碳毡负载Sn气体扩散电极CO2电化学还原性能

doi:10.11949/j.issn.0438-1157.20170616

化工学报 ›› 2017, Vol. 68 ›› Issue (S1): 225-231.DOI: 10.11949/j.issn.0438-1157.20170616

碳毡负载Sn气体扩散电极CO₂电化学还原性能

陈国钱, 叶丁丁, 李俊, 付乾, 张亮, 朱恂, 杨扬

重庆大学低品位能源利用技术及系统教育部重点实验室, 工程热物理研究所, 重庆 400030

收稿日期:2017-05-15 修回日期:2017-05-22 出版日期:2017-08-31 发布日期:2017-08-31
通讯作者: 叶丁丁,dingdingye@cqu.edu.cn
基金资助:
国家杰出青年科学基金项目（51325602）；国家自然科学基金项目（51376203）；国家自然科学基金重点国际（地区）合作研究项目（51620105011）。

Performance of carbon dioxide electrochemical reduction with carbon felt loaded Sn gas diffusion electrode

CHEN Guoqian, YE Dingding, LI Jun, FU Qian, ZHANG Liang, ZHU Xun, YANG Yang

Key Laboratory of Low-Grade Energy Utilization Technologies and Systems, Ministry of Education, Institute of Engineering Thermophysics, Chongqing University, Chongqing 400030, China

Received:2017-05-15 Revised:2017-05-22 Online:2017-08-31 Published:2017-08-31
Supported by:
supported by the National Science Funds for Distinguished Young Scholars of China (51325602), the National Natural Science Foundation of China (51376203) and the International Cooperation and Exchange of the National Natural Science Foundation of China (51620105011).

摘要/Abstract

摘要：

针对CO₂电化学还原中气体扩散电极可强化CO₂的传质，基于碳毡制备了负载锡-石墨烯催化层的新型气体扩散电极，研究了CO₂反应条件、电极厚度、催化剂载量及反应电位对CO₂电化学还原性能的影响。实验结果表明：与溶解态CO₂反应条件相比，采用气相CO₂反应条件电化学还原性能更好；一定范围内增加电极厚度和催化剂载量可以增加气-液-固三相反应界面，提升CO₂电化学还原性能；随着电解电位负移，甲酸产量增加，电流效率先增大后减小；实验中使用厚度为5 mm、载量为5 mg·cm^-2的电极，在-1.8 V（vs Ag/AgCl）条件下进行电化学还原时，平均电流密度为（12.79±1.27） mA·cm^-2，甲酸电流效率达到最佳为41.55%±2.50%。

关键词: 二氧化碳, 还原, 多孔介质, 碳毡电极, 催化剂载量, 电解电位

Abstract:

Gas diffusion electrode can enhance mass transfer of CO₂ for CO₂ electrochemical reduction. A carbon felt loaded Sn-graphene gas diffusion electrode for electrochemical reduction of CO₂ to formic acid. Effects of CO₂ reaction condition,electrode thickness,Sn loading and electrolytic potential were studied. The results showed that the performance of CO₂ electrochemical reduction was better under the gas phase CO₂ reaction condition than that under dissolved CO₂ condition. Increasing the electrode thickness or Sn loading within an appropriate range led to an improvement in electrochemical reduction of carbon dioxide to formic acid due to the increase in the gas-liquid-solid three-phase interface. The production of formic acid was raised with the negative shift of the electrolytic potential,while the Faraday efficiency increased at first and then decreased. The average current density of (12.79±1.27)mA·cm^-2 and highest Faraday efficiency of 41.55%±2.50% for electrochemical reduction of carbon dioxide to formic acid were obtained at -1.8 V (vs Ag/AgCl) using the carbon felt electrode with the electrode thickness of 5 mm and Sn loading of 5 mg·cm^-2.

Key words: carbon dioxide, reduction, porous media, carbon felt electrode, catalyst loading, electrolytic potential

中图分类号:

TQ021.4

陈国钱, 叶丁丁, 李俊, 付乾, 张亮, 朱恂, 杨扬. 碳毡负载Sn气体扩散电极CO₂电化学还原性能[J]. 化工学报, 2017, 68(S1): 225-231.

CHEN Guoqian, YE Dingding, LI Jun, FU Qian, ZHANG Liang, ZHU Xun, YANG Yang. Performance of carbon dioxide electrochemical reduction with carbon felt loaded Sn gas diffusion electrode[J]. CIESC Journal, 2017, 68(S1): 225-231.

参考文献 21

[1]	NEMA P,NEMA S,ROY P. An overview of global climate changing in current scenario and mitigation action[J]. Renewable and Sustainable Energy Reviews,2012,16(4):2329-2336.
[2]	COSTENTIN C,ROBERT M,SAVÉANT J M. Catalysis of the electrochemical reduction of carbon dioxide[J]. Chemical Society Reviews,2013,42(6):2423-2436.
[3]	SPINNER N S,VEGA J A,MUSTAIN W E. Recent progress in the electrochemical conversion and utilization of CO2[J]. Catalysis Science & Technology,2012,2(1):19-28.
[4]	KANG P,CHENG C,CHEN Z,et al. Selective electrocatalytic reduction of CO2 to formate by water-stable iridium dihydride pincer complexes[J]. Journal of the American Chemical Society,2012,134(12):5500-5503.
[5]	WANG Z L,LI C,YAMAUCHI Y. Nanostructured nonprecious metal catalysts for electrochemical reduction of carbon dioxide[J]. Nano Today,2016,11(3):373-391.
[6]	GAWANDE M B,GOSWAMI A,FELPIN F X,et al. Cu and Cu-based nanoparticles:synthesis and applications in catalysis[J]. Chemical Reviews,2016,116(6):3722-3811.
[7]	SEN S,LIU D,PALMORE G T R. Electrochemical reduction of CO2 at copper nanofoams[J]. ACS Catalysis,2014,4(9):3091-3095.
[8]	LI H,OLOMAN C. Development of a continuous reactor for the electro-reduction of carbon dioxide to formate(Ⅰ):Process variables[J]. Journal of Applied Electrochemistry,2006,36(10):1105-1115.
[9]	MACHUNDA R L,JU H K K,LEE J. Electrocatalytic reduction of CO2 gas at Sn based gas diffusion electrode[J]. Current Applied Physics,2011,11(4):986-988.
[10]	WU J,RISALVATO F,ZHOU X D. Effects of the electrolyte on electrochemical reduction of CO2 on Sn electrode[J]. ECS Transactions,2012,41(33):49-60.
[11]	CHEN Y,KANAN M W. Tin oxide dependence of the CO2 reduction efficiency on tin electrodes and enhanced activity for tin/tin oxide thin-film catalysts[J]. Journal of the American Chemical Society,2012,134(4):1986-1989.
[12]	ZHANG S,KANG P,MEYER T J. Nanostructured tin catalysts for selective electrochemical reduction of carbon dioxide to formate[J]. Journal of the American Chemical Society,2014,136(5):1734-1737.
[13]	LEE S,JU H K,JEON H,et al. Electrocatalytic reduction of gas-phased CO2 on nano-sized Sn electrode surface[J]. ECS Transactions,2013,53(29):41-47.
[14]	PRAKASH G K S,VIVA F A,OLAH G A. Electrochemical reduction of CO2 over Sn-Nafion® coated electrode for a fuel-cell-like device[J]. Journal of Power Sources,2013,223:68-73.
[15]	WANG Q,DONG H,YU H. Fabrication of a novel tin gas diffusion electrode for electrochemical reduction of carbon dioxide to formic acid[J]. RSC Advances,2014,4(104):59970-59976.
[16]	DEL CASTILLO A,ALVAREZ-GUERRA M,IRABIEN A. Continuous electroreduction of CO2 to formate using Sn gas diffusion electrodes[J]. AIChE Journal,2014,60(10):3557-3564.
[17]	WU J,SHARMA P P,HARRIS B H,et al. Electrochemical reduction of carbon dioxide:Ⅳ dependence of the Faradaic efficiency and current density on the microstructure and thickness of tin electrode[J]. Journal of Power Sources,2014,258:189-194.
[18]	ZHAO H Z,ZHANG Y,CHANG Y Y,et al. Conversion of a substrate carbon source to formic acid for carbon dioxide emission reduction utilizing series-stacked microbial fuel cells[J]. Journal of Power Sources,2012,217:59-64.
[19]	XIAO K,DING L X,LIU G,et al. Freestanding,hydrophilic nitrogen-doped carbon foams for highly compressible all solid-state supercapacitors[J]. Advanced Materials,2016,28(28):5997-6002.
[20]	LU X,LEUNG D Y C,WANG H,et al. Electrochemical reduction of carbon dioxide to formic acid[J]. Chem Electro Chem,2014,1(5):836-849.
[21]	LATES V,FALCH A,JORDAAN A,et al. An electrochemical study of carbon dioxide electroreduction on gold-based nanoparticle catalysts[J]. Electrochimica Acta,2014,128:75-84.

碳毡负载Sn气体扩散电极CO₂电化学还原性能

Performance of carbon dioxide electrochemical reduction with carbon felt loaded Sn gas diffusion electrode

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 21

相关文章 15

编辑推荐

Metrics

本文评价

[1]	宋瑞涛, 王派, 王云鹏, 李敏霞, 党超镔, 陈振国, 童欢, 周佳琦. 二氧化碳直接蒸发冰场排管内流动沸腾换热数值模拟分析[J]. 化工学报, 2023, 74(S1): 96-103.
[2]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[3]	范孝雄, 郝丽芳, 范垂钢, 李松庚. LaMnO₃/生物炭催化剂低温NH₃-SCR催化脱硝性能研究[J]. 化工学报, 2023, 74(9): 3821-3830.
[4]	程业品, 胡达清, 徐奕莎, 刘华彦, 卢晗锋, 崔国凯. 离子液体基低共熔溶剂在转化CO₂中的应用[J]. 化工学报, 2023, 74(9): 3640-3653.
[5]	杨菲菲, 赵世熙, 周维, 倪中海. Sn掺杂的In₂O₃催化CO₂选择性加氢制甲醇[J]. 化工学报, 2023, 74(8): 3366-3374.
[6]	洪瑞, 袁宝强, 杜文静. 垂直上升管内超临界二氧化碳传热恶化机理分析[J]. 化工学报, 2023, 74(8): 3309-3319.
[7]	李盼, 马俊洋, 陈志豪, 王丽, 郭耘. Ru/α-MnO₂催化剂形貌对NH₃-SCO反应性能的影响[J]. 化工学报, 2023, 74(7): 2908-2918.
[8]	张琦钰, 高利军, 苏宇航, 马晓博, 王翊丞, 张亚婷, 胡超. 碳基催化材料在电化学还原二氧化碳中的研究进展[J]. 化工学报, 2023, 74(7): 2753-2772.
[9]	张谭, 刘光, 李晋平, 孙予罕. Ru基氮还原电催化剂性能调控策略[J]. 化工学报, 2023, 74(6): 2264-2280.
[10]	张艳梅, 袁涛, 李江, 刘亚洁, 孙占学. 高效SRB混合菌群构建及其在酸胁迫条件下的性能研究[J]. 化工学报, 2023, 74(6): 2599-2610.
[11]	胡南, 陶德敏, 杨照岚, 王学兵, 张向旭, 刘玉龙, 丁德馨. 铁炭微电解与硫酸盐还原菌耦合修复铀尾矿库渗滤水的研究[J]. 化工学报, 2023, 74(6): 2655-2667.
[12]	毛磊, 刘冠章, 袁航, 张光亚. 可捕集CO₂的纳米碳酸酐酶粒子的高效制备及性能研究[J]. 化工学报, 2023, 74(6): 2589-2598.
[13]	蔺彩虹, 王丽, 吴瑜, 刘鹏, 杨江峰, 李晋平. 沸石中碱金属阳离子对CO₂/N₂O吸附分离性能的影响[J]. 化工学报, 2023, 74(5): 2013-2021.
[14]	李晨曦, 刘永峰, 张璐, 刘海峰, 宋金瓯, 何旭. O₂/CO₂氛围下正庚烷的燃烧机理研究[J]. 化工学报, 2023, 74(5): 2157-2169.
[15]	贾晓宇, 杨剑, 王博, 林梅, 王秋旺. 金属丝网毛细特性的孔隙尺度数值分析[J]. 化工学报, 2023, 74(5): 1928-1938.