Experimental research on new type of frost-free air source heat pump system in winter

doi:10.11949/j.issn.0438-1157.20180636

Abstract

Abstract:

This paper reports an experimental research of a new type of air source heat pump system in winter. This system can not only operate efficiently in winter, but also improve the performance in summer operation. Through constructing the heat pump system experimental platform, the effects of outdoor air dry bulb temperature, humidity, heat water temperature, heat water flow rate, solution flow rate, solution mass fraction and outdoor air flow rate in winter conditions on system supply heat model performance and the effects of solution flow rate, solution temperature and air flow rate in winter conditions on system regeneration model performance can be acquired. It is concluded that the supply heat model COP of air source heat pump air conditioning system increases with the decrease of heat water temperature, the increase of outdoor air dry bulb temperature, heat water flow rate, and solution flow rate. The effects of humidity and solution mass fraction on system supply heat model performance can be ignored. The regeneration model COP of air source heat pump air conditioning system increases with the decrease of solution temperature, the increase of air flow rate and solution flow rate. At the condition of experimental, the supply heat model COP of system can reach 3.11 and regeneration model COP can reach 4.03, more than the COP of traditional reverse cycle defrosting air source heat pump. The system heating integrated COP is improved in the test conditions compared with the reverse cycle defrosting system. The experiment proves that the system is suitable for low temperature and high humidity areas.

Key words: design, experimental validation, measurement, heat pump

摘要：

为了解决传统空气源热泵系统冬季运行室外换热器结霜温度，提出了一种溶液除湿型无霜空气源热泵空调系统。该热泵系统在冬季可以无霜高效运行的同时夏季性能也有所提高。通过搭建该系统实验平台，研究了室外空气干球温度、湿度、供热水温度、供热水流量、溶液流量、溶液质量分数、室外空气流量等对冬季工况系统供热性能的影响，还研究了溶液流量、溶液温度、室外空气流量等对冬季工况系统再生性能的影响，得出了室外空气湿度、溶液质量分数对系统的供热性能影响较小，随着室外空气干球温度、供热水流量、溶液流量、室外空气流量等参数的升高和供热水温度的减小，系统供热性能逐渐增大最高可达3.11，而随着溶液流量、空气流量等参数的升高和溶液温度的减小，系统再生性能逐渐增大最高可达4.03，系统供热综合COP在实验工况相较逆循环除霜系统有所提升，实验验证了该系统适用于低温高湿地区。

关键词: 设计, 实验验证, 测量, 热泵

CLC Number:

TU831.6

LI Weihao, QIU Junjun, ZHANG Xiaosong. Experimental research on new type of frost-free air source heat pump system in winter[J]. CIESC Journal, 2018, 69(12): 5220-5228.

李玮豪, 邱君君, 张小松. 无霜空气源热泵系统冬季运行性能实验[J]. 化工学报, 2018, 69(12): 5220-5228.

References 31

[1]	江亿. 我国建筑耗能状况及有效的节能途径[J]. 暖通空调, 2005, 35(5):64-64. JIANG Y. Current building energy consumption in China and effective energy efficiency measures[J]. HV& AC, 2005, 35(5):30-40
[2]	沈建芳. 节能——空调行业的大趋势和对策[J]. 制冷技术, 2004, (2):18-22. SHEN J F. Energy conservation-target and countermeasure of AC industry[J]. Refrigeration Technology, 2004, (2):18-22.
[3]	LENIC K, TRP A, FRANKOVIC B. Prediction of an effective cooling output of the fin-and-tube heat exchanger under frosting conditions[J]. Applied Thermal Engineering, 2009, 29(11/12):2534-2543.
[4]	HUANG LY, LIU Z L, LIU Y M, et al. Experimental study on frost release on fin-and-tube heat exchangers by use of a novel anti-frosting paint[J]. Experimental Thermal and Fluid Science, 2009, 33(7):1049-1054.
[5]	HU W J, JIANG Y Q, QU M L, et al. An experimental study on the operating performance of a novel reverse-cycle hot gas defrosting method for air source heat pumps[J]. Applied Thermal Engineering, 2011, 31(2):363-369
[6]	YIN H J, YANG Z, CHEN A Q, et al. Experimental research on a novel cold storage defrost method based on air bypass circulation and electric heater[J]. Energy, 2012, 37(1):623-631.
[7]	孙家正. 空气源热泵除霜方法的研究现状及展望[J]. 建筑热能通风空调, 2017, 36(8):42-46. SUN J Z. Present state and prospect of defrosting method for air source heat pump[J]. Building Energy & Environment, 2017, 36(8):42-46.
[8]	韩志涛, 姚杨, 马最良, 等. 空气源热泵误除霜特性的实验研究[J]. 暖通空调, 2006, 36(2):15-19. HAN Z T, YAO Y, MA Z L, et al. Experiment on characteristics of an air source heat pump in false defrosting[J]. Heating Ventilating & Air Conditioning, 2006, 36(2):15-19.
[9]	张杰, 兰菁, 杜瑞环, 等. 几种空气源热泵除霜方式的性能比较[J]. 制冷学报, 2012, 33(2):47-49. ZHANG J, LAN J, DU R H, et al. The performance comparison of several defrosting modes for air-source heat pump[J]. Journal of Refrigeration, 2012, 33(2):47-49.
[10]	曹小林, 曹双俊, 段飞, 等. 空气源热泵除霜问题研究现状与展望[J]. 流体机械, 2011, 39(4):75-79. CAO X L, CAO S J, DUAN F, et al. Current situation and development prospect of air source heat pump defrosting research[J]. Fluid Machinery, 2011, 39(4):75-79.
[11]	李九如, 孔祥鹏, 王妍, 等. 空气源热泵除霜动态特性实验台研制[J]. 哈尔滨理工大学学报, 2012, 17(5):26-28. LI J R, KONG X P, WANG Y, et al. Development of air source heat pump defrosting structures bench[J]. Journal of Harbin University of Science and Technology, 2012, 17(5):26-28.
[12]	龚建英, 袁秀玲. 空气源热泵蒸发器结霜过程数值模拟[J]. 低温与超导, 2010, 38(5):53-57. GONG J Y, YUAN X L. Simulation study on evaporator frosting process of air source heat pump[J]. Cryogenics & Superconductivity, 2010, 38(5):53-57.
[13]	郭宪民, 王冬丽, 陈轶光, 等. 室外换热器迎面风速对空气源热泵结霜特性的影响[J]. 化工学报, 2012, 63(S2):32-37. GUO X M, WANG D L, CHEN Y G, et al. Effects of face velocity of outdoor heat exchanger on frosting characteristics of air source heat pump system[J]. CIESC Journal, 2012, 63(S2):32-37.
[14]	尹从绪, 陈轶光. 风速对空气源热泵翅片管换热器结霜特性影响[J]. 低温与超导, 2011, 39(12):50-52. YIN C X, CHEN Y G. The effects of wind speed on frosting characteristics of fin-tube heat exchanger for air source heat pump[J]. Cryogenics & Superconductivity, 2011, 39(12):50-52.
[15]	汪峰, 梁彩华, 杨明涛, 等. 翅片表面融霜水滞留机理及其影响因素[J]. 化工学报, 2014, 65(S2):101-106. WANG F, LIANG C H, YANG M T, et al. Mechanism and influence factors of frost melt water retention on fins[J]. CIESC Journal, 2014, 65(S2):101-106.
[16]	薛利平, 郭宪民, 邢震. 环境参数对翅片管换热器表面结霜特性影响的实验研究[J]. 低温与超导, 2017, 45(4):66-71. XUE L P, GUO X M, XING Z. Experimental study on frost growth characteristics on surface of finned-tube heat exchanger[J]. Cryogenics & Superconductivity, 2017, 45(4):66-71.
[17]	黄东, 袁秀玲. 风冷热泵冷热水机组热气旁通除霜与逆循环除霜性能对比[J]. 西安交通大学学报, 2006, 40(05):539-543. HUANG D, YUAN X L. Comparison of dynamic characteristics between the hot-gas bypass defrosting method and reverse-cycle defrosting method on an air-to-water heat pump[J]. Journal of Xi'an Jiaotong University, 2006, 40(05):539-543.
[18]	梁彩华, 文先太, 张小松. 基于热源塔的热泵系统构建与试验[J]. 化工学报, 2010, 61(S2):142-146. LIANG C H, WEN X T, ZHANG X S. Construction and experimental research on heat pump system based on heat-source tower[J]. CIESC Journal, 2010, 61(S2):142-146.
[19]	张小松, 文先太, 梁彩华. 适合夏热冬冷地区的新型双高效热泵系统[J]. 制冷与空调, 2013, 13(11):6-10. ZHANG X S, WEN X T, LIANG C H. New type of dual high-efficiency heat pump system suited to hot summer and cold winter zones[J]. Refrigeration and Air-conditioning, 2013, 13(11):6-10+15.
[20]	LI Y C, CHEN G M, TANG L M, et al. Analysis on performance of a novel frost-free air-source heat pump system[J]. Building and Environment, 2011, 46(10):2052-2059.
[21]	章文杰, 李念平, 王丽洁. 热源塔热泵系统相变潜热的应用研究[J]. 重庆大学学报, 2011, 34(s1):58-61. ZHANG W J, LI N P, WANG L J. Availability of latent heat by moist air condensation with the heat-source tower heat pump units[J]. Journal of Chongqing University, 2011, 34(s1):58-61.
[22]	李念平, 张鼎, 成剑林, 等. 热源塔热泵空调系统经济性分析[J]. 深圳大学学报(理工版), 2015, 32(4):404-410. LI N P, ZHANG D, CHENG J L, et al. Economic analysis of heat pump air conditioning system of heat-source tower[J]. Journal of Shenzhen University(Science & Engineering), 2015, 32(4):404-410.
[23]	ZHANG L, DANG C, HIHARA E. Performance analysis of a no-frost hybrid air conditioning system with integrated liquid desiccant dehumidification[J]. International Journal of Refrigeration, 2010, 33(1):116-124.
[24]	ZHANG L, FUJINAWA T, SAIKAWA M. A new method for preventing air-source heat pump water heaters from frosting[J]. International Journal of Refrigeration, 2012, 35(5):1327-1334.
[25]	郝鹏飞, 王沣浩, 王志华, 等. 蓄热除湿耦合型无霜空气源热泵热水器实验研究[J]. 制冷学报, 2015, 36(4):85-91. HAO P F, WANG F H, WANG Z H, et al. Experimental research on a novel frost-free air-source heat pump water heater system coupling with thermal storage and dehumidification[J]. Journal of Refrigeration, 2015, 36(4):85-91.
[26]	王志华, 王沣浩, 郑煜鑫, 等. 一种新型无霜空气源热泵热水器实验研究[J]. 制冷学报, 2015, 36(1):52-58. WANG Z H, WANG F H, ZHENG Y X, et al. Experimental research on a novel frost-free air-source heat pump water heater system[J]. Journal of Refrigeration, 2015, 36(1):52-58.
[27]	张凡, 吴薇, 王琴, 等. 一种复合型无霜空气源热泵系统性能分析[J]. 暖通空调, 2015, 45(12):82-87. ZHANG F, WU W, WANG Q, et al. Performance analysis of frost-free air source heat pump system integrated with liquid desiccant[J]. Heating Ventilating & Air Conditioning, 2015, 45(12):82-87.
[28]	付慧影, 姜益强, 姚杨, 等. 喷淋溶液对无霜空气源热泵系统特性的影响[J]. 化工学报, 2012, 63(S2):193-198. FU H Y, JIANG Y Q, YAO Y, et al. Influence of spray solution on novel non-frosting air source heat pump system performance[J]. CIESC Journal, 2012, 63(S2):193-198.
[29]	梁明坤, 陈传宝, 刘伟. 板片蒸发冷凝式空气源热泵机组无霜制热的试验与验证[J]. 机械制造与自动化, 2016, 45(6):70-73. LIANG M K, CHEN C B, LIU W. Test & verification of frostless heating of plate-type evaporation-condensation air-source heat pump[J]. Machinery Manufacturing & Automation, 2016, 45(6):70-73.
[30]	许东晟, 闫凌, 姜益强, 等. 无霜空气源热泵系统喷淋溶液质量及浓度变化规律研究[J]. 发电与空调, 2014, 35(4):24-30. XU D S, YAN L, JIANG Y Q, et al. Study on change trend of spray solution quality and concentration for nonfrosting air source heat pump system[J]. Refrigeration Air Conditioning & Electric Power Machinery, 2014, 35(4):24-30.
[31]	CHEN Y G, GUO X M. Dynamic defrosting characteristics of air source heat pump and effects of outdoor air parameters on defrost cycle performance[J]. Applied Thermal Engineering, 2009, 29(13):2701-2707.