基于苯甲酰化的纤维素热解过程中典型脱水糖的定量分析

doi:10.11949/j.issn.0438-1157.20160030

化工学报 ›› 2016, Vol. 67 ›› Issue (6): 2519-2524.DOI: 10.11949/j.issn.0438-1157.20160030

基于苯甲酰化的纤维素热解过程中典型脱水糖的定量分析

王阳¹, 龚勋¹, 冷尔唯¹, 张彪¹, 何剑青², 徐明厚¹

1. 华中科技大学煤燃烧国家重点实验室, 湖北武汉 430074;
2. 华中科技大学中欧清洁与可再生能源学院, 湖北武汉 430074

收稿日期:2016-01-08 修回日期:2016-02-26 出版日期:2016-06-05 发布日期:2016-06-05
通讯作者: 龚勋
基金资助:
国家自然科学基金项目(51306062)。

Quantitative analysis of typical anhydro-sugars obtained during pyrolysis of cellulose based on benzoylation

WANG Yang¹, GONG Xun¹, LENG Erwei¹, ZHANG Biao¹, HE Jianqing², XU Minghou¹

1. State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology, Wuhan 430074, Hubei, China;
2. Institution of Clean and Renewable Energy, Huazhong University of Science and Technology, Wuhan 430074, Hubei, China

Received:2016-01-08 Revised:2016-02-26 Online:2016-06-05 Published:2016-06-05
Supported by:
supported by the National Natural Science Foundation of China (51306062).

摘要/Abstract

摘要：

在固定床中对纤维素进行低温热解实验,采用苯甲酰化的方法,对收集的3种典型的脱水糖进行了深入研究。实验结果表明,基于苯甲酰化的HPLC-UV检测方法是一种快速、有效的糖类物质检测分析方法,满足纤维素热解产物中脱水糖的定量分析研究。纤维二聚糖和纤维三聚糖主要是通过纤维素随机断链形成的,而并非来源于左旋葡聚糖的二次聚合反应。聚合度越高的脱水糖在热解过程中更倾向于进一步反应形成其他产物。

关键词: 纤维素, 热解, 固定床, 苯甲酰化, 色谱, 脱水糖, 定量分析

Abstract:

A derivation method based on bezoylation was applied to quantitative analysis of three typical anhydro-sugars obtained from pyrolysis of cellulose on a fixed bed reactor. The experimental results showed that this precolumn HPLC derivatization was proved to be an efficient and accurate method for the rapid determination of anhydro-sugars. Cellobiosan and cellotriosan may be produced via thermal cleavage of glycosidic bonds during cellulose pyrolysis rather than secondary polymerization of the levoglucosan. The higher DPs anhydro-sugars had less thermal stability and they were more susceptible to decomposition at the higher temperature.

Key words: cellulose, pyrolysis, fixed-bed, benzoylation, chromatography, anhydro-sugars, quantitative analysis

中图分类号:

TQ028.8

王阳, 龚勋, 冷尔唯, 张彪, 何剑青, 徐明厚. 基于苯甲酰化的纤维素热解过程中典型脱水糖的定量分析[J]. 化工学报, 2016, 67(6): 2519-2524.

WANG Yang, GONG Xun, LENG Erwei, ZHANG Biao, HE Jianqing, XU Minghou. Quantitative analysis of typical anhydro-sugars obtained during pyrolysis of cellulose based on benzoylation[J]. CIESC Journal, 2016, 67(6): 2519-2524.

参考文献 27

[1]	METTLER M S, MUSHRIF S H, PAULSEN A D, et al. Revealing pyrolysis chemistry for biofuels production: conversion of cellulose to furans and small oxygenates [J]. Energy & Environmental Science, 2012, 5 (1): 5414-5424.
[2]	CHIARAMONTI D, OASMAA A, SOLANTAUSTA Y. Power generation using fast pyrolysis liquids from biomass [J]. Renewable and Sustainable Energy Reviews, 2007, 11 (6): 1056-1086.
[3]	MCKENDRY P. Energy production from biomass (1): Overview of biomass [J]. Bioresource Technology, 2002, 83 (1): 37-46.
[4]	YANG H, YAN R, CHEN H, et al. In-depth investigation of biomass pyrolysis based on three major components: hemicellulose, cellulose and lignin [J].Energy & Fuels, 2006, 20 (1): 388-393.
[5]	BRADBURY A G W, SAKAI Y, SHAFIZADEH F. A kinetic model for pyrolysis of cellulose [J]. Journal of Applied Polymer Science, 1979, 23 (11): 3271-3280.
[6]	ANTAL M J J, VARHEGYI G. Cellulose pyrolysis kinetics: the current state of knowledge [J]. Industrial & Engineering Chemistry Research, 1995, 34 (3): 703-717.
[7]	BOUTIN O, FERRER M, LÉDÉ J. Radiant flash pyrolysis of cellulose-evidence for the formation of short life time intermediate liquid species [J]. Journal of Analytical and Applied Pyrolysis, 1998, 47 (1): 13-31.
[8]	PISKORZ J, MAJERSKI P, RADLEIN D, et al. Flash pyrolysis of cellulose for production of anhydro-oligomers [J]. Journal of Analytical and Applied Pyrolysis, 2000, 56 (2): 145-166.
[9]	陆强, 张栋, 朱锡锋. 四种金属氯化物对纤维素快速热解的影响 (Ⅱ): 机理分析 [J]. 化工学报, 2010, 61 (4): 1025-1032. LU Q, ZHANG D, ZHU X F. Catalytic effects of four metal chlorides on fast pyrolysis of cellulose (Ⅱ): Mechanism analysis [J].CIESC Journal, 2010,61 (4): 1025-1032.
[10]	刘倩, 王琦, 王健, 等. 纤维素热解过程中活性纤维素的生成研究 [J]. 工程热物理学报, 2007, 28 (5): 897-899. LIU Q, WANG Q, WANG J, et al. Study on formation of active cellulose in pyrolysis process [J]. Journal of Engineering Thermophysics, 2007, 28 (5): 897-899.
[11]	LIAO Y F, WANG S R, MA X Q, et al. Numerical approach to the mechanism of cellulose pyrolysis [J]. Chinese Journal of Chemical Engineering, 2005, 13 (2): 197-203.
[12]	KAWAMOTO H, MURAYAMA M, SAKA S. Pyrolysis behavior of levoglucosan as an intermediate in cellulose pyrolysis: polymerization into polysaccharide as a key reaction to carbonized product formation [J]. Journal of Wood Science, 2003, 49 (5): 469-473.
[13]	KAWAMOTO H, HATANAKA W, SAKA S. Thermochemical conversion of cellulose in polar solvent (sulfolane) into levoglucosan and other low molecular-weight substances [J].Journal of Analytical and Applied Pyrolysis, 2003, 70 (2): 303-313.
[14]	BAI X, JOHNSTON P, SADULA S, et al. Role of levoglucosan physiochemistry in cellulose pyrolysis [J]. Journal of Analytical and Applied Pyrolysis, 2013, 99: 58-65.
[15]	LÉDÉ J, BLANCHARD F, BOUTIN O. Radiant flash pyrolysis of cellulose pellets: products and mechanisms involved in transient and steady state conditions [J]. Fuel, 2002, 81 (10): 1269-1279.
[16]	POUWELS A D, EIJKEL G B, ARISZ P W, et al. Evidence for oligomers in pyrolysates of microcrystalline cellulose [J]. Journal of Analytical and Applied Pyrolysis, 1989, 15: 71-84.
[17]	METTLER M S, VLACHOS D G, DAUENHAUER P J. Top ten fundamental challenges of biomass pyrolysis for biofuels [J]. Energy & Environmental Science, 2012, 5 (7): 7797-7809.
[18]	OASMAA A, MEIER D. Norms and standards for fast pyrolysis liquids (1): Round robin test [J]. Journal of Analytical and Applied Pyrolysis, 2005, 73 (2): 323-334.
[19]	BAYERBACH R, MEIER D. Characterization of the water-insoluble fraction from fast pyrolysis liquids (pyrolytic lignin) (Ⅳ): Structure elucidation of oligomeric molecules [J]. Journal of Analytical and Applied Pyrolysis, 2009, 85 (1): 98-107.
[20]	OEHLKE J, BRUDEL M, BLASIG I E. Benzoylation of sugars, polyols and amino acids in biological fluids for high-performance liquid chromatographic analysis [J]. Journal of Chromatography B: Biomedical Sciences and Applications, 1994, 655 (1): 105-111.
[21]	KWANG-HYOK S, UI-NAM P, SARKAR C, et al. A sensitive assay of red blood cell sorbitol level by high performance liquid chromatography: potential for diagnostic evaluation of diabetes [J].Clinica Chimica Acta, 2005, 354 (1): 41-47.
[22]	MAMLEEV V, BOURBIGOT S, LE BRAS M, et al. The facts and hypotheses relating to the phenomenological model of cellulose pyrolysis: interdependence of the steps [J]. Journal of Analytical and Applied Pyrolysis, 2009, 84 (1): 1-17.
[23]	YU Y, WU H. Significant differences in the hydrolysis behavior of amorphous and crystalline portions within microcrystalline cellulose in hot-compressed water [J]. Industrial & Engineering Chemistry Research, 2010, 49 (8): 3902-3909.
[24]	王鹏, 龚勋, 张彪, 等. 基于离子液体再生的纤维素热解特性 [J].化工学报, 2014, 65 (12): 4793-4798. WANG P, GONG X, ZHANG B, et al. Pyrolysis characteristics of cellulose from ionic liquid regeneration [J].CIESC Journal, 2014, 65 (12): 4793-4798.
[25]	PATWARDHAN P R, DALLUGE D L, SHANKS B H, et al. Distinguishing primary and secondary reactions of cellulose pyrolysis [J]. Bioresource Technology, 2011, 102 (8): 5265-5269.
[26]	SUUBERG E M, MILOSAVLJEVIC I, OJA V. Two-regime global kinetics of cellulose pyrolysis: the role of tar evaporation[C]//Symposium (International) on Combustion. Elsevier, 1996, 26 (1): 1515-1521.
[27]	CZERNIK S, DIEBOLD J. Fast Pyrolysis of Biomass: a Handbook [M]. UK: CPL Press, 1999.

基于苯甲酰化的纤维素热解过程中典型脱水糖的定量分析

Quantitative analysis of typical anhydro-sugars obtained during pyrolysis of cellulose based on benzoylation

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 27

相关文章 15

编辑推荐

Metrics

本文评价

[1]	车睿敏, 郑文秋, 王小宇, 李鑫, 许凤. 基于离子液体的纤维素均相加工研究进展[J]. 化工学报, 2023, 74(9): 3615-3627.
[2]	吴雷, 刘姣, 李长聪, 周军, 叶干, 刘田田, 朱瑞玉, 张秋利, 宋永辉. 低阶粉煤催化微波热解制备含碳纳米管的高附加值改性兰炭末[J]. 化工学报, 2023, 74(9): 3956-3967.
[3]	盛冰纯, 于建国, 林森. 铝基锂吸附剂分离高钠型地下卤水锂资源过程研究[J]. 化工学报, 2023, 74(8): 3375-3385.
[4]	李凯旋, 谭伟, 张曼玉, 徐志豪, 王旭裕, 纪红兵. 富含零价钴活性位点的钴氮碳/活性炭设计及甲醛催化氧化应用研究[J]. 化工学报, 2023, 74(8): 3342-3352.
[5]	董茂林, 陈李栋, 黄六莲, 吴伟兵, 戴红旗, 卞辉洋. 酸性助水溶剂制备木质纳米纤维素及功能应用研究进展[J]. 化工学报, 2023, 74(6): 2281-2295.
[6]	崔张宁, 胡紫璇, 吴雷, 周军, 叶干, 刘田田, 张秋利, 宋永辉. 可降解纤维素基材料的耐水性能研究进展[J]. 化工学报, 2023, 74(6): 2296-2307.
[7]	杨峥豪, 何臻, 常玉龙, 靳紫恒, 江霞. 生物质快速热解下行式流化床反应器研究进展[J]. 化工学报, 2023, 74(6): 2249-2263.
[8]	朱风, 陈凯琳, 黄小凤, 鲍银珠, 李文斌, 刘嘉鑫, 吴玮强, 高王伟. KOH改性电石渣脱除羰基硫的性能研究[J]. 化工学报, 2023, 74(6): 2668-2679.
[9]	葛泽峰, 吴雨青, 曾名迅, 查振婷, 马宇娜, 侯增辉, 张会岩. 灰化学成分对生物质气化特性的影响规律[J]. 化工学报, 2023, 74(5): 2136-2146.
[10]	衣思敏, 马亚丽, 刘伟强, 张金帅, 岳岩, 郑强, 贾松岩, 李雪. 微晶菱镁矿蒸氨及水化动力学研究[J]. 化工学报, 2023, 74(4): 1578-1586.
[11]	吴选军, 王超, 曹子健, 蔡卫权. 数据与物理信息混合驱动的固定床吸附穿透深度学习模型[J]. 化工学报, 2023, 74(3): 1145-1160.
[12]	陈瑞哲, 程磊磊, 顾菁, 袁浩然, 陈勇. 纤维增强树脂复合材料化学回收技术研究进展[J]. 化工学报, 2023, 74(3): 981-994.
[13]	张娜, 潘鹤林, 牛波, 张亚运, 龙东辉. 酚醛树脂热裂解反应机理的密度泛函理论研究[J]. 化工学报, 2023, 74(2): 843-860.
[14]	姜家豪, 黄笑乐, 任纪云, 朱正荣, 邓磊, 车得福. 生物炭吸附溶液中Pb²⁺的定性及定量研究[J]. 化工学报, 2023, 74(2): 830-842.
[15]	陈晨, 杨倩, 陈云, 张睿, 刘冬. 不同氧浓度下煤挥发分燃烧的化学动力学研究[J]. 化工学报, 2022, 73(9): 4133-4146.