewatering of sewage sludge [J]. Drying Technology, 2006, 24 (10): 1257-1262.
[2]	LEE D J, LIU J C. Route to synthesize the sludge management processes [J]. Water Science and Technology, 2004, 49 (10): 259-266.
[3]	ZACK S I. Sludge dewatering and disposal [J]. Sewage and Industrial Wastes, 1950, 22 (8): 975-994.
[4]	NEYENS E, BAEYENS J, WEEMAES M, et al. Pilot-scale peroxidation (H2O2) of sewage sludge [J]. Journal of Hazardous Materials, 2003, 98 (1/2/3): 91-106.
[5]	ZHEN G Y, LU X Q, LI Y C, et al. Novel insights into enhanced dewaterability of waste activated sludge by Fe(Ⅱ)-activated persulfate oxidation [J]. Bioresource Technology, 2012, 119: 7-14.
[6]	NEYENS E, BAEYENS J. A review of classic Fenton's peroxidation as an advanced oxidation technique [J]. Journal of Hazardous Materials, 2003, 98 (1/2/3): 33-50.
[7]	CITEAU M, LARUE O, VOROBIEV E. Influence of salt, pH and polyelectrolyte on the pressure electro-dewatering of sewage sludge [J]. Water Research, 2011, 45 (6): 2167-2180.
[8]	DENEUX-MUSTIN S, LARTIGES B S, VILLEMIN G, et al. Ferric chloride and lime conditioning of activated sludges: an electron microscopic study on resin-embedded samples [J]. Water Research, 2001, 35 (12): 3018-3024.
[9]	LIU H, YANG J K, SHI Y F, et al. Conditioning of sewage sludge by Fenton's reagent combined with skeleton builders [J]. Chemosphere, 2012, 88 (2): 235-239.
[10]	LIU H, YANG J K, ZHU N R, et al. A comprehensive insight into the combined effects of Fenton's reagent and skeleton builders on sludge deep dewatering performance [J]. Journal of Hazardous Materials. 2013, 258/259: 144-150.
[11]	DENG W Y, YAN J H, LI X D, et al. Emission characteristics of volatile compounds during sludges drying process [J]. Journal of Hazardous Materials, 2009, 162 (1): 186-192.
[12]	FRAIKIN L, SALMON T, HERBRETEAU B, et al. Impact of storage duration on the gaseous emissions during convective drying of urban residual sludges [J]. Chemical Engineering & Technology, 2011, 34 (7SI): 1172-1176.
[13]	WERTHER J, OGADA T. Sewage sludge combustion [J]. Progress in Energy and Combustion Science, 1999, 25 (1): 55-116.
[14]	LIU H, LUO G Q, HU H Y, et al. Emission characteristics of nitrogen-and sulfur-containing odorous compounds during different sewage sludge chemical conditioning processes [J]. Journal of Hazardous Materials, 2012, 235/236: 298-306.
[15]	LIU H, ZHANG Q, HU H Y, et al. Dual role of conditioner CaO in product distributions and sulfur transformation during sewage sludge pyrolysis [J]. Fuel, 2014, 134: 514-520.
[16]	LIU H, ZHANG Q, XING H X, et al. Product distribution and sulfur behavior in sewage sludge pyrolysis: synergistic effect of Fenton peroxidation and CaO conditioning [J]. Fuel, 2015, 159: 68-75.
[17]	ZHANG Q, LIU H, LU G, et al. Mechanism of conditioner CaO on NOx precursors evolution during sludge steam gasification [J]. Proceedings of the Combustion Institute, 2017, 36 (3): 4003-4010.
[18]	ZHU F F, ZHANG Z L, JIANG H M, et al. The study of sewage sludge thermo-drying efficiency [J]. Procedia Environmental Sciences, 2012, 16: 363-367.
[19]	BUTT D A E. Formation of phenols from the low-temperature fast pyrolysis of Radiata pine (Pinus radiata) (Ⅰ): Influence of molecular oxygen [J]. Journal of Analytical and Applied Pyrolysis, 2006, 76 (1/2): 38-47.
[20]	LEONARD A, VANDEVENNE P, SALMON T, et al. Wastewater sludge convective drying: influence of sludge origin [J]. Environmental Technology, 2004, 25 (9): 1051-1057.
[21]	LÉONARD A, MENESES E, LE TRONG E, et al. Influence of back mixing on the convective drying of residual sludges in a fixed bed [J]. Water Research, 2008, 42 (10/11): 2671-2677.
[22]	ZHAO F, CHEN Z Q. Numerical study on moisture transfer in ultrasound-assisted convective drying process of sludge [J]. Drying Technology, 2011, 29 (12): 1404-1415.
[23]	BENNAMOUN L. Solar drying of wastewater sludge: a review [J]. Renewable and Sustainable Energy Reviews, 2012, 16 (1): 1061-1073.
[24]	LOWE P. Developments in the thermal drying of sewage sludge [J]. Water and Environment Journal, 1995, 9 (3): 306-316.
[25]	DEWIL R, BAEYENS J, NEYENS E. Fenton peroxidation improves the drying performance of waste activated sludge [J]. Journal of Hazardous Materials, 2005, 117 (2/3): 161-170.
[26]	LI H, ZOU S X, LI C C. Liming pretreatment reduces sludge build-up on the dryer wall during thermal drying [J]. Drying Technology, 2012, 30 (14): 1563-1569.
[27]	GOSTELOW P, PARSONS S A, STUETZ R M. Odour measurements for sewage treatment works [J]. Water Research, 2001, 35 (3): 579-597.
[28]	HOLDER G, VANUGHAN G, DREW W. Kinetic studies of the microbiological conversion of sulphate to hydrogen sulphide and their relevance to sulphide generation within sewers [J]. Water Science & Technology, 1985, 17: 183-196.
[29]	SHAO D K, HUTCHINSON E J, HEIDBRINK J, et al. Behavior of sulfur during coal pyrolysis [J]. Journal of Analytical and Applied Pyrolysis, 1994, 30 (1): 91-100.
[30]	CAO J P, LI L Y, MORISHITA K, et al. Nitrogen transformations during fast pyrolysis of sewage sludge [J]. Fuel, 2013, 104: 1-6.
[31]	ZHANG Q, LIU H, LIU P, et al. Pyrolysis characteristics and kinetic analysis of different dewatered sludge [J]. Bioresource Technology, 2014, 170: 325-330.
[32]	魏强, 唐跃刚, 李薇薇, 等. 煤中有机硫结构研究进展 [J]. 煤炭学报, 2015, 40 (8): 1911-1923.
	WEI Q, TANG Y G, LI W W, et al. Research advances on organic sulfur structures in coal [J]. Journal of China Coal Society, 2015, 40 (8): 1911-1923.
[33]	王兴润, 金宜英, 王志玉, 等. 污水污泥间壁热干燥实验研究 [J]. 环境科学, 2007, 28 (2): 407-410.
	WANG X R, JIN Y Y, WANG Z Y, et al. Experimental research on indirect thermal drying process of sewage sludge [J]. Environmental Science, 2007, 28 (2): 407-410.
[34]	RULKENS W. Sewage sludge as a biomass resource for the production of energy: overview and assessment of the various options? [J]. Energy & Fuels, 2008, 22 (1): 9-15.

深度脱水污泥的热干化特性

Drying characteristics of deep dewatered sludge

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 34

相关文章 15

编辑推荐

Metrics

本文评价

[1]	刘春雨, 周桓宇, 马跃, 岳长涛. CaO调质含油污泥干燥特性及数学模型[J]. 化工学报, 2023, 74(7): 3018-3027.
[2]	屈园浩, 邓文义, 谢晓丹, 苏亚欣. 活性炭/石墨辅助污泥电渗脱水研究[J]. 化工学报, 2023, 74(7): 3038-3050.
[3]	陈宇豪, 陈晓平, 马吉亮, 梁财. 市政污泥回转窑焚烧气态污染物排放特性研究[J]. 化工学报, 2023, 74(5): 2170-2178.
[4]	张兰河, 赖青燚, 王铁铮, 关潇卓, 张明爽, 程欣, 徐小惠, 贾艳萍. H₂O₂对SBR脱氮效率和污泥性能的影响[J]. 化工学报, 2023, 74(5): 2186-2196.
[5]	沈嘉辉, 王侃宏, 郁达伟, 胡大洲, 魏源送. 游离氨调理污泥厌氧消化优化产甲烷过程与强化有机物释放[J]. 化工学报, 2022, 73(9): 4147-4155.
[6]	罗欣宜, 冯超, 刘晶, 乔瑜. 污泥不同热处理工艺产物磷的浸出回收实验研究[J]. 化工学报, 2022, 73(9): 4034-4044.
[7]	张军, 胡升, 顾菁, 袁浩然, 陈勇. 甲醇体系电镀污泥衍生磁性多金属材料催化糠醛加氢转化[J]. 化工学报, 2022, 73(7): 2996-3006.
[8]	宋超宇, 熊亚选, 张金花, 金宇贺, 药晨华, 王辉祥, 丁玉龙. 污泥焚烧炉渣基定型复合相变储热材料的制备和性能[J]. 化工学报, 2022, 73(5): 2279-2287.
[9]	陈冠益, 童图军, 李瑞, 王燕杉, 颜蓓蓓, 李宁, 侯立安. 热解时间对污泥生物炭活化过硫酸盐的影响研究[J]. 化工学报, 2022, 73(5): 2111-2119.
[10]	成珊, 罗睿, 田红, 王振琦, 黄经春, 乔瑜. 水热碳化温度对污泥有机氮固液相迁移转化路径影响研究[J]. 化工学报, 2022, 73(11): 5220-5229.
[11]	杨晓阳, 王宝凤, 宋旭涛, 杨凤玲, 程芳琴. 污泥与高硫煤共水热碳化过程中硫氮形态转化规律[J]. 化工学报, 2022, 73(11): 5211-5219.
[12]	张立, 吴建华, 崔舒惠, 严锋, 孙浩, 钱飞跃. PN/A颗粒污泥-固相反硝化组合工艺的菌群功能解析[J]. 化工学报, 2022, 73(11): 5128-5137.
[13]	张兰河, 汪露, 李梓萌, 唐宏, 郭静波, 贾艳萍, 张明爽. 电极超滤膜生物反应器处理阴离子表面活性剂废水[J]. 化工学报, 2022, 73(10): 4679-4691.
[14]	杨丽, 孙赟冬, 焦勇, 杨烨, 陈建标, 廖传华. 灰分在印染污泥热解气化中的协同催化机理[J]. 化工学报, 2021, 72(9): 4718-4729.
[15]	肖弦, 徐文昊, 沈亮, 王远鹏, 卢英华. 氧化石墨烯与剩余活性污泥聚合制备多孔碳材料及其电化学性能[J]. 化工学报, 2021, 72(7): 3869-3879.