部分氧化对焦油模型化合物苯酚转化的机理

doi:10.3969/j.issn.0438-1157.2013.10.041

化工学报 ›› 2013, Vol. 64 ›› Issue (10): 3790-3796.DOI: 10.3969/j.issn.0438-1157.2013.10.041

部分氧化对焦油模型化合物苯酚转化的机理

赵善辉, 罗永浩, 苏毅, 吴文广, 刘春元

上海交通大学热能工程研究所, 上海 200240

收稿日期:2012-11-29 修回日期:2013-07-06 出版日期:2013-10-05 发布日期:2013-10-05
通讯作者: 罗永浩
作者简介:赵善辉(1987-),男,博士研究生。
基金资助:
国家自然科学基金项目(51176120)

Reaction mechanism for partial oxidation of biomass tar

ZHAO Shanhui, LUO Yonghao, SU Yi, WU Wenguang, LIU Chunyuan

Institute of Thermal Engineering, Shanghai Jiao Tong University, Shanghai 200240, China

Received:2012-11-29 Revised:2013-07-06 Online:2013-10-05 Published:2013-10-05
Supported by:
supported by the National Natural Science Foundation of China(51176120).

摘要/Abstract

摘要： 基于Richter等提出的碳氢化合物燃烧的详细反应机理,结合生物质气化焦油的部分氧化脱除方法,建立了生物质部分氧化的详细反应机理。与Jess的实验比较,验证了模型的准确性。计算了以苯酚为焦油模型化合物在过量空气系数ER=0～0.2条件下的转化,表明氧气的加入提高了焦油的转化率和反应速率。适量的氧气能提高部分氧化的可燃气体的产率。基于ROP分析得到典型PAHs的生成率,结果表明环戊二烯基对于PAHs的形成和成长有重要的促进作用,活性OH和H自由基在焦油裂解为小分子过程中起主要作用。

关键词: 焦油, 详细反应机理, 部分氧化, 模型, 自由基

Abstract: By combining the detailed reaction mechanism proposed by Richter et al. for hydrocarbon combustion and the removal methods of tar oil from biomass gasification by partial oxidation,a detailed reaction mechanism was put forward for partial oxidation of biomass tar.A comparison with the experiment results obtained by Jess confirmed the model's rationality and accuracy.Phenol that was chosen as a model component for biomass tar was converted i.e.partial combustion at condition of ER=0—0.2.The results show that oxygen can promote conversion of tar oil and its reaction rate,and proper oxygen content leads to higher production of combustible gases.Based on typical PAHs production rates obtained by ROP analysis it is found that cyclopentadiene plays an important role in the formation and growing of PAHs and active radicals such as H and OH promote tar cracking.

Key words: tar, detailed reaction mechanism, partial oxidation, model, radical

中图分类号:

TQ018

赵善辉, 罗永浩, 苏毅, 吴文广, 刘春元. 部分氧化对焦油模型化合物苯酚转化的机理[J]. 化工学报, 2013, 64(10): 3790-3796.

ZHAO Shanhui, LUO Yonghao, SU Yi, WU Wenguang, LIU Chunyuan. Reaction mechanism for partial oxidation of biomass tar[J]. CIESC Journal, 2013, 64(10): 3790-3796.

参考文献 14

[1]	Han J,Kim H.The reduction and control technology of tar during biomass gasification/pyrolysis:an overview[J].Renewable and Sustainable Energy Reviews,2008,12(2):397-416
[2]	Liu Yu(柳宇),Xu Guiying(许桂英),Song Jianfei(宋健斐),Wu Guiying(吴桂英),Sun Guogang(孙国刚).Effect of petroleum coke on tar cracking in biomass gasification process[J].CIESC Journal(化工学报),2010,61 (9):2494-2498
[3]	Houben M P,de Lange H C,van Steenhoven A A.Tar reduction through partial combustion of fuel gas[J].Fuel,2005,84(7/8):817-824
[4]	Brandt P,Larsen E,Henriksen U.High tar reduction in a two-stage gasifier[J].Energy & Fuels,2000,14(4):816-819
[5]	Jensen P A,Haahr Joergensen K.Tar reduction by partial oxidation[J].Proceedings of the 9th European Bioenergy Conference,1996,12(31):356
[6]	Norinaga K,Hayashi J I.Numerical simulation of the partial oxidation of hot coke oven gas with a detailed chemical kinetic model[J].Energy & Fuels,2009,24(1):165-172
[7]	Norinaga K,Yatabe H,Matsuoka M,Hayashi J I.Application of an existing detailed chemical kinetic model to a practical system of hot coke oven gas reforming by noncatalytic partial oxidation[J].Industrial & Engineering Chemistry Research,2010, 49(21):10565-10571
[8]	Norinaga K,Sakurai Y,Sato R,Hayashi J I.Numerical simulation of thermal conversion of aromatic hydrocarbons in the presence of hydrogen and steam using a detailed chemical kinetic model[J].Chemical Engineering Journal,2011,178:282-290
[9]	Richter H,Granata S,Green W H,Howard J B.Detailed modeling of PAH and soot formation in a laminar premixed benzene/oxygen/argon low-pressure flame[J].Proceedings of the Combustion Institute,2005,30(1):1397-1405
[10]	Wang H,Frenklach M.A detailed kinetic modeling study of aromatics formation in laminar premixed acetylene and ethylene flames[J].Combustion and Flame,1997,110(1/2):173-221
[11]	Jess A.Mechanisms and kinetics of thermal reactions of aromatic hydrocarbons from pyrolysis of solid fuels[J].Fuel,1996,75(12):1441-1448
[12]	Chen Y,Duan J,Luo Y H.Investigation of agricultural residues pyrolysis behavior under inert and oxidative conditions[J].Journal of Analytical and Applied Pyrolysis,2008,83(2):165-174
[13]	Chen Y,Luo Y H,Wu W G,Su Y.Experimental investigation on tar formation and destruction in a lab-scale two-stage reactor[J].Energy & Fuels,2009,23(9):4659-4667
[14]	Frenklach M.On the driving force of PAH production[J].Symposium(International)on Combustion,1989,22(1):1075-1082

[1]	宋嘉豪, 王文. 斯特林发动机与高温热管耦合运行特性研究[J]. 化工学报, 2023, 74(S1): 287-294.
[2]	连梦雅, 谈莹莹, 王林, 陈枫, 曹艺飞. 地下水预热新风一体化热泵空调系统制热性能研究[J]. 化工学报, 2023, 74(S1): 311-319.
[3]	金正浩, 封立杰, 李舒宏. 氨水溶液交叉型再吸收式热泵的能量及分析[J]. 化工学报, 2023, 74(S1): 53-63.
[4]	王浩, 王振雷. 基于自适应谱方法的裂解炉烧焦模型化简策略[J]. 化工学报, 2023, 74(9): 3855-3864.
[5]	李科, 文键, 忻碧平. 耦合蒸气冷却屏的真空多层绝热结构对液氢储罐自增压过程的影响机制研究[J]. 化工学报, 2023, 74(9): 3786-3796.
[6]	于旭东, 李琪, 陈念粗, 杜理, 任思颖, 曾英. 三元体系KCl + CaCl₂ + H₂O 298.2、323.2及348.2 K相平衡研究及计算[J]. 化工学报, 2023, 74(8): 3256-3265.
[7]	诸程瑛, 王振雷. 基于改进深度强化学习的乙烯裂解炉操作优化[J]. 化工学报, 2023, 74(8): 3429-3437.
[8]	闫琳琦, 王振雷. 基于STA-BiLSTM-LightGBM组合模型的多步预测软测量建模[J]. 化工学报, 2023, 74(8): 3407-3418.
[9]	李锦潼, 邱顺, 孙文寿. 煤浆法烟气脱硫中草酸和紫外线强化煤砷浸出过程[J]. 化工学报, 2023, 74(8): 3522-3532.
[10]	郭雨莹, 敬加强, 黄婉妮, 张平, 孙杰, 朱宇, 冯君炫, 陆洪江. 稠油管道水润滑减阻及压降预测模型修正[J]. 化工学报, 2023, 74(7): 2898-2907.
[11]	何晓崐, 刘锐, 薛园, 左然. MOCVD生长AlN单晶薄膜的气相和表面化学反应综述[J]. 化工学报, 2023, 74(7): 2800-2813.
[12]	刘春雨, 周桓宇, 马跃, 岳长涛. CaO调质含油污泥干燥特性及数学模型[J]. 化工学报, 2023, 74(7): 3018-3027.
[13]	李艳辉, 丁邵明, 白周央, 张一楠, 于智红, 邢利梅, 高鹏飞, 王永贞. 非常规服役超临界锅炉的微纳尺度腐蚀动力学模型建立及应用[J]. 化工学报, 2023, 74(6): 2436-2446.
[14]	刘起超, 周云龙, 陈聪. 起伏振动垂直上升管气液两相流截面含气率分析与计算[J]. 化工学报, 2023, 74(6): 2391-2403.
[15]	毕恩哲, 李双喜, 沙廉翔, 刘登宇, 陈凯放. 高温动压涨圈密封结构参数多目标优化分析[J]. 化工学报, 2023, 74(6): 2565-2579.

部分氧化对焦油模型化合物苯酚转化的机理

Reaction mechanism for partial oxidation of biomass tar

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 14

相关文章 15

编辑推荐

Metrics

本文评价