Effect of the morphology of Ru/α-MnO2 on NH3-SCO performance

doi:10.11949/0438-1157.20230420

Abstract

Abstract:

α-MnO₂ with different morphology, such as wire (w), tube (t) and rod (r) were synthesized as supports to prepare Ru/α-MnO₂, and the effects of support morphology on the ammonia selective catalytic oxidation (NH₃-SCO) were investigated. Meanwhile, the physical and chemical properties, redox properties and acidity of the catalysts were characterized by various methods. The exposed facet was closely related to the morphology of α-MnO₂, for (110), (310) and (200) crystal planes were observed on the wire-, tube-, and rod-α-MnO₂, respectively. The introduction of Ru improves the water resistance of the catalyst, and the tubular Ru/α-MnO₂ has a NH₃ conversion rate of 86% and a N₂ selectivity of 98% under water vapor conditions. The effects of Ru on NH₃-SCO activity performance was closely related to its effect on the surface acidity and redox property of α-MnO₂. The addition of Ru reduced the surface acid amount of α-MnO₂-w and thus lowered its activity, while the improved reducibility of Ru to α-MnO₂-r compensated for the decreasing in the surface acid amount. However, for Ru/α-MnO₂-t, the simultaneous increase in reducibility and surface acid amount by the presence of Ru was the main reason for the enhancement in NH₃-SCO activity.

Key words: catalyst, support, oxidation, NH₃ selective catalytic oxidation, morphologies of α-MnO₂, acidity, redox

摘要：

以具有不同形貌的线状（w）、管状（t）和棒状（r）的α-MnO₂为载体制备了Ru/α-MnO₂催化剂，考察了载体形貌对于氨选择性催化氧化（NH₃-SCO）反应性能的影响，并利用多种手段表征了催化剂的物化性质、氧化还原性能和酸性。α-MnO₂形貌影响所暴露的晶面；线状、纳米棒和管状α-MnO₂分别暴露（110）、（310）和（200）晶面。Ru的引入提高了催化剂的耐水性能，其中管状Ru/α-MnO₂在水汽条件下NH₃转化率为86%，N₂的选择性为98%。Ru的引入对反应性能的影响与其对α-MnO₂表面酸性、氧化还原性能的影响密切相关。Ru降低了α-MnO₂-w表面酸量导致其活性下降；Ru对于α-MnO₂-r氧化性能的提高弥补了其导致的表面酸量的降低；而Ru对α-MnO₂-t氧化性和酸量的同时促进是Ru/α-MnO₂-t反应性能提升的主要原因。

关键词: 催化剂, 载体, 氧化, 氨选择性催化氧化, α-MnO₂形貌, 酸性, 氧化还原性

CLC Number:

TQ 137.1

Pan LI, Junyang MA, Zhihao CHEN, Li WANG, Yun GUO. Effect of the morphology of Ru/α-MnO₂ on NH₃-SCO performance[J]. CIESC Journal, 2023, 74(7): 2908-2918.

李盼, 马俊洋, 陈志豪, 王丽, 郭耘. Ru/α-MnO₂催化剂形貌对NH₃-SCO反应性能的影响[J]. 化工学报, 2023, 74(7): 2908-2918.

Figures/Tables 15

Fig.1 NH3-SCO activity and by-products of Ru/α-MnO2

Table 1 The textural properties of α-MnO2 and Ru/α-MnO2

催化剂	Ru负载量^①/%	比表面积^②/（m²/g）	反应速率^③/（10⁷ mol/(g·s)）	活化能^④/（kJ/mol）
α-MnO₂-w	—	139	3.7	31.3
Ru/α-MnO₂-w	1.84	133	2.4	45.9
α-MnO₂-t	—	26	2.6	43.4
Ru/α-MnO₂-t	1.79	24	3.2	35.7
α-MnO₂-r	—	70	1.5	46.6
Ru/α-MnO₂-r	1.90	65	2.7	42.8

Fig.2 Stability of Ru/α-MnO2 with the presence of water

Fig.3 XRD patterns of α-MnO2 and Ru/α-MnO2

Fig.4 SEM,TEM and HR-TEM images of α-MnO2

Fig.5 SEM，TEM and HR-TEM images of Ru/α-MnO2

Fig.6 EDX-mapping of Ru/α-MnO2

Fig.7 Raman spectra of Ru/α-MnO2

Fig.8 Mn 2p3/2 XPS spectra of α-MnO2 and Ru/α-MnO2

Table 2 XPS data， H2 consumption and relative acidity of α-MnO2 and Ru/α-MnO2

催化剂	Ru⁴⁺/Ru^①	Mn³⁺/Mn^4+①	O_β/O_α^①	表面平均氧化态^②	实际耗氢量^③/(mmol/g)	相对酸浓度^④
α-MnO₂-w	—	1.93	0.24	3.51	8.57	2.9
Ru/α-MnO₂-w	0.64	1.81	0.21	3.35	8.51	0.1
α-MnO₂-t	—	1.78	0.22	3.68	9.77	0.4
Ru/α-MnO₂-t	0.65	1.86	0.24	3.33	9.83	1
α-MnO₂-r	—	1.71	0.20	3.72	9.83	2.2
Ru/α-MnO₂-r	0.61	1.83	0.23	3.58	10.41	0.9

Fig.9 O 1s XPS spectra of α-MnO2 and Ru/α-MnO2

Fig.10 Ru 3p XPS spectra of Ru/α-MnO2

Fig.11 H2-TPR profiles of α-MnO2 and Ru/α-MnO2

Fig.12 NH3-TPD profiles of α-MnO2 and Ru/α-MnO2

References 34

1	Chen Z, Bian C, Guo Y B, et al. Efficient strategy to regenerate phosphorus-poisoned Cu-SSZ-13 catalysts for the NH₃-SCR of NO _x : the deactivation and promotion mechanism of phosphorus[J]. ACS Catalysis, 2021, 11(21): 12963-12976.
2	Shao X Z, Wang H Y, Yuan M L, et al. Thermal stability of Si-doped V₂O₅/WO₃-TiO₂ for selective catalytic reduction of NO _x by NH₃ [J]. Rare Metals, 2019, 38: 292-298.
3	Oravisjärvi K, Timonen K L, Wiikinkoski T, et al. Source contributions to PM_2.5 particles in the urban air of a town situated close to a steel works[J]. Atmospheric Environment, 2003, 37(8): 1013-1022.
4	Wang H F, Murayama T, Lin M Y, et al. Understanding the distinct effects of Ag nanoparticles and highly dispersed Ag species on N₂ selectivity in NH₃-SCO reaction[J]. ACS Catalysis, 2022, 12(10): 6108-6118.
5	Wu P, Zhao S Q, Yu J W, et al. Effect of absorbed sulfate poisoning on the performance of catalytic oxidation of VOCs over MnO₂ [J]. ACS Applied Materials & Interfaces, 2020, 12(45): 50566-50572.
6	Yan G B, Lian Y B, Gu Y D, et al. Phase and morphology transformation of MnO₂ induced by ionic liquids toward efficient water oxidation[J]. ACS Catalysis, 2018, 8(11): 10137-10147.
7	Zhang J, Cao Y D, Wang C G, et al. Design and preparation of MnO₂/CeO₂-MnO₂ double-shelled binary oxide hollow spheres and their application in CO oxidation[J]. ACS Applied Materials & Interfaces, 2016, 8(13): 8670-8677.
8	Wang F, Dai H X, Deng J G, et al. Manganese oxides with rod-, wire-, tube-, and flower-like morphologies: highly effective catalysts for the removal of toluene[J]. Environmental Science & Technology, 2012, 46(7): 4034-4041.
9	李治东, 万佳琪, 刘莹, 等. 一步法合成α-MnO₂/β-MnO₂催化剂及其对甲苯催化氧化的性能研究[J]. 化工学报, 2022, 73(8): 3615-3624.
	Li Z D, Wan J Q, Liu Y, et al. α-MnO₂/β-MnO₂ catalysts synthesized by one-pot method and their catalytic performance for the oxidation of toluene[J]. CIESC Journal, 2022, 73(8): 3615-3624.
10	马俊洋, 刘丹丹, 王丽, 等. 不同晶相MnO₂催化剂的NH₃-SCO反应性能[J]. 稀有金属, 2021, 45(2): 177-186.
	Ma J Y, Liu D D, Wang L, et al. NH₃-SCO reaction performance of different crystal phase MnO₂ catalysts[J]. Chinese Journal of Rare Metals, 2021, 45(2): 177-186.
11	Jiang H X, Wang Y D, Zhou J L, et al. Morphology control of manganese-based catalysts for low-temperature selective catalytic reduction of NO _x [J]. Materials Letters, 2018, 233: 250-253.
12	Rong S P, Zhang P Y, Liu F, et al. Engineering crystal facet of α-MnO₂ nanowire for highly efficient catalytic oxidation of carcinogenic airborne formaldehyde[J]. ACS Catalysis, 2018, 8(4): 3435-3446.
13	Wang H, Xu D Y, Guan E J, et al. Atomically dispersed Ru on manganese oxide catalyst boosts oxidative cyanation[J]. ACS Catalysis, 2020, 10(11): 6299-6308.
14	Qin Y Z, Liu Y, Zhang Y Z, et al. Ru-substituted MnO₂ for accelerated water oxidation: the feedback of strain-induced and polymorph-dependent structural changes to the catalytic activity and mechanism[J]. ACS Catalysis, 2023, 13(1): 256-266.
15	Lin C, Li J L, Li X P, et al. In-situ reconstructed Ru atom array on α-MnO₂ with enhanced performance for acidic water oxidation[J]. Nature Catalysis, 2021, 4(12): 1012-1023.
16	Liu Y, Gu C S, Chen L G, et al. Ru-MnO _x interaction for efficient hydrodeoxygenation of levulinic acid and its derivatives[J]. ACS Applied Materials & Interfaces, 2023, 15(3): 4184-4193.
17	Duan X X, Zhao T, Niu B, et al. Simultaneously constructing active sites and regulating Mn—O strength of Ru-substituted perovskite for efficient oxidation and hydrolysis oxidation of chlorobenzene[J]. Advanced Science, 2023, 10(3): 2205054.
18	Xiao W, Xia H, Fuh J Y H, et al. Growth of single-crystal α-MnO₂ nanotubes prepared by a hydrothermal route and their electrochemical properties[J]. Journal of Power Sources, 2009, 193(2): 935-938.
19	Wang C, Sun L, Cao Q Q, et al. Surface structure sensitivity of manganese oxides for low-temperature selective catalytic reduction of NO with NH₃ [J]. Applied Catalysis B: Environmental, 2011, 101(3/4): 598-605.
20	Wu Y S, Li S, Cao Y, et al. Facile synthesis of mesoporous α-MnO₂ nanorod with three-dimensional frameworks and its enhanced catalytic activity for VOCs removal[J]. Materials Letters, 2013, 97: 1-3.
21	Wang H M, Ning P, Zhang Q L, et al. Effect of different RuO₂ contents on selective catalytic oxidation of ammonia over RuO₂-Fe₂O₃ catalysts[J]. Journal of Fuel Chemistry and Technology, 2019, 47(2): 215-223.
22	Sithambaram S, Nyutu E K, Suib S L. OMS-2 catalyzed oxidation of tetralin: a comparative study of microwave and conventional heating under open vessel conditions[J]. Applied Catalysis A: General, 2008, 348(2): 214-220.
23	Zhu C R, Yang L, Seo J K, et al. Self-branched α-MnO₂/δ-MnO₂ heterojunction nanowires with enhanced pseudocapacitance[J]. Materials Horizons, 2017, 4(3): 415-422.
24	Zhu L, Xu H X, Nan Y, et al. The synergistic effect between crystal planes and promoters on Ag-catalyzed ethylene epoxidation[J]. Applied Surface Science, 2019, 476: 115-122.
25	Kapteijn F, Vanlangeveld A D, Moulijn J A, et al. Alumina-supported manganese oxide catalysts[J]. Journal of Catalysis, 1994, 150(1): 94-104.
26	Hou J T, Liu L L, Li Y Z, et al. Tuning the K⁺ concentration in the tunnel of OMS-2 nanorods leads to a significant enhancement of the catalytic activity for benzene oxidation[J]. Environmental Science & Technology, 2013, 47(23): 13730-13736.
27	Hou J T, Li Y Z, Liu L L, et al. Effect of giant oxygen vacancy defects on the catalytic oxidation of OMS-2 nanorods[J]. Journal of Materials Chemistry A, 2013, 1(23): 6736-6741.
28	Jia J B, Zhang P Y, Chen L. The effect of morphology of α-MnO₂ on catalytic decomposition of gaseous ozone[J]. Catalysis Science & Technology, 2016, 6(15): 5841-5847.
29	Kang B, Jin X Y, Oh S M, et al. An effective way to improve bifunctional electrocatalyst activity of manganese oxide via control of bond competition[J]. Applied Catalysis B: Environmental, 2018, 236: 107-116.
30	Dai Y, Wang X Y, Dai Q G, et al. Effect of Ce and La on the structure and activity of MnO _x catalyst in catalytic combustion of chlorobenzene[J]. Applied Catalysis B: Environmental, 2012, 111/112: 141-149.
31	Lee S M, Lee H H, Hong S C. Influence of calcination temperature on Ce/TiO₂ catalysis of selective catalytic oxidation of NH₃ to N₂ [J]. Applied Catalysis A: General, 2014, 470: 189-198.
32	Wang C, Zhang C H, Hua W C, et al. Low-temperature catalytic oxidation of vinyl chloride over Ru modified Co₃O₄ catalysts[J]. RSC Advances, 2016, 6(101): 99577-99585.
33	Wang X, Xie Y C. The promotion effects of Ba on manganese oxide for CH₄ deep oxidation[J]. Catalysis Letters, 2001, 72(1): 51-57.
34	Gong P J, Xie J L, Fang D, et al. Effects of surface physicochemical properties on NH₃-SCR activity of MnO₂ catalysts with different crystal structures[J]. Chinese Journal of Catalysis, 2017, 38(11): 1925-1934.

[1]	Chao HU, Yuming DONG, Wei ZHANG, Hongling ZHANG, Peng ZHOU, Hongbin XU. Preparation of high-concentration positive electrolyte of vanadium redox flow battery by activating vanadium pentoxide with highly concentrated sulfuric acid [J]. CIESC Journal, 2023, 74(S1): 338-345.
[2]	Yitong LI, Hang GUO, Hao CHEN, Fang YE. Study on operating conditions of proton exchange membrane fuel cells with non-uniform catalyst distributions [J]. CIESC Journal, 2023, 74(9): 3831-3840.
[3]	Jie CHEN, Yongsheng LIN, Kai XIAO, Chen YANG, Ting QIU. Study on catalytic synthesis of sec-butanol by tunable choline-based basic ionic liquids [J]. CIESC Journal, 2023, 74(9): 3716-3730.
[4]	Yihao ZHANG, Zhenlei WANG. Fault detection using grouped support vector data description based on maximum information coefficient [J]. CIESC Journal, 2023, 74(9): 3865-3878.
[5]	Baiyu YANG, Yue KOU, Juntao JIANG, Yali ZHAN, Qinghong WANG, Chunmao CHEN. Chemical conversion of dissolved organic matter in petrochemical spent caustic along a wet air oxidation pretreatment process [J]. CIESC Journal, 2023, 74(9): 3912-3920.
[6]	Xuejin YANG, Jintao YANG, Ping NING, Fang WANG, Xiaoshuang SONG, Lijuan JIA, Jiayu FENG. Research progress in dry purification technology of highly toxic gas PH₃ [J]. CIESC Journal, 2023, 74(9): 3742-3755.
[7]	Xin YANG, Xiao PENG, Kairu XUE, Mengwei SU, Yan WU. Preparation of molecularly imprinted-TiO₂ and its properties of photoelectrocatalytic degradation of solubilized PHE [J]. CIESC Journal, 2023, 74(8): 3564-3571.
[8]	Linzheng WANG, Yubing LU, Ruizhi ZHANG, Yonghao LUO. Analysis on thermal oxidation characteristics of VOCs based on molecular dynamics simulation [J]. CIESC Journal, 2023, 74(8): 3242-3255.
[9]	Jintong LI, Shun QIU, Wenshou SUN. Oxalic acid and UV enhanced arsenic leaching from coal in flue gas desulfurization by coal slurry [J]. CIESC Journal, 2023, 74(8): 3522-3532.
[10]	Feifei YANG, Shixi ZHAO, Wei ZHOU, Zhonghai NI. Sn doped In₂O₃ catalyst for selective hydrogenation of CO₂ to methanol [J]. CIESC Journal, 2023, 74(8): 3366-3374.
[11]	Kaixuan LI, Wei TAN, Manyu ZHANG, Zhihao XU, Xuyu WANG, Hongbing JI. Design of cobalt-nitrogen-carbon/activated carbon rich in zero valent cobalt active site and application of catalytic oxidation of formaldehyde [J]. CIESC Journal, 2023, 74(8): 3342-3352.
[12]	Yajie YU, Jingru LI, Shufeng ZHOU, Qingbiao LI, Guowu ZHAN. Construction of nanomaterial and integrated catalyst based on biological template: a review [J]. CIESC Journal, 2023, 74(7): 2735-2752.
[13]	Bin LI, Zhenghu XU, Shuang JIANG, Tianyong ZHANG. Clean and efficient synthesis of accelerator CBS by hydrogen peroxide catalytic oxidation method [J]. CIESC Journal, 2023, 74(7): 2919-2925.
[14]	Yuming TU, Gaoyan SHAO, Jianjie CHEN, Feng LIU, Shichao TIAN, Zhiyong ZHOU, Zhongqi REN. Advances in the design, synthesis and application of calcium-based catalysts [J]. CIESC Journal, 2023, 74(7): 2717-2734.
[15]	Qiyu ZHANG, Lijun GAO, Yuhang SU, Xiaobo MA, Yicheng WANG, Yating ZHANG, Chao HU. Recent advances in carbon-based catalysts for electrochemical reduction of carbon dioxide [J]. CIESC Journal, 2023, 74(7): 2753-2772.

Effect of the morphology of Ru/α-MnO₂ on NH₃-SCO performance

Ru/α-MnO₂催化剂形貌对NH₃-SCO反应性能的影响

RichHTML

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 15

References 34

Related Articles 15

Recommended Articles 0

Metrics

Comments