一种测量石蜡相变乳液过冷度的新方法：平衡态比容法

doi:10.11949/0438-1157.20190293

摘要/Abstract

摘要：

石蜡相变乳液是集储热与传热于一体的新型功能流体，具有广阔的应用前景。但石蜡相变乳液在降温时会出现过冷现象，极大降低了其储热与传热的性能。采用差示扫描量热法（DSC）测量石蜡相变乳液的过冷度受到升/降温速率的影响，且升/降温速率越大，测得过冷度越大。提出一种测量石蜡相变乳液过冷度的方法——平衡态比容法。该方法通过测量石蜡相变乳液在不同温度下的比容，以确定乳液中石蜡粒子在升/降温过程中的相变温度，并进一步求解石蜡相变乳液的过冷度。实验结果表明，本研究提出的平衡态比容法能准确测量石蜡相变乳液的过冷度，并从比容变化的角度揭示石蜡相变乳液过冷现象的机理。

关键词: 比容法, 差示扫描量热法, 过冷, 石蜡, 相变

Abstract:

Paraffin phase change emulsion is a new type of functional fluid that integrates heat storage and heat transfer, and has broad application prospects. However, the application of phase-change paraffin emulsion suffers from subcooling phenomenon, which weakens its ability to store and transfer heat remarkably. The degree of subcooling in phase-change paraffin emulsion is conventionally determined by differential scanning calorimetry (DSC), the result of which is dependent on the heating / cooling rate. As the heating / cooling rate increases, the degree of subcooling is higher. Here an equilibrium volumetric method was presented to determine the degree of subcooling in phase-change paraffin emulsion by measuring its specific volume at different temperatures. The specific volume obtained was plotted against the temperature to identify the phase transition temperature of paraffin during heating / cooling process, then the degree of subcooling was deduced from the phase transition temperatures obtained. The results showed that the degree of subcooling in phase-change paraffin emulsion can be measured accurately using the equilibrium volumetric method presented in this work. The results also revealed the mechanism of subcooling in phase-change paraffin emulsion from the point of view of specific volume change.

Key words: volumetric method, DSC, subcooling, paraffin, phase transition

中图分类号:

O 648.23

陈琳, 武亚飞, 车黎明. 一种测量石蜡相变乳液过冷度的新方法：平衡态比容法[J]. 化工学报, 2019, 70(9): 3370-3376.

Lin CHEN, Yafei WU, Liming CHE. A new approach to determine the degree of subcooling in phase-change paraffin emulsion: equilibrium volumetry[J]. CIESC Journal, 2019, 70(9): 3370-3376.

图/表 9

图1 平衡态比容法实验装置

Fig.1 Equilibrium volumetric method apparatus

图2 石蜡相变乳液制备

Fig.2 Preparation of phase-change paraffin emulsion

图3 石蜡相变乳液的粒径分布

Fig.3 Particle size distribution of paraffin emulsion

图4 纯石蜡的DSC曲线

Fig.4 DSC curves of bulk paraffin

图5 纯石蜡的相变温度随升/降温速率的变化趋势

Fig.5 Correlation between phase transition temperature of bulk paraffin and heating/cooling rate

图6 不同粒度石蜡相变乳液的DSC曲线

Fig.6 DSC curves of paraffin emulsions with different particle sizes

表1 不同粒度的石蜡相变乳液的过冷度

Table 1 Degree of subcooling of paraffin emulsions with different particle sizes

平均粒径/nm	过冷度/℃
平均粒径/nm	5 K·min^-1	10 K·min^-1	15 K·min^-1	20 K·min^-1	0 K·min^-1
330	16.5	18.1	19.0	20.1	15.5
217	16.3	18.1	19.4	21.0	14.9
147	16.0	17.3	18.6	19.3	15.0

图7 石蜡相变乳液的比容随温度的变化曲线

Fig.7 Volumetric evolution of paraffin emulsion during heating/cooling

图8 不同粒径石蜡相变乳液的热膨胀率曲线

Fig.8 Thermal expansion of paraffin emulsion with different particle sizes

参考文献 37

1	Yagi J , Akiyama T . Storage of thermal energy for effective use of waste heat from industries[J]. Journal of Materials Processing Technology, 1995, 48(1): 793-804.
2	王剑锋 . 相变储热研究进展 (1) :相变材料特性与储热系统优化[J]. 新能源, 2000, (3): 31-35.
	Wang J F . Advances in phase change heat storage (1): Characteristics of phase change materials and optimization of heat storage system[J]. New Energy, 2000, (3): 31-35.
3	Li Q M , Tan X G , Wang H , et al . Advances and trends of energy storage technology in microgrid[J]. International Journal of Electrical Power & Energy Systems, 2013, 44(1): 179-191.
4	韩亚芳, 张汪林, 鲁进利 . 相变微胶囊功能材料制备及应用基础研究[J]. 化工新型材料, 2014, (6): 229-230.
	Han Y F , Zhang W L , Lu J L . Research on preparation and application of microencapsulated phase change materials[J]. New Chemical Materials, 2014, (6): 229-230.
5	郭艳芹 . 膨胀石墨基复合相变储热材料的制备及其在建筑节能中的应用研究[D]. 广州: 华南理工大学, 2010.
	Guo Y Q . Study on preparation of graphite based composite phase change materials and application in building energy conservation[D]. Guangzhou: South China University of Technology, 2010.
6	Sanusi O , Warzoha R , Fleischer A S . Energy storage and solidification of paraffin phase change material embedded with graphite nanofibers[J]. International Journal of Heat & Mass Transfer, 2011, 54(19/20): 4429-4436.
7	Sari A , Karaipekli A . Thermal conductivity and latent heat thermal energy storage characteristics of paraffin/expanded graphite composite as phase change material[J]. Applied Thermal Engineering, 2007, 27(8): 1271-1277.
8	刘永霞, 于才渊 . 微胶囊技术的应用及其发展[J]. 中国粉体技术, 2003, 9(3): 36-40.
	Liu Y X , Yu C Y . Application and recent progress of microencapsulation technology[J]. China Powder Science and Technology, 2003, 9(3): 36-40.
9	田云, 卢向阳, 何小解, 等 . 微胶囊制备技术及其应用研究[J]. 科学技术与工程, 2005, 5(1): 44-47.
	Tian Y , Lu X Y , He X J , et al . Preparation technology and application of microcapsules[J]. Science Technology and Engineering, 2005, 5(1): 44-47.
10	Bjerknes K , Braenden J U , Smistad G , et al . Evaluation of different formulation studies on air-filled polymeric microcapsules by multivariate analysis[J]. International Journal of Pharmaceutics, 2003, 257(1/2): 1-14.
11	Namwong S , Noppalit S , Okubo M , et al . Latent heat enhancement of paraffin wax in poly(divinylbenzene-co-methyl methacrylate) microcapsule[J]. Journal of Macromolecular Science: Part D-Reviews in Polymer Processing, 2015, 54(8): 779-785.
12	李晓燕, 李月明, 赵乔乔, 等 . 相变微胶囊悬浮液的研究进展[J]. 材料导报, 2015, 29(5): 57-61.
	Li X Y , Li Y M , Zhao Q Q , et al . Progress in research of phase change microencapsulated suspension[J]. Materials Review, 2015, 29(5): 57-61.
13	Tyagi V V , Kaushik S C , Tyagi S K , et al . Development of phase change materials based microencapsulated technology for buildings: a review[J]. Renewable & Sustainable Energy Reviews, 2011, 15(2): 1373-1391.
14	孙凯, 张步宁, 晏凤梅, 等 . 石蜡微胶囊型相变储能材料制备及表征[J]. 化工进展, 2011, 30(12): 2676-2678.
	Sun K , Zhang B N , Yan F M , et al . Preparation and characterization of microcapsule with paraffin phase change materials for energy storage[J]. Chemical Industry and Engineering Progress, 2011, 30(12): 2676-2678.
15	揣成智, 程远 . 石蜡微胶囊的制备与应用[J]. 中北大学学报(自然科学版), 2011, 32(2): 179-182.
	Chuai C Z , Cheng Y . Synthesis and application of microencapsulated paraffin[J]. Journal of North University of China(Natural Science Edition), 2011, 32(2): 179-182.
16	宋健 . 微胶囊化技术及应用[M]. 北京: 化学工业出版社, 2001.
	Song J . Microencapsulation Technology and Application[M]. Beijing: Chemical Industry Press, 2001.
17	Abolghasemi M , Keshavarz A , Mehrabian M A . Heat transfer enhancement of a thermal storage unit consisting of a phase change material and nano-particles[J]. Journal of Renewable & Sustainable Energy, 2012, 4(4): 303-317.
18	Kapsalis V , Karamanis D . Solar thermal energy storage and heat pumps with phase change materials[J]. Applied Thermal Engineering, 2016, 99: 1212-1224.
19	Kenisarin M , Mahkamov K . Passive thermal control in residential buildings using phase change materials[J]. Renewable & Sustainable Energy Reviews, 2016, 55: 371-398.
20	Nomura T , Okinaka N , Akiyama T . Waste heat transportation system, using phase change material (PCM) from steelworks to chemical plant[J]. Resources Conservation & Recycling, 2010, 54(11): 1000-1006.
21	Wu Q , Zhao D , Jiao X , et al . Preparation, properties, and supercooling prevention of phase change material n-octadecane microcapsules with peppermint fragrance scent[J]. Industrial & Engineering Chemistry Research, 2015, 54(33): 8130-8136.
22	Huang L , Günther E , Doetsch C , et al . Subcooling in PCM emulsions(1): Experimental[J]. Thermochimica Acta, 2010, 509(1/2): 93-99.
23	黎宇坤, 马素德, 唐国翌 . 对一种新型相变微乳液的物理性质及稳定性的研究[J]. 功能材料, 2010, 41(10): 1813-1815.
	Li Y K , Ma S D , Tang G Y . Research on physical properties and stability of phase change microemulsion[J]. Journal of Functional Materials, 2010, 41(10): 1813-1815.
24	Zhang X X , Fan Y F , Tao X M , et al . Crystallization and prevention of supercooling of microencapsulated n-alkanes[J]. Journal of Colloid and Interface Science, 2005, 281(2): 299-306.
25	Zhang S , Niu J L . Experimental investigation of effects of supercooling on microencapsulated phase-change material(MPCM) slurry thermal storage capacities[J]. Solar Energy Materials & Solar Cells, 2010, 94(6): 1038-1048.
26	Jiang T , Liu M , Peng F , et al . Melting behavior, isothermal and nonisothermal crystallization kinetics of nylon[J]. Polymer Engineering & Science, 2009, 49(7): 1366-1374.
27	谢鹏 . 相变蓄热式太阳能低温地板辐射采暖的设计及性能研究[D]. 南昌: 南昌大学, 2008.
	Xie P . Design and performance study of phase change regenerative solar low temperature floor radiant heating[D]. Nanchang: Nanchang University, 2008.
28	Lindfors L , Forssén S , Westergren J , et al . Nucleation and crystal growth in supersaturated solutions of a model drug[J]. Journal of Colloid Interface Science, 2012, 325(2): 404-413.
29	Xie B , Liu G , Jiang S , et al . Crystallization behaviors of n-octadecane in confined space: crossover of rotator phase from transient to metastable induced by surface freezing[J]. Journal of Physical Chemistry B, 2008, 112(42): 13310-13315.
30	Wedd M W , Price C J , York P , et al . The role of particle characterization in industrial crystallization[J]. Analytical Proceedings, 1993, 30(2): 56-62.
31	Günther E , Schmid T , MehlingH, et al . Subcooling in hexadecane emulsions[J]. International Journal of Refrigeration, 2010, 33(8): 1605-1611.
32	Kaneko N , Horie T , Ueno S , et al . Impurity effects on crystallization rates of n-hexadecane in oil-in-water emulsions[J]. Journal of Crystal Growth 1999, 197(1/2): 263-270.
33	Royon L , Guiffant G . Heat transfer in paraffin oil/water emulsion involving supercooling phenomenon[J]. Energy Conversion & Management, 2001, 42(18): 2155-61.
34	Kousksou T , Arid A , Jamil A , et al . Thermal behavior of building material containing microencapsulated PCM[J]. Thermochimica Acta, 2012, 550: 42-47.
35	Cooper S , Cook O , Loines N . Crystallization in microemulsions: a generic route to thermodynamic control and the estimation of critical nucleus size[J]. Mathematical Proceedings of the Cambridge Philosophical Society, 2012, 31(3): 335-346.
36	Gunther E , Schmid T , Mehling H , et al . Subcooling in hexadecane emulsions[J]. International Journal of Refrigeration, 2010, 33(8): 1605-1611.
37	Kraack H , Deutsch M , Sirota E B . n-Alkane homogeneous nucleation: crossover to polymer behavior[J]. Macromolecules, 2000, 33(16): 6174-6184.

编辑推荐 0

Metrics

阅读次数

全文

140

HTML			PDF

最新录用	在线预览	正式出版	最新录用	在线预览	正式出版
0	0	13	3	0	124

来源	本网站	其他网站

次数	102	38
比例	73%	27%

摘要

621

最新录用	在线预览	正式出版

5	0	616

来源	本网站	其他网站

次数	446	175
比例	72%	28%

[1]	代宝民, 王启龙, 刘圣春, 张佳宁, 李鑫海, 宗凡迪. 非共沸工质辅助过冷CO₂冷热联供系统的热力学性能分析[J]. 化工学报, 2023, 74(S1): 64-73.
[2]	张双星, 刘舫辰, 张义飞, 杜文静. R-134a脉动热管相变蓄放热实验研究[J]. 化工学报, 2023, 74(S1): 165-171.
[3]	江河, 袁俊飞, 王林, 邢谷雨. 均流腔结构对微细通道内相变流动特性影响的实验研究[J]. 化工学报, 2023, 74(S1): 235-244.
[4]	吴延鹏, 刘乾隆, 田东民, 陈凤君. 相变材料与热管耦合的电子器件热管理研究进展[J]. 化工学报, 2023, 74(S1): 25-31.
[5]	张贲, 王松柏, 魏子亚, 郝婷婷, 马学虎, 温荣福. 超亲水多孔金属结构驱动的毛细液膜冷凝及传热强化[J]. 化工学报, 2023, 74(7): 2824-2835.
[6]	史昊鹏, 钟达文, 廉学新, 张君峰. 朝下多尺度沟槽翅片结构表面沸腾换热实验研究[J]. 化工学报, 2023, 74(7): 2880-2888.
[7]	史方哲, 甘云华. 超薄热管启动特性和传热性能数值模拟[J]. 化工学报, 2023, 74(7): 2814-2823.
[8]	邢美波, 张中天, 景栋梁, 张洪发. 磁调控水基碳纳米管协同多孔材料强化相变储/释能特性[J]. 化工学报, 2023, 74(7): 3093-3102.
[9]	李振, 张博, 王丽伟. PEG-EG固-固相变材料的制备和性能研究[J]. 化工学报, 2023, 74(6): 2680-2688.
[10]	代佳琳, 毕唯东, 雍玉梅, 陈文强, 莫晗旸, 孙兵, 杨超. 热物性对混合型CPCMs固液相变特性影响模拟研究[J]. 化工学报, 2023, 74(5): 1914-1927.
[11]	李明川, 樊栓狮, 徐赋海, 卢惠东, 李晓军. 水合物热分解Stefan相变模型解的存在性及Laplace变换求解[J]. 化工学报, 2023, 74(4): 1746-1754.
[12]	尹驰, 张正国, 凌子夜, 方晓明. 含石蜡@二氧化硅纳米胶囊和碳纤维的相变热界面材料及其散热性能[J]. 化工学报, 2023, 74(4): 1795-1804.
[13]	郑书闽, 郭鹏程, 颜建国, 王帅, 李文博, 周淇. 微小通道内过冷流动沸腾阻力特性实验及预测研究[J]. 化工学报, 2023, 74(4): 1549-1560.
[14]	吴学红, 栾林林, 陈亚南, 赵敏, 吕财, 刘勇. 可降解柔性相变薄膜的制备及其热性能[J]. 化工学报, 2023, 74(4): 1818-1826.
[15]	杨灿, 孙雪琦, 尚明华, 张建, 张香平, 曾少娟. 相变离子液体体系吸收分离CO₂的研究现状及展望[J]. 化工学报, 2023, 74(4): 1419-1432.