常温下接种回流污泥实现BAF一体化自养脱氮工艺

doi:10.11949/j.issn.0438-1157.20161699

摘要/Abstract

摘要：

为实现高氨氮废水的高效低耗稳定去除，在常温条件下，对曝气生物滤池（BAF）中实现与稳定短程硝化-厌氧氨氧化自养脱氮工艺进行了研究。研究结果表明：常温条件下，BAF接种二沉池回流污泥，采用闷曝-连续运行结合的接种挂膜方式，可成功实现短程硝化-厌氧氨氧化一体化自养脱氮。闷曝阶段使种泥活性恢复，而连续流运行过程中游离氨（FA）浓度高，可抑制亚硝酸盐氧化菌（NOB），实现BAF中亚硝酸盐累积；通过调整BAF回流方式，降低回流液中NO₂^--N，防止NOB生长，并通过厌氧氨氧化（Anammox）滤池出水回流方式，接种微量Anammox菌，运行80 d可实现短程硝化-厌氧氨氧化，140 d后系统运行稳定，总氮（TN）去除率达76.62%。生物滤池有利于短程硝化-厌氧氨氧化工艺的实现与稳定，生物膜中不同厚度存在好氧缺氧环境，利于氨氧化菌（AOB）和Anammox菌共存；滤料的过滤作用有效地防止了Anammox菌流失，使其在系统中不断累积生长。不仅如此，AOB和Anammox菌均为自养菌且生长缓慢，避免了生物滤池的频繁反冲洗，简化了生物滤池的运行。气水比是BAF中一体化运行的关键参数，本研究中最佳的气水比为12：1，氨氮去除负荷达到0.91 kg N·m^-3·d^-1，氨氮和TN去除率分别可达96.86%和85.47%。

关键词: BAF, 高氨氮废水, 短程硝化, 厌氧氨氧化, 自养脱氮, 启动, 生物膜, 过滤

Abstract:

To treat high ammonia nitrogen wastewater efficiently and low costly, achieving and stabilizing autotrophic nitrogen removal in biology aerated filter (BAF) were studied. The obtained results showed that autotrophic nitrogen removal was achieved through the combination of batch and continuous operation in the BAF with volcanics as filter, using the second pond reflux sludge as seeding sludge. During batch operation, the activity of seeding sludge was recovered. During the continuous operation, high free ammonia (FA) concentration inhibited the growth of nitrite oxidation bacteria (NOB). Through recycling the effluent of anaerobic ammonia oxidation (Anammox) biofilter, very slight of Anammox bacteria was inoculated in BAF. After 80 days operation, autotrophic nitrogen removal was achieved. From the 140th day, the removal rate of total nitrogen (TN) approach to 76.62%, and it can be stable all the time. Since aerobic and anoxic environment occurred in different depth of biofilm, ammonia oxidation bacteria (AOB) and Anammox bacteria can coexist in biofilm. Meanwhile, the filtration of volcanics can prevent Anammox bacteria from flowing out of BAF, making the enrichment of Anammox in the system of autotrophic nitrogen removal. In the meantime, AOB and Anammox as autotrophic bacteria grows slow, preventing the biofilter backwash frequently and simplifying the operation of biofilter. Air and water ratio is one of the key operation parameters in BAF of partial nitrification and Anammox. It was shown that the optimal air and water ratio in this study was 12:1. Accordingly, the removal loading radio of ammonia was 0.91 kg N·m^-3·d^-1. The removal efficiency of ammonia and TN were 96.86% and 85.47%, respectively.

Key words: BAF, high ammonia nitrogen wastewater, partial nitrification, Anammox, autotrophic nitrogen removal, start-up, biofilm, filtration

中图分类号:

X703.1

杨庆, 周桐, 刘秀红, 李海鑫, 李健敏, 余飞, 彭永臻. 常温下接种回流污泥实现BAF一体化自养脱氮工艺[J]. 化工学报, 2017, 68(5): 2081-2088.

YANG Qing, ZHOU Tong, LIU Xiuhong, LI Haixin, LI Jianmin, YU Fei, PENG Yongzhen. Implementation of integrated autotrophic nitrogen removal system at normal temperature by returned sludge[J]. CIESC Journal, 2017, 68(5): 2081-2088.

参考文献 32

[1]	OKABE S, OSHIKI M, TAKAHASHI Y, et al. N2O emission from a partial nitrification-anammox process and identification of a key biological process of N2O emission from anammox granules [J]. Water Research, 2011, 45 (19): 6461-6470.
[2]	KUENEN J G. Anammox bacteria: from discovery to application [J]. Nat. Rev. Microbiol., 2008, 6 (4): 320-326.
[3]	KARTAL B, KUENEN J G, LOOSDRECHT M C M. Sewage treatment with Anammox [J]. Science, 2010, (328): 702-703.
[4]	GAO D, LU J, LIANG H. Simultaneous energy recovery and autotrophic nitrogen removal from sewage at moderately low temperatures [J]. Applied Microbiology and Biotechnology, 2014, 98 (6): 2637-2645.
[5]	LACKNER S, GILBERT E M, VLAEMINCK S E, et al. Full-scale partial nitritation/anammox experiences—an application survey [J]. Water Research, 2014, 55: 292-303.
[6]	JETTEN M S M, STROUS M, VAN DE PAS-SCHONEN K T, et al. The anaerobic oxidation of ammonium [J]. FEMS Microbiology Reviews, 1999, (22): 421-437.
[7]	PARK H, ROSENTHAL A, RAMALINGAM K, et al. Linking community profiles, gene expression and N-removal in Anammox bioreactors treating municipal anaerobic digestion reject water [J]. Environmental Science & Technology, 2010, 44 (16): 6110-6116.
[8]	ALI M, OSHIKI M, AWATE T, et al. Physiological characterization of anaerobic ammonium oxidizing bacterium Candidatus Jettenia caeni [J]. Environmental Microbiology, 2014, 17 (6): 2172-2189.
[9]	AWATA T, OSHIKI M, KINDAICHI T, et al. Physiological characterization of an anaerobic ammonium-oxidizing bacterium belonging to the “Candidatus Scalindua” group [J]. Applied and Environmental Microbiology, 2013, 79 (13): 4145-4148.
[10]	OSHIKI M, SHIMOKAWA M, FUJJII N, et al. Physiological characteristics of the anaerobic ammonium-oxidizing bacterium Candidatus Brocadia sinica [J]. Microbiology, 2011, (157): 1706-1713.
[11]	张倩, 王淑莹, 苗圆圆, 等. 间歇低氧曝气下CANON工艺处理生活污水的启动 [J]. 化工学报, 2017, 68 (1): 289-296. ZHANG Q, WANG S, MIAO Y Y, et al. Start-up of CANON process on domestic wastewater using intermittent aeration with low DO [J]. CIESC Journal, 2017, 68 (1): 289-296.
[12]	余彬, 陈广升. A/O+BAF工艺处理高氨氮煤化工废水 [J]. 中国给水排水, 2013, 29 (6): 81-88. YU B, CHEN G S. A/O+BAF process for treatment of coal chemical wastewater with high ammonia nitrogen [J]. China Water& Wastewater, 2013, 29 (6): 81:88.
[13]	李亚峰, 马晨曦, 张驰. UASBB厌氧氨氧化反应器处理污泥脱水液的影响因素研究 [J]. 环境科学, 2014, 35 (8): 3044-3051. LI Y F, MA C X, ZHANG C. Influencing factors of sludge liquor treatment in UASBB [J]. Environmental Science, 2014, 35 (8): 3044-3051.
[14]	孙洪伟, 彭永臻, 时晓宁. UASB-A/O工艺处理垃圾渗滤液短程生物脱氮的实现 [J]. 中国环境科学, 2009, 29 (10): 1059-1064. SUN H W, PENG Y Z, SHI X N. Achieving nitrogen removal from landfill leachate via UASB-A/O process [J]. China Environmental Science. 2009, 29 (10): 1059-1064.
[15]	李忠明, 王淑莹, 苗蕾. 单级SBR厌氧/好氧/缺氧处理中期垃圾渗滤液深度脱氮 [J]. 化工学报, 2015, 66 (2): 746-752. LI Z M, WANG S Y, MIAO L. Nitrogen removal from medium-age landfill leachate via anaerobic/aerobic/anoxic process in SBR [J]. CIESC Journal, 2015, 66 (2): 746-752.
[16]	张亮, 王淑莹, 张树军, 等. 高氨氮污泥脱水液短程硝化反硝化的启动及稳定 [J]. 环境工程学报, 2012, 6 (4): 1064-1068. ZHANG L, WANG S Y, ZHANG S J. Start up and maintenance of partial nitrification-denitrification of high strength ammonia sludge dewatering water [J]. Chinese Journal of Environmental Engineering. 2012, 6 (4): 1064-1068.
[17]	王成, 孟佳, 李玖龄, 等. 升流式微氧生物膜反应器处理高氨氮低C/N比养猪废水的效能 [J]. 化工学报, 2016, 67 (9): 3895-3901. WANG M,MENG J, LI J L, et al. Pollutant removal efficiency in upflow microaerobic biofilm reactor treating manure-free piggery wastewater with low COD/TN ratio and high [J]. CIESC Journal, 2016, 67 (9): 3895-3901.
[18]	马军, 邱立平. 曝气生物滤池及其研究进展 [J]. 环境工程, 2002, 20 (3): 7-11. MA J, QIU L P. Biological aerated filter and its research progress [J]. Environment Engineering, 2002, 20 (3): 7-11.
[19]	LIU X H, WANG H C, LONG F, et al. Optimizing and real-time control of biofilm formation, growth and renewal in denitrifying biofilter [J]. Bioresource Technology, 2016, (209): 326-332.
[20]	杨庆, 谷鹏超, 刘秀红, 等. 两种典型滤料厌氧氨氧化效果与工艺运行优化 [J]. 化工学报, 2015, 66 (1): 455-463. YANG Q,GU P C, LIU X H, et al. Comparison of performance and optimizing process for two typical filter medias of ANAMMOX biofilters [J]. CIESC Journal, 2015, 66 (1): 455-463.
[21]	李冬, 杨卓, 梁瑜海, 等. 耦合反硝化的CANON生物滤池脱氮研究 [J]. 中国环境科学, 2014, (6): 1448-1456. LI D,YANG Z,LIANG Y H, et al. Nitrogen removal performance by CANON biological filtration with denitrification [J]. China Environmental Science, 2014, (6): 1448-1456.
[22]	GUO J, PENG Y, WANG S, et al. Long-term effect of dissolved oxygen on partial nitrification performance and microbial community structure [J]. Bioresource Technology, 2009, 100 (11): 2796-2802.
[23]	BLACKBUME R, YUAN Z G, KELLER J. Partial nitrification to nitrite using low dissolved oxygen concentration as the main selection factor [J]. Biodegradation, 2008, 19 (2): 303-312.
[24]	HELLINGA C, SCHELLEN A A J C, MULDER J W, et al. The SHARON process: an innovative method for nitrogen removal from ammonium-rich waste water [J]. Water Science and Technology, 1998, 37 (9): 135-142.
[25]	PARK S, BAE W. Modeling kinetics of ammonia oxidation under simultaneious inhibition by free ammonia and free nitrous acid [J]. Process Biochemistry, 2009, 44 (6): 631-640.
[26]	MOSQUERA C A, FERMOSO F G, CAMPOS J L, et al. Partial nitrification in a SHARON reactor in the presence of salts and organic carbon compounds [J]. Process Biochemistry, 2005, 40 (9): 3109-3118.
[27]	ZENG W, LI L, YANG Y, et al. Nitritation and denitritation of domestic wastewater using a continuous anaerobic-anoxic-aerobic (A2O) process at ambient temperatures [J]. Bioresource Technology, 2010, 101 (21): 8074-8082.
[28]	CHO S, TAKAHASHI Y, FUJII N, et al. Nitrogen removal performance and microbial community analysis of an anaerobic up-flow granular bed anammox reactor [J]. Chemosphere, 2010, 78 (9): 1129-1135.
[29]	YANG Q, LIU X H, PENG C Y, et al. N2O production during nitrogen removal via nitrite from domestic wastewater: main sources and control method [J]. Environmental Science & Technology, 2009, 43 (24): 9400-9406.
[30]	LIU X H, PENG Y, WANG C Y, et al. Nitrous oxide production during nitrogen removal from domestic wastewater in lab-scale sequencing batch reactor [J]. Journal of Environmental Sciences, 2008, 20 (6): 641-645.
[31]	ARROJO B, MOSQUERA C A, CAMPOS J L, et al. Effects of mechanical stress on Anammox granules in a sequencing batch reactor (SBR) [J]. Journal of Biotechnology, 2006, 123 (4): 453-463.
[32]	CEMA G, PLAZA E, TRELA J, et al. Dissolved oxygen as a factor influencing nitrogen removal rates in a one-stage system with partial nitritation and Anammox process [J]. Water Science and Technology, 2011, 64 (5): 1009-1015.