Selective hydrogenation of maleic anhydride over Ni/ZrO2 catalysts with ZrO2 prepared by methanol thermal method

doi:10.11949/j.issn.0438-1157.20170005

Abstract

Abstract:

A series of tetragonal ZrO₂ which support different crystalline size were prepared by methanol thermal method. Ni/ZrO₂catalysts with Ni content of 10%(mass) were prepared by impregnation method and applied in the liquid phase hydrogenation of maleic anhydride. All catalysts were characterized by N₂ physical adsorption-desorption, H₂-temperature programmed reduction(H₂-TPR), X-ray diffraction(XRD), X-ray photoelectron spectroscopy(XPS) and in situ Fourier transform infrared spectroscopy(in situ FTIR). Higher dispersion and smaller crystallite size of metallic Ni favored the hydrogenation of C=C to produce succinic anhydride. While the formation of strong metal-support interaction contributed the hydrogenation of C=O to produce γ-butyrolactone. When methanol thermal time was 2 h, the Ni/ZrO₂-2 catalyst showed the highest catalytic activity for C=O hydrogenation.

Key words: liquid phase hydrogenation of maleic anhydride, γ-butyrolactone, catalyst, strong metal-support interaction

摘要：

通过改变甲醇热时间制备了一系列不同晶粒尺寸的四方相 ZrO₂，采用过体积浸渍法制备了Ni 含量（质量分数）为10%的Ni/ZrO₂催化剂，并考察了其催化顺酐液相加氢性能。采用氮气吸附-脱附（BET）、X射线衍射（XRD）、氢气程序升温还原（H₂-TPR）、X射线光电子能谱（XPS）、原位红外光谱（in situ FTIR）等手段对催化剂进行了表征。研究结果表明，分散性好、晶粒尺寸小的Ni物种有利于C=C键加氢生成丁二酸酐；而金属-载体强相互作用的形成则有利于C=O加氢生成 γ-丁内酯。当甲醇热时间为2 h时，制备的Ni/ZrO₂催化剂的C=O加氢活性最高，在反应温度为210℃，反应压力为5 MPa，反应时间为3 h时，其顺酐转化率达100%，γ-丁内酯选择性为44.7%。

关键词: 顺酐加氢, γ-丁内酯, 催化剂, 金属-载体强相互作用

CLC Number:

O643.36

LIANG Eryan, ZHANG Yin, ZHAO Lili, XU Yalin, ZHAO Yongxiang. Selective hydrogenation of maleic anhydride over Ni/ZrO₂catalysts with ZrO₂ prepared by methanol thermal method[J]. CIESC Journal, 2017, 68(6): 2352-2358.

梁二艳, 张因, 赵丽丽, 徐亚琳, 赵永祥. 甲醇热制备四方相ZrO₂及其负载镍催化剂的顺酐加氢性能[J]. 化工学报, 2017, 68(6): 2352-2358.

References 35

[1]	YUAN H J, ZHANG C L, HUO W T, et al. Selective hydrogenation of maleic anhydride over Pd/Al2O3 catalysts prepared via colloid deposition[J]. Chem. Sci., 2014, 126: 141-145.
[2]	HUANG Y Q, MA Y, CHENG Y W. Active ruthenium catalysts prepared by Cacumen Platycladi leaf extract for selective hydrogenation of maleic anhydride[J]. Applied Catalysis A: General, 2015, 495: 124-130.
[3]	YANG Y, WANG C Z, YUN G. Gas-phase hydrogenation of maleic Anhydride to γ-butyrolactone over Cu-CeO2-Al2O3 catalyst at atmospheric pressure: effects of the residual sodium and water in the catalyst precursor[J]. Journal of Molecular Catalysis A: Chemica, 2014, 395: 392-397.
[4]	ZHANG B, ZHU Y L, DING G Q. Modification of the supported Cu/SiO2 catalyst by alkaline earth metals in the selective conversion of 1, 4-butanediol to γ-butyrolactone[J]. Applied Catalysis A: General, 2012, 443/444: 191-201
[5]	GAO D Z, YIN H B, WANG A L, et al. Gas phase dehydrogenation of ethanol using maleic anhydride as hydrogen acceptor over Cu/hydroxylapatite, Cu/SBA-15, and Cu/MCM-41 catalysts[J]. Journal of Industrial and Engineering Chemistry, 2015, 26: 322-332.
[6]	REGENHARDT S A, MEYER C I, GARETTO T F, et al. Selective gas phase hydrogenation of maleic anhydride over Ni-supported catalysts: effect of support on the catalytic performance[J]. Applied Catalysis A: General, 2012, 449: 81-87.
[7]	HUO W T, ZHANG C L, YUAN H J, et al. Vapor-phaseselective hydrogenation of maleic anhydride to succinic anhydride over Ni/TiO2 catalysts[J]. Journal of Industrial and Engineering Chemistry, 2014, 20: 4140-4145.
[8]	张因, 赵丽丽, 张鸿喜, 等. 载体对镍基催化剂顺酐液相加氢性能的影响[J]. 化工学报, 2015, 66(7): 2505-2513.
	ZHANG Y, ZHAO L L, ZHANG H X, et al. Effect of support on catalytic performance of nickel-based catalysts used for liquid phase hydrogenation of maleic anhydride [J]. CIESC Journal, 2015, 66(7): 2505-2513.
[9]	ZHANG D Z, YIN H B, XUE J J, et al. Selective hydrogenation of maleic anhydride to tetrahydrofuran over Cu-Zn-M (M = Al, Ti, Zr) catalysts using ethanol as a solvent[J]. Ind. Chem. Res., 2009, 48: 11220-11224.
[10]	ZHANG X H, SU H Q, YANG X Z. Catalytic performance of a three-dimensionally ordered macroporous Co/ZrO2 catalyst in Fischer-Tropsch synthesis[J]. Journal of Molecular Catalysis A: Chemical, 2012, 360: 16-25.
[11]	林明桂, 杨成, 李文怀. 锰和镧改性 Cu/ZrO2合成甲醇催化剂的结构及催化性能[J].催化学报, 2004, 25(7): 591-595.
	LIU M G, YANG C, LI W H. Structure and catalytic performance of Mn-and La-modified Cu/ZrO2 catalysts for methanol synthesis[J]. Chinese Journal of Catalysis, 2004, 25(7): 591-595.
[12]	张颜鑫. ZrO2晶型对M/ZrO2催化剂顺酐液相加氢性能的影响[D]. 太原: 山西大学, 2013.
	ZHANG Y X. Effect of ZrO2 polymorphs on catalytic performance of Ni/ZrO2 catalyst for liquid phase hydrogenation of maleic anhydride[D]. Taiyuan: Shanxi University, 2013.
[13]	LI S, LI M S, ZHANG C X, et al. Steam reforming of ethanol over Ni/ZrO2 catalysts: effect of support on product distribution[J]. Hydrogen Energy, 2011, (1): 1-10
[14]	张鑫, 徐柏庆. Au/ZrO2催化 CO 氧化反应中 ZrO2纳米粒子的尺寸效应[J]. 化学学报, 2005, (1): 86-90.
	ZHANG X, XU B Q. Nano-size effect of zirconia in Au/ZrO2 catalyst for CO oxidation[J]. Acta Chimica Sinica, 2005, (1): 86-90.
[15]	张鑫, 徐柏庆. Au/ZrO2 催化剂中 ZrO2的尺寸效应: 1, 3-丁二烯加氢反应[J]. 高等学校化学学报, 2005, (1): 106-110.
	ZHANG X, XU B Q. Size effect of zirconia nanoparticles in Au/ZrO2 catalysts for 1, 3-butadiene hydrogenation[J]. Chemical Journal of Chinese Universities, 2005, (1): 106-110.
[16]	TAKANO H, SHINOMIYA H, IZUMIYA K, et al. CO2 methanation of Ni catalysts supported on tetragonal ZrO2 doped with Ca2+ and Ni2+ ions[J]. International Journal of Hydrogen Energy, 2015, 40: 8347-8355.
[17]	LI W Z, ZHAO Z K, DING F S. syngas production via steam-CO2 dual reforming of methane over La-Ni/ZrO2 catalyst prepared by L-arginine ligand-assisted strategy: enhanced activity and stability[J]. ACS Sustainable Chem. Eng., 2015, 3: 3461-3476.
[18]	李为臻, 刘海超. 溶剂热法合成纯单斜和四方晶相氧化锆中的溶剂效应[J]. 物理化学学报, 2008, 24(12): 2172-2178.
	LI W Z, LIU H C. Solvent effects on the solvothermal of pure monoclinic and tetragonal zirconia nanoparticles[J]. Acta Physico-Chimica Sinica, 2008, 24(12): 2172-2178.
[19]	REGENHARDT S A, MEYER C I, GARETTO T F, et al. Selective gas phase hydrogenation of maleic anhydride over Ni-supported catalysts: effect of support on the catalytic performance[J]. Applied Catalysis A: General, 2012, 449: 81-87.
[20]	GAO C, ZHAO Y, ZHANG Y, et al. Synthesis characterization and catalytic evaluation of Ni/ZrO2-SiO2 aerogels catalysts[J]. J. Sol-Gel Sci. Technol., 2007, 44: 145-151.
[21]	MERCY C I, REGENHARDT S A, MARCHI A J. Gas phase hydrogenation of maleic anhydride at low pressure over silica-supported cobalt and nickel catalysts[J]. Applied Catalysis A: General, 2012, 417/418: 59-65.
[22]	孟志宇, 张因, 赵丽丽, 等. 不同晶型TiO2负载镍催化剂催化顺酐液相加氢[J]. 高等学校化学学报, 2015, 36(9): 1779-1785.
	MENG Z Y, ZHANG Y, ZHAO L L, et al. Liquid phase hydrogenation of maleic anhydride over Ni/TiO2 catalysts with different TiO2 polymorphs[J]. Chemical Journal of Chinese Universities, 2015, 36(9): 1779-1785.
[23]	FORAITA S, FULTON J L, CHASE Z A. Impact of the oxygen defects and the hydrogen concentration on the surface of tetragonal and monoclinic ZrO2 on the reduction rates of stearic acid on Ni/ZrO2[J]. Chem. Eur. J., 2015, 21: 2423-2434.
[24]	ZHANG X P, ZHANG Q, TSUBAKI N S. Carbon dioxide reforming of methane over Ni nanoparticles incorporated into mesoporous amorphous ZrO2 matrix[J]. Fuel, 2015, 147: 243-252.
[25]	WANG Q, CHENG H, LIU R, et al. Influence of metal particle size on the hydrogenation of maleic anhydride over Pd/C catalysts in scCO2[J]. Catalysis Today, 2009, 148: 368-372.
[26]	PILLAI U R, YOUNG D. Maleic anhydride hydrogenation over Pd/Al2O3 catalyst under supercritical CO2 medium[J]. Applied Catalysis B: Environmental, 2003, 43: 131-138.
[27]	JASIK A, WOJCIESZAK R, et al. Study of nickel catalysts supported on Al2O3, SiO2 or Nb2O5 oxides[J]. Journal of Molecular Catalysis A: Chemical, 2005, 242: 81-90.
[28]	WU W H, XU J, OHNISHI R. Complete hydrode chlorination of chlorobenzene and its derivatives over supported nickel catalysts under liquid phase conditions[J]. Applied Catalysis B: Environmental, 2005, 60: 129-137.
[29]	盖媛媛, 李杨, 张因, 等. 载体制备方法对Ni/TiO2 催化剂顺酐液相加氢性能的影响[J]. 工业催化, 2014, 22(2): 107-113.
	GE Y Y, LI Y, ZHANG Y, et al. Effect of preparation methods of supports on catalytic performance of Ni/TiO2 catalysts for liquid phase hydrogenation of maleic anhydride[J]. Industrial Catalysis, 2014, 22(2): 107-113.
[30]	WANG N, QIAN W Z, CHU W. Crystal-plane effect of nanoscale CeO2 on the catalytic performance of Ni/CeO2 catalysts for methane dry reforming[J]. Catal. Sci. Technol., 2016, 6(10): 3594-3605.
[31]	HARUTA M, TSUBOTA S, KOBAYASHI T, et al. Low-temperature oxidation of CO over gold supported on TiO2, α-Fe2O3, and Co3O4[J]. Journal of Catalysis, 1993, 144(1): 175-192.
[32]	KUNG H H, KUNG M C, COSTELLO C K. Supported Au catalysts for low temperature CO oxidation[J]. Journal of Catalysis, 2003, 216(1/2): 425-432.
[33]	KUN I, SZOLLOSI G, BARTOK M. Crotonaldehyde hydrogenation over clay-supported platinum catalysts[J]. Journal of Molecular Catalysis A: Chemical, 2001, 169: 235-246.
[34]	孙翠芝, 周仁贤. 乙醇水溶剂体系中Pt-CoZrO2催化剂上肉桂醛的选择加氢性能[J]. 高等学校化学学报. 2011, 32(7): 1551-1555.
	SUN C Z, ZHOU R X. Slective hydrogenation of cinnamaldehyde over Pt-CoZrO2 catalyst in the solvent system of ethanol/water[J]. Chemical Journal of Chinese Universities, 2011, 32(7): 1551-1555.
[35]	刘洪磊, 袁茂林, 郭彩虹, 等. Ru/ZrO2×xH2O催化剂催化肉桂醛选择性加氢制肉桂醇[J]. 催化学报, 2011, 32(7): 1256-1261.
	LIU H L, YUAN M L, GUO C H, et al. Slective hydrogenation of cinnamaldehyde to cinnamyl alcohol over Ru/ZrO2×xH2O catalyst[J]. Chinese Journal of Catalysis, 2011, 32(7): 1256-1261.

Selective hydrogenation of maleic anhydride over Ni/ZrO₂catalysts with ZrO₂ prepared by methanol thermal method

甲醇热制备四方相ZrO₂及其负载镍催化剂的顺酐加氢性能

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References 35

Related Articles 15

Recommended Articles 0

Metrics

Comments

[1]	Xuejin YANG, Jintao YANG, Ping NING, Fang WANG, Xiaoshuang SONG, Lijuan JIA, Jiayu FENG. Research progress in dry purification technology of highly toxic gas PH₃ [J]. CIESC Journal, 2023, 74(9): 3742-3755.
[2]	Yitong LI, Hang GUO, Hao CHEN, Fang YE. Study on operating conditions of proton exchange membrane fuel cells with non-uniform catalyst distributions [J]. CIESC Journal, 2023, 74(9): 3831-3840.
[3]	Jie CHEN, Yongsheng LIN, Kai XIAO, Chen YANG, Ting QIU. Study on catalytic synthesis of sec-butanol by tunable choline-based basic ionic liquids [J]. CIESC Journal, 2023, 74(9): 3716-3730.
[4]	Feifei YANG, Shixi ZHAO, Wei ZHOU, Zhonghai NI. Sn doped In₂O₃ catalyst for selective hydrogenation of CO₂ to methanol [J]. CIESC Journal, 2023, 74(8): 3366-3374.
[5]	Kaixuan LI, Wei TAN, Manyu ZHANG, Zhihao XU, Xuyu WANG, Hongbing JI. Design of cobalt-nitrogen-carbon/activated carbon rich in zero valent cobalt active site and application of catalytic oxidation of formaldehyde [J]. CIESC Journal, 2023, 74(8): 3342-3352.
[6]	Xin YANG, Xiao PENG, Kairu XUE, Mengwei SU, Yan WU. Preparation of molecularly imprinted-TiO₂ and its properties of photoelectrocatalytic degradation of solubilized PHE [J]. CIESC Journal, 2023, 74(8): 3564-3571.
[7]	Yajie YU, Jingru LI, Shufeng ZHOU, Qingbiao LI, Guowu ZHAN. Construction of nanomaterial and integrated catalyst based on biological template: a review [J]. CIESC Journal, 2023, 74(7): 2735-2752.
[8]	Yuming TU, Gaoyan SHAO, Jianjie CHEN, Feng LIU, Shichao TIAN, Zhiyong ZHOU, Zhongqi REN. Advances in the design, synthesis and application of calcium-based catalysts [J]. CIESC Journal, 2023, 74(7): 2717-2734.
[9]	Qiyu ZHANG, Lijun GAO, Yuhang SU, Xiaobo MA, Yicheng WANG, Yating ZHANG, Chao HU. Recent advances in carbon-based catalysts for electrochemical reduction of carbon dioxide [J]. CIESC Journal, 2023, 74(7): 2753-2772.
[10]	Pan LI, Junyang MA, Zhihao CHEN, Li WANG, Yun GUO. Effect of the morphology of Ru/α-MnO₂ on NH₃-SCO performance [J]. CIESC Journal, 2023, 74(7): 2908-2918.
[11]	Tan ZHANG, Guang LIU, Jinping LI, Yuhan SUN. Performance regulation strategies of Ru-based nitrogen reduction electrocatalysts [J]. CIESC Journal, 2023, 74(6): 2264-2280.
[12]	Chen WANG, Xiufeng SHI, Xianfeng WU, Fangjia WEI, Haohong ZHANG, Yin CHE, Xu WU. Preparation of Mn₃O₄ catalyst by redox method and study on its catalytic oxidation performance and mechanism of toluene [J]. CIESC Journal, 2023, 74(6): 2447-2457.
[13]	Yong LI, Jiaqi GAO, Chao DU, Yali ZHAO, Boqiong LI, Qianqian SHEN, Husheng JIA, Jinbo XUE. Construction of Ni@C@TiO₂ core-shell dual-heterojunctions for advanced photo-thermal catalytic hydrogen generation [J]. CIESC Journal, 2023, 74(6): 2458-2467.
[14]	Jipeng ZHOU, Wenjun HE, Tao LI. Reaction engineering calculation of deactivation kinetics for ethylene catalytic oxidation over irregular-shaped catalysts [J]. CIESC Journal, 2023, 74(6): 2416-2426.
[15]	Xiqing ZHANG, Yanting WANG, Yanhong XU, Shuling CHANG, Tingting SUN, Ding XUE, Lihong ZHANG. Effect of Mg content on isobutane dehydrogenation properties over nanosheets supported Pt-In catalysts [J]. CIESC Journal, 2023, 74(6): 2427-2435.