分散颗粒和超声场对鼓泡塔内传质性能的影响

doi:10.3969/j.issn.0438-1157.2013.08.014

化工学报 ›› 2013, Vol. 64 ›› Issue (8): 2801-2806.DOI: 10.3969/j.issn.0438-1157.2013.08.014

分散颗粒和超声场对鼓泡塔内传质性能的影响

邹华生, 熊乔兴, 黄晨

华南理工大学化学与化工学院, 广东广州 510640

收稿日期:2012-12-11 修回日期:2013-02-21 出版日期:2013-08-05 发布日期:2013-08-05
通讯作者: 熊乔兴
作者简介:邹华生(1957- ),男,教授。
基金资助:
广东省教育部产学研结合项目(2011B090400116);广州市科技攻关项目(2012J4300758)。

Influence of dispersed particles in ultrasonic field on mass transfer in bubble column

ZOU Huasheng, XIONG Qiaoxing, HUANG Chen

School of Chemistry and Chemical Engineering, South China University of Technology, Guangzhou 510640, Guangdong, China

Received:2012-12-11 Revised:2013-02-21 Online:2013-08-05 Published:2013-08-05

摘要/Abstract

摘要： 用双电导探针气泡特征参数测量系统实时测定超声场与分散颗粒(活性炭)对鼓泡塔水+CO₂体系气泡Sauter直径和体积传质系数影响的变化规律。实验结果表明:无活性炭颗粒添加时,多频超声场比单频超声场更有利于提高体积传质系数,输入功率为100 W、组合超声频率为20-50-100 kHz时,体积传质系数增幅达40%~64%;加入活性炭颗粒后,体积传质系数随加入活性炭固含量的增大呈现先增大后逐渐减少的趋势,气泡Sauter直径变化规律相反,当体系中活性炭固含量为1.0 kg·m^-3时,传质增强最明显。体积传质系数随加入活性炭粒径的减小呈现增大的趋势。与无活性炭颗粒(d_s=0)比较,活性炭(固含率1.0 kg·m^-3)粒径d_s=38 μm时,液相体积传质系数在扣除吸附传质效果后仍增大1.58倍,同时引入超声场后,当组合超声频率为20-50-100 kHz,超声功率100 W时,液相体积传质系数增大2.02倍,可见超声场和分散颗粒对气液传质有显著的协同强化作用。

关键词: 鼓泡塔, 超声场, 颗粒, 气泡Sauter直径, 体积传质系数

Abstract: The influence of activated carbon dispersed particles on the variation of bubble diameter and volumetric mass transfer coefficient of the system of CO₂-water absorption in ultrasonic field of a single frequency and multi-frequency was investigated in real time in a bubble column with a bubble feature measuring system called duplex conductivity probe.The results showed that multi-frequency ultrasonic field was superior to single-frequency ultrasonic field in enhancing volumetric mass transfer coefficient without dispersed activated carbon particles.Volumetric mass transfer coefficient increased by 40%-64% in the ultrasonic field of multi-frequency of 20-50-100 kHz and input power of 100 W.As activated carbon particles of 38 μm were added to the system,volumetric mass transfer coefficient firstly increased and then gradually decreased. However,the trend of variation in bubble diameter was on the contrary. Enhancement of mass transfer was most significant when solids content was 1.0 kg·m^-3.When solids concentration was at a specific value,volumetric mass transfer coefficient decreased with the increase in activated carbon particle diameter.Compared with the system without activated carbon particles,when solids content was 1.0 kg·m^-3,volumetric mass transfer coefficient was enhanced about by 1.58 times,and volumetric mass transfer coefficient further increased by 2.02 times under combined action of particles and reverberating ultrasonic field of multi-frequency of 20-50-100 kHz and input power 100 W,which suggested that multi-frequency ultrasonic field and dispersed particles had a significant synergistic effect on enhancement of mass transfer in CO₂-water absorption system.

Key words: bubble column, ultrasonic field, particle, bubble Sauter diameter, volumetric mass transfer coefficient

中图分类号:

TQ021.4

邹华生, 熊乔兴, 黄晨. 分散颗粒和超声场对鼓泡塔内传质性能的影响[J]. 化工学报, 2013, 64(8): 2801-2806.

ZOU Huasheng, XIONG Qiaoxing, HUANG Chen. Influence of dispersed particles in ultrasonic field on mass transfer in bubble column[J]. CIESC Journal, 2013, 64(8): 2801-2806.

参考文献 20

[1]	Li Wenxiu(李文秀),Bi Ying(毕颖),Yu Sansan(于三三),Ji Zhiling(纪智玲).Effect of addition of the third phase on gas-liquid mass transfer[J].Chemical Industry and Engineering(化学工业与工程),2007,249(6):535-544
[2]	Dumont E,Delmas H.Mass transfer enhancement of gas absorption in oil-in-water systems:a review[J].Chemical Engineering and Processing,2003,42(6):419-438
[3]	Kantarci N,Borak F,Ulgen K O.Bubble column reactors[J].Process Biochemistry,2005,40:2263-2283
[4]	Kaya A,Schumpe A.Surfactant adsorption rather than "shuttle effect"?[J].Chemical Engineering Science,2005,60(22):6504-6510
[5]	Kordac M,Linek V.Mechanism of enhanced gas absorption in presence of fine soild particles.Effect of molecular diffusivity on mass transfer coefficient in stirred cell[J].Chemical Engineering Science,2006,61(21):7125-7132
[6]	Kars R L,Best R J,Drinkenbur G A A H.The adsorption of propane in slurries of active carbon in water[J].Chemical Engineering Journal,1979,17(3):201-210
[7]	Lu Sumin,Ma Youguang,Zhu Chunying,Shen Shuhua. The effect of hydrophobic modification of zeolites on CO2 absorption enhancement[J].Chinese Journal of Chemical Engineering,2009,17(1):36-41
[8]	Lu Sumin(卢素敏),Ma Youguang(马友光),Zhu Chunying(朱春英),Shen Shuhua(沈树华).Enhancement of CO2 gas absorption in agitated slurry reacor by the adsorptive particles[J].Chemical Engineering(China)(化学工程),2007,35(8):1-4
[9]	Ferreira A,Ferreira C,Teixeira J A,Rocha F. Temperature and solid properties effects on gas-liquid mass transfer[J].Chemical Engineering Journal,2010,162(2):743-752
[10]	Mena P,Frreira A,Teixeira J A,Rocha F.Effect of some solid properties on gas-liquid mass transfer in a bubble column[J].Chemical Engineering and Processing,2011,50(2):181-188
[11]	Kumar A,Gogate P R,Pandit A B,Delmas H,Wilhelm A M.Gas-liquid mass transfer studies in sonochemical reactors[J].Ind.Eng.Chem.Res.,2004,43(8):1812-1819
[12]	Cheng Xiaoping(程小平).Study on ammonia absorption in a bubble column radiated by urtrasonic and numerical simulation.Guangzhou:South China University of Technology,2012
[13]	Laugier F,Andriantsiferana C,Wilhelm A M,Delmas H.Ultrasound in gas-liquid systems:effects on solubility and mass transfer[J].Ultrasonics Sonochemistry,2008,15(6):965-972
[14]	Gogate P R,Sutkar V S,Pandit A B.Sonochemical reactors:important design and scale up considerations with a special emphasis on heterogeneous systems[J].Chemical Engineering Journal,2011,166(3):1066-1082
[15]	Zhou Chao(周超).Study of characteristics of bubbles and mass transfer in bubble column with ultrasonic radiation.Guangzhou: South China University of Technology,2010
[16]	Ye Zeyue(叶泽月),Zhang Lijuan(张丽娟),Shi Kangsheng(石康生).The influence of distributor on bubble size distribution in bubble column[J].Chemical Production and Technology(化工生产与技术),2001,14(4):43-46
[17]	Li Wenxiu(李文秀),Chen Kai(陈凯),Zhang Zhigang(张志刚).Enhancement of tiny soluble gas absorption by dispersed liquid phase[J].Chemical Engineering(China)(化学工程),2010,38(2):8-12
[18]	Ellenberger J,Baten J M,Krishna R.Exploiting the Bjerknes force in bubble column reactors[J].Chemical Engineering Science,2005,60(22):5962-5970
[19]	Zou Huasheng(邹华生),Zhou Chao(周超),Li Minle(黎民乐).Study on the distribution of sound intensity in octangular double-tube continuous sonochemical reactor[J].Journal of Chemical Engineering of Chinese Universities(高校化学工程学报),2010,24(5):789-794
[20]	Tang Lixin(汤立新),Han Pingfang(韩萍芳),Lü Xiaoping(吕效平).Experimental study of mass transfer characteristics in ultrasonic airlift reactor[J].Journal of Chemical Engineering of Chinese Universities(高校化学工程学报),2003,17(3):243-247

分散颗粒和超声场对鼓泡塔内传质性能的影响

Influence of dispersed particles in ultrasonic field on mass transfer in bubble column

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

本文评价

[1]	曾如宾, 沈中杰, 梁钦锋, 许建良, 代正华, 刘海峰. 基于分子动力学模拟的Fe₂O₃纳米颗粒烧结机制研究[J]. 化工学报, 2023, 74(8): 3353-3365.
[2]	郑玉圆, 葛志伟, 韩翔宇, 王亮, 陈海生. 中高温钙基材料热化学储热的研究进展与展望[J]. 化工学报, 2023, 74(8): 3171-3192.
[3]	张孟斌, 李锐, 张嘉杰, 马素霞, 张建胜. 基于共面电容原理的煤炭灰渣介电特性实验研究[J]. 化工学报, 2023, 74(7): 3028-3037.
[4]	陈巨辉, 张谦, 舒崚峰, 李丹, 徐鑫, 刘晓刚, 赵晨希, 曹希峰. 基于DEM方法的旋转流化床纳米颗粒流动特性研究[J]. 化工学报, 2023, 74(6): 2374-2381.
[5]	时国华, 何林珅, 赵玺灵, 张世钢. 余热回收喷淋塔的烟气颗粒物脱除特性研究[J]. 化工学报, 2023, 74(4): 1735-1745.
[6]	陈俊先, 姬忠礼, 赵瑜, 张倩, 周岩, 刘猛, 刘震. 基于微波技术的天然气管道内颗粒物在线检测方法研究[J]. 化工学报, 2023, 74(3): 1042-1053.
[7]	贾龙菲, 付少童, 向星, 张华海, 张弢, 王利民. 颗粒振动影响动量传递过程的格子Boltzmann方法模拟[J]. 化工学报, 2023, 74(2): 735-747.
[8]	李亚芾, 付亮亮, 白浩隆, 白丁荣, 许光文. 菱镁矿浮选尾矿直接合成同时制备镁橄榄石和镁砂研究[J]. 化工学报, 2022, 73(8): 3679-3687.
[9]	王凯玥, 马永丽, 李琛, 刘明言. 气液固微型流化床的气液传质系数[J]. 化工学报, 2022, 73(8): 3529-3540.
[10]	艾承燚, 乔金硕, 王振华, 孙旺, 孙克宁. 原位析出纳米合金的PrBaFe₂O_6-_δ 基阳极构筑及其在固体碳燃料电池中的应用研究[J]. 化工学报, 2022, 73(8): 3708-3719.
[11]	赵庆杰, 胡晓红, 张超, 凡凤仙. 蒸汽在含有不可溶核和可溶无机盐的细颗粒物表面的核化特性[J]. 化工学报, 2022, 73(7): 3251-3261.
[12]	杨晖, 李宏泽, 陈泉, 郑泽希, 李然, 孙其诚. 从质量流向漏斗流转变过程中的动力学分析[J]. 化工学报, 2022, 73(6): 2722-2731.
[13]	孔令菲, 陈延佩, 王维. 气固流态化中颗粒介尺度结构的动力学研究[J]. 化工学报, 2022, 73(6): 2486-2495.
[14]	潘大伟, 汪伟, 谢锐, 巨晓洁, 刘壮, 褚良银. 微流控乳液模板法构建功能微颗粒过程中介尺度结构定向调控的研究进展[J]. 化工学报, 2022, 73(6): 2306-2317.
[15]	施炜斌, 龙姗姗, 杨晓钢, 蔡心悦. 计及气泡诱导与剪切湍流的气泡破碎、湍流相间扩散及传质模型[J]. 化工学报, 2022, 73(6): 2573-2588.