外循环对IC反应器运行效果的影响

doi:10.3969/j.issn.0438-1157.2014.06.051

化工学报 ›› 2014, Vol. 65 ›› Issue (6): 2329-2334.DOI: 10.3969/j.issn.0438-1157.2014.06.051

外循环对IC反应器运行效果的影响

张燚, 刘敏, 陈滢, 辜清, 汤伟

四川大学建筑与环境学院, 四川成都 610065

收稿日期:2013-09-18 修回日期:2013-11-10 出版日期:2014-06-05 发布日期:2014-06-05
通讯作者: 刘敏
作者简介:张燚（1989- ），男，硕士研究生
基金资助:
国家自然科学基金项目（51108285）；国家高技术研究发展计划项目（2011AA060905）。

Effect of external circulation on performance of IC reactor

ZHANG Yi, LIU Min, CHEN Ying, GU Qing, TANG Wei

College of Architecture and Environment, Sichuan University, Chengdu 610065, Sichuan, China

Received:2013-09-18 Revised:2013-11-10 Online:2014-06-05 Published:2014-06-05
Supported by:
supported by the National Natural Science Foundation of China(51108285) and the National High Technology Research and Development Program of China(2011AA060905).

摘要/Abstract

摘要： 为改善已形成颗粒污泥的IC反应器运行性能，增设外循环装置，并在回流比分别为0、1.0、2.0、3.0、4.0的情况下，进行了系统运行稳定性研究。与无外循环的情况相比，在设定的回流比范围内，附加外循环不会破坏反应器内部厌氧条件，反应器运行稳定；在进水COD为6000 mg·L^-1左右，系统HRT约为10 h，容积负荷为14 kg·m^-3·d^-1的情况下，系统污泥MLSS有所增加，COD去除率随回流比的增大而增加，最高可达97.3%，出水COD低至160 mg·L^-1；随回流比的增大，产气总量逐渐增加且最终可达171.2 L·d^-1，甲烷产量先增加后趋于稳定，在回流比为2.0时可达到91.7 L·d^-1；增加外循环运行一段时间后，厌氧颗粒污泥生物相更为丰富，产甲烷优势菌由甲烷杆菌转变为甲烷八叠球菌。结合能耗和去除效率等考虑，回流比为2.0时最佳。

关键词: 厌氧IC反应器, 外循环, 颗粒污泥, 回流比, 甲烷, 运行效果

Abstract: In order to improve the performance of internal circulation(IC) reactor in which granular sludge had formed, an additional external circulation device was added to the reactor. The operation stability of this system was investigated at various reflux ratios of 0, 1.0, 2.0, 3.0 and 4.0. Compared with without external circulation situation, additional device do not indeed damage anaerobic conditions inside the IC reactor and the reactor operation was stable at given range of reflux ratio. When chemical oxygen demand(COD) of influent was 6000 mg·L^-1, hydraulic retention time(HRT) about 10h, and volume loading 14 kg·m^-3·d^-1, the MLSS of system (mixed liquid suspended solids) and the removal rate of COD increased with the growth of reflux ratio, and could reach the maximum 97.3% and the lowest COD of effluent 160 mg·L^-1 respectively. With increase of reflux ratio, the total quantity of biogas produced increased to 171.2 L·d^-1. The methane production increased at the beginning and then maintained stabilization, and was 91.7 L·d^-1 at reflux ratio 2.0. Remarkably, biodiversity in granular sludge had been improved due to additional external circulation. After the system with additional external circulation operated for a period of time, the dominant bacteria for methane production changed from Methanobacterium to Methanococcus. After comprehensive consideration of energy consumption and COD removal rate, the optimal reflux ratio would be 2.0.

Key words: anaerobic IC reactors, external circulation, granular sludge, reflux ratio, methane, operation efficiency

中图分类号:

X703.1

张燚, 刘敏, 陈滢, 辜清, 汤伟. 外循环对IC反应器运行效果的影响[J]. 化工学报, 2014, 65(6): 2329-2334.

ZHANG Yi, LIU Min, CHEN Ying, GU Qing, TANG Wei. Effect of external circulation on performance of IC reactor[J]. CIESC Journal, 2014, 65(6): 2329-2334.

参考文献 24

[1]	Kassam Z A, Yerushalmi L, Guiot S R. A market study on the anaerobic waste-water treatment systems[J]. Water, Air and Soil Pollution. 2003, 143(1-4): 179-192
[2]	Lu Zi(卢姿). Application of IC reactor in a brewery wastewater treatment[J]. Technology of Water Treatment(水处理技术), 2013, 39(7): 124-127
[3]	Guo Fangzheng(郭方峥), Liu Weijing(刘伟京), Tu Yong(涂勇), Xie Lin(解林), Li Duosong(李多松), Lu Xian(陆贤). Operating parameters of IC reactor treating OCC wastewater[J]. Research of Environmental Sciences(环境科学研究), 2011, 24(3): 325-331
[4]	Zhou Lili(周莉莉), Ji Min(季民).Granular sludge acclimation and quick startup of pharmaceutical wastewater with an IC reactor[J]. China Environmental Science(中国环境科学), 2010, 30(6): 758-762
[5]	Zhang Lei(张雷), Zhou Tingting(周婷婷), Rong Wenbing(荣文兵), Zeng Tianwen(曾添文). Operation rule of internal circulation reactor[J]. Environmental Science & Technology(环境科学与技术), 2011, 34(2): 156-158
[6]	Richard M D, Freda R H. Anaerobic digestion of shortchain organic acids in an expanded granular sludge bed reactor [J]. Water Res., 2000, 34 (9): 2433-2438
[7]	van Lier J B, van der Zee F P, Tan N C G, et al. Advances in high-rate anaerobic treatment: staging of reactor systems [J]. Water Sci. Tech., 2001, 44(8): 15-20
[8]	Liu Mu(刘牡), Peng Yongzhen(彭永臻), Song Yanjie(宋燕杰), Wu Lina(吴莉娜), Zhao Yanlin(赵艳琳). Effect of recycling ratio on shortcut nitrification-denitrification of mature landfill leachate in a single-stage UASB-A/O system [J]. CIESC Journal (化工学报), 2011, 62(6): 1675-1681
[9]	Ding Jiannan(丁建南), Yu Yizun(于一尊), Jin Zhinong(金志农). Startup test of external circulating-added IC reactor[J]. China Biogas(中国沼气), 2004, 22(4): 29-31
[10]	Gu Qing(辜清), Luo Haixia(罗海霞), Zhang Yue(张悦), Liu Min(刘敏). Study on the start-up of internal circulation (IC) anaerobic reactor under external circulation state [J]. Industrial Water Treatment(工业水处理), 2013, 33(4): 25-27
[11]	Yu Yaqin(余亚琴), Lü Xiwu(吕锡武), Li Jing(李靖). Start-up of improved external circulation anaerobic reactor treating cyanobacteria and microbial properties of granular sludge [J]. CIESC Journal (化工学报), 2013, 64(11): 4203-4209
[12]	Phd J D, Wang D. Influence of external circulation on sludge characteristics during start-up of internal circulation reactor[J]. Journal of Central South University of Technology. 2005, 12(4): 425-429
[13]	State Environmental Protection Administration of China. Monitoring and Analytic Methods of Water and Wastewater [M]. 4th ed. Beijing: Environmental Science Press of China, 2002: 12-124
[14]	Zhang Wudi(张无敌), Song Hongchuan(宋洪川), Yin Fang(尹芳). Biogas Fermentation and Comprehensive Utilization(沼气发酵与综合利用) [M]. Kunming: Yunnan Science and Technology Press, 2004: 96-103
[15]	Gong Weijia(公维佳), Li Wenzhe(李文哲), Liu Jianyu(刘建禹). Progress of research on methanogens bacteria in anaerobic digestion [J]. Journal of Northeast Agricultural University(东北农业大学报), 2006, 37(6): 838-841
[16]	Li Jianzheng(李建政), Zhu Gefu(朱葛夫), Ouyang Hong(欧阳红), Guo Xiaoyu(郭小宇), Jin Huizheng(靳慧征). Hydrogen production by organic wastewater fermentation in anaerobic baffled reactor [J]. Journal of Chemical Industry and Engineering (China) (化工学报), 2004, 55: 70-74
[17]	Ren Nanqi(任南琪), Ma Fang(马放). Pollution Control of Microbiology(污染控制微生物学)[M]. Harbin: Harbin Industry University Press, 2002: 168
[18]	Liu Tingting(刘亭亭), Cao Jingyu(曹靖瑜). Study on the isolation and growth condition of met hanogen [J]. Journal of Heilongjiang Hydraulic Engineering College(黑龙江水专学报), 2007, 34(4): 120-122
[19]	Zhou Lili(周莉莉), Ji Min(季民). Granular sludge acclimation and quick startup of pharmaceutical wastewater with an IC reactor [J]. China Environmental Science(中国环境科学), 2010, 30(6): 758-762
[20]	Zhang Keqiang(张克强). The Treatment and Disposal of Livestock and Poultry Pollutions (畜禽养殖业污染物处理与处置)[M]. Beijing: Chemical Industry Press, 2004
[21]	Wu Manchang(吴满昌), Sun Kewei(孙可伟), Li Ruyan(李如燕), Sun Yan(孙艳), Zhang Haidong(张海东), Ni Jun(倪骏), Yu Hongyan(于红艳). Bioenergy conversion study of thermophilic anaerobic digestion for treating OFMSW[J]. Energy Engneering(能源与环境), 2005(5): 44-46
[22]	McCarty P L, Smith D P. Anaerobic wastewater treatment [J]. Environ. Sci. Tech., 1986, 20(12): 1200-1206
[23]	Yu Yaqin(余亚琴), Lü Xiwu(吕锡武), Wu Yifeng(吴义锋). Study on performance of external circulation UASB reactor treating algae-laden water from taihu lake [J]. Journal of Hunan University: Natural Sciences(湖南大学学报:自然科学版), 2013, 40(1): 87-92
[24]	Qian Dandan(钱丹丹), Ma Longlong(马隆龙), Yuan Yuexiang(袁月祥), Yan Zhiying(闫志英), Liu Xiaofeng(刘晓风), Liao Yinzhang(廖银章), He Rongna(贺蓉娜). Isolation, identification and phylogenetic analysis of an Alkalophilic Methanosarcina [J]. Chin. J. Appl. Environ. Biol.(应用与环境生物学报), 2012, 18(2): 262-266

外循环对IC反应器运行效果的影响

Effect of external circulation on performance of IC reactor

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 24

相关文章 15

编辑推荐

Metrics

本文评价

[1]	刘晓洋, 喻健良, 侯玉洁, 闫兴清, 张振华, 吕先舒. 螺旋微通道对掺氢甲烷爆轰传播的影响[J]. 化工学报, 2023, 74(7): 3139-3148.
[2]	牛超, 沈胜强, 杨艳, 潘泊年, 李熠桥. 甲烷BOG喷射器流动过程计算与性能分析[J]. 化工学报, 2023, 74(7): 2858-2868.
[3]	周小文, 杜杰, 张战国, 许光文. 基于甲烷脉冲法的Fe₂O₃-Al₂O₃载氧体还原特性研究[J]. 化工学报, 2023, 74(6): 2611-2623.
[4]	胡晗, 杨亮, 李春晓, 刘道平. 天然烟浸滤液水合物法储甲烷动力学研究[J]. 化工学报, 2023, 74(3): 1313-1321.
[5]	彭晓婉, 郭笑楠, 邓春, 刘蓓, 孙长宇, 陈光进. ZIF-8浆液法分离CH₄/N₂的双吸收-吸附塔工艺流程建模与模拟[J]. 化工学报, 2023, 74(2): 784-795.
[6]	沈嘉辉, 王侃宏, 郁达伟, 胡大洲, 魏源送. 游离氨调理污泥厌氧消化优化产甲烷过程与强化有机物释放[J]. 化工学报, 2022, 73(9): 4147-4155.
[7]	廖珊珊, 张少刚, 陶骏骏, 刘家豪, 汪金辉. 竖直射流火撞击障碍管道数值模拟分析[J]. 化工学报, 2022, 73(9): 4226-4234.
[8]	唐翠萍, 张雅楠, 梁德青, 李祥. 聚乙烯己内酰胺链端改性及其对甲烷水合物形成的抑制作用研究[J]. 化工学报, 2022, 73(5): 2130-2139.
[9]	闫帅, 杨家宝, 龚岩, 郭庆华, 于广锁. CO₂稀释对甲烷反扩散火焰结构的影响研究[J]. 化工学报, 2022, 73(3): 1335-1342.
[10]	王保文, 张港, 刘同庆, 李炜光, 王梦家, 林德顺, 马晶晶. CeO₂/CuFe₂O₄氧载体CH₄化学链重整耦合CO₂热催化还原研究[J]. 化工学报, 2022, 73(12): 5414-5426.
[11]	杨霄, 丁锐, 李墨含, 宋正昶. 氧浓度对微通道内甲烷均相/非均相耦合反应特性的影响[J]. 化工学报, 2022, 73(12): 5427-5437.
[12]	张立, 吴建华, 崔舒惠, 严锋, 孙浩, 钱飞跃. PN/A颗粒污泥-固相反硝化组合工艺的菌群功能解析[J]. 化工学报, 2022, 73(11): 5128-5137.
[13]	吴一, 温小萍, 张素梅, 郭志东, 邓浩鑫, 纪文涛. 垂直圆管内掺氢甲烷燃烧不稳定性研究[J]. 化工学报, 2022, 73(10): 4780-4790.
[14]	胡慧慧, 杨亮, 刘道平, 张柯. 低剂量超吸水树脂溶液微滴中甲烷水合物生成动力学[J]. 化工学报, 2022, 73(10): 4659-4667.
[15]	高文莉, 辛忠. Fe对Ni/SBA-16催化CO低温甲烷化促进作用的研究[J]. 化工学报, 2022, 73(1): 241-254.