二段式吸收塔强化水洗技术提纯沼气过程

doi:10.11949/j.issn.0438-1157.20160608

化工学报 ›› 2016, Vol. 67 ›› Issue (10): 4203-4210.DOI: 10.11949/j.issn.0438-1157.20160608

二段式吸收塔强化水洗技术提纯沼气过程

丁键, 任佳佳, 李峥, 杨祝红, 陆小华

南京工业大学材料化学国家重点实验室, 江苏南京 210009

收稿日期:2016-05-09 修回日期:2016-07-20 出版日期:2016-10-05 发布日期:2016-10-05
通讯作者: 杨祝红
基金资助:
国家重点基础研究发展计划项目（2013CB733503）；江苏高校优势学科建设工程资助项目。

Process of two-stage absorption column to strengthen water scrubbing technology to purify biogas

DING Jian, REN Jiajia, LI Zheng, YANG Zhuhong, LU Xiaohua

State Key Laboratory of Materials-Oriented Chemical Engineering, Nanjing Tech University, Nanjing 210009, Jiangsu, China

Received:2016-05-09 Revised:2016-07-20 Online:2016-10-05 Published:2016-10-05
Supported by:
supported by the National Basic Research Program of China (2013CB733503) and the Priority Academic Program Development of Jiangsu Higher Education Institutions (PAPD).

摘要/Abstract

摘要：

压力水洗技术已成为提纯沼气的关键技术之一。采用填料吸收塔进行CO₂脱除实验研究，考察了液气比、吸收压力、吸收温度、CO₂初始含量、填料层高度对CO₂脱除率的影响，以及液气比、沼气流量对总体积吸收系数的影响，并运用填料塔与喷雾塔结合的二段式吸收塔进行压力水洗提纯沼气的过程强化实验。实验结果表明，吸收压力和液气比的增大、吸收温度的降低、填料层高度的增加有利于CO₂的脱除，体积总吸收系数随着液气比及沼气流量的增加而增大。二段式吸收塔能够提高CO₂吸收效果，当沼气处理量为10 L·min^-1，填料层高度为100 cm，CO₂含量小于3%时，与填料塔相比二段式吸收塔可以减少约12%的吸收液用量，并且采用110 cm填料的二段式吸收塔获得最佳的提纯效果，CO₂脱除率达到97.4%。

关键词: 沼气, 二氧化碳, 压力水洗, 二段式吸收塔, 体积总吸收系数, 生物甲烷

Abstract:

Pressure water scrubbing technology has become one of the key technologies of biogas purification. This paper adopted a packed absorption column to study on carbon dioxide removal. The influences of absorption pressure, absorption temperature, carbon dioxide content on the product gas and height of packing layer on carbon dioxide removal rate as well as those of liquid/gas ratio and biogas flow on volumetric overall absorption coefficient were investigated. At the same time, the intensive tests used a two-stage absorption column combined with a packed column and a spray column for purification process of pressure water. It was shown from the results that the increased absorption pressure, liquid-gas ratio and height of packing layer and reduced absorption temperature were favorable of removing carbon dioxide. Besides, volumetric overall absorption coefficient rose with increasing liquid/gas ratio and biogas flow. Two-stage absorption column was able to improve the effect of carbon dioxide absorption. When the biogas flow was 10 L·min^-1, the height of packing layer 100 cm and carbon dioxide content less than 3%, about 12% of the amount of absorption liquid can be reduced by two-stage absorption column compared with the traditional packed tower. Furthermore, when the two-stage absorption column of 110 cm was used, the optimum purification effect can be obtained and the carbon dioxide removal rate can reach 97.4%.

Key words: biogas, carbon dioxide, pressure water scrubbing, two-stage absorption column, volumetric overall absorption coefficient, biomethane

中图分类号:

TK6
S216.4

丁键, 任佳佳, 李峥, 杨祝红, 陆小华. 二段式吸收塔强化水洗技术提纯沼气过程[J]. 化工学报, 2016, 67(10): 4203-4210.

DING Jian, REN Jiajia, LI Zheng, YANG Zhuhong, LU Xiaohua. Process of two-stage absorption column to strengthen water scrubbing technology to purify biogas[J]. CIESC Journal, 2016, 67(10): 4203-4210.

参考文献 17

[1]	ABATZOGLOU N, BOIVIN S. A review of biogas purification processes[J]. Biofuels Bioproducts and Biorefining, 2009, 3(1):42-71.
[2]	RYCKEBOSCH E, DROUILLON M, VERVAEREN H. Techniques for transformation of biogas to biomethane[J]. Biomass and Bioenergy, 2011, 35(5):1633-1645.
[3]	RASI S, LANTELA J, VEIJANEN A. Landfill gas upgrading with countercurrent water wash[J]. Waste Management, 2008, 28(9):1528-1534.
[4]	JIANG X Y, SOMMER S G, CHRISTENSEN K V. A review of the biogas industry in China[J]. Energy Policy, 2011, 39(10):6073-6081.
[5]	BAUER F, PERSSON T, HULTEBERG C, et al. Biogas upgrading-technology overview, comparison and perspectives for the future[J]. Biofuels Bioproducts and Biorefining, 2013, 7(5):499-511.
[6]	OFORI-BOATENG C, KWOFIE E M. Water scrubbing:a better option for biogas purification for effective storage[J]. World Applied Sciences Journal, 2009, 5(Special Issue for Environment):122-125.
[7]	LANTELA J, RASI S, LEHTINEN J, et al. Landfill gas upgrading with pilot-scale water scrubber:performance assessment with absorption water recycling[J]. Applied Energy, 2012, 92:307-314.
[8]	RASI S, LANTELA J, RINTALA J. Upgrading landfill gas using a high pressure water absorption process[J]. Fuel, 2014, 115:539-543.
[9]	XIAO Y, YUAN H R, PANG Y Z, et al. CO2 removal from biogas by water washing system[J]. Chinese Journal of Chemical Engineering, 2014, 22(2):950-953.
[10]	KOLACZKOWSKI S T, AWDRY S, LE C D, et al. Removal of CO2 from a submersible atmosphere by scrubbing with water-experiments in a single column[J]. Chemical Engineering Research and Design, 2015, 100:157-169.
[11]	刘应书, 魏广飞, 张辉, 等.沼气提纯过程中醇胺溶液吸收CO2传质性能[J].化工学报, 2013, 64(11):4096-4044. LIU Y S, WEI G F, ZHANG H, et al. Mass transfer in CO2 absorption by alkanolamine aqueous solution for biogas purification[J]. CIESC Journal, 2013, 64(11):4096-4044.
[12]	夏清, 陈常贵. 化工原理(下册)[M]. 11版. 天津:天津大学出版社, 2009:221. XIA Q, CHEN C G. Unit Operations of Chemical Engineering (Part Ⅱ)[M].11th ed. Tianjin:Tianjin University Press, 2009:130.
[13]	曾庆, 郭印诚, 牛振祺, 等.填料塔中氨水吸收二氧化碳的传质性能[J].化工学报, 2011, 65(S1):146-150. ZENG Q, GUO Y C, NIU Z Q, et al. Mass transfer performance of CO2 absorption into aqueous ammonia in a packed column[J]. CIESC Journal, 2011, 65(S1):146-150.
[14]	LUCILE F, CEZAC P, CONTAMINE F, et al. Solubility of carbon dioxide in water and aqueous solution containing sodium hydroxide at temperatures from (293.15 to 393.15) K and pressure up to 5 MPa:experimental measurements[J]. Journal of Chemical and Engineering Data, 2012, 57(3):784-789.
[15]	NAJAFI M J, MOHEBBI V. Solubility measurement of carbon dioxide in water in the presence of gas hydrate[J]. Journal of Natural Gas Science and Engineering, 2014, 21:738-745.
[16]	JAVED K H, MAHMUD T, PURBA E. The CO2 capture performance of a high-intensity vortex spray scrubber[J]. Chemical Engineering Journal, 2010, 162(2):448-456.
[17]	KUNTZ J, AROONWILAS A. Performance of spray column for CO2 capture application[J]. Industrial & Engineering Chemistry Research, 2008, 47(1):145-153.

二段式吸收塔强化水洗技术提纯沼气过程

Process of two-stage absorption column to strengthen water scrubbing technology to purify biogas

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 17

相关文章 15

编辑推荐

Metrics

本文评价

[1]	宋瑞涛, 王派, 王云鹏, 李敏霞, 党超镔, 陈振国, 童欢, 周佳琦. 二氧化碳直接蒸发冰场排管内流动沸腾换热数值模拟分析[J]. 化工学报, 2023, 74(S1): 96-103.
[2]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[3]	程业品, 胡达清, 徐奕莎, 刘华彦, 卢晗锋, 崔国凯. 离子液体基低共熔溶剂在转化CO₂中的应用[J]. 化工学报, 2023, 74(9): 3640-3653.
[4]	杨菲菲, 赵世熙, 周维, 倪中海. Sn掺杂的In₂O₃催化CO₂选择性加氢制甲醇[J]. 化工学报, 2023, 74(8): 3366-3374.
[5]	洪瑞, 袁宝强, 杜文静. 垂直上升管内超临界二氧化碳传热恶化机理分析[J]. 化工学报, 2023, 74(8): 3309-3319.
[6]	张琦钰, 高利军, 苏宇航, 马晓博, 王翊丞, 张亚婷, 胡超. 碳基催化材料在电化学还原二氧化碳中的研究进展[J]. 化工学报, 2023, 74(7): 2753-2772.
[7]	毛磊, 刘冠章, 袁航, 张光亚. 可捕集CO₂的纳米碳酸酐酶粒子的高效制备及性能研究[J]. 化工学报, 2023, 74(6): 2589-2598.
[8]	蔺彩虹, 王丽, 吴瑜, 刘鹏, 杨江峰, 李晋平. 沸石中碱金属阳离子对CO₂/N₂O吸附分离性能的影响[J]. 化工学报, 2023, 74(5): 2013-2021.
[9]	李晨曦, 刘永峰, 张璐, 刘海峰, 宋金瓯, 何旭. O₂/CO₂氛围下正庚烷的燃烧机理研究[J]. 化工学报, 2023, 74(5): 2157-2169.
[10]	王皓, 唐思扬, 钟山, 梁斌. MEA吸收CO₂富液解吸过程中固体颗粒表面的强化作用分析[J]. 化工学报, 2023, 74(4): 1539-1548.
[11]	朱兵国, 何吉祥, 徐进良, 彭斌. 冷却条件下渐扩/渐缩管内超临界压力二氧化碳的传热特性[J]. 化工学报, 2023, 74(3): 1062-1072.
[12]	何仁初, 张朝晖, 杨明磊, 王聪, 奚桢浩. 考虑碳排放因素的汽油调合在线优化[J]. 化工学报, 2023, 74(2): 818-829.
[13]	王煦清, 严圣林, 朱礼涛, 张希宝, 罗正鸿. 填料塔中有机胺吸收CO₂气液传质的研究进展[J]. 化工学报, 2023, 74(1): 237-256.
[14]	李沐紫, 贾国伟, 赵砚珑, 张鑫, 李建荣. 金属有机框架材料对非二氧化碳温室气体捕捉研究进展[J]. 化工学报, 2023, 74(1): 365-379.
[15]	李鑫, 曾少娟, 彭奎霖, 袁磊, 张香平. CO₂电催化还原制合成气研究进展及趋势[J]. 化工学报, 2023, 74(1): 313-329.