螺旋扁管干式蒸发器的传热性能

doi:10.11949/j.issn.0438-1157.20161299

化工学报 ›› 2017, Vol. 68 ›› Issue (4): 1318-1325.DOI: 10.11949/j.issn.0438-1157.20161299

螺旋扁管干式蒸发器的传热性能

尹应德^1,2,3, 朱冬生^1,2,3, 孙晋飞^1,2,3, 李修真^1,2,3, 刘峰⁴, 王洪⁴

1 中国科学院广州能源研究所, 广东广州 510640;
2 中国科学院可再生能源重点实验室, 广东广州 510640;
3 广东省新能源和可再生能源研究开发和应用重点实验室, 广东广州 510640;
4 TCL空调器(中山)有限公司, 广东中山 528427

收稿日期:2016-09-18 修回日期:2016-11-18 出版日期:2017-04-05 发布日期:2017-04-05
通讯作者: 尹应德
基金资助:
广东美的制冷设备有限公司院市合作项目（科技创新项目）(2014HK100283)；中国南方智谷引进创新团队（顺府办函[2014]365号）。

Heat transfer performance of twisted-tube dry-expansion evaporator

YIN Yingde^1,2,3, ZHU Dongsheng^1,2,3, SUN Jinfei^1,2,3, LI Xiuzhen^1,2,3, LIU Feng⁴, WANG Hong⁴

1 Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640, Guangdong, China;
2 Key Laboratory of Renewable Energy, Chinese Academy of Sciences, Guangzhou 510640, Guangdong, China;
3 Guangdong Key Laboratory of New and Renewable Energy Research and Development, Guangzhou 510640, Guangdong, China;
4 TCL Air Conditioner(Zhongshan) Co. Ltd., Zhongshan 528427, Guangdong, China

Received:2016-09-18 Revised:2016-11-18 Online:2017-04-05 Published:2017-04-05
Supported by:
supported by the Science and Technology Innovation Project(2014HK100283) and China Southern Chile Valley Introduced Innovative Team (Shun Fu Letter No. [2014]365).

摘要/Abstract

摘要：

对螺旋扁管干式蒸发器（TDE）和常规折流板干式蒸发器（BDE）的传热性能进行实验研究。研究了蒸发温度（T_e）、冷凝温度（T_c）、管外壳程流体Reynolds数（Re_o）和热通量（q_i）对传热性能的影响。研究表明，随着T_e、Re_o和q_i的增大，TDE和BDE的传热性能均提高。随着T_c的增大，TDE和BDE的传热性能降低。对装配TDE和BDE的风冷热泵分别进行了测试，测试表明，在相同制冷工况下，TDE的总传热系数比BDE提高了36.3%，风冷热泵的制冷性能系数（COP）相应地提高了6.0%；在相同制热工况下，TDE的总传热系数比BDE提高了41.7%，风冷热泵的制热COP值相应地提高了15.8%；说明TDE可应用于风冷热泵，且其性能优于BDE。

关键词: 螺旋扁管, 干式蒸发器, 传热系数, 相变, 热力学, 汽化

Abstract:

The objective of this paper is to study the heat transfer performance of twisted-tube dry-expansion evaporator (TDE) and conventional baffle dry-expansion evaporator (BDE). The effect of evaporating temperature (T_e), condensing temperature (T_c), Reynolds number (Re_o) outside tube and heat flux (q_i) on heat transfer performance was investigated. The results showed that with the increase of T_e, Re_o and q_i, the heat transfer performances of TDE and BDE were increased, while with the increase of T_c, both of the heat transfer performances were decreased. The air-cooled heat pump (ACHP) applied with TDE and BDE was tested, respectively. The results showed that at the same cooling state the overall heat transfer coefficient (K) of TDE was 36.3% higher than that of BDE, and the ACHP's cooling coefficient of performance (COP) was increased by 6.0%. At the same heating state, the K of TDE was 41.7% higher than that of BDE and the ACHP's heating COP was increased by 15.8%. It was proved that TDE applied in ACHP was feasible, and its performance was better than BDE.

Key words: twisted-tube, dry-expansion evaporator, heat transfer coefficient, phase change, thermodynamics, vaporization

中图分类号:

TU831.4

尹应德, 朱冬生, 孙晋飞, 李修真, 刘峰, 王洪. 螺旋扁管干式蒸发器的传热性能[J]. 化工学报, 2017, 68(4): 1318-1325.

YIN Yingde, ZHU Dongsheng, SUN Jinfei, LI Xiuzhen, LIU Feng, WANG Hong. Heat transfer performance of twisted-tube dry-expansion evaporator[J]. CIESC Journal, 2017, 68(4): 1318-1325.

参考文献 20

[1]	张猛, 周帼彦, 朱冬生. 降膜蒸发器的研究进展[J]. 流体机械, 2012, 40(6):82-86.ZHANG M, ZHOU G Y, ZHU D S. Research progress of falling film evaporator[J]. Fluid Machinery, 2012, 40(6):82-86.
[2]	王学会, 袁晓蓉, 吴美, 等. 制冷用水平降膜式蒸发器研究进展[J].制冷学报, 2014, 35(2):19-29.WANG X H, YUAN X R, WU M, et al. Research progress of horizontal falling film evaporator in refrigeration system[J]. Journal of Refrigeration, 2014, 35(2):19-29.
[3]	刘斌. 干式壳管蒸发器的应用和优化设计[J]. 制冷与空调, 2007, 7(2):40-42.LIU B. Application and design optimization of dry-expansion shell and tube evaporator[J]. Refrigeration and Air Conditioning, 2007, 7(2):40-42.
[4]	BUTTERWORTH D, GUY A R, WELKEY J J. Design and application of twisted-tube exchanger[C]//Advances in Industrial Heat Transfer. Birmingham:ICheE, 1996:87-95.
[5]	BUTTERWORTH D. Process heat transfer[J]. Applied Thermal Engineering, 2004, 24(8/9):1395-1407.
[6]	DZYUBENKO B V. Influence of flow twisting on convective heat transfer in banks of twisted tubes[J]. Heat Transfer Res., 2005, 36(6):449-459.
[7]	DZYUBENKO B V. Estimation of the thermo hydraulic efficiency of heat exchanging apparatuses with twisted tubes[J]. Heat Transfer Res., 2006, 37(4):349-363.
[8]	高学农, 邹华春, 王端阳,等. 高扭曲比螺旋扁管的管内传热及流阻性能[J].华南理工大学学报(自然科学版), 2008, 63(11):17-21.GAO X N, ZOU H C, WANG D Y, et al. Heat transfer and flow resistance properties in twisted oblate tube with large twist ratio[J]. Journal of South China University of Technology(Natural Science Edition), 2008, 63(11):17-21.
[9]	BISHARA F, JOG M A, MANGLIK R M. Computational simulation of swirl enhanced flow and heat transfer in a twisted oval tube[J]. J. Heat Transfer-TASME, 2009, 131(8):1.
[10]	周吉成, 朱冬生, 唐新宜, 等. 扭曲管换热器壳程流体流动及传热的数值模拟[J].化学工程, 2011, 39(5):59-62.ZHOU J C, ZHOU D S, TANG X Y, et al. Numerical simulation of fluid flow and heat transfer in shell side of twisted tube heat exchanger[J]. Chemical Engineering, 2011, 39(5):59-62.
[11]	谭祥辉, 孙赫, 张立振, 等. 扭曲椭圆管换热的壳程强化传热特性[J].化工学报, 2012, 63(3):713-720.TAN X H, SUN H, ZHANG L Z, et al. Shell side heat transfer enhancement in twisted elliptical tube heat exchanger[J]. CIESC Journal, 2012, 63(3):713-720.
[12]	朱冬生, 安冬旭, 李霞, 等. 高效复合强化换热器的管程性能[J]. 化工学报, 2014, 65(2):453-459.ZHU D S, AN D X, LI X, et al. Tube side performance of new efficient composite enhanced heat exchange[J]. CIESC Journal, 2014, 65(2):453-459.
[13]	ZHANG L, YANG S, XU H. Experimental study on condensation heat transfer characteristics of steam on horizontal twisted elliptical tubes[J]. Applied Energy, 2012, 97:881-887.
[14]	GAO X N, YIN H B, HUANG Y, et al. Nucleate pool-boiling enhancement outside a horizontal bank of twisted tubes with machined porous surface[J]. Applied Thermal Engineering, 2009, 29:3212-3217.
[15]	朱冬生, 周吉成, 霍正齐, 等. 满液式蒸发器中螺旋扁管的池沸腾传热[J]. 化工学报, 2013, 64(4):1151-1156.ZHU D S, ZHOU J C, HUO Z Q, et al. Pool boiling heat transfer characteristics of twisted tube in flooded evaporator[J]. CIESC Journal, 2013, 64(4):1151-1156.
[16]	彦启森, 石文星, 田长青. 空气调节用制冷技术[M]. 北京:建筑工业出版社, 2009:89-93, 109-110.YAN Q S, SHI W X, TIAN C Q. Air-conditioning Refrigeration Technology[M]. Beijing:China Architecture & Building Press, 2009:89-93, 109-110.
[17]	余建祖.换热器原理与设计[M]. 北京:北京航空航天大学出版社, 2006:131-198.YU J Z. Heat Exchanger Principle and Design[M]. Beijing:Beihang University Press, 2006:131-198.
[18]	董其伍, 刘敏珊.纵流壳程换热器[M]. 北京:化学工业出版社, 2007:60-85.DONG Q W, LIU M S. Longitudinal Flow Shell-side Heat Exchanger[M]. Beijing:Chemical Industry Press, 2007:60-85.
[19]	MOFFAT R J. Using uncertainty analysis in the planning of an experiment[J]. Journal of Fluids Engineering, 1985, 107(2):173-178.
[20]	KLINE S J, MCCLINTOCK F A. Describing uncertainties in single-sample experiment[J]. ASME Mechanical Engineering, 1953, 75:3-8.

螺旋扁管干式蒸发器的传热性能

Heat transfer performance of twisted-tube dry-expansion evaporator

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张双星, 刘舫辰, 张义飞, 杜文静. R-134a脉动热管相变蓄放热实验研究[J]. 化工学报, 2023, 74(S1): 165-171.
[2]	江河, 袁俊飞, 王林, 邢谷雨. 均流腔结构对微细通道内相变流动特性影响的实验研究[J]. 化工学报, 2023, 74(S1): 235-244.
[3]	吴延鹏, 刘乾隆, 田东民, 陈凤君. 相变材料与热管耦合的电子器件热管理研究进展[J]. 化工学报, 2023, 74(S1): 25-31.
[4]	杨欣, 王文, 徐凯, 马凡华. 高压氢气加注过程中温度特征仿真分析[J]. 化工学报, 2023, 74(S1): 280-286.
[5]	常明慧, 王林, 苑佳佳, 曹艺飞. 盐溶液蓄能型热泵循环特性研究[J]. 化工学报, 2023, 74(S1): 329-337.
[6]	张化福, 童莉葛, 张振涛, 杨俊玲, 王立, 张俊浩. 机械蒸汽压缩蒸发技术研究现状与发展趋势[J]. 化工学报, 2023, 74(S1): 8-24.
[7]	胡建波, 刘洪超, 胡齐, 黄美英, 宋先雨, 赵双良. 有机笼跨细胞膜易位行为的分子动力学模拟研究[J]. 化工学报, 2023, 74(9): 3756-3765.
[8]	杨越, 张丹, 郑巨淦, 涂茂萍, 杨庆忠. NaCl水溶液喷射闪蒸-掺混蒸发的实验研究[J]. 化工学报, 2023, 74(8): 3279-3291.
[9]	张佳怡, 何佳莉, 谢江鹏, 王健, 赵鹬, 张栋强. 渗透汽化技术用于锂电池生产中N-甲基吡咯烷酮回收的研究进展[J]. 化工学报, 2023, 74(8): 3203-3215.
[10]	张曼铮, 肖猛, 闫沛伟, 苗政, 徐进良, 纪献兵. 危废焚烧处理耦合有机朗肯循环系统工质筛选与热力学优化[J]. 化工学报, 2023, 74(8): 3502-3512.
[11]	史昊鹏, 钟达文, 廉学新, 张君峰. 朝下多尺度沟槽翅片结构表面沸腾换热实验研究[J]. 化工学报, 2023, 74(7): 2880-2888.
[12]	史方哲, 甘云华. 超薄热管启动特性和传热性能数值模拟[J]. 化工学报, 2023, 74(7): 2814-2823.
[13]	邢美波, 张中天, 景栋梁, 张洪发. 磁调控水基碳纳米管协同多孔材料强化相变储/释能特性[J]. 化工学报, 2023, 74(7): 3093-3102.
[14]	张贲, 王松柏, 魏子亚, 郝婷婷, 马学虎, 温荣福. 超亲水多孔金属结构驱动的毛细液膜冷凝及传热强化[J]. 化工学报, 2023, 74(7): 2824-2835.
[15]	卫雪岩, 钱勇. 微米级铁粉燃料中低温氧化反应特性及其动力学研究[J]. 化工学报, 2023, 74(6): 2624-2638.