局部开口受限空间油气爆燃的超压瞬变与火焰行为

doi:10.11949/j.issn.0438-1157.20161640

化工学报 ›› 2017, Vol. 68 ›› Issue (8): 3310-3318.DOI: 10.11949/j.issn.0438-1157.20161640

• 其他 • 上一篇

局部开口受限空间油气爆燃的超压瞬变与火焰行为

王世茂^1,2, 杜扬^1,2, 李国庆^1,2, 齐圣^1,2, 王波^1,2, 李阳超^1,2

1 后勤工程学院军事供油工程系, 重庆 401331;
2 重庆市火灾与爆炸重点实验室, 重庆 401331

收稿日期:2017-01-18 修回日期:2017-03-24 出版日期:2017-08-05 发布日期:2017-08-05
通讯作者: 杜扬
基金资助:
国家自然科学基金项目（51276195）；重庆市研究生科研创新项目（CYB16128，CYB17150）。

Overpressure transients and flame behaviors of gasoline-air mixture deflagration in confined space with local opening

WANG Shimao^1,2, DU Yang^1,2, LI Guoqing^1,2, QI Sheng^1,2, WANG Bo^1,2, LI Yangchao^1,2

Department of Petroleum Supply Engineering, Logistical Engineering University, Chongqing 401331, China;
2 Chongqing Key Laboratory of Fire and Explosion Safety, Chongqing 401331, China

Received:2017-01-18 Revised:2017-03-24 Online:2017-08-05 Published:2017-08-05
Supported by:
supported by the National Natural Science Foundation of China (51276195) and the Graduate Research Innovation Project of Chongqing (CYB16128, CYB17150).

摘要/Abstract

摘要：

开展了油气在局部开口受限空间内油气爆燃的实验研究，获得了不同初始浓度下油气爆燃超压及火焰特性。研究结果表明：内场有两个超压峰值，外场仅有一个，开口处出现负压区。内外最大超压大小基本相同，均由外部爆燃形成。随着浓度的升高，超压先增后减，最大超压对应初始浓度为1.88%。火焰的传播过程分为3个阶段，火焰的形态、颜色、各阶段持续时间、直径、平均速度均受初始浓度的影响。随着初始浓度升高，火焰从淡蓝色层流光滑火焰变为亮黄色褶皱火焰，层流传播阶段和加速变形阶段的持续时间先增后减，溃散熄灭阶段的持续时间增加。火球直径与浓度的关系可用三次多项式描述，火焰平均速度随时间的变化可用二次多项式描述。随着开口率的升高，爆燃超压和火焰速度逐渐减小，火球直径先增大后减小。

关键词: 局部开口, 受限空间, 油气, 混合物, 爆燃, 实验验证

Abstract:

Experiments on gasoline-air mixture deflagration in the confined space with a local opening was carried out. Overpressure transients and flame behaviors under different concentration were acquired and the results showed that:there were two overpressure peaks inside the vessel but only one outside the vessel, and negative pressure zone was formed near the opening. The maximum value of internal and external overpressure were the same and both of them were caused by external deflagration. The value of overpressure peak showed the trend of first increasing and then decreasing with the increase of concentration, and the concentration corresponding to maximum overpressure peaks was 1.88%. The process of flame propagation could be divided into three stages, and the flame shape, color, duration of each stage, diameter of external fireball and average flame speed were dominated by initial concentration. With the increase of the concentration, the blue laminar flame with smooth front was changed into bright yellow flame with wrinkled front, and the duration of laminar propagating stage as well as accelerating and distorting stage showed the same trend of first increasing and then decreasing, but the duration of extinguishing stage showed a decreasing trend. The relationship between the diameter of fireball and concentration could be fitted by cubic polynomial, and the flame speed of 1st and 2nd stage could be fitted by quadratic polynomial. With the increase of opening ratio, the pressure peaks and flame speed of 2nd stage showed a decreasing trend, and the diameter of fireball showed a first increasing and then decreasing trend.

Key words: local opening, confined space, gasoline-air, mixture, explosion, experimental validation

中图分类号:

X932

王世茂, 杜扬, 李国庆, 齐圣, 王波, 李阳超. 局部开口受限空间油气爆燃的超压瞬变与火焰行为[J]. 化工学报, 2017, 68(8): 3310-3318.

WANG Shimao, DU Yang, LI Guoqing, QI Sheng, WANG Bo, LI Yangchao. Overpressure transients and flame behaviors of gasoline-air mixture deflagration in confined space with local opening[J]. CIESC Journal, 2017, 68(8): 3310-3318.

参考文献 31

[1]	CHAO J, BAUWENS C, DOROFEEV S B. An analysis of peak overpressures in vented gaseous explosions[J]. Proceedings of the Combustion Institute, 2011, 33(2):2367-2374.
[2]	QI S, DU Y, WANG S M, et al. The effect of vent size and concentration in vented gasoline-air explosions[J]. Journal of Loss Prevention in the Process Industries, 2016, 44:88-94.
[3]	FAKANDU B M, ANDREWS G E, PHYLAKTOU H N. Vent burst pressure effects on vented gas explosion reduced pressure[J]. Journal of Loss Prevention in the Process Industries, 2015, 36:429-438.
[4]	KUZNETSOV M, FRIEDRICH A, STERN G, et al. Medium-scale experiments on vented hydrogen deflagration[J]. Journal of Loss Prevention in the Process Industries, 2015, 36:416-428.
[5]	TOMLIN G, JOHNSON D M, CRONIN P, et al. The effect of vent size and congestion in large-scale vented natural gas/air explosions[J]. Journal Loss Prevention in the Process Industries, 2015, 35:169-181.
[6]	GUO J, SUN X X, RUI S C, et al. Effect of ignition position on vented hydrogen-air explosions[J]. International Journal of Hydrogen Energy, 2015, 40(45):15780-15788.
[7]	GUO J, LI Q, CHEN D D, et al. Effect of burst pressure on vented hydrogen-air explosion in a cylindrical vessel[J]. International Journal of Hydrogen Energy, 2015, 40(19):6478-6486.
[8]	BAUWENS C, CHAFFEE J, DOROFEEV S B. Vented explosion overpressures from combustion of hydrogen and hydrocarbon mixtures[J]. International Journal of Hydrogen Energy, 2011, 36(3):2329-2336.
[9]	GUO J, WANG C J, LIU X Y. Experimental study on duct-vented explosion of hydrogen-air mixtures in a wide range of equivalence ratio[J]. Industrial & Engineering Chemistry Research, 2016, 55(35):9518-9523.
[10]	BAO Q, FANG Q, ZHANG Y D, et al. Effects of gas concentration and venting pressure on overpressure transients during vented explosion of methane-air mixtures[J]. Fuel, 2016, 175:40-48.
[11]	BAUWENS C, CHAFFEE J, DOROFEEV S. Experimental and numerical study of methane-air deflagrations in a vented enclosure[J]. Fire Safety Science, 2008, 9:1043-1054.
[12]	KEENAN J, MAKAROV D V, MOLKOV V. Rayleigh-Taylor instability:modeling and effect on coherent deflagrations[J]. International Journal of Hydrogen Energy, 2014, 39(35):20467-20473.
[13]	QUILLATRE P, VERMOREL O, POINSOT T, et al. Large eddy simulation of vented deflagration[J]. Industrial & Engineering Chemistry Research, 2013, 52(33):11414-11423.
[14]	YAN X Q, YU J L, GAO W. Flame behaviors and pressure characteristics of vented dust explosions at elevated static activation overpressures[J]. Journal of Loss Prevention in the Process Industries, 2015, 33:101-108.
[15]	MA Q J, ZHANG Q, PANG L, et al. Effects of hydrogen addition on the confined and vented explosion behavior of methane in air[J]. Journal of Loss Prevention in the Process Industries, 2014, 27:65-73.
[16]	MAKAROV D, VERBECKE F, MOLKOV V. Numerical analysis of hydrogen deflagration mitigation by venting through a duct[J]. Journal of Loss Prevention in the Process Industries, 2007, 20(4/5/6):433-438.
[17]	LEE H G, KIM J. Numerical simulation of the three-dimensional Rayleigh-Taylor instability[J]. Computers & Mathematics with Applications, 2013, 66(8):1466-1474.
[18]	SARLI D V, BENEDETTO D A, RUSSO G. Using large eddy simulation for understanding vented gas explosions in the presence of obstacles[J]. Journal of Hazardous Materials, 2009, 169(1/2/3):435-442.
[19]	VYAZMINA E, JALLAIS S. Validation and recommendations for FLACS CFD and engineering approaches to model hydrogen vented explosions:effects of concentration, obstruction vent area and ignition position[J]. International Journal of Hydrogen Energy, 2016, 41(33):15101-15109.
[20]	BAUWENS C R, DOROFEEV S B. Effect of initial turbulence on vented explosion overpressures from lean hydrogen-air deflagrations[J]. International Journal of Hydrogen Energy, 2014, 39(35):20509-20515.
[21]	李阳超, 杜扬, 王世茂, 等. 端部开口受限空间汽油蒸气爆燃超压特性研究[J]. 中国安全生产科学技术, 2016, 12(7):32-36. LI Y C, DU Y, WANG S M, et al. Study on characteristics of deflagration overpressure for gasoline vapor in confined space with end opening[J]. Journal of Safety Science and Technology, 2016, 12(7):32-36.
[22]	吴松林, 杜扬, 欧益宏, 等. 圆柱形管道旁侧油气泄爆实验研究[J]. 爆炸与冲击, 2016, 36(5):680-687. WU S L, DU Y, OU Y H, et al, Experimental study for lateral gasoline-air venting explosion in cylindrical pipeline[J]. Explosion and Shock Wave, 2016, 36(5):680-687.
[23]	姜孝海, 范宝春, 叶经方. 泄爆诱导的湍流、旋涡和外部爆炸[J]. 应用数学和力学, 2004, 25(12):1271-1277. JIANG X H, FAN B C, YE J F. Turbulence, vortex and external explosion induced by venting[J]. Applied Mathematics and Mechanics, 2004, 25(12):1271-1277.
[24]	王世茂, 杜扬, 张少波, 等. 顶部开口条件下油罐油气爆炸数值模拟[J]. 后勤工程学院学报, 2015, 31(4):51-56. WANG S M, DU Y, ZHANG S B, et al. Numerical simulation research on fuel-air mixture explosion in the oil tank with an open top[J]. Journal of Logistical Engineering University, 2015, 31(4):51-56.
[25]	王世茂, 杜扬, 李阳超, 等. 含弱约束结构受限空间油气爆炸外部火焰特性[J]. 后勤工程学院学报, 2016, 32(5):39-43. WANG S M, DU Y, LI Y C, et al. External flame characteristics of gasoline-air mixture explosion in confined space with weakly constrained structure[J]. Journal of Logistical Engineering University, 2015, 32(5):39-43.
[26]	张培理. 受限空间油气爆炸及其抑制实验与数值分析研究[D]. 重庆:后勤工程学院, 2015. ZHANG P L. Study on experiment and numerical analysis of gasoline-air mixture explosion in confined space[D]. Chongqing:Logistical Engineering University, 2015.
[27]	LI G, DU Y, QI S, et al. Explosions of gasoline-air mixtures in a closed pipe containing a T-shaped branch structure[J]. Journal of Loss Prevention in the Process Industries, 2016, 43:529-536.
[28]	ZHANG P L, DU Y, WU S L, et al. Flame regime estimations of gasoline explosion in a tube[J]. Journal of Loss Prevention in the Process Industries, 2015, 33:304-310.
[29]	HU E, TIAN H, ZHANG X, et al. Explosion characteristics of n-butanol/iso-octane-air mixtures[J]. Fuel, 2017, 188:90-97.
[30]	王世茂. 含弱约束结构受限空间油气爆炸特性实验研究与数值模拟[D]. 重庆:后勤工程学院, 2016. WANG S M. Experimental study and numerical simulation on gasoline-air mixture explosion in the confined space with weakly confined structure[D]. Chongqing:Logistical Engineering University, 2016.
[31]	CASHDOLLAR K L, ZLOCHOWER A I, GREEN G M, et al. Flammability of methane, propane, and hydrogen gases[J]. Journal of Loss Prevention in the Process Industries, 2000, 13(3/4/5):327-340.

局部开口受限空间油气爆燃的超压瞬变与火焰行为

Overpressure transients and flame behaviors of gasoline-air mixture deflagration in confined space with local opening

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 31

相关文章 15

编辑推荐

Metrics

本文评价

[1]	汪尔奇, 彭书舟, 杨震, 段远源. 含HFO混合体系气液相平衡的理论模型评价[J]. 化工学报, 2023, 74(8): 3216-3225.
[2]	闫琳琦, 王振雷. 基于STA-BiLSTM-LightGBM组合模型的多步预测软测量建模[J]. 化工学报, 2023, 74(8): 3407-3418.
[3]	江锦波, 彭新, 许文烜, 门日秀, 刘畅, 彭旭东. 泵出型螺旋槽油气密封泄漏特性及参数影响研究[J]. 化工学报, 2023, 74(6): 2538-2554.
[4]	姚晓宇, 沈俊, 李健, 李振兴, 康慧芳, 唐博, 董学强, 公茂琼. 流体气液临界参数测量方法研究进展[J]. 化工学报, 2023, 74(5): 1847-1861.
[5]	许文烜, 江锦波, 彭新, 门日秀, 刘畅, 彭旭东. 宽速域三种典型型槽油气密封泄漏与成膜特性对比研究[J]. 化工学报, 2023, 74(4): 1660-1679.
[6]	罗来明, 张劲, 郭志斌, 王海宁, 卢善富, 相艳. 1~5 kW高温聚合物电解质膜燃料电池堆的理论模拟与组装测试[J]. 化工学报, 2023, 74(4): 1724-1734.
[7]	唐茹意, 潘罕骞, 郑侠俊, 张广欣, 汪星平, 崔希利, 邢华斌. Z型全氟聚醚的结构表征[J]. 化工学报, 2023, 74(1): 479-486.
[8]	席国君, 刘子涵, 雷广平. FeTPPs-CuBTC协同强化低浓度煤层气吸附分离[J]. 化工学报, 2022, 73(9): 3940-3949.
[9]	杨克, 王辰升, 纪虹, 郑凯, 邢志祥, 毕海普, 蒋军成. 聚多巴胺包覆混合粉体抑制甲烷爆炸的实验研究[J]. 化工学报, 2022, 73(9): 4245-4254.
[10]	刘潜, 张香兰, 李志平, 李玉龙, 韩梦醒. 油酚分离过程低共熔溶剂的筛选及萃取性能研究[J]. 化工学报, 2022, 73(9): 3915-3928.
[11]	朱莲峰, 王超, 张梦娟, 刘方正, 贾鑫, 安萍, 许光文, 韩振南. 水蒸气/氧流化床两段煤气化制备低焦油合成气工艺实验[J]. 化工学报, 2022, 73(8): 3720-3730.
[12]	解文潇, 贾胜坤, 张会书, 罗祎青, 袁希钢. 受限空间内浮升气泡与液体间传质行为实验研究[J]. 化工学报, 2022, 73(7): 2902-2911.
[13]	黄陆月, 刘畅, 许勇毅, 邢浩若, 王峰, 马双忱. CDI二维浓度传质模型的建立以及实验验证[J]. 化工学报, 2022, 73(7): 2933-2943.
[14]	高欢, 丁国良, 周发贤, 庄大伟. R410A制冷剂在润滑油中的动态析出特性的研究[J]. 化工学报, 2022, 73(3): 1054-1062.
[15]	张建伟, 安丰元, 董鑫, 冯颖. 基于阶跃射流的撞击流反应器流场动态特性分析[J]. 化工学报, 2022, 73(2): 622-633.