破坏压力对含有弱顶面受限空间内油气爆燃超压荷载的影响

doi:10.11949/j.issn.0438-1157.20170220

化工学报 ›› 2017, Vol. 68 ›› Issue (12): 4865-4873.DOI: 10.11949/j.issn.0438-1157.20170220

破坏压力对含有弱顶面受限空间内油气爆燃超压荷载的影响

王世茂¹, 杜扬¹, 梁建军¹, 周艳杰², 李国庆¹, 齐圣¹

1 中国人民解放军陆军勤务学院, 重庆 401311;
2 中国石油长庆油田分公司规划设计处, 陕西西安 710018

收稿日期:2017-03-07 修回日期:2017-08-30 出版日期:2017-12-05 发布日期:2017-12-05
通讯作者: 杜扬
基金资助:
国家自然科学基金项目（51704301）；重庆市研究生科研创新项目（CYB17150）。

Effect of static rupture pressure on overpressure loadings of gasoline-air mixture deflagration in confined space with weak roof

WANG Shimao¹, DU Yang¹, LIANG Jianjun¹, ZHOU Yanjie², LI Guoqing¹, QI Sheng¹

1 The Army Logistics University of PLA, Chongqing 401311, China;
2 Planning Division of PetroChina Changqing Oilfield Company, Xi'an 710018, Shaanxi, China

Received:2017-03-07 Revised:2017-08-30 Online:2017-12-05 Published:2017-12-05
Supported by:
supported by the National Natural Science Foundation of China (51704301) and the Graduate Research Innovation Project of Chongqing (CYB17150).

摘要/Abstract

摘要：

基于实验研究了静态破坏压力（p_ST）对含有弱顶面受限空间内油气爆燃超压荷载的影响，实验结果显示：不同p_ST下超压时序曲线分为4种类型，超压峰值包括破膜峰值（Δp₁）、泄流峰值（Δp₂）、外部爆燃峰值（Δp₃）和局部不稳定燃烧峰值（Δp₄）。当0≤p_ST≤2.5 kPa时，内部的最大峰值为Δp₃；而当5 kPa≤p_ST≤30 kPa时，内部的最大峰值为Δp₁。对于受限空间外部，最大峰值均为Δp₃。当2.5 kPa≤p_ST≤20 kPa时，外部爆燃和泄放负压耦合会诱导容器内形成压力振荡，振荡周期和持续时间与p_ST有关。破膜阶段持续时间与p_ST呈正比，而泄流、外部爆燃、压力荷载振荡阶段持续时间与p_ST呈反比。内外超压峰值均随着p_ST的增大而升高，内部Δp₁和Δp₂的数值与p_ST呈线性关系，外部Δp₃的数值与p_ST呈二次函数关系。

关键词: 弱顶面, 受限空间, 油气, 超压, 混合物, 爆燃, 实验验证

Abstract:

The effect of static rupture pressure (p_ST) on overpressure loadings caused by gasoline-air mixture deflagration was obtained based on experimental research in a vessel with a weak roof. The results showed that Δp-t profiles under different p_ST were divided into four types, and the main overpressure peaks were burst peak (Δp₁), vent flow peak (Δp₂), external deflagration peak (Δp₃) and locally instable combustion peak (Δp₄). The maximum overpressure peak inside the vessel was Δp₃ when p_ST was greater than or equal to 2.5 kPa, however, the maximum overpressure peak was Δp₁ when p_ST was greater than or equal to 5 kPa and less than or equal to 30 kPa. For the external overpressure, the maximum overpressure peak was Δp₃. Induced by the coupling of external deflagration and negative pressure, pressure oscillation occurred when p_ST was greater than or equal to 2.5 kPa and less than or equal to 20 kPa, and the frequency as well as the duration of pressure oscillation were related to p_ST. Duration of burst stage showed an increasing trend with the increase of p_ST, while duration of venting stage, external deflagration stage, and pressure oscillation stage showed an opposite trend. The value of internal and external overpressure peaks were both proportional to p_ST. With the increase of the p_ST, the internal pressure peak Δp₁ and Δp₂ increased in linear and the external pressure peak Δp₃ increased in quadratic.

Key words: weak roof, confined space, gasoline-air, overpressure, mixture, explosion, experimental validation

中图分类号:

X932

王世茂, 杜扬, 梁建军, 周艳杰, 李国庆, 齐圣. 破坏压力对含有弱顶面受限空间内油气爆燃超压荷载的影响[J]. 化工学报, 2017, 68(12): 4865-4873.

WANG Shimao, DU Yang, LIANG Jianjun, ZHOU Yanjie, LI Guoqing, QI Sheng. Effect of static rupture pressure on overpressure loadings of gasoline-air mixture deflagration in confined space with weak roof[J]. CIESC Journal, 2017, 68(12): 4865-4873.

参考文献 30

[1]	丁宇奇. 立式拱顶储罐超压破坏机理与弱顶结构研究[D]. 大庆:东北石油大学, 2014. DING Y Q. Research on broken mechanism of vertical dome roof tank overpressure and weak roof structure[D]. Daqing:Northeast Petroleum University, 2014.
[2]	MERCX M, VAN DEN BERG C.The explosion blast prediction model in the revised "Yellow Book"//The 31stAnnual Loss Prevention Meeting. Houston, 1997.
[3]	BJERKETVEDT D, BAAKE J, WINGERDEN K. Gas explosion handbook[J]. Journal of Hazardous Materials, 1997, (52):1-150.
[4]	BAO Q, FANG Q, ZHANG Y D, et al. Effects of gas concentration and venting pressure on overpressure transients during vented explosion of methane-air mixtures[J]. Fuel, 2016, 175:40-48.
[5]	BAUWENS C, CHAFFEE J, DOROFEEV S B. Vented explosion overpressures from combustion of hydrogen and hydrocarbon mixtures[J]. International Journal of Hydrogen Energy, 2011, 36(3):2329-2336.
[6]	BAUWENS C R, DOROFEEV S B. Effect of initial turbulence on vented explosion overpressures from lean hydrogen-air deflagrations[J]. International Journal of Hydrogen Energy, 2014, 39(35):20509-20515.
[7]	BAUWENS C, CHAFFEE J, DOROFEEV S. Experimental and numerical study of methane-air deflagrations in a vented enclosure[J]. Fire Safety Science, 2008, 9:1043-1054.
[8]	BAUWENS C. Effect of ignition location, vent size, and obstacles on vented explosion overpressures in propane-air mixtures[J]. Combustion Science and Technology, 2010, 182:1915-1932.
[9]	CHAO J, BAUWENS C, DOROFEEV S B. An analysis of peak overpressures in vented gaseous explosions[J]. Proceedings of the Combustion Institute, 2011, 33(2):2367-2374.
[10]	FAKANDU B. The venting of hydrogen-air explosions in an enclosure with L/D=2.8[C]//Proc. Ninth International Symposium on Hazardous Process Materials and Industrial Explosions (IX ISHPMIE). Krakow, 2012.
[11]	FAKANDU B M, ANDREWS G E, PHYLAKTOU H N. Vent burst pressure effects on vented gas explosion reduced pressure[J]. Journal of Loss Prevention in the Process Industries, 2015, 36:429-438.
[12]	GUO J, SUN X X, RUI S C, et al. Effect of ignition position on vented hydrogen-air explosions[J]. International Journal of Hydrogen Energy, 2015, 40(45):15780-15788.
[13]	GUO J, WANG C J, LIU X Y. Experimental study on duct-vented explosion of hydrogen-air mixtures in a wide range of equivalence ratio[J]. Industrial & Engineering Chemistry Research, 2016, 55(35):9518-9523.
[14]	KEENAN J, MAKAROV D V, MOLKOV V. Rayleigh-Taylor instability:modeling and effect on coherent deflagrations[J]. International Journal of Hydrogen Energy, 2014, 39(35):20467-20473.
[15]	KUZNETSOV M, FRIEDRICH A, STERN G, et al. Medium-scale experiments on vented hydrogen deflagration[J]. Journal of Loss Prevention in the Process Industries, 2015, 36:416-428.
[16]	MA Q J, ZHANG Q, PANG L, et al. Effects of hydrogen addition on the confined and vented explosion behavior of methane in air[J]. Journal of Loss Prevention in the Process Industries, 2014, 27:65-73.
[17]	QI S, DU Y, WANG S M, et al. The effect of vent size and concentration in vented gasoline-air explosions[J]. Journal of Loss Prevention in the Process Industries, 2016, 44:88-94.
[18]	QUILLATRE P, VERMOREL O, POINSOT T, et al. Large eddy simulation of vented deflagration[J]. Industrial & Engineering Chemistry Research, 2013, 52(33):11414-11423.
[19]	ROCOURT X, AWAMAT S, SOCHET I, et al. Vented hydrogen-air deflagration in a small enclosed volume[J]. International Journal of Hydrogen Energy, 2014, 39(35):20462-20466.
[20]	SCHIAVETTI M, MARANGON A, CARCASSI M. Experimental study of vented hydrogen deflagration with ignition inside and outside the vented volume[J]. International Journal of Hydrogen Energy, 2014, 39(35):20455-20461.
[21]	TOMLIN G, JOHNSON D M, CRONIN P, et al. The effect of vent size and congestion in large-scale vented natural gas/air explosions[J]. Journal of Loss Prevention in the Process Industries, 2015, 35:169-181.
[22]	TASCON A, AGUADO P J. CFD simulations to study parameters affecting dust explosion venting in silos[J]. Powder Technology, 2015, 272:132-141.
[23]	VYAZMINA E, JALLAIS S. Validation and recommendations for FLACS CFD and engineering approaches to model hydrogen vented explosions:effects of concentration, obstruction vent area and ignition position[J]. International Journal of Hydrogen Energy, 2016, 41(33):15101-15109.
[24]	SARLI D, BENEDETTO A, RUSSO G. Using large eddy simulation for understanding vented gas explosions in the presence of obstacles[J]. Journal of Hazardous Materials, 2009, 169(1/2/3):435-442.
[25]	杜扬, 王世茂, 齐圣, 等. 油气在顶部含弱约束结构受限空间内的爆炸特性[J]. 爆炸与冲击, 2017, 37(1):53-60. DU Y, WANG S M, QI S, et al, Explosion of gasoline/air mixture in confined space with weakly constrained structure at the top[J]. Explosion and Shock Wave, 2017, 37(1):53-60.
[26]	王世茂, 杜扬, 李国庆, 等. 局部开口受限空间油气爆燃的超压瞬变与火焰行为[J]. 化工学报, 2017, 68(8):3310-3318. WANG S M, DU Y, LI G Q, et al. Overpressure transients and flame behaviors of gasoline-air mixture deflagration in confined space with local opening[J]. CIESC Journal, 2017, 68(8):3310-3318.
[27]	李阳超, 杜扬, 王世茂, 等. 端部开口受限空间汽油蒸气爆燃超压特性研究[J]. 中国安全生产科学技术, 2016, 12(7):32-36. LI Y C, DU Y, WANG S M, et al. Study on characteristics of deflagration overpressure for gasoline vapor in confined space with end opening[J]. Journal of Safety Science and Technology, 2016, 12(7):32-36.
[28]	吴松林, 杜扬, 欧益宏, 等. 圆柱形管道旁侧油气泄爆实验研究[J]. 爆炸与冲击, 2016, 36(5):680-687. WU S L, DU Y, OU Y H, et al, Experimental study for lateral gasoline-air venting explosion in cylindrical pipeline[J]. Explosion and Shock Wave, 2016, 36(5):680-687.
[29]	GUO J, LI Q, CHEN D D, et al. Effect of burst pressure on vented hydrogen-air explosion in a cylindrical vessel[J]. International Journal of Hydrogen Energy, 2015, 40(19):6478-6486.
[30]	YAN X Q, YU J L, GAO W. Flame behaviors and pressure characteristics of vented dust explosions at elevated static activation overpressures[J]. Journal of Loss Prevention in the Process Industries, 2015, 33:101-108.

破坏压力对含有弱顶面受限空间内油气爆燃超压荷载的影响

Effect of static rupture pressure on overpressure loadings of gasoline-air mixture deflagration in confined space with weak roof

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 30

相关文章 15

编辑推荐

Metrics

本文评价

[1]	汪尔奇, 彭书舟, 杨震, 段远源. 含HFO混合体系气液相平衡的理论模型评价[J]. 化工学报, 2023, 74(8): 3216-3225.
[2]	闫琳琦, 王振雷. 基于STA-BiLSTM-LightGBM组合模型的多步预测软测量建模[J]. 化工学报, 2023, 74(8): 3407-3418.
[3]	江锦波, 彭新, 许文烜, 门日秀, 刘畅, 彭旭东. 泵出型螺旋槽油气密封泄漏特性及参数影响研究[J]. 化工学报, 2023, 74(6): 2538-2554.
[4]	姚晓宇, 沈俊, 李健, 李振兴, 康慧芳, 唐博, 董学强, 公茂琼. 流体气液临界参数测量方法研究进展[J]. 化工学报, 2023, 74(5): 1847-1861.
[5]	许文烜, 江锦波, 彭新, 门日秀, 刘畅, 彭旭东. 宽速域三种典型型槽油气密封泄漏与成膜特性对比研究[J]. 化工学报, 2023, 74(4): 1660-1679.
[6]	罗来明, 张劲, 郭志斌, 王海宁, 卢善富, 相艳. 1~5 kW高温聚合物电解质膜燃料电池堆的理论模拟与组装测试[J]. 化工学报, 2023, 74(4): 1724-1734.
[7]	武子超, 汪志雷, 李荣业, 李可昕, 华敏, 潘旭海, 王三明, 蒋军成. 点火方式对欠膨胀氢气射流爆炸超压影响规律研究[J]. 化工学报, 2023, 74(3): 1409-1418.
[8]	唐茹意, 潘罕骞, 郑侠俊, 张广欣, 汪星平, 崔希利, 邢华斌. Z型全氟聚醚的结构表征[J]. 化工学报, 2023, 74(1): 479-486.
[9]	席国君, 刘子涵, 雷广平. FeTPPs-CuBTC协同强化低浓度煤层气吸附分离[J]. 化工学报, 2022, 73(9): 3940-3949.
[10]	刘潜, 张香兰, 李志平, 李玉龙, 韩梦醒. 油酚分离过程低共熔溶剂的筛选及萃取性能研究[J]. 化工学报, 2022, 73(9): 3915-3928.
[11]	杨克, 王辰升, 纪虹, 郑凯, 邢志祥, 毕海普, 蒋军成. 聚多巴胺包覆混合粉体抑制甲烷爆炸的实验研究[J]. 化工学报, 2022, 73(9): 4245-4254.
[12]	朱莲峰, 王超, 张梦娟, 刘方正, 贾鑫, 安萍, 许光文, 韩振南. 水蒸气/氧流化床两段煤气化制备低焦油合成气工艺实验[J]. 化工学报, 2022, 73(8): 3720-3730.
[13]	解文潇, 贾胜坤, 张会书, 罗祎青, 袁希钢. 受限空间内浮升气泡与液体间传质行为实验研究[J]. 化工学报, 2022, 73(7): 2902-2911.
[14]	黄陆月, 刘畅, 许勇毅, 邢浩若, 王峰, 马双忱. CDI二维浓度传质模型的建立以及实验验证[J]. 化工学报, 2022, 73(7): 2933-2943.
[15]	高欢, 丁国良, 周发贤, 庄大伟. R410A制冷剂在润滑油中的动态析出特性的研究[J]. 化工学报, 2022, 73(3): 1054-1062.