不同运行环境蒸汽动力系统特性

doi:10.11949/j.issn.0438-1157.20160546

化工学报 ›› 2016, Vol. 67 ›› Issue (S1): 318-325.DOI: 10.11949/j.issn.0438-1157.20160546

不同运行环境蒸汽动力系统特性

李健¹, 张国磊¹, 史智俊², 杨龙滨¹, 马彪¹, 曾帅¹, 李子豪¹

1 哈尔滨工程大学动力与能源工程学院, 黑龙江哈尔滨 150001;
2 中国船舶重工集团公司第703研究所, 黑龙江哈尔滨 150078

收稿日期:2016-04-26 修回日期:2016-05-03 出版日期:2016-08-31 发布日期:2016-08-31
通讯作者: 张国磊,zhangguolei@hrbeu.edu.cn
基金资助:
国家自然科学基金项目（51479040，51409070）；黑龙江省自然科学基金项目（E201422）。

Characteristics of steam dynamic system in different operating environment

LI Jian¹, ZHANG Guolei¹, SHI Zhijun², YANG Longbin¹, MA Biao¹, ZENG Shuai¹, LI Zihao¹

1 College of Power and Energy Engineering, Harbin Engineering University, Harbin 150001, Heilongjiang, China;
2 703 Research Institute of China Shipbuilding Industry Corporation, Harbin 150078, Heilongjiang, China

Received:2016-04-26 Revised:2016-05-03 Online:2016-08-31 Published:2016-08-31
Supported by:
supported by the National Natural Science Foundation of China (51479040，51409070)and the Natural Science Foundation of Heilongjiang Province (E201422).

摘要/Abstract

摘要：

环境温度和压力作为蒸汽动力系统的自然工作条件，对于动力系统尤其是增压锅炉装置运行的安全性及经济性有重要影响。建立了蒸汽动力系统仿真模型，对不同环境条件下的动力系统运行特性进行仿真研究。结果表明：环境温度越高，涡轮增压机组辅机功率及蒸汽消耗量越大，动力系统燃油消耗量越大；环境压力越低，涡轮增压机组辅机功率及蒸汽消耗量越大，动力系统燃油消耗量越大；动力系统负荷越低，辅助汽轮机在为压气机提供功率时所占的比重越大。

关键词: 蒸汽动力, 环境条件, 响应规律, 过程系统, 模型, 动态仿真

Abstract:

Environmental temperature and pressure, which act as the operating condition of the steam power system, play an important role in the safety and economy of the whole system. The simulation model of a steam power system was established to analyze and discuss the characteristics of the system under different ambient temperature and pressure. The results show that auxiliary engine power, steam flow and fuel flow increase with the raise of environmental temperature. Also, auxiliary engine power, steam flow and fuel flow increase with the decline of environmental pressure.Moreover, a lower load of dynamic system leads to a greater proportion of auxiliary engine power.

Key words: steam power, environment condition, response pattern, process systems, model, dynamic simulation

中图分类号:

TQ028.8

李健, 张国磊, 史智俊, 杨龙滨, 马彪, 曾帅, 李子豪. 不同运行环境蒸汽动力系统特性[J]. 化工学报, 2016, 67(S1): 318-325.

LI Jian, ZHANG Guolei, SHI Zhijun, YANG Longbin, MA Biao, ZENG Shuai, LI Zihao. Characteristics of steam dynamic system in different operating environment[J]. CIESC Journal, 2016, 67(S1): 318-325.

参考文献 20

[1]	张志华. 船舶动力装置概论[M]. 哈尔滨:哈尔滨工程大学出版社, 2001:7-8. ZHANG Z H. Introduction to Ship Power Equipment[M]. Harbin:Harbin Engineering University Press, 2001:7-8.
[2]	韩静.舰用增压锅炉热平衡及动态仿真研究[D].哈尔滨:哈尔滨工程大学,2006. HAN J.Heat balance analysis and dynamic simulation in marine supercharged boiler[D].Harbin:Harbin Eng-ineering Uninersity,2006.
[3]	刘云生,陈华清,张宁,等.舰船动力系统综合评估指标体系[J].船舶工程,2008,30(4):32-35. LIU Y S,CHEN H Q,ZHANG N,et al. An index system for the comprehensive evaluation of warship propulsion system[J].Ship Engineering,2008,30(4):32-35.
[4]	于文轩. 船用增压锅炉动力系统的仿真研究[D]. 重庆:重庆大学, 2008. YU W X. Simulation research on the dynamic system of marine turbocharged boiler[D]. Chongqing:Chongqing University, 2008.
[5]	AKIBA M.Thermodynamic analysis of new combination of supercharged boiler cycle and heat recovery cycle for power generation[J].Journal of Engineering for Gas Turbines and Power,1996,118:453-460.
[6]	薛敏.增压锅炉热力性能校核计算机动态性能研究[D].哈尔滨:哈尔滨工程大学,2007. XUE M.Calculation and dynamic performance study of the thermal performance of a turbocharged boiler[D].Harbin:Harbin Engineering Uninersity,2007.
[7]	沈志刚,邹积国,姜任秋,等.增压锅炉机组重要热工参数的选择[J].热能动力工程,2003,18(103):27-29. SHEN Z G,ZOU J G,JIANG R Q,et al.The selection of major thermodynamic parameters for a supercharged boiler unit[J].Journal of Engineering for Thermal Energy and Power,2003,18(103):27-29.
[8]	李可顺,孙培廷,常东晓.环境条件对船舶柴油机涡轮增压器性能的影响[J].世界海运,2004,27(6):48-49. LI K S,SUN P T,CHANG D X.Influence of ambient conditions to the performance of marine diesel turbocharger[J].World Shipping,2004,27(6):48-49.
[9]	王剑平,周国义,孙丰瑞.大气温度对涡轮增压机组性能影响的分析[J].燃气轮机技术,2005,18(1):35-37. WANG J P,ZHOU G Y,SUN F R.Influence analyses of atmospheric temperature on performance of turbo-charger set[J].Gas Turbine Technology,2005,18(1):35-37.
[10]	赵进刚.舰用蒸汽动力装置特有的环境适应性[J].船舶工程,2010,32(5):19-22. ZHAO J G.Particular environmental suitability of marine steam power plant[J].Ship Engineering,2010,32(5):19-22.
[11]	罗向龙,陈颖,华贲.参数不确定性条件下蒸汽动力系统的运行优化[J].石油学报(石油加工),2009,25(2):233-240. LUO X L,CHEN Y,HUA B.Operational planning optimization of utility system under parameters uncertainty[J]. Acta Petrolei Sinica(Petroleum Processing Section),2009,25(2):233-240.
[12]	李晖,孙力,贺高红.考虑不确定汽电需求的蒸汽动力系统优化设计[J].化工学报,2013,64(1):318-325. LI H,SUN L,HE G H.Design and optimization of steam power system with uncertain steam and power demands[J].CIESC Journal,2013,64(1):318-325.
[13]	刘畅,孙力,贺高红,等.基于不确定蒸汽需求和设备故障的锅炉系统随机规划设计[J].化工学报,2014,65(9):3512-3517. LIU C,SUN L,HE G H,et al.Boiler system design based on stochastic programming under uncertain steam demand and equipment failure[J].CIESC Journal,2014,65(9):3512-3517.
[14]	WOJNAR W, PRONOBIS M.The model of flow and temperature dostribution in the superheater of a power boiler[J].Rynek Energii,2008,6:39-46.
[15]	姜洋.基于流体网络的船舶蒸汽动力系统动态性能研究[D].哈尔滨:哈尔滨工程大学,2013. JIANG Y. Research on dynamic performance of marine steam power system based on fluid network[D].Harbin:Harbin Engineering Uninersity,2013.
[16]	李彦军.增压锅炉热力性能参数变化规律及动态性能研究[D]. 哈尔滨:哈尔滨工程大学,2006 LI Y J. Study of the thermal performance parameters and dynamic characters in the supercharged boiler[D]. Harbin:Harbin Engineering University,2006.
[17]	COHEN H,ROGERS G F C,Saravanamuttoo H I H. Gas Turbine Theory[M].London:Longman Group Limited,1996:338-341.
[18]	姚寿广. 船舶热力系统分析[M]. 北京:科学出版社, 2003:8-10. YAO S G.Analysis of Ship Thermodynamic System[M].Beijing:Science Press,2003:8-10.
[19]	王成.基于GSE的增压锅炉系统动态性能仿真研究[D].哈尔滨:哈尔滨工程大学,2012. WANG C.Simulation research on dynamic performance of supercharged boiler system based on GSE[D].Harbin:Harbin Engineering Uninersity,2012.
[20]	史智俊,张国磊,李彦军,等.回汽保护控制下舰用蒸汽动力系统响应规律[J].化工学报,2015,66(S2):287-293. SHI Z J,ZHANG G L,LI Y J,et al.Response pattern of marine steam power system under back-steam protection[J].CIESC Journal,2015,66(S2):287-293.

不同运行环境蒸汽动力系统特性

Characteristics of steam dynamic system in different operating environment

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

本文评价

[1]	杨欣, 王文, 徐凯, 马凡华. 高压氢气加注过程中温度特征仿真分析[J]. 化工学报, 2023, 74(S1): 280-286.
[2]	宋嘉豪, 王文. 斯特林发动机与高温热管耦合运行特性研究[J]. 化工学报, 2023, 74(S1): 287-294.
[3]	张思雨, 殷勇高, 贾鹏琦, 叶威. 双U型地埋管群跨季节蓄热特性研究[J]. 化工学报, 2023, 74(S1): 295-301.
[4]	连梦雅, 谈莹莹, 王林, 陈枫, 曹艺飞. 地下水预热新风一体化热泵空调系统制热性能研究[J]. 化工学报, 2023, 74(S1): 311-319.
[5]	金正浩, 封立杰, 李舒宏. 氨水溶液交叉型再吸收式热泵的能量及分析[J]. 化工学报, 2023, 74(S1): 53-63.
[6]	王浩, 王振雷. 基于自适应谱方法的裂解炉烧焦模型化简策略[J]. 化工学报, 2023, 74(9): 3855-3864.
[7]	陈哲文, 魏俊杰, 张玉明. 超临界水煤气化耦合SOFC发电系统集成及其能量转化机制[J]. 化工学报, 2023, 74(9): 3888-3902.
[8]	李科, 文键, 忻碧平. 耦合蒸气冷却屏的真空多层绝热结构对液氢储罐自增压过程的影响机制研究[J]. 化工学报, 2023, 74(9): 3786-3796.
[9]	李锦潼, 邱顺, 孙文寿. 煤浆法烟气脱硫中草酸和紫外线强化煤砷浸出过程[J]. 化工学报, 2023, 74(8): 3522-3532.
[10]	郑玉圆, 葛志伟, 韩翔宇, 王亮, 陈海生. 中高温钙基材料热化学储热的研究进展与展望[J]. 化工学报, 2023, 74(8): 3171-3192.
[11]	于旭东, 李琪, 陈念粗, 杜理, 任思颖, 曾英. 三元体系KCl + CaCl₂ + H₂O 298.2、323.2及348.2 K相平衡研究及计算[J]. 化工学报, 2023, 74(8): 3256-3265.
[12]	诸程瑛, 王振雷. 基于改进深度强化学习的乙烯裂解炉操作优化[J]. 化工学报, 2023, 74(8): 3429-3437.
[13]	闫琳琦, 王振雷. 基于STA-BiLSTM-LightGBM组合模型的多步预测软测量建模[J]. 化工学报, 2023, 74(8): 3407-3418.
[14]	郭雨莹, 敬加强, 黄婉妮, 张平, 孙杰, 朱宇, 冯君炫, 陆洪江. 稠油管道水润滑减阻及压降预测模型修正[J]. 化工学报, 2023, 74(7): 2898-2907.
[15]	李贵贤, 曹阿波, 孟文亮, 王东亮, 杨勇, 周怀荣. 耦合固体氧化物电解槽的CO₂制甲醇过程设计与评价研究[J]. 化工学报, 2023, 74(7): 2999-3009.