Defrosting characteristics and energy consumption of new air-water dual source composite heat pump system

doi:10.11949/j.issn.0438-1157.20171277

Abstract

Abstract:

Based on the operation testing of new air-water double source composite heat pump system (AWDSHPS-N), three defrosting modes were investigated under the same ambient condition, which included the condenser outlet refrigerant recooling defrosting(D-I), the low temperature-hot water defrosting(D-Ⅱ), the condenser outlet refrigerant recooling and low temperature-hot water defrosting at same time (D-Ⅲ). Total coefficient of performance (COP) of AWDSHPS-N was used to evaluate the influence of the three modes. The influence on the total COP, defrosting operating characteristics and energy consumption of D-I, D-Ⅱ and D-Ⅲ were discussed and compared with those in the reverse-cycle defrosting mode, under the same ambient condition. The results of test conditions indicated that for D-I and D-Ⅱ, the total COP can be decreased by 0.42% and 3.93%, respectively, compared with the COP of frosting period. The heating power and COP during D-Ⅱ defrosting were 27.4% and 17.8% higher than those of frosting operation, respectively. The total COP of AWDSHPS-N choosing D-I, D-Ⅱ and D-Ⅲ were 26.06%, 29.79% and 17.02% higher than that of verse-cycle defrosting, and the defrosting energy consumption of D-I, D-Ⅱ and D-Ⅲ were only 3.11%, 34.78% and 28.26% of the reverse-cycle defrosting energy consumption.

Key words: composite heat pump, renewable energy, defrosting, coefficient of performance, optimization, compressor

摘要：

基于新型空气-水双热源复合热泵系统（AWDSHPS-N），实验研究了AWDSHPS-N采用冷凝器出口制冷剂再冷却除霜（D-I）、低温热水除霜（D-Ⅱ）、低温热水+冷凝器出口制冷剂再冷却除霜（D-Ⅲ）3种除霜模式进行除霜时对系统整体性能系数（COP）的影响，除霜期间系统运行特性及除霜所消耗的能量，并与逆循环除霜模式进行了对比分析。测试工况下的实验结果表明，除霜模式D-I和D-Ⅲ仅使系统整体COP较结霜运行期间的COP分别降低了0.42%和3.93%；D-Ⅱ除霜期间系统的制热功率和COP分别较结霜运行期间提高了27.4%和17.8%。D-I、D-Ⅱ和D-Ⅲ完成一次除霜能耗仅分别为逆循环除霜能耗的3.11%、34.78%和28.26%；采用此3种除霜模式时系统整体COP较采用逆循环除霜时分别提高了26.06%、29.79%和17.02%。

关键词: 复合热泵, 再生能源, 除霜, 性能系数, 优化, 压缩机

CLC Number:

TK519

XU Junfang, ZHAO Yaohua, QUAN Zhenhua, WANG Huifen, ZHAO Huigang, WANG Jieteng. Defrosting characteristics and energy consumption of new air-water dual source composite heat pump system[J]. CIESC Journal, 2018, 69(6): 2646-2654.

徐俊芳, 赵耀华, 全贞花, 王会粉, 赵会刚, 王皆腾. 新型空气-水双热源复合热泵系统除霜特性及能耗[J]. 化工学报, 2018, 69(6): 2646-2654.

References 30

[1]	BUKER M S, RIFFAT S B. Solar assisted heat pump systems for low temperature water heating applications:a systematic review[J].Renewable and Sustainable Energy Reviews, 2016, 55:399-413.
[2]	LERCH W, HEINZ A, HEIMRATH R. Direct use of solar energy as heat source for a heat pump in comparison to a conventional parallel solar air heat pump system.[J]. Energy and Buildings, 2015, 100:34-42.
[3]	ÇAKIR U, ÇOMAKLI K, ÇOMAKLI Ömer, et al. An experimental exergetic comparison of four different heat pump systems working at same conditions:as air to air, air to water, water to water and water to air[J].Energy, 2013, 58(3):210-219.
[4]	WANG G, QUAN Z H, ZHAO Y H, et al. Experimental study on a novel PV/T air dual-heat-source composite heat pump hot water system[J]. Energy and Buildings, 2015, 108:175-184.
[5]	王岗,全贞花,赵耀华,等.太阳能-空气复合热源热泵热水系统[J]. 化工学报, 2014, 65(3):1033-1039 WANG G, QUAN Z H, ZHAO Y H, et al. Solar-air composite heat source heat pump hot water system[J]. CIESC Journal, 2014, 65(3):1033-1039.
[6]	LIU Y, MA J, ZHOU G H. The coupling performance of a solar-air heat pump[J]. Procedia Engineering, 2011, 15(1):4058-4062.
[7]	LIU Y, ZHOU G H, MA J. Experimental Investigation on a solar air heat pump by heat source[J].Energy Procedia,2012, 14:1590-1594.
[8]	LIU Y, MA J, ZHOU G H, et al. Performance of a solar air composite heat source heat pump system[J]. Renewable Energy, 2016, 87(6):1053-1058.
[9]	徐鹏, 全贞花, 赵耀华, 等. 新型太阳能光伏-热泵复合建筑供能系统及其性能实验研究[J]. 建筑科学,2015,31(6):99-105. XU P, QUAN Z H, ZHAO Y H, et al. New-type solar photovoltaic and heat pump combined building energy supply system and experimental study of its performance[J]. Building Science, 2015, 31(6):99-105.
[10]	BRIAN P L T, REID R C, SHAH Y T. Frost deposition on cold surfaces[J]. Industrial & Engineering Chemistry Fundamentals, 1970, 9(3):375-80.
[11]	SANDER C T. Testing of air coolers operating under frosting conditions, in heat and mass transfer in refrigeration systems and in air-conditioning[J]. International Institute of Refrigeration, 1972:383-396.
[12]	WANG W, XIAO J, GUO Q C, et al. Field test investigation of the characteristics for the air source heat pump under two typical mal-defrost phenomena[J]. Applied Energy, 2011, 88(12):4470-4480.
[13]	SONG M J, DENG S M, PAN D M, et al. An experimental study on the effects of downwards flowing of melted frost over a vertical multi-circuit outdoor coil in an air source heat pump on defrosting performance during reverse cycle defrosting[J]. Applied Thermal Engineering, 2014, 67(1/2):258-265.
[14]	O'NEAL D L, PETERSON K T, ANAND N K, et al. Refrigeration system dynamics during the reverse cycle defrost[J]. ASHRAE Trans., 1989, 95 (2):689-698.
[15]	QU M L, XIA L, JANG Y Q, et al. A study of the reverse cycle defrosting performance on a multi-circuit outdoor coil in an air source heat pump(I):Experiments[J]. Applied Energy, 2012, 91(1):122-129.
[16]	SONG M J, XIA L, DENG S M. A modeling study on alleviating uneven defrosting for a vertical three-circuit outdoor coil in an air source heat pump unit during reverse cycle defrosting[J]. Applied Energy, 2016, 161(1):268-278.
[17]	HU B, WANG X L, CAO F, et al. Experimental analysis of an air-source transcritical CO2 heat pump water heater using the hot gas bypass defrosting method[J]. Applied Thermal Engineering, 2014, 71(1):528-535.
[18]	JI Y J, BASE H H, LEE S L, et al. Continuous heating of an air-source heat pump during defrosting and improvement of energy efficiency[J]. Applied Energy, 2013, 110(5):9-16.
[19]	YIN H J, YANG Z, CHEN A.Q, et al. Experimental research on a novel cold storage defrost method based on air bypass circulation and electric heater[J]. Energy, 2012, 37(1):623-631.
[20]	ABDEL-WAHED R M, HIFNI M A, SHERIF S A. Hot water defrosting of a horizontal flat plate cooling surface[J]. International Journal of Refrigeration, 1983, 6(3):152-154.
[21]	AMEEN F R, CONEY J E R, SHEPPARD C G W. Experimental study of warm-air defrosting of heat-pump evaporator[J]. International Journal of Refrigeration, 1993, 16(1):13-18.
[22]	WANG Z Y, WANG X.M, DONG Z M. Defrost improvement by heat pump refrigerant charge compensating[J], Applied Energy,2008, 85 (11):1050-1059.
[23]	BAXTER V D, MOYERS J C. Field-measured cycling, frost and defrosting losses for a high efficiency air source heat pump[J].ASHRAE Trans., 1985, 91(2B-2):537-554.
[24]	NIDERER D H. Frost and defrosting effect on coil heat transfer[J]. ASHRAE Trans., 1976, 83(1):467-473..
[25]	CHEN Y G, GUO X M. Dynamic defrosting characteristics of air source heat pump and effects of outdoor air parameters on defrost cycle performance[J]. Applied Thermal Engineering, 2009, 29(13):2701-2707.
[26]	徐俊芳, 赵耀华, 王皆腾, 等. 新型空气-水双热源复合热泵系统性能和除霜实验[J]. 化工学报, 2017, 68(11):4301-4308. XU J F, ZHAO Y H, WANG J T, et al. System performance and defrosting test of the new air-water double source composite heat pump system[J]. CIESC Journal, 2017, 68(11):4301-4308.
[27]	XU J F, WANG J T,ZHAO Y H, et al. Analysis on operation condition of a village air source heat pump heating system project in beijing[C]//20154th International Conference on Energy and Environmental Protection.Shenzhen, 2015:1141-1147.
[28]	GB50736-2012. 民用建筑供暖通风与空气调节设计规范[S]. GB50736-2012. Design code for heating ventilation and air conditioning of civil buildings[S].
[29]	MACHIELSEV C H M, KERSCHBAUMER H G. Influence of frost formation and defrosting on the performance of air coolers standards and dimensionless coefficients for the system designer[J]. International Journal of Refrigeration, 1989, 12(5):283-290.
[30]	DONG J K, DENG S M, JIANG Y Q, et al. An experimental study on defrosting heat supplies and energy consumptions[J].Applied Thermal Engineering, 2012, 37(5):380-387.