Preparation of levoglucosenone by catalytic pyrolysis of cellulose over solid phosphoric acid

doi:10.3969/j.issn.0438-1157.2014.03.021

CIESC Journal ›› 2014, Vol. 65 ›› Issue (3): 912-920.DOI: 10.3969/j.issn.0438-1157.2014.03.021

Previous Articles Next Articles

Preparation of levoglucosenone by catalytic pyrolysis of cellulose over solid phosphoric acid

ZHANG Zhibo, DONG Changqing, YE Xiaoning, LU Qiang, LIU Yongqian

National Engineering Laboratory for Biomass Power Generation Equipment, North China Electric Power University, Beijing 102206, China

Received:2013-05-26 Revised:2013-07-27 Online:2014-03-05 Published:2014-03-05
Supported by:
supported by the National Natural Science Foundation of China (51276062), the National Key Technology R&D Program (2012BAD30B01) and 111 Project (B12034).

利用固体磷酸催化热解纤维素制备左旋葡萄糖酮

张智博, 董长青, 叶小宁, 陆强, 刘永前

华北电力大学生物质发电成套设备国家工程实验室, 北京 102206

通讯作者: 陆强
作者简介:张智博（1988—），男，博士研究生。
基金资助:
国家自然科学基金项目（51276062）；国家科技支撑计划项目（2012BAD30B01）；高等学校学科创新引智计划项目（B12034）。

Abstract

Abstract: Solid phosphoric acid supported on SBA-15 carrier was mechanically mixed with the cellulose, and then the mixture was subjected to fast pyrolysis to prepare levoglucosenone (LGO). Using Py-GC/MS (pyrolysis-gas chromatography/mass spectrometry) the effect of temperature and catalyst/cellulose ratio on pyrolytic products mainly LGO was examined. The results indicated that the presence of solid phosphoric acid could inhibit formation of levoglucosan (LG) and other byproducts, but promote greatly and selective formation of LGO, one of major pyrolytic products. The maximal LGO yield and relative content were obtained at the temperature of 350℃ and the catalyst/cellulose ratio of 1/1, having the relative peak area of 68.6%. Moreover, the solid phosphoric acid would also promote the dehydration of LG to form LGO.

Key words: solid phosphoric acid, pyrolysis, catalysis, biomass, levoglucosenone, Py-GC/MS

摘要： 以SBA-15为载体制备了固体磷酸，将其和纤维素机械混合后进行快速热解制备左旋葡萄糖酮（LGO）。通过Py-GC/MS（快速热解-气相色谱/质谱联用）实验，考察了催化热解温度、催化剂/纤维素比例对纤维素热解生成LGO以及其他产物的影响。实验结果表明，固体磷酸能够抑制纤维素热解形成左旋葡萄糖（LG）等产物，并大幅促进LGO的生成，从而高选择性地获得以LGO为主的热解产物。在热解温度为350℃以及催化剂/纤维素比例为1/1的条件下，可获得最高的LGO产率与相对含量，相对峰面积值高达68.6%。此外固体磷酸还能促进LG脱水形成LGO。

关键词: 固体磷酸, 热解, 催化, 生物质, 左旋葡萄糖酮, Py-GC/MS

CLC Number:

ZHANG Zhibo, DONG Changqing, YE Xiaoning, LU Qiang, LIU Yongqian. Preparation of levoglucosenone by catalytic pyrolysis of cellulose over solid phosphoric acid[J]. CIESC Journal, 2014, 65(3): 912-920.

张智博, 董长青, 叶小宁, 陆强, 刘永前. 利用固体磷酸催化热解纤维素制备左旋葡萄糖酮[J]. 化工学报, 2014, 65(3): 912-920.

References 22

[1]	Bridgwater A V. Review of fast pyrolysis of biomass and product upgrading[J]. Biomass and Bioenergy, 2012, 38: 68-94
[2]	Halpern Y, Riffer R, Broido A. Levoglucosenone (1,6-anhydro-3,4-dideoxy-Δ3-β-D-pyranosen-2-one). A major product of the acid-catalyzed pyrolysis of cellulose and related carbohydrates[J]. The Journal of Organic Chemistry, 1973, 38(2): 204-209
[3]	Dobele G, Dizhbite T, Rossinskaja G, Telysheva G, Meier D, Radtke S, Faix O. Pretreatment of biomass with phosphoric acid prior to fast pyrolysis. A promising method for obtaining 1,6-anhydrosaccharides in high yields[J]. Journal of Analytical and Applied Pyrolysis, 2003, 68/69: 197-211
[4]	Fu Q R, Argyropoulos D S, Tilotta C D, Lucia L A. Understanding the pyrolysis of CCA-treated wood (Ⅱ): Effect of phosphoric acid[J]. Journal of Analytical and Applied Pyrolysis, 2008, 82(1): 140-144
[5]	Sui X W, Wang Z, Liao B, Zhang Y, Guo X Q. Preparation of levoglucosenone through sulfuric acid promoted pyrolysis of bagasse at low temperature[J]. Bioresource Technology, 2012, 103(1): 466-469
[6]	Dobele G, Rossinskaja G, Dizhbite T, Telysheva G, Meier D, Faix O. Application of catalysts for obtaining 1,6-anhydrosaccharides from cellulose and wood by fast pyrolysis[J]. Journal of Analytical and Applied Pyrolysis, 2005, 74(1/2): 401-405
[7]	Lu Qiang(陆强), Zhu Xifeng(朱锡峰). Production of levoglucosenone from pyrolysis of cellulose catalyzed by solid superacids[J]. Journal of Fuel Chemistry and Technology(燃料化学学报), 2011, 39(6): 425-431
[8]	Zhao D Y, Feng J L, Huo Q S, Nelosh N, Fredrickson G H, Chmelka B F, Stucky G D. Triblock copolymer syntheses of mesoporous silica with periodic 50 to 300 angstrom pores[J]. Science, 1998, 279(5350): 548-552
[9]	Shen D K, Gu S. The mechanism for thermal decomposition of cellulose and its main products[J]. Bioresource Technology, 2009, 100(24): 6496-6504
[10]	Lu Q, Yang X C, Dong C Q, Zhang Z F, Zhang X M, Zhu X F. Influence of pyrolysis temperature and time on the cellulose fast pyrolysis products: analytical Py-GC/MS study[J]. Journal of Analytical and Applied Pyrolysis, 2011, 92(2): 430-438
[11]	Lu Qiang(陆强), Zhang Dong(张栋), Zhu Xifeng(朱锡峰). Catalytic effects of four metal chlorides on fast pyrolysis of cellulose(Ⅰ): Py-GC/MS experiments[J]. CIESC Journal(化工学报), 2010, 61(4): 1018-1024
[12]	Lu Qiang(陆强), Zhang Dong(张栋), Zhu Xifeng(朱锡峰). Catalytic effects of four metal chlorides on fast pyrolysis of cellulose(Ⅱ): Mechanism analysis[J]. CIESC Journal(化工学报), 2010, 61(4): 1025-1032
[13]	Huang Jinbao(黄金保), Liu Chao(刘朝), Wei Shun'an(魏顺安). Thermodynamic studies of pyrolysis mechanism of cellulose monomer[J]. Acta Chimica Sinica(化学学报), 2009, 67(18): 2081-2086
[14]	Shafizadeh F, Furneaux R H, Stevenson T T, Cochran T G. 1,5-Anhydro-4-deoxy-D-glycero-hex-1-en-3-ulose and other pyrolysis products of cellulose[J]. Carbohydrate Research, 1978, 67(1): 433-447
[15]	Shafizadeh F, Furneaux R H, Stevenson T T, Cochran T G. Acid-catalyzed pyrolytic synthesis and decomposition of 1,4:3,6-dianhydro-α-d-glucopyranose[J]. Carbohydrate Research, 1978, 61(1): 519-528
[16]	Mullen C A, Boateng A A. Catalytic pyrolysis-GC/MS of lignin from several sources[J]. Fuel Processing Technology, 2010, 91(11): 1446-1458
[17]	Paine J B, Pithawalla Y B, Naworal J D. Carbohydrate pyrolysis mechanisms from isotopic labeling (Ⅳ): The pyrolysis of D-glucose: the formation of furans[J]. Journal of Analytical and Applied Pyrolysis, 2008, 83(1): 37-63
[18]	Richards G N. Glycolaldehyde from pyrolysis of cellulose[J]. Journal of Analytical and Applied Pyrolysis, 1987,10(3): 251-255
[19]	Paine J B, Pithawalla Y B, Naworal J D. Carbohydrate pyrolysis mechanisms from isotopic labeling (Ⅱ): The pyrolysis of D-glucose: general disconnective analysis and the formation of C-1 and C-2 carbonyl compounds by electrocyclic fragmentation mechanisms[J]. Journal of Analytical and Applied Pyrolysis, 2008, 82(1): 10-41
[20]	Lu Q, Zhang X M, Zhang Z B, Zhang Y, Zhu X F, Dong C Q. Catalytic fast pyrolysis of cellulose mixed with sulfated titania to produce levoglucosenone: analytical Py-GC/MS study[J]. Bioresources, 2012, 7(3): 2820-2834
[21]	Ohnishi A, Kato K, Takagi E. Curie-point pyrolysis of cellulose[J]. Polymer Journal, 1975, 7(4): 431-437
[22]	Fabbri D, Torri C, Mancini I. Pyrolysis of cellulose catalysed by nanopowder metal oxides: production and characterisation of a chiral hydroxylactone and its role as building block[J]. Green Chemistrys, 2007, 9(12): 1374-1379

Preparation of levoglucosenone by catalytic pyrolysis of cellulose over solid phosphoric acid

利用固体磷酸催化热解纤维素制备左旋葡萄糖酮

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 22

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Lei WU, Jiao LIU, Changcong LI, Jun ZHOU, Gan YE, Tiantian LIU, Ruiyu ZHU, Qiuli ZHANG, Yonghui SONG. Catalytic microwave pyrolysis of low-rank pulverized coal for preparation of high value-added modified bluecoke powders containing carbon nanotubes [J]. CIESC Journal, 2023, 74(9): 3956-3967.
[2]	Yepin CHENG, Daqing HU, Yisha XU, Huayan LIU, Hanfeng LU, Guokai CUI. Application of ionic liquid-based deep eutectic solvents for CO₂ conversion [J]. CIESC Journal, 2023, 74(9): 3640-3653.
[3]	Jiali ZHENG, Zhihui LI, Xinqiang ZHAO, Yanji WANG. Kinetics of ionic liquid catalyzed synthesis of 2-cyanofuran [J]. CIESC Journal, 2023, 74(9): 3708-3715.
[4]	Jiaqi CHEN, Wanyu ZHAO, Ruichong YAO, Daolin HOU, Sheying DONG. Synthesis of pistachio shell-based carbon dots and their corrosion inhibition behavior on Q235 carbon steel [J]. CIESC Journal, 2023, 74(8): 3446-3456.
[5]	Yaxin CHEN, Hang YUAN, Guanzhang LIU, Lei MAO, Chun YANG, Ruifang ZHANG, Guangya ZHANG. Advances in enzyme self-immobilization mediated by protein nanocages [J]. CIESC Journal, 2023, 74(7): 2773-2782.
[6]	Wentao WU, Liangyong CHU, Lingjie ZHANG, Weimin TAN, Liming SHEN, Ningzhong BAO. High-efficient preparation of cardanol-based self-healing microcapsules [J]. CIESC Journal, 2023, 74(7): 3103-3115.
[7]	Xiaoling TANG, Jiarui WANG, Xuanye ZHU, Renchao ZHENG. Biosynthesis of chiral epichlorohydrin by halohydrin dehalogenase based on Pickering emulsion system [J]. CIESC Journal, 2023, 74(7): 2926-2934.
[8]	Maolin DONG, Lidong CHEN, Liulian HUANG, Weibing WU, Hongqi DAI, Huiyang BIAN. Research progress in preparation of lignonanocellulose by acid hydrotropes and their functional applications [J]. CIESC Journal, 2023, 74(6): 2281-2295.
[9]	Tan ZHANG, Guang LIU, Jinping LI, Yuhan SUN. Performance regulation strategies of Ru-based nitrogen reduction electrocatalysts [J]. CIESC Journal, 2023, 74(6): 2264-2280.
[10]	Zhenghao YANG, Zhen HE, Yulong CHANG, Ziheng JIN, Xia JIANG. Research progress in downer fluidized bed reactor for biomass fast pyrolysis [J]. CIESC Journal, 2023, 74(6): 2249-2263.
[11]	Lei MAO, Guanzhang LIU, Hang YUAN, Guangya ZHANG. Efficient preparation of carbon anhydrase nanoparticles capable of capturing CO₂ and their characteristics [J]. CIESC Journal, 2023, 74(6): 2589-2598.
[12]	Zefeng GE, Yuqing WU, Mingxun ZENG, Zhenting ZHA, Yuna MA, Zenghui HOU, Huiyan ZHANG. Effect of ash chemical components on biomass gasification properties [J]. CIESC Journal, 2023, 74(5): 2136-2146.
[13]	Simin YI, Yali MA, Weiqiang LIU, Jinshuai ZHANG, Yan YUE, Qiang ZHENG, Songyan JIA, Xue LI. Study on ammonia evaporation and hydration kinetics of microcrystalline magnesite [J]. CIESC Journal, 2023, 74(4): 1578-1586.
[14]	Tianhao BAI, Xiaowen WANG, Mengzi YANG, Xinwei DUAN, Jie MI, Mengmeng WU. Study on release and inhibition behavior of COS during high-temperature gas desulfurization process using Zn-based oxide derived from hydrotalcite [J]. CIESC Journal, 2023, 74(4): 1772-1780.
[15]	Zijian WANG, Ming KE, Jiahan LI, Shuting LI, Jinru SUN, Yanbing TONG, Zhiping ZHAO, Jiaying LIU, Lu REN. Progress in preparation and application of short b-axis ZSM-5 molecular sieve [J]. CIESC Journal, 2023, 74(4): 1457-1473.