一种低位热驱动除湿冷却空调系统的热性能分析

doi:10.11949/j.issn.0438-1157.20161411

化工学报 ›› 2016, Vol. 67 ›› Issue (S2): 275-283.DOI: 10.11949/j.issn.0438-1157.20161411

一种低位热驱动除湿冷却空调系统的热性能分析

张凡, 殷勇高

东南大学能源与环境学院, 能源热转换及其过程测控教育部重点实验室, 江苏南京 210096

收稿日期:2016-10-08 修回日期:2016-10-08 出版日期:2016-12-30 发布日期:2016-12-30
通讯作者: 殷勇高
基金资助:
国家科技支撑计划项目（2014BAJ01B06）；江苏省杰出青年基金项目（BK20140026）。

Thermal performance analysis of liquid desiccant evaporative cooling air-conditioning system driven by low-grade heat

ZHANG Fan, YIN Yonggao

Key Laboratory of Energy Thermal Conversion and Control of Ministry of Education, School of Energy and Environment, Southeast University, Nanjing 210096, Jiangsu, China

Received:2016-10-08 Revised:2016-10-08 Online:2016-12-30 Published:2016-12-30
Supported by:
supported by the National Key Technology Support Program(2014BAJ01B06)and the Foundation for Distinguished Young Scientists of Jiangsu Province(BK20140026).

摘要/Abstract

摘要：

溶液除湿蒸发冷却空调系统（LDECS）结合了溶液除湿与蒸发冷却技术的优势，是一种具有广阔发展前景的非压缩式空调系统。提出了一种低品位热能驱动的LDECS，该系统由处理全部湿负荷的溶液除湿系统和承担显热负荷的再生式间接蒸发冷却器构成。建立了系统各主要部件的数学模型，研究了再生器进口溶液温度T_s，reg，in、液-液热交换器效率ε_SSHX、室外空气温度和相对湿度对该系统用作全新风机组时稳态热力性能的影响。结果表明，在南京夏季典型工况下，该系统送风参数为17.9℃、9.2 g·kg，热力系数TCOP可达0.56。T_s，reg，in在70℃左右时可以满足送风参数的要求同时保持较高的TCOP。自循环比越小，ε_SSHX对TCOP以及溶液加热器和冷却器负荷的影响越大。此外，该系统适合应用在夏季高温高湿地区。

关键词: 水溶液, 蒸发冷却, 再生, 低品位热能, 数学模拟

Abstract:

Liquid desiccant evaporative cooling air-conditioning system (LDECS),which combines both advantages of liquid desiccant and evaporative cooling technology,is a very promising alternative to the non-vapor-compression air-conditioning system.In this paper,a LDECS driven by low-grade heat is proposed,which consists of a liquid desiccant system with self-cycles that handles the total latent load and a regenerative evaporative cooler that removes the sensible heat.Mathematical models of the major components of the system are established to investigate the effects of four key parameters,namely,regenerator inlet solution temperature T_s,reg,in,solution-to-solution heat exchanger effectiveness ε_SSHX,ambient air temperature and relative humidity on steady-state thermal performance of the LDECS used as a dedicated outdoor air system.The results show that the supply air of 17.9℃ and 9.2 g·kg^-1 with the thermal coefficient of performance TCOP of 0.56 can be achieved under the typical summer condition of Nanjing. The T_s,reg,in of about 70℃ can achieve a high TCOP with the qualified supply air condition. The impacts of ε_SSHX on TCOP and the capacities of solution heater and cooler are more significant when the value of self-cycle ratio is smaller.Besides,the proposed LDECS is suitable for the application in hot-humid zone.

Key words: aqueous solution, evaporative cooling, regeneration, low-grade heat, mathematical modeling

中图分类号:

TU831.6

张凡, 殷勇高. 一种低位热驱动除湿冷却空调系统的热性能分析[J]. 化工学报, 2016, 67(S2): 275-283.

ZHANG Fan, YIN Yonggao. Thermal performance analysis of liquid desiccant evaporative cooling air-conditioning system driven by low-grade heat[J]. CIESC Journal, 2016, 67(S2): 275-283.

参考文献 17

[1]	MOHAMMAD A T, MAT S B, SULAIMAN M Y, et al. Survey of hybrid liquid desiccant air conditioning systems[J]. Renewable and Sustainable Energy Reviews, 2013, 20(4): 186-200.
[2]	BUKER M S, RIFFAT S B.Recent developments in solar assisted liquid desiccant evaporative cooling technology-a review[J]. Energy and Buildings, 2015, 96: 95-108.
[3]	张小松, 殷勇高, 曹毅然.蓄能型液体除湿冷却空调系统的建立与实验研究[J]. 工程热物理学报, 2004, 25(4): 546-549. ZHANG X S, YIN Y G, CAO Y R.Experimental study on the performance of liquid desiccant cooling air conditioning with energy storage[J]. Journal of Engineering Thermophysics, 2004, 25(4): 546-549.
[4]	蒋毅, 张小松, 殷勇高.溶液除湿蒸发冷却系统构建及其性能[J]. 东南大学学报(自然科学版), 2006, 36(5): 780-784. JIANG Y, ZHANG X S, YIN Y G.Construct and performance research on liquid desiccant evaporative cooling system[J]. Journal of Southeast University(Natural Science Edition), 2006, 36(5): 780-784.
[5]	YIN Y G, ZHANG X S, CHEN Z Q.Experimental study on dehumidifier and regenerator of liquid desiccant cooling air conditioning system[J]. Building and Environment, 2007, 42(7): 2505-2511.
[6]	李士强.一种基于溶液除湿的直接蒸发冷却空调系统实验研究[D]. 南京: 东南大学, 2012. LI S Q.Experiment study of a kind of direct evaporative cooling air conditioning system based on liquid desiccant[D]. Nanjing: Southeast University, 2012.
[7]	TU M, REN C Q, ZHANG L A, et al.Simulation and analysis of a novel liquid desiccant air-conditioning system[J]. Applied Thermal Engineering, 2009, 29(11): 2417-2425.
[8]	KIM M H, PARK J Y, HAM S W, et al.Energy conservation benefit of water-side free cooling in a liquid desiccant and evaporative cooling-assisted 100% outdoor air system[J]. Energy and Buildings, 2015, 104: 302-315.
[9]	XIE X Y, JIANG Y.Comparison of two kinds of indirect evaporative cooling system: to produce cold water and to produce cooling air[J]. Procedia Engineering, 2015, 121: 881-890.
[10]	唐易达, 郑文亨, 贾彬, 等.热湿条件下溶液除湿空调的性能分析[J]. 化工学报, 2010, 61(11): 2804-2809. TANG Y D, ZHENG W H,JIA B, et al.Performance analysis of dehumidifier/regenerator in hot-humid conditions[J]. CIESC Journal, 2010, 61(11): 2804-2809.
[11]	QI R H, LU L.Energy consumption and optimization of internally cooled/heated liquid desiccant air-conditioning system: a case study in Hong Kong[J]. Energy, 2014, 73(7): 801-808.
[12]	CHEN Y, YIN Y G, ZHANG X S.Performance analysis of a hybrid air-conditioning system dehumidified by liquid desiccant with low temperature and low concentration[J]. Energy and Buildings, 2014, 77: 91-102.
[13]	LIU X H, JIANG Y, QU K Y.Heat and mass transfer model of cross flow liquid desiccant air dehumidifier/regenerator[J]. Energy Conversion and Management, 2007, 48(2): 546-554.
[14]	彭冬根.太阳能溶液再生装置热湿耦合特性及性能研究[D]. 南京: 东南大学, 2009. PENG D G.Study of combined heat and mass transfer characteristic and performance on solar liquid regenerator[D]. Nanjing: Southeast University, 2009.
[15]	CONDE M R.Properties of aqueous solutions of lithium and calcium chlorides: formulations for use in air conditioning equipment design[J]. International Journal of Thermal Sciences, 2004, 43(4): 367-382.
[16]	钱俊飞.一种太阳能溶液除湿空调系统模型验证及实验研究[D]. 南京: 东南大学, 2014. QIAN J F.Model validation and experimental investigation of liquid desiccant air conditioning system driven by solar energy[D]. Nanjing: Southeast University, 2014.
[17]	李永存.无霜型空气源热泵系统的理论与实验研究[D]. 杭州: 浙江大学, 2011. LI Y C.Theoretical and experimental study on a frost-free air-source heat pump system[D]. Hangzhou: Zhejiang University, 2011.

一种低位热驱动除湿冷却空调系统的热性能分析

Thermal performance analysis of liquid desiccant evaporative cooling air-conditioning system driven by low-grade heat

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 17

相关文章 15

编辑推荐

Metrics

本文评价

[1]	车睿敏, 郑文秋, 王小宇, 李鑫, 许凤. 基于离子液体的纤维素均相加工研究进展[J]. 化工学报, 2023, 74(9): 3615-3627.
[2]	文兆伦, 李沛睿, 张忠林, 杜晓, 侯起旺, 刘叶刚, 郝晓刚, 官国清. 基于自热再生的隔壁塔深冷空分工艺设计及优化[J]. 化工学报, 2023, 74(7): 2988-2998.
[3]	陈朝光, 贾玉香, 汪锰. 以低浓度废酸驱动中和渗析脱盐的模拟与验证[J]. 化工学报, 2023, 74(6): 2486-2494.
[4]	卫雪岩, 钱勇. 微米级铁粉燃料中低温氧化反应特性及其动力学研究[J]. 化工学报, 2023, 74(6): 2624-2638.
[5]	陈科, 杜理, 曾英, 任思颖, 于旭东. 四元体系LiCl+MgCl₂+CaCl₂+H₂O 323.2 K相平衡研究及计算[J]. 化工学报, 2023, 74(5): 1896-1903.
[6]	罗来明, 张劲, 郭志斌, 王海宁, 卢善富, 相艳. 1~5 kW高温聚合物电解质膜燃料电池堆的理论模拟与组装测试[J]. 化工学报, 2023, 74(4): 1724-1734.
[7]	潘煜, 王子航, 王佳韵, 王如竹, 张华. 基于可得然-氯化锂复合吸附剂的除湿换热器热湿性能研究[J]. 化工学报, 2023, 74(3): 1352-1359.
[8]	陈瑞哲, 程磊磊, 顾菁, 袁浩然, 陈勇. 纤维增强树脂复合材料化学回收技术研究进展[J]. 化工学报, 2023, 74(3): 981-994.
[9]	鲁文静, 李先锋. 液流电池多孔离子传导膜研究进展[J]. 化工学报, 2023, 74(1): 192-204.
[10]	黄宽, 马永德, 蔡镇平, 曹彦宁, 江莉龙. 油脂催化加氢转化制备第二代生物柴油研究进展[J]. 化工学报, 2023, 74(1): 380-396.
[11]	李彬, 宋文明, 杨坤龙, 姜爽, 张天永. 水系有机液流电池活性材料的分子工程研究进展[J]. 化工学报, 2022, 73(7): 2806-2818.
[12]	陈永安, 周安宁, 李云龙, 石智伟, 贺新福, 焦卫红. 磁性MgFe₂O₄及其核壳催化剂制备与煤热解性能研究[J]. 化工学报, 2022, 73(7): 3026-3037.
[13]	刘庆祎, 肖桐, 孙文杰, 张家豪, 刘昌会. 纳米二氧化钛强化的相变储能研究进展[J]. 化工学报, 2022, 73(5): 1863-1882.
[14]	徐劲松, 林敏, 陈晓平, 马吉亮, 耿鹏飞, 鲍学兵, 刘道银, 梁财. 不锈钢酸洗废混酸流化床焙烧再生特性的实验研究[J]. 化工学报, 2022, 73(5): 2242-2250.
[15]	周云龙, 林东尧, 叶校源, 孙博. 常见离子对玉米秸秆为牺牲剂的光催化制氢影响[J]. 化工学报, 2022, 73(2): 722-729.