微碱强化超临界法制备生物柴油组分分析及工艺过程

doi:10.3969/j.issn.0438-1157.2013.02.037

化工学报 ›› 2013, Vol. 64 ›› Issue (2): 683-688.DOI: 10.3969/j.issn.0438-1157.2013.02.037

微碱强化超临界法制备生物柴油组分分析及工艺过程

高艺霞, 闫理宾, 辛忠

华东理工大学化学工程联合国家重点实验室,上海200237

收稿日期:2012-07-17 修回日期:2012-09-18 出版日期:2013-02-05 发布日期:2013-02-05
通讯作者: 辛忠
作者简介:高艺霞(1981—),女,博士研究生。
基金资助:
国家高技术研究发展计划项目(2009AA05Z404);吉林燃料乙醇有限公司资助项目。

Component confirmation and process of biodiesel produced in supercritical conditions with addition of tiny KOH

GAO Yixia, YAN Libin, XIN Zhong

State Key Laboratory of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, China

Received:2012-07-17 Revised:2012-09-18 Online:2013-02-05 Published:2013-02-05
Supported by:
supported by the High-tech Research and Development Program of China(2009AA05Z404) and Jilin Fuel Alcohol Company Limited.

摘要/Abstract

摘要： 对超临界条件下添加微量氢氧化钾催化碳酸二甲酯与棕榈油制备无甘油副产的生物柴油反应进行了研究,微碱的添加有效降低了苛刻的反应条件。利用气质联用技术对反应产物的组分进行了定性确证并建立了产物的定量分析方法。结果表明,酯交换反应的产物组分为甘油碳酸酯、脂肪酸甲酯、甘油单酯、脂肪酸甘油碳酸酯、甘油二酯和甘油三酯。考察了反应温度、反应时间、酯油摩尔比以及催化剂添加量对酯交换反应的影响。当反应温度280℃、反应时间20 min、KOH添加量为0.1%、酯油摩尔比20:1、反应压力3.5MPa时,脂肪酸甲酯的收率可达到83.11%。

关键词: 生物柴油, 超临界, 酯交换, 甘油

Abstract: Production of biodiesel without byproduct glycerol using tiny KOH as catalyst from dimethyl carbonate and palm oil in supercritical conditions was carried out.The catalyst tiny KOH increased reaction rates while less severe supercritical reaction conditions could be employed.All components of reaction product were confirmed by GC and GC-MS analysis.Effects of temperature, time, mass ratio of KOH to palm oil and mole ratio of DMC to palm oil on transesterification reaction were investigated.The optimal conditions of transesterification are temperature 280℃, time 20 min, n(DMC):n(oil)=20:1 and m(KOH):m(oil)=0.1%, and at these conditions FAME yield was 83.11%.

Key words: biodiesel, supercritical method, transesterification, glycerol

中图分类号:

高艺霞, 闫理宾, 辛忠. 微碱强化超临界法制备生物柴油组分分析及工艺过程[J]. 化工学报, 2013, 64(2): 683-688.

GAO Yixia, YAN Libin, XIN Zhong. Component confirmation and process of biodiesel produced in supercritical conditions with addition of tiny KOH[J]. CIESC Journal, 2013, 64(2): 683-688.

参考文献 20

[1]	Samart C, Chaiya C, Reubroycharoen P.Biodiesel production by methanolysis of soybean oil using calcium supported on mesoporous silica catalyst[J].Energy Conversion and Management, 2010, 51(7):1428-1431
[2]	Liu X J, Piao X L, Wang Y J,Zhu S L, He H Y.Calcium methoxide as a solid base catalyst for the transesterification of soybean oil to biodiesel with methanol[J].Fuel, 2008, 87(7):1076-1082
[3]	Nie K, Xie F, Wang F, Tan T W.Lipase catalyzed methanolysis to produce biodiesel:optimization of the biodiesel production[J].Journal of Molecular Catalysis B:Enzymatic, 2006, 43(1/2/3/4):142-147
[4]	Chen X, Du W, Liu D H.Lipase-mediated methanolysis of soybean oils for biodiesel production[J].Journal of Chemical Technology and Biotechnology, 2008, 83(1):71-76
[5]	Fabbri D, Bevoni V, Notari M, Rivetti F.Properties of a potential biofuel obtained from soybean oil by transmethylation with dimethyl carbonate[J].Fuel, 2007, 86(5/6):690-697
[6]	Zhang L P, Sheng B Y, Xin Z, Liu Q, Sun S Z.Kinetics of transesterification of palm oil and dimethyl carbonate for biodiesel production at the catalysis of heterogeneous base catalyst[J].Bioresource Technology, 2010, 101(21):8144-8150
[7]	Zhang L P, Sun S Z, Xin Z, Sheng B Y, Liu Q.Synthesis and component confirmation of biodiesel from palm oil and dimethyl carbonate catalyzed by immobilized-lipase in solvent-free system[J].Fuel, 2010,89(12):3960-3965
[8]	Ilham Z, Saka S.Dimethyl carbonate as potential reactant in non-catalytic biodiesel production by supercritical method[J].Bioresource Technology, 2009, 100(5):1793-1796
[9]	Ilham Z, Saka S.Two-step supercritical dimethyl carbonate method for biodiesel production from Jatropha curcas oil[J].Bioresource Technology, 2010, 101(8):2735-2740
[10]	Saka S, Isayama Y.A new process for catalyst-free production of biodiesel using supercritical methyl acetate[J].Fuel, 2009, 88(7):1307-1313
[11]	Yin J Z, Xiao M, Song J B.Biodiesel from soybean oil in supercritical methanol with co-solvent[J].Energy Conversion and Management, 2008, 49(5):908-912
[12]	Trentin C M, Lima A P, Alkimim I P, Silva C D, Castilhos F D, Mazutti M A, Oliveira J V.Continuous catalyst-free production of fatty acid ethyl esters from soybean oil in microtube reactor using supercritical carbon dioxide as co-solvent[J].The Journal of Supercritical Fluids, 2011, 56(3):283-291
[13]	Wang Guanghui(王光辉), Xiong Shaoxiang(熊少祥).Organic Spectrum Analytical(有机质谱解析)[M].Beijing:Chemical Industry Press, 2005:107-108
[14]	Zhang Hua(张华), Peng Qinji(彭勤纪), Li Yaming(李亚明), Zhang Rong(张蓉).Modern Organic Spectrum Analysis(现代有机波谱分析)[M].Beijing:Chemical Industry Press, 2005:52
[15]	Zhang Liping(张丽平).Study on the preparation of biodiesel at the catalysis of heterogeneous catalysts.Shanghai:East China University of Science and Technology, 2010
[16]	Oehlenschlger J, Gercken G.Synthesis and mass spectrometry of 1-acyl and 3-acyl-sn-glycerol carbonates[J].Lipids, 1978, 13(8):557-562
[17]	EN 14106—2009 Fat and oil derivatives.Fatty acid methyl esters(FAME).Determination of free and total glycerol and mono-, di-, triglyceride contents[S]
[18]	SNT 1945—2007 Determination of trans fatty acids in foods—capillary gas chromatography[S]
[19]	Zhao Anmin(赵安民), Wang Cunwen(王存文), Wang Tielin(汪铁林), Wang Weiguo(王为国),Zhang Junfeng(张俊峰).Weak acid intensification for continuous synthesis of biodiesel by supercritical methanol method[J].Chemical Engineering(China)(化学工程), 2009, 37(9):52-55
[20]	Bernard F, Royden O B.Transesterification kinetics of soybean oil[J].J.Am.Oil Chem.Soc., 1986, 63(10):1375-1380

微碱强化超临界法制备生物柴油组分分析及工艺过程

Component confirmation and process of biodiesel produced in supercritical conditions with addition of tiny KOH

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[2]	陈杰, 林永胜, 肖恺, 杨臣, 邱挺. 胆碱基碱性离子液体催化合成仲丁醇性能研究[J]. 化工学报, 2023, 74(9): 3716-3730.
[3]	陈哲文, 魏俊杰, 张玉明. 超临界水煤气化耦合SOFC发电系统集成及其能量转化机制[J]. 化工学报, 2023, 74(9): 3888-3902.
[4]	洪瑞, 袁宝强, 杜文静. 垂直上升管内超临界二氧化碳传热恶化机理分析[J]. 化工学报, 2023, 74(8): 3309-3319.
[5]	涂玉明, 邵高燕, 陈健杰, 刘凤, 田世超, 周智勇, 任钟旗. 钙基催化剂的设计合成及应用研究进展[J]. 化工学报, 2023, 74(7): 2717-2734.
[6]	董明, 徐进良, 刘广林. 超临界水非均质特性分子动力学研究[J]. 化工学报, 2023, 74(7): 2836-2847.
[7]	李艳辉, 丁邵明, 白周央, 张一楠, 于智红, 邢利梅, 高鹏飞, 王永贞. 非常规服役超临界锅炉的微纳尺度腐蚀动力学模型建立及应用[J]. 化工学报, 2023, 74(6): 2436-2446.
[8]	姚晓宇, 沈俊, 李健, 李振兴, 康慧芳, 唐博, 董学强, 公茂琼. 流体气液临界参数测量方法研究进展[J]. 化工学报, 2023, 74(5): 1847-1861.
[9]	朱兵国, 何吉祥, 徐进良, 彭斌. 冷却条件下渐扩/渐缩管内超临界压力二氧化碳的传热特性[J]. 化工学报, 2023, 74(3): 1062-1072.
[10]	戚新刚, 路利波, 陈渝楠, 葛志伟, 郭烈锦. 造纸黑液超临界水气化制氢与高附加值化学品回收研究进展[J]. 化工学报, 2022, 73(8): 3338-3354.
[11]	潘多涛, 王旭东, 史洪岩, 修志龙. 生物基1， 3-丙二醇连续发酵过程的稳态分析与反馈控制[J]. 化工学报, 2022, 73(5): 2094-2100.
[12]	张家仁, 刘海超. 大豆油与甲醇酯交换反应体系的相平衡研究[J]. 化工学报, 2022, 73(5): 1920-1929.
[13]	李梦雨, 王冬祥, 郑晓阳, 徐桂转, 杜朝军, 常春. 粗甘油生物基聚氨酯材料的制备及吸附性能研究[J]. 化工学报, 2022, 73(5): 2270-2278.
[14]	许婉婷, 许波, 王鑫, 陈振乾. 方形微通道内超临界CO₂流动换热特性研究[J]. 化工学报, 2022, 73(4): 1534-1545.
[15]	黄志豪, 李光熙, 唐桂华, 李小龙, 范元鸿. 单侧加热方形通道内超临界水传热研究[J]. 化工学报, 2022, 73(4): 1523-1533.