干气密封的实际气体焦耳-汤姆逊效应分析

doi:10.11949/j.issn.0438-1157.20151892

摘要/Abstract

摘要：

干气密封系统中气体通过过滤器、阀门、孔板和密封端面等组件时会发生焦耳-汤姆逊（JT）效应，可能导致密封气温度降低，甚至出现液相凝析。焦耳-汤姆逊效应一般通过焦耳-汤姆逊系数来反映。针对干气密封常面临的氢气、氮气、空气和二氧化碳，利用VDW方程、RK方程、SRK方程和PR方程4个经典状态方程（EOS）分别计算了相应的焦耳-汤姆逊（JT）系数，并与文献实验数据进行了比较，选择最佳状态方程作出各气体的JT系数曲线和焦耳-汤姆逊反转曲线（JTIC），并利用编程计算出空气和氮气通过干气密封端面时，由于JT效应引起的气体温降。结果表明：实际气体的焦耳-汤姆逊效应，对干气密封的节流环节会产生重要影响。常温条件下，氢气发生致热效应，而氮气、空气和二氧化碳气体发生致冷效应。采用4种状态方程计算焦耳-汤姆逊系数时，RK方程的平均相对误差和最大相对误差最低且分别小于4%和10%。干气密封气体的实际气体焦耳-汤姆逊效应能引起较大的温度变化，其中气体介质压力比介质温度对温差的影响更大。压力较小时JT效应引起的温降可以忽略。关键词：干气密封；实际气体；状态方程；焦耳-汤姆逊系数；反转曲线

关键词: 干气密封, 实际气体, 状态方程, 焦耳-汤姆逊系数, 反转曲线

Abstract:

In a system sealed by dry gas, the Joule-Thomson (JT) effect occurs when the gas flows through the components of filters, valves, orifices and end faces, which may cause the temperature drop of sealing gas, even the appearance of liquid condensation. Generally, the Joule-Thomson effect is represented by Joule-Thomson coefficient. As to the hydrogen, nitrogen, air and carbon dioxide, which are often encountered for the cases of sealing by dry gas, the corresponding Joule-Thomson (JT) coefficients were calculated by four classical equations of state (EOS) of VDW, RK, SRK and PR. Subsequently, those calculated coefficients are compared with the experimental data in the literatures. The JT coefficient curves and Joule-Thomson inversion curves (JTIC) were plotted using the optimal equation of state. As to air and nitrogen through the end faces of dry sealing gas, the gas temperature drops caused by JT effect were calculated by applying the computer program. It shows that the Joule-Thomson effect of real gas, which have important influence on the throttle of dry sealing gas. At room temperature, hydrogen showed exothermic effect, while nitrogen, air and carbon dioxide endothermic (cooling) effect. The corresponding Joule-Thomson (JT) coefficients were calculated by the four classical EOS, the average relative error and maximum relative error of RK equation were the minimum, less than 4% and 10%, respectively. The JT effect of real gas causes large temperature difference in the dry sealing gas, of which the gas pressure more influences on the temperature drop than the gas temperature does. When the pressure is small, the temperature drop by the JT effect can be negligible.

Key words: dry gas seal, real gas, equation of state, Joule-Thomson coefficient, inversion curve

中图分类号:

TB42
TQ031.1

邓成香, 宋鹏云, 马爱琳. 干气密封的实际气体焦耳-汤姆逊效应分析[J]. 化工学报, 2016, 67(9): 3833-3842.

DENG Chengxiang, SONG Pengyun, MA Ailin. Analysis of Joule-Thomson effect of real gas system sealed by dry gas[J]. CIESC Journal, 2016, 67(9): 3833-3842.

参考文献 27

[1]	钟桂香, 罗潇, 郗祥远. 干气密封失效原因分析与有效性措施[J]. 油气储运, 2014, 33(3):335-339. DOI:10. 6047/j.issn.1000-8241.2014.03.026. ZHONG G X, LU X, XI X Y. Failure analysis and effective measures in the dry gas seal[J]. Oil & Gas Storage and Transportation, 2014, 33(3):335-339. DOI:10.6047/j.issn.1000-8241.2014.03.026.
[2]	马丽芳. 干气密封气析出液处理[J]. 兰州石化职业技术学院学报, 2010, 10(4):7-9. MA L F. Processing for separation fluid of dry gas seal gas[J]. Journal of Lanzhou Petrochemical College of Technology, 2010, 10(4):7-9.
[3]	许静, 彭旭东, 白少先, 等. 气体热黏效应对干气密封性能影响的数值分析[J]. 上海交通大学学报, 2012, 46(5):722-728. XU J, PENG X D, BAI S X, et al. Numerical analysis of gas thermal viscosity effect on performance of a spiral-groove gas face seal[J]. Journal of Shanghai Jiaotong University, 2012, 46(5):722-728.
[4]	许静, 彭旭东, 白少先, 等. 端面微尺度效应和热黏效应对干气密封性能的影响[J]. 化工学报, 2013, 64(9):3291-3330. DOI:10.3969/j.issn.0438-1157.2013.09.030. XU J, PENG X D, BAI S X, et al. Effect of surface micro-scale and thermal viscosity on sealing performance of spiral-groove dry gas seal[J]. CIESC Journal, 2013, 64(9):3291-3330. DOI:10.3969/j.issn.0438-1157.2013.09.030.
[5]	丁雪兴, 刘勇, 张伟政, 等. 螺旋槽干气密封微尺度气膜的温度场计算[J]. 化工学报, 2014, 65(4):1353-1358. DOI:10.3969/j.issn.0438-1157.2014.04.027. DING X X, LIU Y, ZHANG W Z, et al. Calculation of temperature filed of micro-scale gas film in spiral groove dry gas seal[J]. CIESC Journal, 2014, 65(4):1353-1352. DOI:10.3969/j.issn.0438-1157.2014.04.027.
[6]	宋鹏云, 胡晓鹏, 许恒杰, 等. 实际气体对T槽干气密封动态特性的影响[J]. 化工学报, 2014, 65(4):1344-1352. DOI:10.3969/j.issn.0438-1157.2014.04.026. SONG P Y, HU X P, XU H J, et al. Effect of real gas on dynamic T-groove dry gas seal[J]. CIESC Journal, 2014, 65(4):1344-1352. DOI:10.3969/j.issn.0438-1157.2014.04.026.
[7]	朱自强, 吴有庭. 化工热力学[M]. 北京:化学工业出版社, 2010:126-147. ZHU Z Q, WU Y T. Chemical Engineering Thermodynamics[M]. Beijing:Chemical Industry Press, 2010:126-147.
[8]	李西平, 司云森.物理化学[M]. 昆明:云南大学出版社, 2006:40-41. LI X P, SI Y S. Physical Chemical[M]. Kunming:Yunnan University Press, 2006:40-41.
[9]	王竹溪. 热力学[M]. 2版. 北京:北京大学出版社, 2014:67-72. WANG Z X. Thermodynamics[M].2nd ed. Beijing:Peking University Press, 2014:67-72.
[10]	PERRY R H. Perry's Chemical Engineers' Handbook[M]. 7th ed. New York:McGraw-Hill, 1997:132-182.
[11]	陈钟秀, 顾燕飞, 胡望明. 化工热力学[M]. 3版. 北京:化学工业出版社, 2011:184-185. CHEN Z X, GU Y F, HU W M. Chemical Engineering Thermodynamics[M]. 3rd ed. Beijing:Chemical Industry Press, 2011:184-185.
[12]	曾彪, 张旭, 鲍谦. 湿空气绝热节流系数计算及讨论[J]. 暖通空调, 2011, 41(9):115-119. ZENG B, ZHANG X, BAO Q, et al. Calculation and discussion of adiabatic throttling coefficient for moist air[J]. Heating Ventilating and Air Conditioning, 2011, 41(9):115-119.
[13]	马沛生, 宣爱国, 周彩荣,等. 化工热力学[M]. 北京:化学工业出版社, 2009:40-42. MA P S, XUAN A G, ZHOU C R, et al. Chemical Engineering Thermodynamics[M]. Beijing:Chemical Industry Press, 2009:40-42.
[14]	程阳, 李东升, 胡佳成. 空气静压润滑焦耳-汤姆逊系数的计算方法[J]. 润滑与密封, 2014, 39(6):103-107. CHEN Y, LI D S, HU J C. The calculation method of Joule-Thomson coefficient in air aerostatic lubrication[J]. Lubrication Engineering, 2014, 39(6):103-107.
[15]	清华大学. 数学手册[M]. 北京:高等教育出版社, 2004:88-89. Tsinghua University. Mathematics Handbook[M]. Beijing:Higher Education Press, 2004:88-89.
[16]	石玉冰. 真实气体等压热容的关联[J]. 化肥设计, 2010, 48(3):11-13. SHI Y B. Correlation of heat capacity at constant pressure for real gas[J].Chemical Fertilizer Design, 2010, 48(3):11-13.
[17]	MATIN N S, HAGHIGHI B. Calculation of the Joule-Thomson inversion curves from cubic equation of state[J]. Fluid Equilibria, 2000, 175(1):273-284. DOI:10.1016/S0378-3812(00)00443.
[18]	WISNIAK J, AVRAHAM H. On the Joule-Thomson integral inversion curves[J]. Thermochimica Acta, 1996, 286(1):33-40.
[19]	MAYTAL B Z, SHAVIT A. On the Joule-Thomson integral inversion curves of quantum gases[J]. Cryogenics, 1997, 37(1):33-38. DOI:10. 1016/S0011-2275(96)00094-X.
[20]	COLINA C M, OLIVERA-FUENTS C. Prediction of the Joule-Thomson inversion curve of air from cubic equations of state[J]. Cryogenics, 1998, 8(7):721-728. DOI:10.1016/S0011-2275(98)00036-8.
[21]	刘延雷. 高压氢气快充温升控制及泄漏扩散规律研究[D]. 杭州:浙江大学, 2009. LIU Y L. Investigating on control of temperature rise in fast filling of high pressure hydrogen and diffusion due to its leakage[D]. Hangzhou:Zhejiang University, 2009.
[22]	胡登辉. 非理想气体节流过程热力学研究及实践应用[D]. 大庆:东北石油大学, 2011. HU D H. Non-ideal gas throttling process thermodynamic analysis and applied research[D]. Daqing:Northeast Petroleum University. 2011.
[23]	刘丰, 李晶晶. 基于HYSYS的焦耳-汤姆逊效应实验装置设计与模拟分析[J]. 广州化工, 2014, 42(14):164-166. LIU F, LI J J. Experimental design and simulation of Joule-Thomson effect based on HYSYS[J]. Guangzhou Chemical Industry, 2014, 42(14):164-166.
[24]	高光华, 童景山. 化工热力学[M]. 北京:清华大学出版社, 2007:204-207. GAO G H, TONG J S. Chemical Engineering Thermodynamics[M]. Beijing:Tsinghua University Press, 2009:204-207.
[25]	马沛生, 夏淑倩, 夏清. 化工物性数据简明手册[M]. 北京:化学工业出版社, 2013:17-18. MA P S, XIA S Q, XIA Q. Chemical Property Data Concise Guide[M]. Beijing:Chemical Industry Press, 2013:17-18.
[26]	郭天明. 多元汽-液平衡和精馏[M]. 北京:化学工业出版社, 2002:161-300. GUO T M. Diverse Vapor-Liquid Equilibrium and Distillation[M]. Beijing:Chemical Industry Press, 2002:161-300.
[27]	李云, 姜培正. 过程流体机械[M]. 2版. 北京:化学工业出版社, 2008:13-21. LI Y, JIANG P Z. Process Fluid Machinery[M]. 2nd ed. Beijing:Chemical Industry Press, 2008:13-21.