石英砂滤料表面干法改性制备疏水性除油滤料

doi:10.11949/j.issn.0438-1157.20151397

化工学报 ›› 2016, Vol. 67 ›› Issue (5): 2101-2108.DOI: 10.11949/j.issn.0438-1157.20151397

石英砂滤料表面干法改性制备疏水性除油滤料

刘光, 未碧贵, 武福平, 常青

兰州交通大学环境与市政工程学院, 甘肃兰州 730070

收稿日期:2015-09-06 修回日期:2015-12-03 出版日期:2016-05-05 发布日期:2016-05-05
通讯作者: 未碧贵
基金资助:
甘肃省自然科学基金项目(1014RJZA041);兰州交通大学青年科学基金项目(2012009)。

Hydrophobic oil filter prepared by dry surface modification of quartz sand

LIU Guang, WEI Bigui, WU Fuping, CHANG Qing

School of Environmental and Municipal Engineering, Lanzhou Jiaotong University, Lanzhou 730070, Gansu, China

Received:2015-09-06 Revised:2015-12-03 Online:2016-05-05 Published:2016-05-05
Supported by:
supported by the Natural Science Foundation of Gansu Province (1014RJZA041) and the Young Scholars Science Foundation of Lanzhou Jiaotong University (2012009).

摘要/Abstract

摘要：

采用钛酸酯偶联剂DN101对石英砂滤料进行表面干法改性,增强滤料的亲油疏水性。通过单因素实验研究改性时间、DN101浓度以及改性温度对改性效果的影响,并以亲油亲水比LHR作为评判改性效果的标准。结果表明,反应时间为70 min、DN101用量为1.2%、反应温度为60℃时,DN101干法改性石英砂效果最好,LHR值由未改性时的1.25提高到最大值11.1;改性石英砂对15.61 mg·L^-1含油废水的吸附容量由未改性时的0.17 mg·g^-1增大到0.25 mg·g^-1;对17.3 mg·L^-1含油废水的过滤去除率由未改性时的72.6%提高到97.8%。扫描电镜、电子能谱和红外光谱分析结果表明,DN101以化学键的方式与石英砂表面官能团结合,对石英砂形成了均匀稳定的包覆层。

关键词: 石英砂, 界面张力, 干法改性, 过滤, 石油, 废水, 疏水性

Abstract:

The surface of quartz sand was modified by a dry method using Titanate coupling agent DN101 to improve the hydrophobic property of oil filter. The effects of reaction time, dosage of Titanate coupling agent DN101 and reaction temperature on the performance of the oil filter were studied by single factor experiment. The results show that the quartz sand modified by dry process using DN101 exhibits the best performance when the reaction time is 70 min, DN101 dosage 1.2% and reaction temperature 60℃. Lipophilic-Hydrophilic Ratio (LHR) increases from 1.25 to 11.1, the adsorption capacity has great improvement from 0.17 mg·g^-1 to 0.25 mg·g^-1 for 15.61 mg·L^-1 oily wastewater and the oil removal rate of the modified quartz sand filter improves from 72.6% to 97.8% for 17.3 mg·L^-1 oily wastewater. The analysis by SEM, XPS and FTIR shows that the chemical bonding combination of DN101 with the functional groups on quartz sand surface forms a uniform and stable cladding layer on the surface of quartz sand.

Key words: quartz sand, interfacial tension, dry process modification, filtration, petroleum, wastewater, hydrophobic

中图分类号:

X703.1

刘光, 未碧贵, 武福平, 常青. 石英砂滤料表面干法改性制备疏水性除油滤料[J]. 化工学报, 2016, 67(5): 2101-2108.

LIU Guang, WEI Bigui, WU Fuping, CHANG Qing. Hydrophobic oil filter prepared by dry surface modification of quartz sand[J]. CIESC Journal, 2016, 67(5): 2101-2108.

参考文献 29

[1]	ZHOU Y B, TANG X Y, XU Y X, et al. Effect of quaternary ammonium surfactant modification on oil removal capability of polystyrene resin [J]. Separation and Purification Technology, 2010, 75 (3): 266-272.
[2]	MUELLER J, CEN Y W, DAVIS R H. Crossflow microfiltration of oily water [J]. Journal of Membrane Science, 1997, 129 (2): 221-235.
[3]	TAKAHASHI T, MIYAHARA T, NISHIZAKI Y. Separation of oily water by bubble column [J]. Journal of Chemical Engineering of Japan, 1979, 12 (5): 394-399.
[4]	LIM T T, HUANG X F. Evaluation of hydrophobicity/oleophilicity of kapok and its performance in oily water filtration: comparison of raw and solvent-treated fibers [J]. Industrial Crops and Products, 2007, 26 (2): 125-134.
[5]	LECOANET H F, WIESNER M R. Velocity effects on fullerene and oxide nanoparticle deposition in porous media [J]. Environmental Science and Technology, 2004, 38 (16): 4377-4382.
[6]	RIBEIROA T H, RUBIOA J, SMITH R W. A dried hydrophobic aquaphyte as an oil filter for oil/water emulsions [J]. Spill Science and Technology Bulletin, 2003, 8 (5/6): 483-489.
[7]	WANG C X, MAO H Y, WANG C X, et al. dispersibility and hydrophobicity analysis of titanium dioxide nanoparticles grafted with silane coupling agent [J].Industrial and Engineering Chemistry Research, 2011, 50 (21): 11930-11934.
[8]	CHENG G J, TONG B, TANG Z F, et al. Surface functionalization of coal powder with different coupling agents for potential applications in organic materials [J]. Applied Surface Science, 2014, 313 (15): 954-960.
[9]	LI Z W, ZHU Y F. Surface-modification of SiO2 nanoparticles with oleic acid [J]. Applied Surface Science, 2003, 211 (1/2/3/4): 315-320.
[10]	PARK B J, LEE J Y, SUNG J H, et al. Microcapsules containing electrophoretic suspension of TiO2 modified with poly(methyl methacrylate) [J]. Current Applied Physics, 2006, 6 (4): 632-635.
[11]	FUJI M, TAKEI T, WATANABE T, et al. Wettability of fine silica powder surfaces modified with several normal alcohols [J]. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 1999, 154 (1/2): 13-24.
[12]	郑水林, 王彩丽. 粉体表面改性 [M]. 3版. 北京: 中国建材工业出版社, 2011: 28-30. ZHENG S L, WANG C L. Powder Surface Modification [M]. 3rd ed. Beijing: China Building Materials Press, 2011: 28-30.
[13]	包彩霞, 未碧贵, 常青. 硅烷偶联剂对石英砂滤料的表面改性 [J]. 中国环境科学, 2013, 33 (5): 848-853. BAO C X, WEI B G, CHANG Q. Silane coupling agent for surface modification of quartz sand filter medium [J]. China Environmental Science, 2013, 33 (5): 848-853.
[14]	WEI B G, CHANG Q, BAO C X, et al. Surface modification of filter medium particles with silane coupling agent KH550 [J]. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2013, 434 (5): 276-280.
[15]	包彩霞. 滤料表面改性与含油废水处理的研究 [D]. 兰州: 兰州交通大学, 2013. BAO C X. Study on treatment of oily wastewater and filter surface modification [D]. Lanzhou: Lanzhou Jiaotong University, 2013.
[16]	未碧贵. 滤料表面湿润性的研究及其对除油性能的影响 [D]. 兰州:兰州交通大学, 2009. WEI B G. The study of wettability of filter media and influence on oil-removal performance [D]. Lanzhou:Lanzhou Jiaotong University, 2009.
[17]	杨斌武, 常青, 何超. 毛细上升法研究水处理滤料的表面热力学特性 [J]. 化工学报, 2007, 58 (2): 269-275. YANG B W, CHANG Q, HE C. Capillary rise for thermodynamic characterization of wastewater treatment filter media [J]. Journal of Chemical Industry and Engineering (China), 2007, 58 (2): 269-275.
[18]	YANG B W, CHANG Q. Wettability studies of filter media using capillary rise test [J]. Separation and Purification Technology, 2008, 60 (3): 335-340.
[19]	YANG B W, CHANG Q, HE C, et al. Wettability study of mineral wastewater treatment filter media [J]. Chemical Engineering and Processing: Process Intensification, 2007, 46 (10): 975-981.
[20]	包彩霞, 未碧贵, 常青. 石英砂滤料表面润湿改性 [J]. 环境工程学报, 2014, 8 (5): 1915-1920. BAO C X, WEI B G, CHANG Q. Surface modification of quartz sand filter for wetting property [J]. Chinese Journal of Environmental Engineering, 2014, 8 (5): 1915-1920.
[21]	LIN C Y, CHEN L W. Emulsification characteristics of three-and two-phase emulsions prepared by the ultrasonic emulsification method [J]. Fuel Processing Technology, 2006, 87 (4): 309-317.
[22]	缪旭光, 倪小红, 袁武建, 等. 正己烷萃取-紫外分光光度法测定矿井水中微量油 [J]. 煤矿环境保护, 2001, 15 (1): 21-23. MIAO X H, NI X H, YUAN W J, et al. Determination of trace oil in mine drainage by ultraviolet spectrophotometry with n-hexane extraction [J].Coal Mine Environmental Protection, 2001, 15 (1): 21-23.
[23]	邓慧萍, 徐迪民, 易小萍, 等. 几种改性滤料去除水中有机物的性能比较 [J]. 同济大学学报, 2001, 29 (4): 444-447. DENG H P, XU D M, YI X P, et al. Study on removal of organic matter by preparing coated media [J]. Journal of Tongji University, 2001, 29 (4): 444-447.
[24]	吕建波. 改性滤料高速过滤技术用于再生水生产的研究 [D]. 天津: 天津大学, 2009. LÜ J B. The research on enhanced high-rate filtration technology for wastewater reuse using metal-oxides-coated sand filter media [D]. Tianjin: Tianjin University, 2009.
[25]	蒋建平, 陈小文, 贾欣茹. 单烷氧基钛酸酯偶联剂在涂料中的应用 [J]. 中国涂料, 2006, 12 (6): 35-51. JIANG J P, CHEN X W, JIA X R. Monoalkoxy-titanate coupling agent application in paint [J]. China Coatings, 2006, 12 (6): 35-51.
[26]	YANG X L, ZHAO N, ZHOU Q Z, et al. Facile preparation of hollow amino-functionalized organosilica microspheres by a template-free method [J]. Journal of Materials Chemistry, 2012, 22 (34): 18010-18017.
[27]	BAO N, WU G L, NIU J J, et al. Wide spectral response and enhanced photocatalytic activity of TiO2 continuous fibers modified with aminosilane coupling agents [J]. Journal of Alloys and Compounds, 2014, 599 (25): 40-48.
[28]	CHEN Q F, SHI W M, XU Y, et al. Visible-light-responsive Ag-Si codoped anatase TiO2 photocatalyst with enhanced thermal stability [J]. Materials Chemistry and Physics, 2011, 125 (3): 825-832.
[29]	西尔弗斯坦. 有机化合物的波谱解析 [M]. 上海: 华东理工大学出版社, 2007: 71-130. SILVERSTEIN R M. Spectrometric Identification of Organic Compounds [M]. Shanghai: East China University of Science and Technology Press, 2007: 71-130.

石英砂滤料表面干法改性制备疏水性除油滤料

Hydrophobic oil filter prepared by dry surface modification of quartz sand

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 29

相关文章 15

编辑推荐

Metrics

本文评价

[1]	吴馨, 龚建英, 靳龙, 王宇涛, 黄睿宁. 超声波激励下铝板表面液滴群输运特性的研究[J]. 化工学报, 2023, 74(S1): 104-112.
[2]	吴延鹏, 李晓宇, 钟乔洋. 静电纺丝纳米纤维双疏膜油性细颗粒物过滤性能实验分析[J]. 化工学报, 2023, 74(S1): 259-264.
[3]	杨百玉, 寇悦, 姜峻韬, 詹亚力, 王庆宏, 陈春茂. 炼化碱渣湿式氧化预处理过程DOM的化学转化特征[J]. 化工学报, 2023, 74(9): 3912-3920.
[4]	林典, 江国梅, 徐秀彬, 赵波, 刘冬梅, 吴旭. 硅基类液防原油黏附涂层的研制及其减阻性能研究[J]. 化工学报, 2023, 74(8): 3438-3445.
[5]	刘爽, 张霖宙, 许志明, 赵锁奇. 渣油及其组分黏度的分子层次组成关联研究[J]. 化工学报, 2023, 74(8): 3226-3241.
[6]	杨欣, 彭啸, 薛凯茹, 苏梦威, 吴燕. 分子印迹-TiO₂光电催化降解增溶PHE废水性能研究[J]. 化工学报, 2023, 74(8): 3564-3571.
[7]	张艳梅, 袁涛, 李江, 刘亚洁, 孙占学. 高效SRB混合菌群构建及其在酸胁迫条件下的性能研究[J]. 化工学报, 2023, 74(6): 2599-2610.
[8]	张兰河, 赖青燚, 王铁铮, 关潇卓, 张明爽, 程欣, 徐小惠, 贾艳萍. H₂O₂对SBR脱氮效率和污泥性能的影响[J]. 化工学报, 2023, 74(5): 2186-2196.
[9]	李正涛, 袁志杰, 贺高红, 姜晓滨. 疏水界面上的NaCl液滴蒸发过程内环流调控机制研究[J]. 化工学报, 2023, 74(5): 1904-1913.
[10]	王晓萱, 胡晓红, 陆雨楠, 王士勇, 凡凤仙. 旋转膜过滤器内部流动特性数值模拟[J]. 化工学报, 2023, 74(4): 1489-1498.
[11]	闫新龙, 黄志刚, 胡清勋, 张新, 胡晓燕. Cu/Co掺杂多孔炭活化过硫酸盐降解水中硝基酚研究[J]. 化工学报, 2023, 74(3): 1102-1112.
[12]	刘海芹, 李博文, 凌喆, 刘亮, 俞娟, 范一民, 勇强. 羟基-炔点击化学改性半乳甘露聚糖薄膜的制备及性能研究[J]. 化工学报, 2023, 74(3): 1370-1378.
[13]	张家庆, 蒋榕培, 史伟康, 武博翔, 杨超, 刘朝晖. 煤基/石油基火箭煤油高参数黏温特性与组分特性研究[J]. 化工学报, 2023, 74(2): 653-665.
[14]	黄宽, 马永德, 蔡镇平, 曹彦宁, 江莉龙. 油脂催化加氢转化制备第二代生物柴油研究进展[J]. 化工学报, 2023, 74(1): 380-396.
[15]	范怡平, 卢春喜. 离心力场-移动床耦合气固分离装备的研究进展[J]. 化工学报, 2023, 74(1): 157-169.