竖直管内重力对非共沸工质组分迁移的影响

doi:10.3969/j.issn.0438-1157.2013.07.012

化工学报 ›› 2013, Vol. 64 ›› Issue (7): 2394-2399.DOI: 10.3969/j.issn.0438-1157.2013.07.012

竖直管内重力对非共沸工质组分迁移的影响

张建元, 赵力

天津大学机械工程学院, 中低温热能高效利用教育部重点实验室, 天津 300072

收稿日期:2012-11-06 修回日期:2013-01-06 出版日期:2013-07-05 发布日期:2013-07-05
通讯作者: 赵力
作者简介:张建元(1990- ),男,博士研究生。
基金资助:
国家自然科学基金项目(51276123)。

Influence of gravity on composition shift of zeotropic mixtures in vertical tube

ZHANG Jianyuan, ZHAO Li

Key Laboratory of Efficient Utilization of Low and Medium Grade Energy, Ministry of Education, School of Mechanical Engineering, Tianjin University, Tianjin 300072, China

Received:2012-11-06 Revised:2013-01-06 Online:2013-07-05 Published:2013-07-05
Supported by:
supported by the National Natural Science Foundation of China (51276123).

摘要/Abstract

摘要： 为探究重力对非共沸混合工质组分迁移的影响,在竖直管式色谱分析实验台上,以R290/R600(Z1、Z2、Z3,质量比分别为25%/75%、50%/50%、75%/25%)为工质,通过改变配比、温度和静置时间等变量进行了不同工况下的实验研究,对组分变化的规律做出了理论分析并提出了进一步的研究建议。实验发现:对于工质Z1、Z2、Z3,组分迁移度受混合物配比的影响很小;温度28.0℃的条件下,将静置的时间由3 h延长至24 h后,液相中丙烷递减率由"大—小—大"的趋势向"逐渐减小"变化,同时丙烷组分迁移度增大了70.13%;静置3 h的条件下,将温度由28.0℃升高至40.0℃后,丙烷的组分迁移度减小了61.25%。

关键词: 非共沸混合工质, 重力, 组分迁移, 竖直管

Abstract: Zeotropic mixtures are considered to be popular alternatives to chlorofluorocarbons and hydrochlorofluorocarbons in refrigeration systems.It has been discovered that composition shift of multicomponent mixtures will have negative effect on system performance.In order to reveal the influence of gravity on composition shift,by varying mass fraction,temperature and standing time and using refrigerants Z1,Z2 and Z3 (R290/R600,25%/75%,50%/50% and 75%/25%,by mass fraction)as working fluids,an experimental study of composition shift was carried out in a vertical copper tube with internal diameter of 10 mm and length of 2 m.A chromatographic analysis test bench was used to make an analysis on the composition shift and bring forward research suggestions.The results show that composition shift is weakly dependent on the mass fractions of mixtures.At 28.0℃,prolonging the standing time from 3 h to 24 h,decline rate of propane in the liquid phase varies from "large—small—large" to "decrease gradually",and composition shift of propane increases by 70.13%.In 3 h of standing time,composition shift of propane decreases 61.25% as the temperature increases from 28.0℃ to 40.0℃.

Key words: zeotropic mixture, gravity, composition shift, vertical tube

中图分类号:

TK11⁺4

张建元, 赵力. 竖直管内重力对非共沸工质组分迁移的影响[J]. 化工学报, 2013, 64(7): 2394-2399.

ZHANG Jianyuan, ZHAO Li. Influence of gravity on composition shift of zeotropic mixtures in vertical tube[J]. CIESC Journal, 2013, 64(7): 2394-2399.

参考文献 14

[1]	Gao Pan(高攀),Zhao Li(赵力).Incomplete condensation of non-azeotropic working fluids in high temperature heat pumps[J].Chinese Journal of Mechanical Engineering(机械工程学报),2006,42(3):83-87
[2]	Leelananda Rajapaksha.Influence of special attributes of zeotropic refrigerant mixtures on design and operation of vapour compression refrigeration and heat pump systems[J].Energy Conversion and Management,2007,48(2):539-545
[3]	Boiarskii M J,Brodyanskii V M,Longsworth A R C.Retrospective of mixed-refrigerant technology and modern status of cryocoolers based on one-stage,oil-lubricated compressors[J].Advances in Cryogenic Engineering,1998,43:1701-1708
[4]	Zhang Shaozhi(张绍志),Wang Jianfeng(王剑锋),Zhang Hongxian(张红线),Chen Guangming(陈光明).Analysis of an auto-refrigerating cascade system utilizing a rectifying column[J].Journal of Engineering Thermophysics(工程热物理学报),2001,22(1):25-27
[5]	Du Kai,Zhang Shaoqian,Xu Weirong,Niu Xiaofeng.A study on the cycle characteristics of an auto-cascade refrigeration system[J].Experimental Thermal and Fluid Science,2009,33(2):240-245
[6]	Hua Junye,Chen Yaping,Liu Huajin,Wu Jiafeng. Thermodynamic analysis of simplified dual-pressure ammonia-water absorption power cycle[J].Journal of Central South University,2012,19(3):797-802
[7]	Youbi-Idrissi M,Bonjour J,Meunier F.Local shifts of the fluid composition in a simulated heat pump using R407C[J].Applied Thermal Engineering,2005,25:2827-2841
[8]	Gong Maoqiong(公茂琼).Analysis on the composition shift for low-temperature mixed-refrigerant caused by phase holdup in a horizontal pipe[J].Journal of Engineering Thermophysics(工程热物理学报),2006,27(s1):45-48
[9]	Gong Maoqiong (公茂琼).Composition shift due to phase hold-up in two phase flow for multicomponent mixed-refrigerant[J].Journal of Refrigeration(制冷学报),2006,27(4):10-12
[10]	Deng Zhaobin(邓昭彬),Gong Maoqiong(公茂琼),Wu Jianfeng(吴剑锋).Experiment study on compositions shift in a multicomponent mixed-refrigerant Joule-Thomson cryocooler driven by an oil-free compressor[J].Journal of Refrigeration(制冷学报),2006,27(6):5-9
[11]	Bao Junjiang(鲍军江),Zhao Li(赵力),Song Weidong(宋卫东).Theoretical investigation on the influence of composition shift on the heat exchange during the phase change using R407C[J].Journal of Mechanical Engineering(机械工程学报),2011,47(16):127-132
[12]	Liu Jinping(刘金平),Zhu Yulong(朱宇龙).Experimental study on phase holdup in auto-cascade heat pump with zeotropic mixture[J].Journal of Refrigeration(制冷学报),2009,30(6):5-10
[13]	Xu Xiongwen(许雄文),Liu Jinping(刘金平),Cao Le(曹乐),Qin Yan(秦岩),Qiu Guoxiong(邱国雄),Deng Xue(邓雪).Composition shift analysis of zeotropic mixed refrigerant in refrigeration cycle[J].CIESC Journal (化工学报),2011,62(11):3066-3072
[14]	Chen Jiufa,Kruse H.Concentration shift simulation for the mixed refrigerants R404A,R32/R134a and R407C in an air conditioning system[J].HVAC & Research,1997,3(2):149-157

[1]	党玉荣, 莫春兰, 史科锐, 方颖聪, 张子杨, 李作顺. 综合评价模型联合遗传算法的混合工质ORC系统性能研究[J]. 化工学报, 2023, 74(5): 1884-1895.
[2]	杨辉著, 兰精灵, 杨月, 梁嘉林, 吕传文, 朱永刚. 高功率平板热管传热性能的实验研究[J]. 化工学报, 2023, 74(4): 1561-1569.
[3]	王瑞恒, 何品晶, 吕凡, 章骅. 垃圾焚烧飞灰水洗后三种固液分离方法参数比较及优化[J]. 化工学报, 2023, 74(4): 1712-1723.
[4]	陈建勋, 刘金平, 许雄文, 余银豪. 一种新型环路重力热管的数值模拟和性能优化[J]. 化工学报, 2023, 74(2): 721-734.
[5]	李子航, 王占博, 苗政, 纪献兵. 亚临界有机朗肯循环系统工质筛选及热经济性分析[J]. 化工学报, 2021, 72(9): 4487-4495.
[6]	初广文,廖洪钢,王丹,李晖,李洒,姜红,金万勤,陈建峰. 微纳介尺度气液反应过程强化[J]. 化工学报, 2021, 72(7): 3435-3444.
[7]	江澜, 罗勇, 邹海魁, 孙宝昌, 张亮亮, 初广文. 超重力多相催化反应器的研究进展[J]. 化工学报, 2021, 72(6): 3194-3201.
[8]	黄文博, 曹文炅, 李庭樑, 蒋方明. 干热岩热能重力热管采热系统数值模拟研究与经济性分析[J]. 化工学报, 2021, 72(3): 1302-1313.
[9]	沈逸, 张泽宇, 梁益涛, 黄永华, 耑锐, 张亮, 卜劭华. 磁补偿微重力环境实现及磁流体微重力内角流动研究[J]. 化工学报, 2020, 71(8): 3490-3499.
[10]	陈超男, 罗向龙, 杨智, 黄仁龙, 卢沛, 陈健勇, 陈颖. 非共沸混合工质组分调控ORC系统热经济性分析和优化[J]. 化工学报, 2020, 71(5): 2373-2381.
[11]	李庭樑, 岑继文, 黄文博, 曹文炅, 蒋方明. 超长重力热管传热性能实验研究[J]. 化工学报, 2020, 71(3): 997-1008.
[12]	马奕新, 金宇, 张虎, 王娴, 唐桂华. 翅片重力热管传热性能实验研究[J]. 化工学报, 2020, 71(2): 594-601.
[13]	赵佳腾,王增鹏,戴宇成,刘昌会,饶中浩. 两亲性纳米流体太阳能重力热管传热性能研究[J]. 化工学报, 2020, 71(12): 5461-5469.
[14]	张亮亮, 付纪文, 罗勇, 孙宝昌, 邹海魁, 初广文, 陈建峰. 面向海洋工程的超重力过程强化技术及应用[J]. 化工学报, 2020, 71(1): 1-15.
[15]	张雷刚, 许波, 施娟, 陈振乾. 微重力条件下FC-72在针肋表面冷凝传热的实验研究[J]. 化工学报, 2019, 70(S1): 45-53.

竖直管内重力对非共沸工质组分迁移的影响

Influence of gravity on composition shift of zeotropic mixtures in vertical tube

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 14

相关文章 15

编辑推荐

Metrics

本文评价