“活性污泥-生物膜”杂合ABR制氢系统的启动与运行

doi:10.11949/j.issn.0438-1157.20160112

摘要/Abstract

摘要：

对ABR系统进行改良，建立新型的“活性污泥-生物膜”杂合厌氧折流板生物制氢反应器（SMHABR），研究其乙醇型发酵的形成及其产氢及COD处理能力。反应器分为5个格室，有效容积43.2 L，实验共进行180 d。系统以红糖废水为原料，在HRT为12 h，温度为（35±1）℃，通过分阶段提高进水COD的方式，可使ABR系统在35 d内培育驯化形成乙醇型发酵菌群体系。进水COD在约3500 mg·L^-1时产氢量最大，总产氢量可达到44.75 L·d^-1。进水COD浓度达到约7100 mg·L^-1时COD去除率最大，平均总去除率可达到49.33%。COD去除率最大值并未与产氢量最大值同时出现，说明产氢最适进水浓度与COD去除最适进水浓度并非相同。

关键词: 制氢, 生物膜, 活性污泥, 厌氧, SMHABR

Abstract:

The new sluge-micobial film hybrid anaerobic baffled reactor (SMHABR) was obtained by the improvement of the original ABR with five compartments and effective volume of 43.2 L. The experimentation studied on the formation of ethanol type fermentation, the hydrogen production capacity and the COD removal capacity. The result of 180 days experiment showed that using brown sugar wastewater as raw material with hydraulic retention time of 12 h, temperature of 35℃±1℃, the system of ethanol type fermentation bacteria could be formatted in 35 days through increasing the influent COD in a phased operation mode. When the influent COD was about 3500 mg·L^-1, the maximum hydrogen production was achieved with the total hydrogen production of 44.75 L·d^-1. The hydrogen production of the second compartment was larger than that of the other compartments. When the influent COD was about 7100 mg·L^-1, the maximum COD removal capacity was achieved with the average total COD removal rate of 49.33%. The maximum hydrogen production and the maximum COD removal rate did not appear at the same time. When the influent COD concentration was too high, the organic acid accumulation in the reactor was too much, resulting in the reactor pH down to 3. Low pH affected the hydrogen production efficiency of the system. Although ethanol fermentation was formed in the system, the hydrogen production capacity was low.

Key words: hydrogen production, biofilm, activated sludge, anaerobic, SMHABR

中图分类号:

X703

郑阳, 王鲁宁, 张宝艺, 李永峰, 任南琪. “活性污泥-生物膜”杂合ABR制氢系统的启动与运行[J]. 化工学报, 2016, 67(9): 3861-3871.

ZHENG Yang, WANG Luning, ZHANG Baoyi, LI Yongfeng, REN Nanqi. Start-up and operation of “sluge-micobial film” hybrid ABR used as hydrogen production system[J]. CIESC Journal, 2016, 67(9): 3861-3871.

参考文献 25

[1]	李冬敏, 陈洪章, 李佐虎. 生物制氢技术的研究进展[J]. 生物技术通报, 2003, (4):1-5. DOI:10.13560/j.cnki.biotech.bull.1985.2003.04.001. LI D M, CHEN H Z, LI Z H. Research progress of biological hydrogen production technology[J]. Biotechnology Bulletin, 2003, (4):1-5. DOI:10.13560/j.cnki.biotech.bull.1985.2003.04.001.
[2]	徐国泉.中国能源效率问题研究[D]. 大连:大连理工大学, 2007. XU G Q. Research on energy efficiency of China[D]. Dalian:Dalian University of Technology, 2007.
[3]	朱轩彤. 国际能源格局发展新趋势[J]. 中国能源, 2011, 33(1):27-28. DOI:10.3969/j.issn.1003-2355.2011.01.005. ZHU X T. New trend of the international energy pattern[J]. Energy of China Journal, 2011, 33(1):27-28. DOI:10.3969/j.issn.1003-2355.2011.01.005.
[4]	DAS D, VEZIROGLU T N. Advances in biological hydrogen production processes[J]. International Journal of Hydrogen Energy, 2008, 33:6046-6057.
[5]	宗文明, 于瑞嵩, 樊美珍, 等. 一株利用生物柴油废水产氢的光合菌的筛选、鉴定[J]. 中国环境科学, 2009, 29(10):1076-1081. ZONG W M, YU R S, FAN M Z, et al. Screening and identification of a photosynthetic bacterial strain for biohydrogen production from biodiesel wastewater[J]. China Environmental Science Journal, 2009, 29(10):1076-1081.
[6]	KOTHARI R, SINGH D P, TYAGI V V, et al. Fermentative hydrogen production-an alternative clean energy source[J].Renewable and Sustainable Energy Reviews, 2012, 16(4):2337-2346.
[7]	任南琪, 秦智, 李建政. 不同产酸发酵菌群产氢能力的对比与分析[J]. 环境科学, 2003, 24(1):70-74. DOI:10.13227/j.hjkx.2003.01.011. REN N Q, QIN Z, LI J Z. Comparison and analysis of hydrogen production capacity with different acidogenic fermentative microflora[J]. Environmental Science, 2003, 24(1):70-74. DOI:10.13227/j.hjkx.2003.01.011.
[8]	任南琪, 李永峰, 郑国香, 等. 生物制氢(Ⅰ):理论研究进展[J]. 地球科学进展, 2004, (S1):537-541. REN N Q, LI Y F, ZHENG G X, et al. Bio hydrogen production (Ⅰ):Progress in theoretical research[J]. Advance in Earth Sciences, 2004, (S1):537-541.
[9]	王继华, 赵爱萍. 生物制氢技术的研究进展与应用前景[J]. 环境科学研究, 2005, 18(4):129-135. WANG J H, ZHAO A P. Research progress and application prospect of biological hydrogen production technology[J]. Research of Environmental Sciences, 2005, 18(4):129-135.
[10]	BARBER W P, STUCKEY D C. The use of the anaerobic baffled reactor (ABR) for wastewater treatment:a review[J]. Water Research, 1999, 33(7):1559-1578.
[11]	KRISHNA G V T G, KUMAR P, KUMAR P. Treatment of low strength complex wastewater using an anaerobic baffled reactor (ABR)[J]. Bioresource Technology, 2008, 99(17):8193-8200.
[12]	李建政, 蒋凡, 郑国臣. ABR发酵产氢系统的控制运行及产氢效能[J]. 环境科学学报, 2010, 30(1):79-87. DOI:10.13671/j.hjkxxb.2010.01.010. LI J Z, JIANG F, ZHENG G C. Performance characteristics and hydrogen production efficiency of an anaerobic baffled reactor (ABR) used as a fermentation system[J]. Acta Scientiae Circumstantiae, 2010, 30(1):79-87. DOI:10.13671/j.hjkxxb.2010.01.010.
[13]	王娜, 杨涛, 韩静, 等. 厌氧发酵生物制氢的研究进展及应用前景[J]. 中国农学通报, 2008, 24(7):454-456. WANG N, YANG T, HAN J, et al. Present research situation and application prospect of hydrogen producing by biotechnology of anaerobic fermentation[J]. Chinese Agricultural Science Bulletin, 2008, 24(7):454-456.
[14]	刘晓烨, 张洪, 李永峰, 等. 复合式厌氧折流板反应器作为制氢系统的乙醇型发酵调控研究[J]. 环境科学学报, 2014, 34(4):881-887. DOI:10.13671/j.hjkxxb.2014.0145. LIU X Y, ZHANG H, LI Y F, et al. Ethanol type fermentation control with hybrid anaerobic baffled reactor as the hydrogen production system[J]. Acta Scientiae Circumstantiae, 2014, 34(4):881-887. DOI:10.13671/j.hjkxxb.2014.0145.
[15]	耿亚鸽, 张翔, 张浩勤, 等.ABR反应器工程设计的技术探讨[J]. 水处理技术, 2009, 35(2):103-107. GENG Y G, ZHANG X, ZHANG H Q, et al. Discussion on engineering design of ABR reactor[J]. Technology of Water Treatment, 2009, 35(2):103-107.
[16]	郑国臣, 赵峰, 李建政, 等. 微量元素对ABR发酵产氢产甲烷的影响[J]. 中国给水排水, 2012, 28(3):20-23. ZHENG G C, ZHAO F, LI J Z, et al. Effect of trace elements on fermentative co-production of hydrogen and methane in anaerobic baffled reactor[J]. China Water&Wastewater, 2012, 28(3):20-23.
[17]	李永峰, 王艺璇, 程国玲, 等. 二价铁离子对UASB反应器厌氧发酵产氢效能的影响[J]. 环境科学, 2013, 34(6):2290-2294. DOI:10.13227/j.hjkx.2013.06.016. LI Y F, WANG Y X, CHENG G L, et al. Effect of Fe2+on fermentation hydrogen production in an UASB[J]. Environmental Science, 2013, 34(6):2290-2294. DOI:10.13227/j.hjkx.2013.06.016.
[18]	韩伟, 陈红, 王占青, 等. 进水COD浓度变化对连续流搅拌槽式发酵制氢系统的影响[J]. 太阳能学报, 2012, (12):2038-2043. HAN W, CHEN H, WANG Z Q, et al. Effect of influent COD concentration on performance of biohydrogen production in continuous stirred tank reactor[J]. Acta Energiae Solaris Sinica, 2012, (12):2038-2043.
[19]	陈广银, 郑正, 常志州, 等. 不同氮源对麦秆厌氧消化过程的影响[J]. 中国环境科学, 2011, 31(1):73-77. CHEN G Y, ZHENG Z, CHANG Z Z, et al. Effects of nitrogen sources on anaerobic digestion process of wheat straw[J]. China Environmental Science, 2011, 31(1):73-77.
[20]	郑国臣, 李建政, 昌盛, 等. ABR发酵系统运行特性及产氢效能研究[J]. 中国环境科学, 2013, 33(1):75-81. DOI:10.13671/j.hjkxxb.2010.01.010. ZHENG G C, LI J Z, CHANG S, et al. Characteristics and hydrogen production efficiency in anaerobic baffled reactor (ABR) system[J]. China Environmental Science, 2013, 33(1):75-81. DOI:10.13671/j.hjkxxb.2010.01.010.
[21]	任南琪, 宫曼丽, 邢德峰. 连续流生物制氢反应器乙醇型发酵的运行特性[J]. 环境科学, 2004, (6):113-116. REN N Q, GONG M L, XING D F. Continuous operation of hydrogen bio-production reactor with ethanol type fermentation[J]. Environmental Science, 2004, (6):113-116. DOI:10.13227/j.hjkx.2004.06.023.
[22]	姜潇, 王毅力, 张桐, 等. 厌氧折流板反应器(ABR)中成熟颗粒污泥的分形分析[J]. 环境科学学报, 2008, 28(4):649-658. DOI:10.13671/j.hjkxxb.2008.04.018. JIANG X, WANG Y L, ZHANG T, et al. Fractal analysis on mature granular sludge in an anaerobic baffled reactor (ABR)[J]. Acta Scientiae Circumstantiae, 2008, 28(4):649-658. DOI:10.13671/j.hjkxxb.2008.04.018.
[23]	ZHU G F, LI J Z, WU P, et al. The performance and phase separated characteristics of an anaerobic baffled reactor treating soybean protein processing wastewater[J]. Bioresource Technology, 2008, 99:8027-8033.
[24]	REN N Q, WANG B Z, HUANG J C. Ethanol-type fermentation from carbohydrate in high rate acidogenic reactor[J]. Biotechnology and Bioengineering, 1997, 54(5):428-433.
[25]	朱葛夫, 李建政, 吕炳南, 等. ABR大豆蛋白废水处理系统的产氢性能分析[C]//第七届全国氢能学术会议专辑2006专辑Ⅱ, 2006:196-201. ZHU G F, LI J Z, LÜ B N, et al. Hydrogen production by soybean wastewater fermentation in an anaerobic baffled reactor[C]//The 7th Chinese Hydrogen Energy Conference Album 2006 AlbumⅡ, 2006:196-201.13] 王娜,杨涛,韩静,等.厌氧发酵生物制氢的研究进展及应用前景[J].中国农学通报,2008,24(7):454-456. WANG N,YANG T,HAN J, et al.Present research situation and application prospect of hydrogen producing by biotechnology of anaerobic fermentation[J].Chinese Agricultural Science Bulletin, 2008,24(7):454-456.
[14]	刘晓烨,张洪,李永峰,等. 复合式厌氧折流板反应器作为制氢系统的乙醇型发酵调控研究[J]. 环境科学学报,2014,34(4):881-887. DOI:10.13671/j.hjkxxb.2014.0145. LIU X Y,ZHANG H,LI Y F,et al.20.Ethanol type fermentation control with hybrid anaerobic baffled reactor as the hydrogen production system[J].Acta Scientiae Circumstantiae,2014,34(4):881-887. DOI:10.13671/j.hjkxxb.2014.0145.
[15]	耿亚鸽,张翔,张浩勤,等.ABR反应器工程设计的技术探讨[J].水处理技术,2009,35(2):103-107. GENG Y G,ZHANG X,HAO Q, et al. Discussion on engineering design of ABR reactor[J].Technology of Water Treatment, 2009,35(2):103-107.
[16]	郑国臣,赵峰,李建政,等.微量元素对ABR发酵产氢产甲烷的影响[J].中国给水排水,2012,28(3):20-23. ZHENG G C,ZHAO F,LI J Z,et al.Effect of trace elements on fermentative co-production of hydrogen and methane in anaerobic baffled reactor[J].China Water&Wastewater, 2012,28(3):20-23.
[17]	李永峰,王艺璇,程国玲,等.二价铁离子对UASB反应器厌氧发酵产氢效能的影响[J].环境科学,2013,34(6):2290-2294. DOI:10.13227/j.hjkx.2013.06.016. LI Y F,WANG Y X,CHENG G L,et al.Effect of Fe2+ on fermentation hydrogen production in an UASB[J]. Environmental Science,2013,34(6):2290-2294. DOI:10.13227/j.hjkx.2013.06.016.
[18]	韩伟,陈红,王占青,等.进水COD浓度变化对连续流搅拌槽式发酵制氢系统的影响[J]. 太阳能学报,2012,(12):2038-2043. HAN W,CHEN H,WANG Z Q,et al.Effect of influent COD concentration on performance of biohydrogen production in continuous stirred tank reactor[J]. Acta Energiae Solaris Sinica, 2012,(12):2038-2043.
[19]	陈广银,郑正,常志州,等.不同氮源对麦秆厌氧消化过程的影响[J].中国环境科学, 2011,31(1):73-77. CHEN G Y,ZHENG Z,CHANG Z Z,et al.Effects of nitrogen sources on anaerobic digestion process of wheat straw[J].China Environmental Science, 2011,31(1):73-77.
[20]	郑国臣,李建政,昌盛,等.ABR发酵系统运行特性及产氢效能研究[J].中国环境科学,2013,33(1):75-81.DOI:10.13671/j.hjkxxb.2010.01.010. ZHENG G C,LI J Z,CHANG S, et al. Characteristics and hydrogen production efficiency in anaerobic baffled reactor (ABR) system[J]. China Environmental Science, 2013,33(1):75-81.DOI:10.13671/j.hjkxxb.2010.01.010.
[21]	姜潇,王毅力,张桐,等.厌氧折流板反应器(ABR)中成熟颗粒污泥的分形分析[J]. 环境科学学报, 2008,28(4):649-658.DOI:10.13671/j.hjkxxb.2008.04.018. JIANG X,WANG Y L,ZHANG T, et al. Fractal analysis on mature granular sludge in an anaerobic baffled reactor(ABR)[J]. Acta Scientiae Circumstantiae, 2008,28(4):649-658.DOI:10.13671/j.hjkxxb.2008.04.018.
[22]	ZHU G F, LI J Z, WU P, et al. The performance and phase separated characteristics of an anaerobic baffled reactor treating soybean protein processing wastewater[J]. Bioresource Technology, 2008,99(80)27-8033.
[23]	REN NQ, WANG BZ, HUANG JC. Ethanol-type fermentation from carbohydrate in high rate acidogenic reactor[J].Biotechnologyand Bioengineering,1997,54(5):428-433.
[24]	朱葛夫,李建政,吕炳南,等.ABR大豆蛋白废水处理系统的产氢性能分析[C]//第七届全国氢能学术会议专辑2006专辑Ⅱ.2006:196-201. ZHU G F, LI J Z, LV B N,et al. Hydrogen production by soybean wastewater fermentation in an anaerobic baffled reactor[C]//The 7th Chinese Hydrogen Energy Conference Album 2006 AlbumⅡ, 2006:196-201..
[25]	任南琪,宫曼丽,邢德峰. 连续流生物制氢反应器乙醇型发酵的运行特性[J]. 环境科学,2004,(6):113-116. REN N Q,GONG M L,XING D F.Continuous operation of hydrogen bio-production reactor with ethanol type fermentation[J].Environmental Science,2004,(6):113-116.DOI:10.13227/j.hjkx.2004.06.023