Research on air-cathode of anaerobic fluidized bed microbial fuel cell

doi:10.3969/j.issn.0438-1157.2013.01.041

CIESC Journal ›› 2013, Vol. 64 ›› Issue (1): 352-356.DOI: 10.3969/j.issn.0438-1157.2013.01.041

Previous Articles Next Articles

Research on air-cathode of anaerobic fluidized bed microbial fuel cell

YUE Xuehai, KONG Weifang, WANG Xuyun, GUO Qingjie

School of Chemical Engineering, Qingdao University of Science & Technology, Qingdao 266042, Shandong, China

Received:2012-08-03 Revised:2012-08-22 Online:2013-01-05 Published:2013-01-05
Supported by:
supported by the Science Foundation for Distinguished Young Scholars of Shandong Province (JQ200904), Research Fund for the Doctoral Program of Higher Education of China (20103719120004), and College Science and Technology Plan of Shandong Province, China (J11LB62).

厌氧流化床微生物燃料电池空气阴极研究

岳学海, 孔维芳, 王许云, 郭庆杰

青岛科技大学化工学院,山东青岛 266042

通讯作者: 郭庆杰
作者简介:岳学海(1971—),男,博士研究生,副教授。
基金资助:
山东省自然科学杰出青年基金项目(JQ200904);高校博士点基金项目(20103719120004);山东省高等学校科研计划项目(J11LB62)。

Abstract

Abstract: The conductivity of cathode and the activity of catalyst coated on cathode are critical to the electricity-generating capacity of AFBMFC.Carbon cloth cathode was loaded with a small amount of silver to investigate its influence for the conductivity of cathode.Then, four kinds of Pt/Co catalysts were prepared and coated to the cathode.The performance of AFBMFC was examined after the cathode was reformed.The results indicated that the performance of AFBMFC was improved remarkably when the carbon base layer was loaded with silver.With the addition of 0.7 mg Ag·cm^-2, the maximum output voltage and volumetric power density of AFBMFC increased to 154% and 330% of the original values respectively.PtCo catalysts annealed at 600℃ showed higher catalytic activity than that annealed at 950℃. The power generation of AFBMFC was much higher than those investigated by other researchers, although the dosage of Pt was reduced to half.

Key words: fluidized bed, microbial fuel cell, cathode, catalyst

摘要： 流化床微生物燃料电池(AFBMFC)的阴极导电性和催化剂性能是影响微生物燃料电池产电性能的重要因素。本文首先在阴极负载少量银研究其对AFBMFC产电性能的影响。其次,制备四种铂钴合金催化剂,考察了催化剂对AFBMFC产电性能的影响。研究表明,阴极碳基层负载少量的银可以显著改善AFBMFC的产电性能,银负载量为0.7 mg·cm^-2时AFBMFC最大输出电压和输出功率密度分别为纯碳基层阴极的154%和330%。600℃比950℃制备的PtCo合金催化剂有较好的催化性能,在保证催化剂总量不变的情况下,铂用量为原来的50%,AFBMFC产电性能仍有较大幅度的提高。

关键词: 流化床, 微生物燃料电池, 阴极, 催化剂

CLC Number:

X382
X703

YUE Xuehai, KONG Weifang, WANG Xuyun, GUO Qingjie. Research on air-cathode of anaerobic fluidized bed microbial fuel cell[J]. CIESC Journal, 2013, 64(1): 352-356.

岳学海, 孔维芳, 王许云, 郭庆杰. 厌氧流化床微生物燃料电池空气阴极研究[J]. 化工学报, 2013, 64(1): 352-356.

References 16

[1]	Kong W F, Guo Q J, Wang X Y.Electricity generation from wastewater using an anaerobic fluidized bed microbial fuel cell[J].Ind.Eng.Chem.Res., 2011,50(21):12225-12232
[2]	Zhao Shuju(赵书菊),Yue Xuehai(岳学海),Guo Qingjie(郭庆杰),Wang Xuyun(王许云),Hou Liangyu(侯良玉).Electricity generation using the anaerobic fluidized bed membrane-less microbial fuel cell[J].Environmental Chemistry(环境化学),2010,29(4):705-709
[3]	Zhao Shuju(赵书菊),Guo Qingjie(郭庆杰),Wang Xuyun(王许云),Yue Xuehai(岳学海).Electricity generation using the anaerobic fluidized bed microbial fuel cell[J].Acta Scientiae Circumstantiae(环境科学学报), 2010,30(3): 513-518
[4]	Yue Xuehai(岳学海), Zhao Shuju(赵书菊),Wang Xuyun(王许云),Guo Qingjie(郭庆杰).Effect of bed expansion height on electrogenesis capacity of anaerobic fluidized bed membraneless microbial fuel cell[J].The Chinese Journal of Process Engineering(过程工程学报), 2011,11(2):199-203
[5]	Fu Jie(付洁), Zhao Hai(赵海), Jin Yanling(靳艳玲), Gan Mingzhe(甘明哲).Characteristics of electricigens in anode and cathodic acceptors and research progresses in microbial fuel cell[J].Biotechnology Bulletin(生物技术通报), 2008(z1):90-94
[6]	Xie J, Wood D L, More K L, et al.Microstructural changes of membrane electrode assemblies during PEFC durability testing at high humidity conditions[J].J. Electrochem. Soc., 2005,152:A 1011-A 1020
[7]	Roen L M, Paik C H, Jarvi T D.Electrocatalytic corrosion of carbon support in PEMFC cathodes[J].Electro Chem. Solid-State Lett., 2004,7:A 19-22
[8]	Lawrence D’Souza, Sampath S. Preparation and characterization of silane-stabilized, highly uniform, nanobimetallic Pt-Pd particles in solid and liquid matrixes[J].Langmuir, 2000,16:8510-8517
[9]	Ozaki Y, Suzuki S, et al.Enhanced long term stability of SnO2 based CO gas sensors modified by sulfuric acid treatment[J].Sens Actuators B, 2000,62:220
[10]	Gasteiger H A, Markovic N M, Ross P N.Electrooxidation of CO and H2 mixtures on a well characterized Pt-Sn electrode surface[J].J.Phys.Chem., 1995,99:8945-8949
[11]	Zhang J, Vukmirovic M B, Sasaki K, et al.Mixed-metal Pt monolayer electrocatalysts for enhanced oxygen reduction kinetics[J].J.Am.Chem.Soc., 2005,127(36):12480-l2481
[12]	Morimitsu M, Ozaki Y, Suzuki S, et al.Effects of surface modification with platinum and ruthenium on temperature and humidity dependence of SnO2 based CO gas sensors[J].Sens Actuators B, 2000,67:184
[13]	Watansbe M, Tsurumi K, Mizukami T, et al.Activity and stability of ordered and disordered Co-Pt alloys for phosphoric acid fuel cells[J].J.Electrochem.Soc., 1994(11):2659
[14]	Paffett M T, Beery J G, Gotterfeld S.Oxygen reduction at Pt0.65Cr0.35Pt0.2Cr0.8 and roughened platinum[J].J. Electrochem. Soc., 1988,135:1431
[15]	Kong Weifang(孔维芳), Guo Qingjie(郭庆杰),Wang Xuyun(王许云).Electricity generation of anaerobic fluidized bed microbial fuel cell using different electron mediators[J].Journal of Chemical Engineering of Chinese Universities(高校化学工程学报), 2011,25(5):858-863
[16]	Zheng Congcong(郑聪聪), Guo Qingjie(郭庆杰),Wang Xuyun(王许云), Kong Weifang(孔维芳).Preparation and performance of graphite anode modified electrochemically by polyaniline and carbon nanotubes for MFC[J].CIESC Journal(化工学报), 2012,63(5):1659-1606

Research on air-cathode of anaerobic fluidized bed microbial fuel cell

厌氧流化床微生物燃料电池空气阴极研究

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 16

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Yitong LI, Hang GUO, Hao CHEN, Fang YE. Study on operating conditions of proton exchange membrane fuel cells with non-uniform catalyst distributions [J]. CIESC Journal, 2023, 74(9): 3831-3840.
[2]	Jie CHEN, Yongsheng LIN, Kai XIAO, Chen YANG, Ting QIU. Study on catalytic synthesis of sec-butanol by tunable choline-based basic ionic liquids [J]. CIESC Journal, 2023, 74(9): 3716-3730.
[3]	Xuejin YANG, Jintao YANG, Ping NING, Fang WANG, Xiaoshuang SONG, Lijuan JIA, Jiayu FENG. Research progress in dry purification technology of highly toxic gas PH₃ [J]. CIESC Journal, 2023, 74(9): 3742-3755.
[4]	Feifei YANG, Shixi ZHAO, Wei ZHOU, Zhonghai NI. Sn doped In₂O₃ catalyst for selective hydrogenation of CO₂ to methanol [J]. CIESC Journal, 2023, 74(8): 3366-3374.
[5]	Kaixuan LI, Wei TAN, Manyu ZHANG, Zhihao XU, Xuyu WANG, Hongbing JI. Design of cobalt-nitrogen-carbon/activated carbon rich in zero valent cobalt active site and application of catalytic oxidation of formaldehyde [J]. CIESC Journal, 2023, 74(8): 3342-3352.
[6]	Xin YANG, Xiao PENG, Kairu XUE, Mengwei SU, Yan WU. Preparation of molecularly imprinted-TiO₂ and its properties of photoelectrocatalytic degradation of solubilized PHE [J]. CIESC Journal, 2023, 74(8): 3564-3571.
[7]	Yajie YU, Jingru LI, Shufeng ZHOU, Qingbiao LI, Guowu ZHAN. Construction of nanomaterial and integrated catalyst based on biological template: a review [J]. CIESC Journal, 2023, 74(7): 2735-2752.
[8]	Zhilong WANG, Ye YANG, Zhenzhen ZHAO, Tao TIAN, Tong ZHAO, Yahui CUI. Influence of mixing time and sequence on the dispersion properties of the cathode slurry of lithium-ion battery [J]. CIESC Journal, 2023, 74(7): 3127-3138.
[9]	Yuming TU, Gaoyan SHAO, Jianjie CHEN, Feng LIU, Shichao TIAN, Zhiyong ZHOU, Zhongqi REN. Advances in the design, synthesis and application of calcium-based catalysts [J]. CIESC Journal, 2023, 74(7): 2717-2734.
[10]	Qiyu ZHANG, Lijun GAO, Yuhang SU, Xiaobo MA, Yicheng WANG, Yating ZHANG, Chao HU. Recent advances in carbon-based catalysts for electrochemical reduction of carbon dioxide [J]. CIESC Journal, 2023, 74(7): 2753-2772.
[11]	Jiali GE, Tuxiang GUAN, Xinmin QIU, Jian WU, Liming SHEN, Ningzhong BAO. Synthesis of FeF₃ nanoparticles covered by vertical porous carbon for high performance Li-ion battery cathode [J]. CIESC Journal, 2023, 74(7): 3058-3067.
[12]	Pan LI, Junyang MA, Zhihao CHEN, Li WANG, Yun GUO. Effect of the morphology of Ru/α-MnO₂ on NH₃-SCO performance [J]. CIESC Journal, 2023, 74(7): 2908-2918.
[13]	Tan ZHANG, Guang LIU, Jinping LI, Yuhan SUN. Performance regulation strategies of Ru-based nitrogen reduction electrocatalysts [J]. CIESC Journal, 2023, 74(6): 2264-2280.
[14]	Zhenghao YANG, Zhen HE, Yulong CHANG, Ziheng JIN, Xia JIANG. Research progress in downer fluidized bed reactor for biomass fast pyrolysis [J]. CIESC Journal, 2023, 74(6): 2249-2263.
[15]	Chen WANG, Xiufeng SHI, Xianfeng WU, Fangjia WEI, Haohong ZHANG, Yin CHE, Xu WU. Preparation of Mn₃O₄ catalyst by redox method and study on its catalytic oxidation performance and mechanism of toluene [J]. CIESC Journal, 2023, 74(6): 2447-2457.