Performance of high-rate denitrifying compartmentalized anoxic reactor

doi:10.3969/j.issn.0438-1157.2013.04.022

CIESC Journal ›› 2013, Vol. 64 ›› Issue (4): 1276-1282.DOI: 10.3969/j.issn.0438-1157.2013.04.022

Previous Articles Next Articles

Performance of high-rate denitrifying compartmentalized anoxic reactor

LI Wei¹, ZHENG Ping¹, XIE Zuofu^1,2, ZHANG Meng¹, SONG Ji¹, HUANG Shenmin¹, LIAN Guoqiang¹

1. Department of Environmental Engineering, Zhejiang University, Hangzhou 310058, Zhejiang, China;
2. Zhejiang University of Science and Technology, Hangzhou 310023, Zhejiang, China

Received:2012-07-16 Revised:2012-09-03 Online:2013-04-05 Published:2013-04-05
Supported by:
supported by the National Natural Science Foundation of China (31070110), the Research Fund for the Doctoral Program of Higher Education of China(20110101110078) and the Key Project of the Natural Science Foundation of Zhejiang Province(Z5110094).

高效反硝化分段组合式反应器运行性能

厉巍¹, 郑平¹, 谢作甫^1,2, 张萌¹, 宋吉¹, 黄慎敏¹, 练国强¹

1. 浙江大学环境工程系,浙江杭州 310058;
2. 浙江科技学院,浙江杭州 310023

通讯作者: 郑平
作者简介:厉巍(1990—),男,博士研究生。
基金资助:
国家自然科学基金项目(31070110);高等学校博士学科点专项科研基金(20110101110078);浙江省自然科学基金重点项目(Z5110094)。

Abstract

Abstract: Pollution of nitrogen compounds is one of the main factors that lead to eutrophication of water bodies, and biological denitrification has become an effective technology for control of nitrogen pollution.The performance of denitrifying compartmentalized anoxic reactor(CAR) was investigated with synthetic wastewater.The results showed that CAR is a high-rate reactor for nitrate removal.When influent nitrate concentration was 964.7 mg稬^-1, hydraulic retention time was 0.86 h, the nitrate removal rate(NRR) and COD removal rate(CRR) reached as high as 26.8 kg?(m³穌)^-1 and 93.76 kg?(m³穌)^-1, respectively, which all were at the top level reported in the literature.During the operation, CAR's performance was stability.In both efficiency-elevation phase and efficiency-stationary phase, relative variation coefficient and relative range of effluent nitrate are less than 9.85 and 9.07, respectively.At the same time, the relative standard deviation of effluent pH is less than 1.The good performance of CAR could be ascribed to high biomass concentration(more than 17 g稬^-1(MLVSS)) and high specific activity(more than 1.57 g NO₃^--N?(g VSS)^-1穌^-1).

Key words: nitrogen and COD removal, denitrification, CAR, high-rate, steady performance

摘要： 氮素污染是水体富营养化的主要诱因之一,反硝化技术是氮素污染控制的有效手段。采用模拟废水,研究了反硝化分段组合式反应器(CAR)的脱氮除碳性能。实验结果表明,CAR具有很高的容积效能,在进水NO₃^--N浓度为964.7 mg·L^-1、水力停留时间为0.86 h条件下,硝氮去除速率(NRR)为26.8 kg·(m³·d)^-1,COD去除速率(CRR)为93.76 kg·(m³·d)^-1,NRR高于文献报道的最高值,CRR也达到文献报道的领先水平。CAR具有良好的运行稳定性,在反应器的效能上升阶段和效能稳定阶段,出水基质浓度的变异系数比和极差分别小于9.85和9.07,出水pH的相对标准差小于1。CAR运行性能出众的原因是它能持留浓度高(MLVSS高于17 g·L^-1)、活性强(最大比活性为1.573 g NO₃^--N·(g VSS)^-1·d^-1)的颗粒污泥。

关键词: 废水脱氮除碳, 反硝化, 分段组合式反应器, 高效性, 稳定性

CLC Number:

X703

LI Wei, ZHENG Ping, XIE Zuofu, ZHANG Meng, SONG Ji, HUANG Shenmin, LIAN Guoqiang. Performance of high-rate denitrifying compartmentalized anoxic reactor[J]. CIESC Journal, 2013, 64(4): 1276-1282.

厉巍, 郑平, 谢作甫, 张萌, 宋吉, 黄慎敏, 练国强. 高效反硝化分段组合式反应器运行性能[J]. 化工学报, 2013, 64(4): 1276-1282.

References 20

[1]	Hamlin H J, Michaels J T, Beaulaton C M, Graham W F, Dutt W, Steinbach P, Losordo T M, Schrader K K, Main K L.Comparing denitrification rates and carbon sources in commercial scale upflow denitrification biological filters in aquaculture[J].Aquacultural Engineering, 2008, 38(2):79-92
[2]	Wang Shuying(王淑莹), Sun Hongwei(孙洪伟), Yang Qing(杨庆), Peng Yongzhen(彭永臻).Biochemical reaction mechanism and kinetics of denitrification[J].Chinese Journal of Applied and Environmental Biology(应用与环境生物学报), 2008, 14(5):732-736
[3]	Ge S J, Peng Y Z, Wang S Y, Lu C C, Cao X, Zhu Y P.Nitrite accumulation under constant temperature in anoxic denitrification process:the effects of carbon sources and COD/NO3-N[J].Bioresource Technology, 2012, 114:137-143
[4]	Adav S S, Lee D J, Lai J Y.Enhanced biological denitrification of high concentration of nitrite with supplementary carbon source[J].Applied Microbiology and Biotechnology, 2010, 85(3):773-778
[5]	Nancharaiah Y V, Venugopalan V P.Denitrification of synthetic concentrated nitrate wastes by aerobic granular sludge under anoxic conditions[J].Chemosphere, 2011, 85(4):683-688
[6]	Cuhel J, Simek M.Proximal and distal control by pH of denitrification rate in a pasture soil[J].Agriculture Ecosystems & Environment, 2011, 141(1/2):230-233
[7]	Peng Y Z, Wang S P, Wang S Y, Hu J G, Qiao H B.Effect of denitrification type on pH profiles in the sequencing batch reactor process[J].Water Science and Technology, 2006, 53(9):87-93
[8]	Jin Xuebiao(金雪标), Liu Guohong(刘国红), Yan Ning(阎宁), Zhao Qingxiang (赵庆祥),Liu Yongdi(刘勇弟).Cultivation of a high rate denitrifying granular sludge[J].Techniques and Equipment for Environmental Pollution Control(环境污染治理技术与设备), 2006, 7(8):52-56
[9]	Bode H, Seyfried C, Kraft A.High-rate denitrification of concentrated nitrate wastewater[J].Water Science & Technology, 1987,19(1/2):163-174
[10]	Deng Kang(邓康).Study on denitrification and character of denitrifying bacteria[D].Guangzhou:South China University of Technology, 2010
[11]	Bolzonella D, Innocenti L, Pavan P, Cecchi F. Denitrification potential enhancement by addition of anaerobic fermentation products from the organic fraction of municipal solid waste[J].Water Science and Technology, 2001, 44(1):187-194
[12]	China Bureau of Environmental Protection(国家环保局).Methods for Monitor and Analysis of Water and Wastewater(水和废水监测分析方法)[M].4th ed.Beijing:China Press of Environmental Science, 2002
[13]	Pagacova P, Galbova K, Drtil M, Jonatova I.Denitrification in USB reactor with granulated biomass[J].Bioresource Technology, 2010, 101(1):150-156
[14]	Li Bo(李博), Yang Chi(杨持), Lin Peng(林鹏).Ecology(生态学)[M].Beijing:Higher Education Press, 2004
[15]	Tang Chongjian(唐崇俭).Characteristics and control strategies of ANAMMOX process[D].Hangzhou:Zhejiang University, 2011
[16]	Chen Jianwei(陈建伟), Zheng Ping(郑平), Ding Shuang(丁爽), Zhang Jiqiang(张吉强),Tang Chongjian(唐崇俭).Performance of partial nitrification process with high-rate air-lift circulation reactor[J].CIESC Journal(化工学报), 2010,61(3):740-746
[17]	Chen J, Ji Q, Zheng P, Chen T T,Wang C H, Mahmood Q.Floatation and control of granular sludge in a high-rate anammox reactor[J].Water Research, 2010,44(11):3321-3328
[18]	Fernandez-Nava Y, Maranon E, Soons J, Castrillon L. Denitrification of high nitrate concentration wastewater using alternative carbon sources[J].Journal of Hazardous Materials, 2010,173(1/2/3):682-688
[19]	Jin Xuebiao(金雪标), Bian Huafeng(卞华锋), Liu Guohong(刘国红), Zhao Qingxiang(赵庆祥).Denitrification characteristics with granular sludge in USB reactor[J].Water and Wastewater Engineering(给水排水), 2006, 32(2):5-9
[20]	Wang Yi(王怡), Peng Dangcong(彭党聪).Studies of granular sludge for denitrification[J].Environmental Science and Technology(环境科学与技术), 2004, 27(1):15-17

Performance of high-rate denitrifying compartmentalized anoxic reactor

高效反硝化分段组合式反应器运行性能

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 20

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Ruitao SONG, Pai WANG, Yunpeng WANG, Minxia LI, Chaobin DANG, Zhenguo CHEN, Huan TONG, Jiaqi ZHOU. Numerical simulation of flow boiling heat transfer in pipe arrays of carbon dioxide direct evaporation ice field [J]. CIESC Journal, 2023, 74(S1): 96-103.
[2]	Yifei ZHANG, Fangchen LIU, Shuangxing ZHANG, Wenjing DU. Performance analysis of printed circuit heat exchanger for supercritical carbon dioxide [J]. CIESC Journal, 2023, 74(S1): 183-190.
[3]	Lei WU, Jiao LIU, Changcong LI, Jun ZHOU, Gan YE, Tiantian LIU, Ruiyu ZHU, Qiuli ZHANG, Yonghui SONG. Catalytic microwave pyrolysis of low-rank pulverized coal for preparation of high value-added modified bluecoke powders containing carbon nanotubes [J]. CIESC Journal, 2023, 74(9): 3956-3967.
[4]	Yepin CHENG, Daqing HU, Yisha XU, Huayan LIU, Hanfeng LU, Guokai CUI. Application of ionic liquid-based deep eutectic solvents for CO₂ conversion [J]. CIESC Journal, 2023, 74(9): 3640-3653.
[5]	Ruihang ZHANG, Pan CAO, Feng YANG, Kun LI, Peng XIAO, Chun DENG, Bei LIU, Changyu SUN, Guangjin CHEN. Analysis of key parameters affecting product purity of natural gas ethane recovery process via ZIF-8 nanofluid [J]. CIESC Journal, 2023, 74(8): 3386-3393.
[6]	Xingzhi HU, Haoyan ZHANG, Jingkun ZHUANG, Yuqing FAN, Kaiyin ZHANG, Jun XIANG. Preparation and microwave absorption properties of carbon nanofibers embedded with ultra-small CeO₂ nanoparticles [J]. CIESC Journal, 2023, 74(8): 3584-3596.
[7]	Rui HONG, Baoqiang YUAN, Wenjing DU. Analysis on mechanism of heat transfer deterioration of supercritical carbon dioxide in vertical upward tube [J]. CIESC Journal, 2023, 74(8): 3309-3319.
[8]	Lingding MENG, Ruqing CHONG, Feixue SUN, Zihui MENG, Wenfang LIU. Immobilization of carbonic anhydrase on modified polyethylene membrane and silica [J]. CIESC Journal, 2023, 74(8): 3472-3484.
[9]	Longyi LYU, Wenbo JI, Muda HAN, Weiguang LI, Wenfang GAO, Xiaoyang LIU, Li SUN, Pengfei WANG, Zhijun REN, Guangming ZHANG. Enhanced anaerobic removal of halogenated organic pollutants by iron-based conductive materials: research progress and future perspectives [J]. CIESC Journal, 2023, 74(8): 3193-3202.
[10]	Jiaqi CHEN, Wanyu ZHAO, Ruichong YAO, Daolin HOU, Sheying DONG. Synthesis of pistachio shell-based carbon dots and their corrosion inhibition behavior on Q235 carbon steel [J]. CIESC Journal, 2023, 74(8): 3446-3456.
[11]	Qiyu ZHANG, Lijun GAO, Yuhang SU, Xiaobo MA, Yicheng WANG, Yating ZHANG, Chao HU. Recent advances in carbon-based catalysts for electrochemical reduction of carbon dioxide [J]. CIESC Journal, 2023, 74(7): 2753-2772.
[12]	Mengmeng ZHANG, Dong YAN, Yongfeng SHEN, Wencui LI. Effect of electrolyte types on the storage behaviors of anions and cations for dual-ion batteries [J]. CIESC Journal, 2023, 74(7): 3116-3126.
[13]	Wentao WU, Liangyong CHU, Lingjie ZHANG, Weimin TAN, Liming SHEN, Ningzhong BAO. High-efficient preparation of cardanol-based self-healing microcapsules [J]. CIESC Journal, 2023, 74(7): 3103-3115.
[14]	Yuanhao QU, Wenyi DENG, Xiaodan XIE, Yaxin SU. Study on electro-osmotic dewatering of sludge assisted by activated carbon/graphite [J]. CIESC Journal, 2023, 74(7): 3038-3050.
[15]	Xiaowen ZHOU, Jie DU, Zhanguo ZHANG, Guangwen XU. Study on the methane-pulsing reduction characteristics of Fe₂O₃-Al₂O₃ oxygen carrier [J]. CIESC Journal, 2023, 74(6): 2611-2623.