Cluster frequency and existence time in dense transport bed

doi:10.3969/j.issn.0438-1157.2013.05.016

CIESC Journal ›› 2013, Vol. 64 ›› Issue (5): 1614-1620.DOI: 10.3969/j.issn.0438-1157.2013.05.016

Previous Articles Next Articles

Cluster frequency and existence time in dense transport bed

ZENG Xin^1,2, YANG Shaojun^1,2, WANG Shengdian^1,2, ZHAO Kai^1,2, XU Xiang^1,2, XIAO Yunhan^1,2

1. Research Center for Clean Energy and Power, Chinese Academy of Sciences, Beijing 100190, China;
2. Key Laboratory of Advanced Energy and Power, Chinese Academy of Sciences (Institute of Engineering Thermo-physics), Beijing 100190, China

Received:2012-08-10 Revised:2012-11-12 Online:2013-05-05 Published:2013-05-05
Supported by:
supported by the High-tech Research and Development Program of China(2006AA05A103)and the Main Direction Program of Knowledge Innovation of Chinese Academy of Sciences(KGCX2-YW-348).

密相输运床的团聚物频率和持续时间

曾鑫^1,2, 阳绍军^1,2, 王圣典^1,2, 赵凯^1,2, 徐祥^1,2, 肖云汉^1,2

1. 中国科学院能源动力研究中心, 北京 100190;
2. 中国科学院先进能源动力重点实验室(工程热物理研究所), 北京 100190

通讯作者: 曾鑫
作者简介:曾鑫(1987-),男,硕士研究生。
基金资助:
国家高技术研究发展计划项目(2006AA05A103);中国科学院知识创新重要方向性项目(KGCX2-YW-348)。

Abstract

Abstract: Cluster characteristics(cluster frequency and cluster existence time)were investigated with wavelet analysis in a cold dense transport bed with Geldart B particle using a fiber optic probe.The superficial gas velocities and solids circulating rate were in the range of 8.2-11.2 m穝^-1 and 139-530 kg穖^-2穝^-1, respectively.The results indicated that large scale clusters were easier to form in the near wall and bottom zone than in the center and the top zone of the riser, respectively.Cluster frequency decreased from center to wall, while cluster existence time increased from center to wall.Cluster frequency increased with increasing superficial gas velocity, while cluster existence time decreased with increasing superficial gas velocity.At the riser bottom, cluster frequency decreased with increasing solids circulating rate while cluster existence time increased with increasing solids circulating rates.

Key words: dense transport bed, fiber optic probe, cluster, wavelet analysis

摘要： 在内径0.102 m、高17 m的密相输运床冷态实验台上,以石英砂(属Geldart B类颗粒)作为循环物料,对光纤探针在表观气速8.2~11.2 m·s^-1,固体循环流率139~530 kg·m^-2·s^-1下获得的瞬态信号,采用小波分析的方法研究了团聚物频率、团聚物持续时间。结果表明:提升管边壁与底部区域更易形成大尺度团聚物,径向上团聚物频率中心高边壁低,而团聚物持续时间中心短边壁长。轴向上提升管底部团聚物频率低、持续时间长。团聚物频率随表现气速增大而增大,而团聚物持续时间随表现气速增大而缩短,提升管底部团聚物频率随固体循环流率增大而降低,团聚物持续时间随固体循环流率增大而变长。

关键词: 密相输运床, 光纤探针, 团聚物, 小波分析

CLC Number:

ZENG Xin, YANG Shaojun, WANG Shengdian, ZHAO Kai, XU Xiang, XIAO Yunhan. Cluster frequency and existence time in dense transport bed[J]. CIESC Journal, 2013, 64(5): 1614-1620.

曾鑫, 阳绍军, 王圣典, 赵凯, 徐祥, 肖云汉. 密相输运床的团聚物频率和持续时间[J]. 化工学报, 2013, 64(5): 1614-1620.

References 20

[1]	Wang Shengdian(王圣典).Hydrodynamic characteristics in dense transport bed.Beijing:Institute of Engineering Thermophysics, Chinese Academy of Sciences, 2012
[2]	Shadle L J, Monazam E R, Swanson M L.Coal gasification in a transport reactor[J].Industrial & Engineering Chemistry Research, 2001, 40(13):2782-2792
[3]	Horio M, Grace J R, Avidin A A, Knowton T M. Hydrodynamics in Circulating Fluidized Beds[M].London:Blackie Academic, 1997
[4]	Li Y, Kwauk M.The dynamics of fast fluidization[J].Fluidization, 1980, 3:537-544
[5]	Chew J W, Hays R, Findlay J G, Knowlton T M, Karri S B R, Cocco R A, Hrenya C M.Cluster characteristics of Geldart group B particles in a pilot-scale CFB riser(Ⅰ):Monodisperse systems[J].Chemical Engineering Science, 2012, 68(1):72-81
[6]	Guenther C, Breault R.Wavelet analysis to characterize cluster dynamics in a circulating fluidized bed[J].Powder Technology, 2007, 173(3):163-173
[7]	Qi Xiaobo(漆小波).Gas-solid two-phase flow dynamics in circulating fluidized bed risers.Chengdu:Sichuan University, 2003
[8]	Soong C, Tuzla K, Chen J.Identification of particle clusters in circulating fluidized bed//Circulating Fluidized Bed Technology Ⅳ.New York:Pergamon Press, 1994:615-620
[9]	Tuzla K, Sharma A, Chen J, Schiewe T, Wirth K, Molerus O.Transient dynamics of solid concentration in downer fluidized bed[J].Powder Technology, 1998, 100(2):166-172
[10]	Afsahi F A, Sotudeh‐Gharebagh R, Mostoufi N.Clusters identification and characterization in a gas-solid fluidized bed by the wavelet analysis[J].The Canadian Journal of Chemical Engineering, 2009, 87(3):375-385
[11]	Yang T Y, Leu L.Multiresolution analysis on identification and dynamics of clusters in a circulating fluidized bed[J].AIChE Journal, 2009, 55(3):612-629
[12]	Manyele S, Pärssinen J, Zhu J X.Characterizing particle aggregates in a high-density and high-flux CFB riser[J].Chemical Engineering Journal, 2002, 88(1/2/3):151-161
[13]	Liu Xinhua(刘新华), Gao Shiqiu(高士秋), Li Jinghai(李静海).Characteristics of particle clusters in gas -solids circulating fluidized beds by using PDPA[J].Journal of Chemical Industry and Engineering(China)(化工学报), 2004, 55(4):555-562
[14]	Sharma A K, Tuzla K, Matsen J, Chen J C.Parametric effects of particle size and gas velocity on cluster characteristics in fast fluidized beds[J].Powder Technology, 2000, 111(1):114-122
[15]	Wei F, Yang G Q, Jin Y, Yu Z Q.The characteristics of cluster in a high density circulating fluidized bed[J].The Canadian Journal of Chemical Engineering, 1995, 73(5):650-655
[16]	Ren J, Mao Q, Li J, Lin W.Wavelet analysis of dynamic behavior in fluidized beds[J].Chemical Engineering Science, 2001, 56(3):981-988
[17]	Yang T Y, Leu L.Study of transition velocities from bubbling to turbulent fluidization by statistic and wavelet multi-resolution analysis on absolute pressure fluctuations[J].Chemical Engineering Science, 2008, 63(7):1950-1970
[18]	Coifman R R, Donoho D L.Translation-invariant de-noising//Lecture Notes in Statistics[M]. New York:Springer Verlag, 1995:125
[19]	Wei Fei(魏飞), Lu Fangbin(陆坊斌), Jin Yong(金涌), Yu Zhiqing(俞芷青).Mass flux profiles and flow regimes in a high density circulating fluidized bed[J].Journal of Chemical Industry and Engineering(China)(化工学报), 1996, 47(3):346-351
[20]	Berruti F, Pugsley T, Godfroy L, Chaouki J, Patience G.Hydrodynamics of circulating fluidized bed risers:a review[J].The Canadian Journal of Chemical Engineering, 1995, 73(5):579-602

Cluster frequency and existence time in dense transport bed

密相输运床的团聚物频率和持续时间

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 20

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Zhihang ZHENG, Junnan MA, Zihan YAN, Chunxi LU. Study on the pressure pulsation characteristics in jet influence zone of riser [J]. CIESC Journal, 2023, 74(6): 2335-2350.
[2]	Guojuan QU, Tao JIANG, Tao LIU, Xiang MA. Modulating luminescent behaviors of Au nanoclusters via supramolecular strategies [J]. CIESC Journal, 2023, 74(1): 397-407.
[3]	Feng DU, Siqi YIN, Hui LUO, Wenan DENG, Chuan LI, Zhenwei HUANG, Wenjing WANG. Study on size effect of H₂ adsorption and dissociation on Mo _x S _y clusters [J]. CIESC Journal, 2022, 73(9): 3895-3903.
[4]	Xinjie ZHOU, Jianlin WANG, Xingcong AI, Enguang SUI, Rutong WANG. IDPC-RVM based online prediction of quality variables for multimode batch processes [J]. CIESC Journal, 2022, 73(7): 3120-3130.
[5]	Wen LI, Zhong LAN, Weili QIANG, Wenzhi REN, Bingang DU, Xuehu MA. Evolution characteristics of clusters in transitional region near subcooled wall during condensation process of steam [J]. CIESC Journal, 2022, 73(7): 2865-2873.
[6]	Xiaogang SHI, Chengxiu WANG, Jinsen GAO, Xingying LAN. Numerical simulation study on influence of mesoscale structure in riser reactor [J]. CIESC Journal, 2022, 73(6): 2708-2721.
[7]	Ke XU, Guoqiang SHI, Dongfeng XUE. Inorganic hybrid perovskite cluster materials: luminescence properties of mesoscale perovskite materials [J]. CIESC Journal, 2022, 73(6): 2748-2756.
[8]	Rongshan BI, Zhihui HAN, Shaohui TAO, Xiaoyan SUN, Shuguang XIANG. Recognizing historical operating conditions by determining the density peaks at kernel density estimation of heat diffusion [J]. CIESC Journal, 2022, 73(4): 1615-1622.
[9]	Huaixu LI, Xiaoyan SUN, Shaohui TAO, Li XIA, Shuguang XIANG. Lumping gasoline with molecular properties and density peak clustering [J]. CIESC Journal, 2022, 73(12): 5449-5460.
[10]	Xiaojie TANG, Bo YANG, Hongguang LI. Deep learning approaches to complex chemical process control manipulating strategies [J]. CIESC Journal, 2021, 72(9): 4830-4837.
[11]	SONG Bennan, WU Chunmei, LI Yourong. Investigation on cluster distribution and phase transition of adsorption at solid-vapor interface [J]. CIESC Journal, 2021, 72(5): 2680-2687.
[12]	LIU Cong, XIE Li, YANG Huizhong. Multi-model soft sensor development for penicillin fermentation process based on improved density peak clustering [J]. CIESC Journal, 2021, 72(3): 1606-1615.
[13]	Xiaofang CHENG,Qiqi PAN,Ziqi CHENG. Radiation measurement for real temperature [J]. CIESC Journal, 2019, 70(S2): 8-14.
[14]	Jian ZHU, Bo YANG, Yongjian WANG, Xiaojie TANG, Hongguang LI. New operation optimization method with time series based on Levenshtein distance hierarchical clustering [J]. CIESC Journal, 2019, 70(2): 581-589.
[15]	Wenpeng JI, Huizhong YANG. Multi-manifold soft sensor based on modified expanding search clustering algorithm [J]. CIESC Journal, 2019, 70(2): 723-729.