Heating performance of air preheated integrated ground water heat pump air-conditioning system

doi:10.11949/0438-1157.20221600

Abstract

Abstract:

An integrated ground water heat pump air-conditioning (IGWHP) system is proposed to solve the problem of limited utilization of ground water thermal storage in conventional ground water source heat pump air-conditioning (CGWHP) system. Based on distributed parameter method and lumped parameter method, a steady-state simulation model of IGWHP system is developed, and the heating performance of the proposed system is simulated. The influence of hot water on the performance of IGWHP system is analyzed, and the heating performance of IGWHP system is compared with CGWHP system. The results show that IGWHP system has good energy saving advantages over CGWHP system. As heating temperature of the hot water increases from 40℃ to 55℃, the energy consumption of IGWHP system decreases by 36.12% on average compared with CGWHP system. Moreover, the simulation results are in good agreement with the experimental results, and the error is with in ±10%.

Key words: ground water, fresh air, heat pump, distributed parameter model, energy consumption

摘要：

针对传统地下水源热泵空调（conventional ground water heat pump air-conditioning，CGWHP）系统对地下水储热利用有限的缺陷，提出一种地下水预热新风一体化热泵空调（integrated ground water heat pump air-conditioning，IGWHP）系统。基于分布参数法和集总参数法，建立了IGWHP系统稳态仿真模型，对组成系统部件和整个系统的制热性能进行仿真计算，分析空调热水对IGWHP系统性能影响，同时比较分析IGWHP系统和CGWHP系统的制热性能，并进行了实验验证。研究结果表明：IGWHP系统较CGWHP系统有显著节能优势。当热水供热温度从40℃升高到55℃，IGWHP系统的能耗比CGWHP系统平均下降36.12%。仿真结果与实验结果吻合较好，仿真值与实验值的误差在±10%以内。

关键词: 地下水, 新风, 热泵, 分布参数模型, 能耗

CLC Number:

TU 833

Mengya LIAN, Yingying TAN, Lin WANG, Feng CHEN, Yifei CAO. Heating performance of air preheated integrated ground water heat pump air-conditioning system[J]. CIESC Journal, 2023, 74(S1): 311-319.

连梦雅, 谈莹莹, 王林, 陈枫, 曹艺飞. 地下水预热新风一体化热泵空调系统制热性能研究[J]. 化工学报, 2023, 74(S1): 311-319.

Figures/Tables 10

Fig.1 Schematic diagram of IGWHP system

Fig.2 Experimental setup of IGWHP system

Fig.3 The uncertainty results of the experimental values of IGWHP system

Fig.4 Flow chart of IGWHP system simulation algorithm

Fig.5 Comparison of experimental and simulated energy consumption of heat pump unit

Fig.6 Comparison of COP experimental value and simulation value of heat pump unit

Fig.7 Effect of hot water temperature on heat exchanger load of IGWHP system

Fig.8 Effect of hot water flow on heat exchanger load of IGWHP system

Fig.9 Effect of hot water temperature on heat exchanger load of IGWHP and CGWHP systems

Fig.10 Effect of hot water flow on heat exchanger load of IGWHP and CGWHP systems

References 18

1	Masood E. Net-zero carbon pledges must be meaningful to avert climate disaster[J]. Nature, 2021, 592(7852): 8.
2	徐斌, 龙林爽, 孟宪春, 等. 不同典型气候区内建筑屋面及外墙使用隔热涂层后节能作用的分析与评价[J]. 太阳能学报, 2012, 33(4): 670-676.
	Xu B, Long L S, Meng X C, et al. Analyzing and evaluating the effect of thermal insulation coating used in building roof and exterior walls on building energy-saving in various typical climates[J]. Acta Energiae Solaris Sinica, 2012, 33(4): 670-676.
3	王荣光, 沈天行. 可再生能源利用与建筑节能[M]. 北京: 机械工业出版社, 2004.
	Wang R G, Shen T X. Renewable Energy Utilization and Building Energy Conservation[M]. Beijing: China Machine Press, 2004.
4	张春路. 制冷空调系统仿真原理与技术[M]. 北京: 化学工业出版社, 2013.
	Zhang C L. Fundamentals of Vapor-Compression Refrigeration and Air-Conditioning System Modeling[M]. Beijing: Chemical Industry Press, 2013.
5	刘萍, 柳建华, 张良. R32与R410A在滚动转子式压缩机中变工况仿真研究[J]. 流体机械, 2020, 48(6): 72-76.
	Liu P, Liu J H, Zhang L. Simulation of R32 and R410A under variable conditions in rolling rotor compressor[J]. Fluid Machinery, 2020, 48(6): 72-76.
6	孙浩然, 任滔, 丁国良, 等. 一种产品数据交互式的变频压缩机理论模型[J]. 制冷学报, 2015, 36(3): 73-78.
	Sun H R, Ren T, Ding G L, et al. A product-data interactive theoretical model of variable-speed compressor[J]. Journal of Refrigeration, 2015, 36(3): 73-78.
7	Ayub Z H. Plate heat exchanger literature survey and new heat transfer and pressure drop correlations for refrigerant evaporators[J]. Heat Transfer Engineering, 2003, 24(5): 3-16.
8	Qiao H T. A new model for plate heat exchangers with generalized flow configurations and phase change[J]. International Journal of Refrigeration, 2013, 36(2): 622-632.
9	顾屹, 谢建, 张俊, 等. 小通道钎焊板式冷凝器性能仿真与实验研究[J]. 制冷学报, 2020, 41(4): 111-117.
	Gu Y, Xie J, Zhang J, et al. Simulation and experimental study on performance of a mini-channel brazed plate condenser[J]. Journal of Refrigeration, 2020, 41(4): 111-117.
10	刘启媛, 吕鸿斌, 蔡博伟, 等. 微通道平行流冷凝器两相流传热和压降的修正方法[J]. 制冷学报, 2020, 41(3): 31-37.
	Liu Q Y, Lv H B, Cai B W, et al. Correction method of two-phase flow heat transfer and pressure drop in micro-channel parallel flow condenser[J]. Journal of Refrigeration, 2020, 41(3): 31-37.
11	Wang Z W, Wang L, Ma A H, et al. Performance evaluation of ground water-source heat pump system with a fresh air pre-conditioner using ground water[J]. Energy Conversion and Management, 2019, 188: 250-261.
12	宋尊, 王林, 王占伟, 等. 新风比对改进型地下水源热泵制热特性的影响[J]. 河南科技大学学报(自然科学版), 2018, 39(4): 6,34-38.
	Song Z, Wang L, Wang Z W, et al. Effect of fresh air fraction on heating performance of modified ground-water heat pump[J]. Journal of Henan University of Science and Technology (Natural Science), 2018, 39(4): 6,34-38.
13	王林, 何慧, 王占伟, 等. 采用地下水预热新风的热泵空调系统的适用性[J]. 化工学报, 2018, 69(S2): 485-491.
	Wang L, He H, Wang Z W, et al. Applicability of heat pump air-conditioning system with groundwater preheating fresh air[J]. CIESC Journal, 2018, 69(S2): 485-491.
14	Hasan A L. Performance investigation of plain and finned tube evaporatively cooled heat exchangers[J]. Applied Thermal Engineering, 2003, 23(3): 325-340.
15	丁国良, 张春路. 制冷空调装置仿真与优化[M]. 北京: 科学出版社, 2001.
	Ding G L, Zhang C L. Simulation and Optimization of Refrigeration Device[M]. Beijing: Science Press, 2001.
16	Dittus F W, Boelter L M K. Heat transfer in automobile radiators of the tubular type[J]. International Communications in Heat and Mass Transfer, 1985, 12(1): 3-22.
17	Yan Y Y. Condensation heat transfer and pressure drop of refrigerant R-134a in a plate heat exchanger[J]. International Journal of Heat and Mass Transfer, 1999, 42(6): 993-1006.
18	中华人民共和国住房和城乡建设部. 民用建筑供暖通风与空气调节设计规范附条文说明: [S]. 北京: 中国建筑工业出版社, 2012.
	Ministry of Housing and Urban-Rural Development of the People's Republic of China. Design code for heating, ventilation and air conditioning of civil buildings: [S]. Beijing: China Architecture & Building Press, 2012.

[1]	Xianggang ZHANG, Yulong CHANG, Hualin WANG, Xia JIANG. Low energy consumption non-phase change second drying of waste straw and other biomass [J]. CIESC Journal, 2024, 75(7): 2433-2445.
[2]	Qiong SUN, Fuxin YANG, Houzhang TAN, Xiaopo WANG. Simulation study of CO₂ capture from flue gas by deep eutectic solvent [J]. CIESC Journal, 2024, 75(10): 3705-3717.
[3]	Jiapeng YU, Na XU, Wei ZHANG, Qingyuan KANG, Hong ZHANG, Muxuan QIN, Jiabin FANG. Modeling and multi-objective optimization of yield and energy consumption of gas-liquid sulfonation reaction in microreactor [J]. CIESC Journal, 2024, 75(10): 3681-3690.
[4]	Minghui CHANG, Lin WANG, Jiajia YUAN, Yifei CAO. Study on the cycle performance of salt solution-storage-based heat pump [J]. CIESC Journal, 2023, 74(S1): 329-337.
[5]	Xin YANG, Wen WANG, Kai XU, Fanhua MA. Simulation analysis of temperature characteristics of the high-pressure hydrogen refueling process [J]. CIESC Journal, 2023, 74(S1): 280-286.
[6]	Tianyang YANG, Huiming ZOU, Hui ZHOU, Chunlei WANG, Changqing TIAN. Experimental investigation on heating performance of vapor-injection CO₂ heat pump for electric vehicles at -30℃ [J]. CIESC Journal, 2023, 74(S1): 272-279.
[7]	Qihong ZOU, Qian LI, Tianshu GE. Experimental study of two-stage parallel desiccant coated heat pump system based on multi-objectives [J]. CIESC Journal, 2023, 74(S1): 265-271.
[8]	Guangyu WANG, Kai ZHANG, Kaihua ZHANG, Dongke ZHANG. Heat and mass transfer and energy consumption for microwave drying of coal slime [J]. CIESC Journal, 2023, 74(6): 2382-2390.
[9]	Bowen LEI, Jianhua WU, Qihang WU. Research on high injection superheat cycle for R290 low pressure ratio heat pump [J]. CIESC Journal, 2023, 74(5): 1875-1883.
[10]	Can YANG, Xueqi SUN, Minghua SHANG, Jian ZHANG, Xiangping ZHANG, Shaojuan ZENG. Research status and prospect of CO₂ absorption and separation by phase-change ionic liquid systems [J]. CIESC Journal, 2023, 74(4): 1419-1432.
[11]	Fang ZHOU, Jian LIU, Xiaosong ZHANG. Selection of ternary zeotropic mixtures for high-temperature heat pumps on multiparameter evaluation principles [J]. CIESC Journal, 2023, 74(11): 4487-4500.
[12]	Yixiu DONG, Ruzhu WANG. High temperature heat pump: cycle configurations, working fluids and application potentials [J]. CIESC Journal, 2023, 74(1): 133-144.
[13]	Zixuan HUANG, Huan CHEN, Hai LI, Minglong WANG, Guangjin CHEN, Bei LIU. Process simulation and energy consumption analysis of CO₂/N₂ pilot-scale separation using ZIF-8 slurry [J]. CIESC Journal, 2022, 73(1): 322-331.
[14]	LUO Jielin, YANG Kaiyin, ZHAO Zhen, WANG Qin, CHEN Guangming. Heating performance of recuperative heat pump using low-GWP mixed refrigerant [J]. CIESC Journal, 2021, 72(S1): 84-90.
[15]	WANG Qianxu, LIU Yicai, LIANG Heng, LI Zheng, ZHAO Xiangle. Impact of defrost falling water on defrost performance of heat exchanger [J]. CIESC Journal, 2021, 72(S1): 356-361.