三元水盐体系冰点和共晶点的测定、相图表达及计算

doi:10.11949/j.issn.0438-1157.20161809

化工学报 ›› 2017, Vol. 68 ›› Issue (9): 3336-3342.DOI: 10.11949/j.issn.0438-1157.20161809

三元水盐体系冰点和共晶点的测定、相图表达及计算

刘福云, 黄雪莉, 黄文婷, 王雪莹, 潘毅

新疆煤炭洁净转化与化工过程重点实验室, 新疆大学化学化工学院, 新疆乌鲁木齐 830046

收稿日期:2016-12-26 修回日期:2017-05-12 出版日期:2017-09-05 发布日期:2017-09-05
通讯作者: 黄雪莉
基金资助:
国家自然科学基金项目（21166022）。

Determination, graphics expression and calculation of freezing point and eutectic point in ternary salt-water system

LIU Fuyun, HUANG Xueli, HUANG Wenting, WANG Xueying, PAN Yi

Key Laboratory of Cleaner Transition of Coal & Chemicals Engineering of Xinjiang Uyghur Autonomous Region, College of Chemistry and Chemical Engineering, Xinjiang University, Urumqi 830046, Xinjiang, China

Received:2016-12-26 Revised:2017-05-12 Online:2017-09-05 Published:2017-09-05
Contact: 10.11949/j.issn.0438-1157.20161809
Supported by:
supported by the National Natural Science Foundation of China (21166022).

摘要/Abstract

摘要：

针对Na⁺//Cl^-，NO₃^--H₂O、Na⁺//Cl^-，SO₄^2--H₂O和Na⁺，K⁺//Cl^--H₂O 3个三元水盐体系，测定了不同组成时溶液的冰点、共晶点以及降温过程的析盐规律，绘制出三元体系温度-组成立体相图。结果表明：三元体系的冰点、共晶点、相关系与组成可用三棱柱表达，3个三元水盐体系在共晶点温度下均无复盐存在，各含有1个两盐与冰的共晶点，3条单盐与冰或盐盐的共晶线，1个冰和两个单盐结晶区；用三元体系温度-组成立体相图能更直观地表达三元水盐体系的结晶区、冰点、共晶点和溶液组成的关系，可以判断溶液降温过程中的盐或冰的析出类型、温度；同时建立了冰点经验公式，应用经验公式和过量吉布斯自由能模型预测三元体系的冰点和共晶点，计算值和实验值吻合良好。

关键词: 水盐体系, 共晶点, 冰点, 相图, 计算

Abstract:

In this paper, aiming at ternary salt-water systems of Na⁺//Cl^-,NO₃^--H₂O, Na⁺//Cl^-,SO₄^2--H₂O and Na⁺,K⁺//Cl^--H₂O, the freezing points, eutectic points and the crystallization regularities of salts were investigated; the three-dimensional phase diagrams of temperature-composition of the ternary systems were plotted according to experimental data. The results were as following:the relationships among the freezing point, eutectic point, phases and the compositions of solution for the ternary system can be expressed by triangular prism. In the three ternary systems, there were no double salts at the eutectic point temperature, and there was an eutectic point with two salts and ice, three eutectic lines with single salt and ice or two salts, a crystallization zone with ice and two single salt. The three-dimensional phase diagram of temperature-composition of solution can be used to describe the relationships among the crystalline regions, freezing points or eutectic points and the compositions of liquids for the ternary salt-water systems visually, and to determine the precipitation processes of salts or ice as cooling solution. Three empirical formulas about freezing points were established. The empirical formulas of freezing point and the excess Gibbs free energy model were used to predict the freezing point and eutectic point of the ternary systems, which turned out that the calculated values were in good agreement with the experimental values.

Key words: salt-water system, eutectic point, freezing point, phase diagram, calculation

中图分类号:

O642.5⁺4

刘福云, 黄雪莉, 黄文婷, 王雪莹, 潘毅. 三元水盐体系冰点和共晶点的测定、相图表达及计算[J]. 化工学报, 2017, 68(9): 3336-3342.

LIU Fuyun, HUANG Xueli, HUANG Wenting, WANG Xueying, PAN Yi. Determination, graphics expression and calculation of freezing point and eutectic point in ternary salt-water system[J]. CIESC Journal, 2017, 68(9): 3336-3342.

参考文献 32

[1]	SONG P S, LI W, SUN B, et al. Recent development on comprehensive utilization of salt lake resources[J]. Chinese Journal of Inorganic Chemistry, 2011, 27(5):801-815.
[2]	MA P. Sustainable exploitation and comprehensive utilization of salt lake resources in China[J]. Progress in Chemistry, 2009, 21(11):2349-2357.
[3]	SHEPARD M L, GOLDSTON C S, COCKS F H. The H2O-NaCl-glycerol phase diagram and its application in cryobiology[J]. Cryobiology, 1976, 13(1):9-23.
[4]	朱巧丽, 黄雪莉. -15℃下Na+,K+,Mg2+//Cl-,SO42--H2O体系相平衡[J]. 化工学报, 2015, 66(4):1252-1257. ZHU Q L, HUANG X L. Liquid-solid phase equilibrium of Na+,K+,Mg2+//Cl-,SO42--H2O system at -15℃[J]. CIESC Journal, 2015, 66(4):1252-1257.
[5]	COCKS F H, BROWER W E. Phase diagram relationships in cryobiology[J]. Cryobiology, 1974, 11(4):340-358.
[6]	PERALTA J M, RUBIOLO A C, ZORRILLA S E. Prediction of heat capacity, density and freezing point of liquid refrigerant solutions using an excess Gibbs energy model[J]. Journal of Food Engineering, 2007, 82(4):548-558.
[7]	付振海, 张志宏, 马艳芳, 等. 硫酸盐型卤水低温处理及其液相蒸发析盐规律的理论研究[J]. 无机盐工业, 2013, 45(2):29-32. FU Z H, ZHANG Z H, MA Y F, et al. Freeze sulfate-type brine at low temperature in stages and theoretical study on evaporation and crystallization behavior[J]. Inorganic Chemicals Industry, 2013, 45(2):29-32.
[8]	BEIER N, SEGO D, DONAHUE R, et al. Laboratory investigation on freeze separation of Saline mine waste water[J]. Cold Regions Science and Technology, 2007, 48(3):239-247.
[9]	张杰, 史学伟, 赵双良, 等. 水盐体系相平衡研究进展[J]. 化工学报, 2016, 67(2):379-389. ZHANG J, SHI X W, ZHAO S L, et al. Progress in study on phase equilibria of salt-water systems[J]. CIESC Journal, 2016, 67(2):379-389.
[10]	GAYLE F W, COCKS F H, SHEPARD M L. The H2O-NaCl-sucrose phase diagram and applications in cryobiology[J]. Journal of Chemical Technology and Biotechnology, 1977, 27(5):599-607.
[11]	伍倩, 郑绵平, 乜贞, 等. 西藏当雄错盐湖卤水冬季日晒蒸发实验研究[J]. 地质学报, 2013, 87(3):433-440. WU Q, ZHENG M P, NIE Z, et al. Experiment study of solar evaporation of brine form the Dangxiongcuo salt lake in winter[J]. Acta Geologica Sinica, 2013, 87(3):433-440.
[12]	GE X, WANG X. Estimation of freezing point depression, boiling point elevation, and vaporization enthalpies of electrolyte solutions[J]. Industrial & Engineering Chemistry Research, 2009, 48(4):2229-2235.
[13]	李青海, 顾同欣, 于升松, 等. 南翼山油田卤水低温结晶过程研究[J]. 物理化学学报, 2011, 27(8):1803-1808. LI Q H, GU T X, YU S S, et al. Study on the precipitation pathway of Nanyishan oilfield brine at subzero temperatures[J]. Acta Physico-Chimica Sinica, 2011, 27(8):1803-1808.
[14]	张霞, 黄雪莉. 低温下Na+//Cl-,SO42-,NO3--H2O体系相平衡研究[J]. 化学通报, 2015, 78(4):337-341. ZHANG X, HUANG X L. Study on the phase equilibrium of the quaternary system Na+//Cl-,SO42-,NO3--H2O at low temperatures[J]. Chemistry Bulletin, 2015, 78(4):337-341.
[15]	SUN Y, ZHANG Y, QUAN X. Treatment of petroleum refinery wastewater by microwave-assisted catalytic wet air oxidation under low temperature and low pressure[J]. Separation & Purification Technology, 2008, 62(3):565-570.
[16]	GAO W, SMITH D W, SEGO D C. Ice nucleation in industrial wastewater[J]. Cold Regions Science & Technology, 1999, 29(2):121-133.
[17]	LANGENHOFF A, STUCKEY D C. Treatment of dilute wastewater using an anaerobic baffled reactor:effect of low temperature[J]. Water Research, 2000, 34(15):3867-3875.
[18]	SILCOK H. Solubilities of Inorganic and Organic Compounds[M]. 3rd ed. Oxford:New York Pergamon Press, 1979:1151.
[19]	牛自得, 程芳琴. 水盐体系相图及应用[M]. 天津:天津大学出版社, 2002:269. NIU Z D, CHENG F Q. The Phase Diagram of Salt-Water System and Its Application[M]. Tianjin:Tianjin University Press, 2002:269.
[20]	WEAST R C. CRC Handbook of Chemistry and Physics[M]. BocaRaton, USA:CRC Press, 1974:2661.
[21]	OAKES C S, BODNAR R J, SIMONSON J M. The system NaCl-CaCl2-H2O(Ⅰ):The ice liquidus at 1 atm total pressure[J]. Geochimica Et Cosmochimica Acta, 1990, 54(3):603-610.
[22]	GIBBARD J R H F, GOSSMANN A F. Freezing points of electrolyte mixtures (Ⅰ):Mixtures of sodium chloride and magnesium chloride in water[J]. Journal of Solution Chemistry, 1974, 3(5):385-393.
[23]	DESNOYERS J E, BILLON M, LÉGER S, et al. Salting out of alcohols by alkali halides at the freezing temperature[J]. Journal of Solution Chemistry, 1976, 5(10):681-691.
[24]	王雪莹, 黄文婷, 黄雪莉. 多元水盐体系冰盐共晶点的测定和图形表达[J]. 化工学报, 2016, 67(5):1687-1693. WANG X Y, HUANG W T, HUANG X L. Determination and graphics expression of ice-salt eutectic points of multicomponent salt-water systems[J]. CIESC Journal, 2016, 67(5):1687-1693.
[25]	黄文婷. 水盐体系冰点实验研究与计算预测[D]. 乌鲁木齐:新疆大学, 2015. HUANG W T. The experimental determinatinon and prediction of freezing point of salt-water systems[D]. Urumqi:Xinjiang University, 2015.
[26]	张寒琦, 林英杰, 宋利珠, 等. 实用化学手册[M]. 北京:科学出版社, 2001:774. ZHANG H Q, LIN Y J, SONG L Z, et al. Handbook of Practical Chemistry[M]. Beijing:Science Press, 2001:774.
[27]	ALONSO H A T, PERALTA J M, RUBIOLO A C, et al. Prediction of the freezing point of multicomponent liquid refrigerant solutions[J]. Journal of Food Engineering, 2011, 104(1):143-148.
[28]	THOMSEN K, RASMUSSEN P, GANI R. Correlation and prediction of thermal properties and phase behaviour for a class of aqueous electrolyte systems[J]. Chemical Engineering Science, 1996, 51(14):3675-3683.
[29]	THOMSEN K. Aqueous electrolytes:model parameters and process simulation[D]. Denmark:Technical University of Denmark, 1997.
[30]	GARCÍA A V, THOMSEN K, STENBY E H. Prediction of mineral scale formation in geothermal and oilfield operations using the extended UNIQUAC model(Ⅰ):Sulfate scaling minerals[J]. Geothermics, 2005, 34(1):61-97.
[31]	GARCÍA A V, THOMSEN K, STENBY E H. Prediction of mineral scale formation in geothermal and oilfield operations using the extended UNIQUAC model(Ⅱ):Carbonate-scaling minerals[J]. Geothermics, 2006, 35(3):239-284.
[32]	黄文婷, 黄雪莉. 水盐体系冰点的预测[J]. 盐湖研究, 2015, 23(1):38-43. HUANG W T, HUANG X L. The experimental determinatinon and prediction of freezing point of salt-water systems[J]. Journal of Salt Lake Research, 2015, 23(1):38-43.

三元水盐体系冰点和共晶点的测定、相图表达及计算

Determination, graphics expression and calculation of freezing point and eutectic point in ternary salt-water system

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 32

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张思雨, 殷勇高, 贾鹏琦, 叶威. 双U型地埋管群跨季节蓄热特性研究[J]. 化工学报, 2023, 74(S1): 295-301.
[2]	肖明堃, 杨光, 黄永华, 吴静怡. 浸没孔液氧气泡动力学数值研究[J]. 化工学报, 2023, 74(S1): 87-95.
[3]	温凯杰, 郭力, 夏诏杰, 陈建华. 一种耦合CFD与深度学习的气固快速模拟方法[J]. 化工学报, 2023, 74(9): 3775-3785.
[4]	陈哲文, 魏俊杰, 张玉明. 超临界水煤气化耦合SOFC发电系统集成及其能量转化机制[J]. 化工学报, 2023, 74(9): 3888-3902.
[5]	刘远超, 关斌, 钟建斌, 徐一帆, 蒋旭浩, 李耑. 单层XSe₂（X=Zr/Hf）的热电输运特性研究[J]. 化工学报, 2023, 74(9): 3968-3978.
[6]	王俐智, 杭钱程, 郑叶玲, 丁延, 陈家继, 叶青, 李进龙. 离子液体萃取剂萃取精馏分离丙酸甲酯+甲醇共沸物[J]. 化工学报, 2023, 74(9): 3731-3741.
[7]	岳林静, 廖艺涵, 薛源, 李雪洁, 李玉星, 刘翠伟. 凹坑缺陷对厚孔板喉部空化流动特性影响研究[J]. 化工学报, 2023, 74(8): 3292-3308.
[8]	汪林正, 陆俞冰, 张睿智, 罗永浩. 基于分子动力学模拟的VOCs热氧化特性分析[J]. 化工学报, 2023, 74(8): 3242-3255.
[9]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[10]	牛超, 沈胜强, 杨艳, 潘泊年, 李熠桥. 甲烷BOG喷射器流动过程计算与性能分析[J]. 化工学报, 2023, 74(7): 2858-2868.
[11]	何晓崐, 刘锐, 薛园, 左然. MOCVD生长AlN单晶薄膜的气相和表面化学反应综述[J]. 化工学报, 2023, 74(7): 2800-2813.
[12]	文兆伦, 李沛睿, 张忠林, 杜晓, 侯起旺, 刘叶刚, 郝晓刚, 官国清. 基于自热再生的隔壁塔深冷空分工艺设计及优化[J]. 化工学报, 2023, 74(7): 2988-2998.
[13]	邵伟明, 韩文学, 宋伟, 杨勇, 陈灿, 赵东亚. 基于分布式贝叶斯隐马尔可夫回归的动态软测量建模方法[J]. 化工学报, 2023, 74(6): 2495-2502.
[14]	刘起超, 周云龙, 陈聪. 起伏振动垂直上升管气液两相流截面含气率分析与计算[J]. 化工学报, 2023, 74(6): 2391-2403.
[15]	邵远哲, 赵忠盖, 刘飞. 基于共同趋势模型的非平稳过程质量相关故障检测方法[J]. 化工学报, 2023, 74(6): 2522-2537.