柠檬酸和谷氨酸N，N-二乙酸优化处理污泥重金属

doi:10.11949/j.issn.0438-1157.20170001

化工学报 ›› 2017, Vol. 68 ›› Issue (6): 2535-2545.DOI: 10.11949/j.issn.0438-1157.20170001

柠檬酸和谷氨酸N，N-二乙酸优化处理污泥重金属

徐大勇¹, 洪亚军¹, 唐海¹, 程维明², 宋珍霞¹, 占玲玲¹, 姚巧凤¹

1. 安徽工程大学生物与化学工程学院, 安徽芜湖 241000;
2. 奇瑞汽车股份有限公司, 安徽芜湖 241009

收稿日期:2017-01-03 修回日期:2017-02-26 出版日期:2017-06-05 发布日期:2017-06-05
通讯作者: 徐大勇
基金资助:
国家自然科学基金项目（51408001）；芜湖市科技计划项目（2016hm11）；国家级大学生创新创业训练计划项目（201510363083）；安徽工程大学2016年度研究生实践与创新项目

Optimization treatment of sludge heavy metals by citric acid and GLDA

XU Dayong¹, HONG Yajun¹, TANG Hai¹, CHENG Weiming², SONG Zhenxia¹, ZHAN Lingling¹, YAO Qiaofeng¹

1. Department of Biological and Chemical Engineering, Anhui Polytechnic University, Wuhu 241000, Anhui, China;
2. Chery Automobile Co., Ltd., Wuhu 241009, Anhui, China

Received:2017-01-03 Revised:2017-02-26 Online:2017-06-05 Published:2017-06-05
Contact: 10.11949/j.issn.0438-1157.20170001
Supported by:
supported by the National Natural Science Foundation of China (51408001), Wuhu Science and Technology Plan Projects (2016hm11), the National College Students' Innovative Entrepreneurial Training Program of China (201510363083) and the Graduate Students Practice and Innovation Projects of Anhui Polytechnic University in 2016

摘要/Abstract

摘要：

采用柠檬酸（CA）和谷氨酸N，N-二乙酸（GLDA）处理污泥重金属，研究了试剂浓度、pH和反应时间对重金属去除效果的影响，并以重金属去除率为表征，通过正交试验获得CA和GLDA处理重金属的最佳条件。结果表明，增加试剂用量、降低体系pH均有利于重金属的去除，但延长反应时间对重金属的去除效果影响不明显。CA和GLDA处理污泥重金属的最佳条件分别为：CA 0.3 mol·L^-1、pH 4、反应时间2 h和GLDA 0.05 mol·L^-1、pH 4、反应时间3 h。最佳反应条件下，对于CA和GLDA，重金属Cd、Cu、Pb和Ni的去除率可分别达80.25%、77.75%、64.66%和75.16%，及78.57%、78.48%、64.84%和76.71%。CA和GLDA对重金属的去除效果大小顺序均为：Cd>Cu> Ni>Pb，但GLDA的处理效果优于CA。污泥经CA和GLDA处理后，污泥固相酸溶态重金属含量下降幅度最大，平均达81%，残渣态重金属含量下降52.1%，而污泥液相中重金属含量则增加了17.54倍，说明重金属从污泥固相向液相转移。SEM镜检发现，污泥由处理前表面分散的絮状结构，变成更为明显的团块结构和片层结构，污泥的吸附能力下降，且体积缩小。研究结果表明，CA和GLDA处理污泥能有效降低污泥重金属含量并提高污泥固相重金属的化学稳定性，有利于污泥脱水及脱水后的进一步处理及其资源化。

关键词: 环境, 污染, 优化设计, 柠檬酸, 谷氨酸N, N-二乙酸, 重金属, 去除率, 正交试验

Abstract:

High heavy metals content is the major drawback of sludge resource, especially for sludge derived from industrial wastewater treatment plan. Citric acid and GLDA were used to treat sludge heavy metals in the present study, and the effects of the reagent concentration, pH and reaction time of citric acid and GLDA on the availability and removal of sludge heavy metals were investigated. An orthogonal experiment was performed to obtain the optimum reaction condition of CA and GLDA treatment of the sludge heavy metals. The results indicated that the higher reagent concentrations and the lower pH led to the higher removal rate of heavy metals, but the effect of longer reaction time on heavy metal removal was not obvious. The best conditions of CA andGLDA treatment of sludge heavy metals were: CA 0.3 mol·L^-1, pH 4 and reaction time 2 h, and GLDA 0.05 mol·L^-1, pH 4 and reaction time 3 h. Under the optimum reaction conditions of the CA and GLDA, the removal rate of Cd, Cu, Pb and Ni can reach 80.25%, 77.75%, 64.66% and 75.16%, and 78.57%, 78.48%, 64.84% and 76.71%, respectively. Both of CA and GLDA, the removal efficiency of heavy metals was ranged as Cd>Cu> Ni>Pb, but the effect of GLDA treatment was better than that of CA. After CA and GLDA treatment, the acid-soluble contents of heavy metals in the solid phase of sludge decreased most and reached an average of 81%, the residual contents decreased an average of 52.1%, and the heavy metals in the liquid phase of sludge increased an average of 17.54 times, leading to the transfer of the heavy metals from the solid phase into liquid phase. SEM observation showed that the flocculent structure of sludge was replaced obviously by mass structure and the layered structure after treatment. And at the same time, the adsorption ability and volume were reduced. The research results showed that the CA and GLDA treatment of sludge can effectively reduce the sludge heavy metal content and improve the chemical stability of heavy metals in solid phase of sludge, which was advantageous to the sludge dehydrating and its further processing and utilization.

Key words: environment, pollution, optimal design, citric acid, GLDA, heavy metals, removal rate, orthogonal experiment

中图分类号:

X703

徐大勇, 洪亚军, 唐海, 程维明, 宋珍霞, 占玲玲, 姚巧凤. 柠檬酸和谷氨酸N，N-二乙酸优化处理污泥重金属[J]. 化工学报, 2017, 68(6): 2535-2545.

XU Dayong, HONG Yajun, TANG Hai, CHENG Weiming, SONG Zhenxia,ZHAN Lingling, YAO Qiaofeng. Optimization treatment of sludge heavy metals by citric acid and GLDA[J]. CIESC Journal, 2017, 68(6): 2535-2545.

参考文献 33

[1]	DOMINGUEZ M T, ALEGRE J M, MADEJON P, et al. River banks and channels as hotspots of soil pollution after large-scale remediation of a river basin [J]. Geoderma, 2016, 261: 133-140.
[2]	HUBER M A, WELKER B H. Critical review of heavy metal pollution of traffic area runoff: occurrence, influencing factors, and partitioning [J]. Science of the Total Environment, 2016, 541: 895-919.
[3]	SHARMA S, SINGH B, MANCHANDA V K. Phytoremediation: role of terrestrial plants and aquatic macrophytes in the remediation of radionuclides and heavy metal contaminated soil and water [J]. Environmental Science and Pollution Research, 2015, 22 (2): 946-962.
[4]	可欣, 李培军, 张昀, 等. 利用乙二胺四乙酸淋洗修复重金属污染的土壤及其动力学 [J]. 应用生态学报, 2007, 18 (3): 601-606.
	KE X, LI P J, ZHANG J, et al. Heavy metals removal and its kinetics in contaminated soil under effects of EDTA washing [J]. Chinese Journal of Applied Ecology, 2007, 18 (3): 601-606.
[5]	KOWALCZYK M, ZBIGNIEW H, DOROTA K. Removal of heavy metal ions in the presence of the biodegradable complexing agent of EDDS from waters [J]. Chemical Engineering Journal, 2013, 221 (2): 512-521.
[6]	MEERS E, TACK F M, VERLOO M G. Degradability of ethylenediaminedisuccinic acid (EDDS) in metal contaminated soils: implications for its use soil remediation [J]. Chemosphere, 2008, 70 (3): 358-363.
[7]	宋相国. 生物酸化联合类Fenton氧化去除城市污泥中重金属 [D]. 长沙: 湖南大学, 2008.
	SONG X G. Heavy metal removal from sewage sludge by bioacidification and Fenton-like oxidation [D]. Changsha: Hunan University, 2008.
[8]	徐大勇, 操沛沛, 乐王旭, 等. Fenton氧化剩余污泥过程重金属迁移及其形态变化 [J]. 环境工程学报, 2016, 10 (10): 5893-5900.
	XU D Y, CAO P P, YUE W X, et al. The heavy metal migration and speciation changes of residual sludge during the Fenton oxidation processing [J]. Chinese Journal of Environmental Engineering, 2016, 10 (10): 5893-5900.
[9]	BOROWIEC M, MARTA H, KRYSTYNA H, et al. Biodegradation of selected substances used in liquid fertilizers as an element of life cycle assessment [J].Polish Journal of Chemical Technology, 2009, 11 (1): 1-3.
[10]	ITRICH, N R, MCDONOUGH K, VAN G, et al. Widespread microbial adaptation to L-glutamate-N,N-diacetate (L-GLDA) following its market introduction in a consumer cleaning product [J]. Environmental Science & Technology, 2015, 49 (22): 13314-13321.
[11]	VAN G, GEERTS R. Biodegradation of N,N-bis(carboxymethyl)-L-glutamate and its utilization as sole source of carbon, nitrogen, and energy by a Rhizobium radiobacter strain in seawater [J]. Toxicological & Environmental Chemistry, 2016, 98 (1): 26-35.
[12]	胡造时, 莫创荣, 戴知友, 等. 鳌合剂GLDA对土壤Cr的淋洗修复研究 [J]. 西南农业学报, 2016, (10): 2422-2426.
	HU Z S, MO C R, DAI Z Y, et al. Leaching chromium from soil using GLDA as eluting agent [J]. Southwest China Journal of Agricultural Sciences, 2016, (10): 2422-2426.
[13]	VAN DEURZEN M P J, MOLL R J. Detergent composition comprising glutamic-N,N-diacetate (GLDA), water and enzyme: US20160152927 [P]. 2016.
[14]	BEGUM Z A, RAHMAN I M M, TATE Y, et al. Remediation of toxic metal contaminated soil by washing with biodegradable aminopolycarboxylate chelants [J]. Chemosphere, 2012, 87 (10): 1161-1170.
[15]	WU Q, CUI Y, LI Q, et al. Effective removal of heavy metals from industrial sludge with the aid of a biodegradable chelating ligand GLDA [J]. Journal of Hazardous Materials, 2015, 283: 748-754.
[16]	YOBOUET Y A, ADOUBY K, TROKOUREY A, et al. Cadmium, copper, lead and zinc speciation in contaminated soils [J]. International Journal of Engineering Science & Technology, 2010, 2 (5): 802-812.
[17]	ZHU G X, GUO Q J, YANG J X, et al. Research on the effect and technique of remediation for multi-metal contaminated tailing soils [J]. Environmental Science, 2013, 34 (9): 3690-3696.
[18]	罗冰, 张清东. 柠檬酸浸出土壤中铜、锌的优化设计 [J]. 环境工程学报, 2013, 7 (9): 3629-3634.
	LUO B, ZHANG Q D. Optimal design to extract Cu and Zn soils with heavy metals from mixed contaminated by citric acid [J]. Chinese Journal of Environmental Engineering, 2013, 7 (9): 3629-3634.
[19]	SUN L, HAN Q L, GUO X W, et al. Removal of heavy metals from contaminated soils by washing with citric acid and subsequent treatment of soil-washing solutions [J].Advanced Materials Research, 2014, 937: 646-651.
[20]	MOON D H, JU R L, MAHMOUD W, et al. Assessment of soil washing for Zn contaminated soils using various washing solutions [J]. Journal of Industrial & Engineering Chemistry, 2012, 18 (2): 822-825.
[21]	ALVAREZ E A, MOCHÓN M C, JIMÉNEZ SÁNCHEZ J C, et al. Heavy metal extractable forms in sludge from wastewater treatment plants [J]. Chemosphere, 2002, 47 (7): 765-775.
[22]	卢更, 刘欢, 胡红云, 等. 氧化钙调理污泥气化过程中重金属的迁移转化规律 [J]. 化工学报, 2017, 68 (1): 272-280.
	LU G, LIU H, HU H Y, et al. Fate of heavy metals in CaO-conditioned sludge gasification [J]. CIESC Journal, 2017, 68 (1): 272-280.
[23]	ARAIN M B, TASNEEM G K, MUHAMMAD K J, et al. Speciation of heavy metals in sediment by conventional, ultrasound and microwave assisted single extraction methods: a comparison with modified sequential extraction procedure [J]. Journal of Hazardous Materials, 2008, 154 (1/2/3): 998-1006.
[24]	KOLODYNSKA, DOROTA. The effect of the novel complexing agent in removal of heavy metal ions from waters and waste waters [J].Chemical Engineering Journal, 2010, 165 (3): 835-845.
[25]	闵甜, 王林, 曹珂, 等. 微波-柠檬酸浸出城市污泥中重金属 [J]. 应用化工, 2012, 41 (12): 2081-2084.
	MIN T, WANG L, CAO K, et al. Citric acid extraction of heavy metals in municipal sludge with microwave [J]. Applied Chemical Industry, 2012, 41 (12): 2081-2084.
[26]	WU, L, HU L, SU C, et al. Remediation of heavy metals contaminated soil by washing with environmentally friendly washing liquids [J]. Chinese Journal of Environmental Engineering, 2014, 8 (10): 4486-4491.
[27]	李玉双, 胡晓钧, 宋雪英, 等. 柠檬酸对重金属复合污染土壤的淋洗修复效果与机理 [J]. 沈阳大学学报(自然科学版), 2012, 24 (2): 6-9.
	LI Y S, HU X J, SONG X Y, et al. Remediation of soil co-contaminted with heavy metals by washing with citric acid: batch experiment and extraction mechanism [J]. Journal of Shenyang University (Natural Science), 2012, 24 (2): 6-9.
[28]	MULLIGAN C N,YONG R N,GINNOS B F. Heavy metal removal from sediments by biosurfactants [J]. Journal of Hazardous Materials, 2001, 85 (1/2): 111-25.
[29]	RAHMAN I M M, BEGUM Z A, SAWAI H, et al. Chelant-assisted depollution of metal-contaminated Fe-coated sands and subsequent recovery of the chemicals using solid-phase extraction systems [J]. Water, Air & Soil Pollution, 2015, 226 (3): 1-12.
[30]	吴青. 生物可降解螯合剂IDS与GLDA去除工业污泥中重金属的研究 [D]. 新乡: 河南师范大学, 2015.
	WU Q. Research on the removal of heavy metals in industrial sludge by biodegradable chelating agents IDS and GLDA [D]. Xinxiang: Henan Normal University, 2015.
[31]	陈翔, 梁卫玖. 建立Excel宏快速处理正交试验设计数据 [J]. 中国卫生检验杂志, 2009, (11): 2696-2697.
	CHEN X, LIANG W M. Build Excel macro fast orthogonal design of experiment data processing [J]. Chinese Journal of Health Laboratory Technology, 2009, (11): 2696-2697.
[32]	刘艺芸, 崔爽, 张倩茹, 等. 可降解氨基羧酸型螯合剂在重金属污染土壤修复中的应用研究进展 [J]. 山东农业科学, 2015, (5): 136-140.
	LIU Y Y, CUI S, ZHANG Q R, et al. Application research progress of biodegradable aminopolycarboxylate chelating agents on soil remediation contaminated by heavy metal [J]. Shandong Agricultural Sciences, 2015, (5): 136-140.
[33]	唐海, 沙俊鹏, 欧阳龙, 等. Fe(Ⅱ)活化过硫酸盐氧化破解剩余污泥 [J]. 化工学报, 2015, 66 (2): 785-792.
	TANG H, SHA J P, OUYANG L, et al. Persulfate activated by Fe (Ⅱ) for oxidation and disintegration of excess sludge [J]. CIESC Journal, 2015, 66 (2): 785-792.

柠檬酸和谷氨酸N，N-二乙酸优化处理污泥重金属

Optimization treatment of sludge heavy metals by citric acid and GLDA

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 33

相关文章 15

编辑推荐

Metrics

本文评价

[1]	杨百玉, 寇悦, 姜峻韬, 詹亚力, 王庆宏, 陈春茂. 炼化碱渣湿式氧化预处理过程DOM的化学转化特征[J]. 化工学报, 2023, 74(9): 3912-3920.
[2]	陈哲文, 魏俊杰, 张玉明. 超临界水煤气化耦合SOFC发电系统集成及其能量转化机制[J]. 化工学报, 2023, 74(9): 3888-3902.
[3]	齐聪, 丁子, 余杰, 汤茂清, 梁林. 基于选择吸收纳米薄膜的太阳能温差发电特性研究[J]. 化工学报, 2023, 74(9): 3921-3930.
[4]	段重达, 姚小伟, 朱家华, 孙静, 胡南, 李广悦. 环境因素对克雷白氏杆菌诱导碳酸钙沉淀的影响[J]. 化工学报, 2023, 74(8): 3543-3553.
[5]	吕龙义, 及文博, 韩沐达, 李伟光, 高文芳, 刘晓阳, 孙丽, 王鹏飞, 任芝军, 张光明. 铁基导电材料强化厌氧去除卤代有机污染物：研究进展及未来展望[J]. 化工学报, 2023, 74(8): 3193-3202.
[6]	文兆伦, 李沛睿, 张忠林, 杜晓, 侯起旺, 刘叶刚, 郝晓刚, 官国清. 基于自热再生的隔壁塔深冷空分工艺设计及优化[J]. 化工学报, 2023, 74(7): 2988-2998.
[7]	江锦波, 彭新, 许文烜, 门日秀, 刘畅, 彭旭东. 泵出型螺旋槽油气密封泄漏特性及参数影响研究[J]. 化工学报, 2023, 74(6): 2538-2554.
[8]	朱理想, 罗默也, 张晓东, 龙涛, 余冉. 醌指纹法指示三氯乙烯污染土功能微生物活性应用研究[J]. 化工学报, 2023, 74(6): 2647-2654.
[9]	孙永尧, 高秋英, 曾文广, 王佳铭, 陈艺飞, 周永哲, 贺高红, 阮雪华. 面向含氮油田伴生气提质利用的膜耦合分离工艺设计优化[J]. 化工学报, 2023, 74(5): 2034-2045.
[10]	刘尚豪, 贾胜坤, 罗祎青, 袁希钢. 基于梯度提升决策树的三组元精馏流程结构最优化[J]. 化工学报, 2023, 74(5): 2075-2087.
[11]	周必茂, 许世森, 王肖肖, 刘刚, 李小宇, 任永强, 谭厚章. 烧嘴偏转角度对气化炉渣层分布特性的影响[J]. 化工学报, 2023, 74(5): 1939-1949.
[12]	王泽栋, 石至平, 刘丽艳. 考虑气泡非均匀耗散的矩形反应器声流场数值模拟及结构优化[J]. 化工学报, 2023, 74(5): 1965-1973.
[13]	张建华, 陈萌萌, 孙雅雯, 彭永臻. 部分短程硝化同步除磷耦合Anammox实现生活污水高效脱氮除磷[J]. 化工学报, 2023, 74(5): 2147-2156.
[14]	胡香凝, 尹渊博, 袁辰, 是赟, 刘翠伟, 胡其会, 杨文, 李玉星. 成品油在土壤中运移可视化的实验研究[J]. 化工学报, 2023, 74(4): 1827-1835.
[15]	李纪元, 李金旺, 周刘伟. 不同扰流结构冷板传热性能研究[J]. 化工学报, 2023, 74(4): 1474-1488.