处理油库污水的改性PVDF超滤膜结构与性能

doi:10.3969/j.issn.0438-1157.2013.10.024

化工学报 ›› 2013, Vol. 64 ›› Issue (10): 3658-3664.DOI: 10.3969/j.issn.0438-1157.2013.10.024

处理油库污水的改性PVDF超滤膜结构与性能

竺柏康, 王北福

浙江海洋学院石化与能源工程学院, 浙江舟山 316000

收稿日期:2013-02-19 修回日期:2013-05-30 出版日期:2013-10-05 发布日期:2013-10-05
通讯作者: 竺柏康(1965-),男,副教授
作者简介:竺柏康(1965-),男,副教授。
基金资助:
中国石油化工股份有限公司科技开发项目(309044)

Properties and structures of modified PVDF ultrafiltration membranes for oily sewage treatment from coastal oil depot

ZHU Baikang, WANG Beifu

School of PetroChemical & Energy Engineering, Zhejiang Ocean University, Zhoushan 316000, Zhejiang, China

Received:2013-02-19 Revised:2013-05-30 Online:2013-10-05 Published:2013-10-05
Supported by:
supported by the Key Science and Technology Development Project of SINOPEC(309044).

摘要/Abstract

摘要： 在PVDF/PVP体系中添加Al₂O₃和TiO₂两种无机纳米颗粒,利用沉浸凝胶相转化法制得纳米颗粒总量不同和比例不同的改性PVDF平板超滤膜。探讨了纳米颗粒比例和总量对膜性能的影响。利用SEM、XRD对改性膜的结构进行了表征。并利用该改性膜处理典型沿海油库含油污水。结果显示:两种无机纳米颗粒的加入,明显增强了纳米改性膜的亲水性,使膜的抗污染性能得到提高;膜的韧性和强度得到改进;膜表面及膜孔的微观结构、改性膜的结晶度没有受到无机纳米颗粒的明显影响。最佳的纳米颗粒总含量为3%,两种纳米颗粒最佳质量比例为1:2。采用改性膜处理油库含油污水,稳定时出水中悬浮物含量低于0.4 mg·L^-1;石油烃类含量低于0.5 mg·L^-1;COD值在60～70 mg·L^-1之间,达到了国家污水排放标准。

关键词: 二氧化钛, 氧化铝, 纳米粒子, 改性聚偏氟乙烯, 平板超滤膜, 油库含油污水

Abstract: By mixing nano-particles of Al₂O₃ and TiO₂ into the casting solution,the nano-modified PVDF flat ultrafiltration membranes with different nano-particle aggregates and proportions were prepared by means of the immerged gel phase inversion process.The effects of different nano-particle aggregates and proportions on membrane performance were discussed.The modification membranes were investigated with SEM and XRD.These modified membranes were used to dispose of the typical oily sewage from coastal oil depot.The hydrophilicity of membrane and its anti-fouling property were improved significantly.The toughness and strength of the membrane were improved effectively which tensile rupture elongation of membrane showed a maximum increase of 6.75% and tensile strength a maximum increase of 43.3%.The suitable total content of nanometer particles was 3% and the best proportion of two nanometer particles was 1:2.Optimized modified membrane showed good treatment for oily wastewater from coastal oil depot.The content of suspended solids in the effluent was less than 0.4 mg·L^-1,the content of petroleum hydrocarbon was less than 0.5 mg·L^-1,COD was between 60—70 mg·L^-1,complying with discharge standard.

Key words: TiO₂, Al₂O₃, nanometer particles, modified PVDF, flat ultrafiltration membrane, oily sewage from coastal oil depot

中图分类号:

TQ028.8

竺柏康, 王北福. 处理油库污水的改性PVDF超滤膜结构与性能[J]. 化工学报, 2013, 64(10): 3658-3664.

ZHU Baikang, WANG Beifu. Properties and structures of modified PVDF ultrafiltration membranes for oily sewage treatment from coastal oil depot[J]. CIESC Journal, 2013, 64(10): 3658-3664.

参考文献 19

[1]	Farnand B A,Krug T A.Oil removal from oilfield produced water by crossflow ultrafiltration[J].Journal of Ganadian Petroleum Technology,1989,28(6):18-24
[2]	Bilstad T,Espedal E.Membrane separation of produced water[J].Water Science and Technology,1996,34(9):239-246
[3]	Liu Tinghui(刘廷惠),Wu Guangxia(吴光夏),Zhang Donghua(张东华),Wang Jingrong(王静荣),Feng Baohe(冯宝和),Guo Xuedi(郭学弟),Liu Fuliang(刘福谅),Xu Shuguang(续曙光).Treatment of wastewater containing oil by ultrafiltration[J].Acta Scientiae Circumstantiae(环境科学学报),1986,6(4):455-461
[4]	Wang Jingrong(王静荣),Wu Guangxia(吴光夏),Wu Kaifen(吴开芬),Ren Dongwei(任冬伟).The treatment of oil-contained waste water in oil field by hollow fiber UF membrane[J].Membrane Science and Technology(膜科学与技术),1998,18(2):25-27
[5]	Lü Hui(吕慧),Ban Hui(班辉),Yu Shuili(于水利),Zhao Qing(赵晴).Study on effect of nano-sized particles on PVDF ultrafiltration membrane performance[J].Journal of Harbin University of Commerce:Natural Sciences Edition(哈尔滨商业大学学报:自然科学版),2008,24(1):26-28
[6]	Lu Y,Sun H,Meng L L,Yu S L.Application of the Al2O3-PVDF nanocomposite tubular ultrafiltration(UF)membrane for oily wastewater treatment and its antifouling research[J].Separation and Purification Technology,2009,66(2):347-352
[7]	Yi X S,Shi W X,Yu S L,Sun N,Jin L M,Wang S,Zhang B,Ma C,Sun L P.Comparative study of anion polyacrylamide(APAM)adsorption-related fouling of a PVDF UF membrane and a modified PVDF UF membrane[J].Desalination,2012,286:254-262
[8]	Rezvanpour A,Roostaazad R,Hesampour M,Nyström M,Ghotbi C.Effective factors in the treatment of kerosene-water emulsion by using UF membranes[J].Journal of Hazardous Materials,2009,161(2/3):1216-1224
[9]	Ochoa N A,Masuelli M,Marchese J.Effect of hydrophilicity on fouling of an emulsified oil wastewater with PVDF/PMMA membranes[J].Journal of Membrane Science,2003,226(1/2):203-211
[10]	Yuliwati E,Ismail A F,Matsuura T,Kassim M A,Abdullah M S.Effect of modified PVDF hollow fiber submerged ultrafiltration membrane for refinery wastewater treatment[J].Desalination,2011,283:214-220
[11]	Zhou C,Wang Z,Liang Y L,Yao J M.Study on the control of pore sizes of membranes using chemical methods(Ⅱ):Optimization factors for preparation of membranes[J].Desalination,2008,225(1/2/3):123-138
[12]	Liu Fu,Moghareh Abed M R,Li K.Preparation and characterization of poly(vinylidene fluoride)(PVDF)based ultrafiltration membranes using nano γ-Al2O3[J].Journal of Membrane Science,2011,366(1/2):97-103
[13]	Su Jin Oh,Nowon Kim,Yong Taek Lee.Preparation and characterization of PVDF/TiO2 organic-inorganic composite membranes for fouling resistance improvement[J].Journal of Membrane Science,2009,345(1/2):13-20
[14]	Bae T-H,Tak T-M.Effect of TiO2 nanoparticles on fouling mitigation of ultrafiltration membranes for activated sludge filtration[J].Journal of Membrane Science,2005,249(1/2):1-8
[15]	Li Jiansheng(李健生),Wang Lianjun(王连军),Liang Yi(梁祎),Wang Huiya(王慧雅),Sun Xiuyun(孙秀云),Liu Xiaodong(刘晓东).Effects of nanoscale oxide particles on structure and property of PVDF hollow fiber membrane[J].Environmental Science(环境科学),2005,26(3):126-129
[16]	Zhang P Y,Wang Y L,Xu Z L,Yang H.Preparation of poly(vinyl butyral)hollow fiber ultrafiltration membrane via wet-spinning method using PVP as additive[J].Desalination,2011,278(1/2/3):186-193
[17]	Shen J N,Ruan H M,Wu L G,Gao C J.Preparation and characterization of PES-SiO2 organic-inorganic composite ultrafiltration membrane for raw water pretreatment[J].Chemical Engineering Journal,2011,278(1/2/3):186-193
[18]	Lu Yin(陆茵),Zhang Lin(张林),Chen Huanlin(陈欢林),Li Bogeng(李伯耿).The polymer-rich phase solidification process of PVDF-PVP-DMAc-H2O solution[J].Journal of Chemical Engineering of Chinese Universities(高校化学工程学报),2006,20(4):505-509
[19]	Yan Yong(闫勇),Zhao Changwei(赵长伟),Zen Chuyi(曾楚怡),Wang Tao(王涛),Luan Zhaokun(栾兆坤).Effect of TiO2 sol on PVDF ultrafiltration membrane structure and performance[J].Technology of Water Treatment(水处理技术),2011,37(8):35-39

处理油库污水的改性PVDF超滤膜结构与性能

Properties and structures of modified PVDF ultrafiltration membranes for oily sewage treatment from coastal oil depot

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 19

相关文章 15

编辑推荐

Metrics

本文评价

[1]	仪显亨, 周骛, 蔡小舒, 蔡天意. 光纤后向动态光散射测量纳米颗粒的浓度适用范围研究[J]. 化工学报, 2023, 74(8): 3320-3328.
[2]	李勇, 高佳琦, 杜超, 赵亚丽, 李伯琼, 申倩倩, 贾虎生, 薛晋波. Ni@C@TiO₂核壳双重异质结的构筑及光热催化分解水产氢[J]. 化工学报, 2023, 74(6): 2458-2467.
[3]	吴学红, 栾林林, 陈亚南, 赵敏, 吕财, 刘勇. 可降解柔性相变薄膜的制备及其热性能[J]. 化工学报, 2023, 74(4): 1818-1826.
[4]	何金峰, 李秀珍, 寇建耀, 陶庭杰, 余灿, 刘欢, 陈永元, 赵豪健, 江大好, 李小年. 乙醇制高级醇有序介孔氧化铝负载铜基催化剂研究[J]. 化工学报, 2023, 74(3): 1082-1091.
[5]	黄心童, 耿宇昊, 刘恒源, 陈卓, 徐建鸿. 微流控制备新型功能纳米粒子研究进展[J]. 化工学报, 2023, 74(1): 355-364.
[6]	曲国娟, 江涛, 刘涛, 马骧. 超分子策略调控金纳米团簇的发光行为[J]. 化工学报, 2023, 74(1): 397-407.
[7]	袁妮妮, 郭拓, 白红存, 何育荣, 袁永宁, 马晶晶, 郭庆杰. 化学链燃烧过程Fe₂O₃/Al₂O₃载氧体表面CH₄反应：ReaxFF-MD模拟[J]. 化工学报, 2022, 73(9): 4054-4061.
[8]	张炜, 李昊阳, 徐纯刚, 李小森. 气体水合物生成微观机理及分析方法研究进展[J]. 化工学报, 2022, 73(9): 3815-3827.
[9]	张鑫, 许蕊, 路馨语, 牛永安. SiO₂@BiOCl-Bi₂₄O₃₁Cl₁₀核壳微球的合成及光催化[J]. 化工学报, 2022, 73(8): 3636-3646.
[10]	刘庆祎, 肖桐, 孙文杰, 张家豪, 刘昌会. 纳米二氧化钛强化的相变储能研究进展[J]. 化工学报, 2022, 73(5): 1863-1882.
[11]	张苗, 杨洪海, 尹勇, 徐悦, 沈俊杰, 卢心诚, 施伟刚, 王军. 氧化石墨烯/水脉动热管的启动及传热特性[J]. 化工学报, 2022, 73(3): 1136-1146.
[12]	李文祥, 王钧禾, 郝怡静, 周乐平. 淬火初温影响疏水表面沸腾传热特性的实验研究[J]. 化工学报, 2022, 73(12): 5394-5404.
[13]	高奕吟, 付睿, 王丽, 郭耘. NbO _x 掺杂对Pt/TiO₂催化燃烧氯乙烯的促进作用[J]. 化工学报, 2022, 73(10): 4429-4437.
[14]	朱晓兵, 李佳佳, 李怡宁, 杨洪月, 李小松, 刘景林. 氧化锰电催化析氧反应及其电极界面特性[J]. 化工学报, 2021, 72(S1): 398-405.
[15]	姚彦虎, 杨晨, 张兵, 吴永红, 王同华. 基于TiO₂溶胶杂化的分子筛炭膜制备及其结构与性能[J]. 化工学报, 2021, 72(8): 4418-4424.