响应曲面法优化电化学耦合体系预处理焦化废水

doi:10.11949/j.issn.0438-1157.20180332

摘要/Abstract

摘要：

针对焦化废水有机负荷高、生物抑制性强等特点，采用电化学耦合体系进行预处理研究。以原厂污泥制备污泥活性炭（AC）粒子电极，并表征其表面含有羟基、醚基、羰基、羧基等多种含氧官能团，有利于催化反应。考察阴极曝气对预处理的影响及降解机理分析，结果表明曝气有利于开环反应。基于Central-Composite响应曲面法考察外加电压、初始pH、曝气量、AC填充比等因素对预处理的单独影响及交互作用，并以COD去除率为评价指标。结果表明：各因子的影响显著性顺序为AC填充比 > 初始pH > 曝气量 > 外加电压，其中初始pH和曝气量的交互作用较显著。最佳运行条件为外加电压15 V，初始pH 5.8，曝气量12.4 ml·min^-1，AC填充比50%，反应时间45 min，此时COD去除率达46.8%。废水COD由4700 mg·L^-1降至2500 mg·L^-1，色度去除率为50%，B/C由0.05增至0.37，可生化性明显提高，且能耗较低为0.971 kW·h·（kg COD）^-1。研究表明，采用电化学技术能有效预处理焦化废水，并提高可生化性。

关键词: 电化学, 焦化废水, 预处理, 曝气, 活性炭, Central-Composite响应曲面法

Abstract:

The electrochemical coupling system was used on the pretreatment of coking waste water with high organic loading and biological inhibition. The sludge-derived activated carbon(AC) particle electrodes were prepared from in-site sludge and characterized, indicating that surface oxygen groups contained hydroxyl, ether, carbonyl, carboxyl, etc., which could accelerate catalytic reaction. The effects of cathode aeration were investigated and degradation mechanism of organic contaminants was analyzed. The results showed that aeration was beneficial to open-loop reaction. Based on the Central-Composite response surface method, the separate action and interaction effects of impressed voltage, initial pH, aeration rate, and AC filling ratio were evaluated, and COD removal rate was used as the evaluation index. The significance of influencing factors followed the order:AC filling ratio > initial pH > aeration rate > impressed voltage, and the most significant interaction occurred between initial pH and aeration rate. The optimal conditions were determined to be impressed voltage 15 V, pH 5.8, aeration rate 12.4 ml·min^-1, AC filling ratio 50%, and reaction time 45 min. Then COD removal rate reached 46.8%. Under optimal conditions, COD of the treated waste water decreased from 4700 mg·L^-1 to 2500 mg·L^-1, and chroma removal rate was 50% with low energy consumption of 0.971 kW·h·(kg COD)^-1. And B/C increased from 0.05 to 0.37, indicating the biochemical properties were improved. Therefore, the electrochemical technique can efficiently pretreat the coking waste water and improve its biodegradability.

Key words: electrochemistry, coking waste water, pretreatment, aeration, activated carbon, Central-Composite response surface method

中图分类号:

X703.1

宋迪慧, 安路阳, 张立涛, 张亚峰, 徐歆未, 王宇楠, 卫皇曌. 响应曲面法优化电化学耦合体系预处理焦化废水[J]. 化工学报, 2018, 69(9): 4001-4011.

SONG Dihui, AN Luyang, ZHANG Litao, ZHANG Yafeng, XU Xinwei, WANG Yunan, WEI Huangzhao. Optimization of electrochemical coupling system process for coking waste water pretreatment by response surface method[J]. CIESC Journal, 2018, 69(9): 4001-4011.

参考文献 32

[1]	ZHAO J L, CHEN X W, YAN B, et al. Estrogenic activity and identification of potential xenoestrogens in a coking wastewater treatment plant[J]. Ecotoxicology and Environmental Safety, 2015, 112:238-246.
[2]	XIE D H, LI C C, TANG R, et al. Ion-exchange membrane bioelectrochemical reactor for removal of nitrate in the biological effluent from a coking Wastewater treatment plant[J]. Electrochemistry Communication, 2014, 46:99-102.
[3]	孙怡, 于利亮, 黄浩斌, 等. 高级氧化技术处理难降解有机废水的研发趋势及实用化进展[J]. 化工学报, 2017, 68(5):1743-1756. SUN Y, YU L L, HUANG H B, et al. Research trend and practical development of advanced oxidation process on degradation of recalcitrant organic wastewater[J]. CIESC Journal, 2017, 68(5):1743-1756.
[4]	NA C H, ZHANG Y, QUAN X, et al. Evaluation of the detoxification of coking wastewater treated by combined anaerobic-anoxic-oxic(A2O) and advanced oxidation process[J]. Hazardous Material, 2017, 338(15):186-193.
[5]	WU X H, ZHANG Y, WU G M, et al. Simulation and optimization of a coking wastewater biological treatment process by activated sludge models(ASM)[J]. Journal of Environmental Management, 2016, 165(1):235-242.
[6]	杜宪, 岳秀萍, 王孝维, 等. 厌氧复合床处理模拟焦化废水的反硝化动力学[J]. 化工学报, 2013, 64(7):2650-2655. DU X, YUE X P, WANG X W, et al. Denitrification dynamics of treating analog coking wastewater in upflow blanket filter[J]. CIESC Journal, 2013, 64(7):2650-2655.
[7]	林琳, 李玉平, 曹宏斌, 等. 焦化废水厌氧氨氧化生物脱氮的研究[J]. 中国环境科学, 2010, 30(9):1201-1206. LIN L, LI Y P, CAO H B, et al. Anaerobic ammonium oxidation (ANAMMOX) for biological nitrogen removal from coking wastewater[J]. China Environmental Science, 2010, 30(9):1201-1206.
[8]	ZHOU J, LI H S, CHEN X L, et al. Cometabolic degradation of low-strength coking wastewater and the bacterial community revealed by high-throughput sequencing[J]. Bioresource Technology, 2017, 245(Part A):379-385.
[9]	LI X F, CHEN W Y, MA L M, et al. Industrial wastewater advanced treatment via catalytic ozonation with an Fe-based catalyst[J]. Chemosphere, 2018, 195:336-343.
[10]	侯韦竹, 丁晶, 赵庆良, 等. 响应曲面法优化电氧化-絮凝耦合工艺深度处理垃圾渗滤液[J]. 中国环境科学, 2017, 37(3):948-956. HOU W Z, DING J, ZHAO Q L, et al. Optimization of electro-oxidation and electro-coagulation combination process for landfill leachate advanced treatment by response surface methodology[J]. China Environmental Science, 2017, 37(3):948-956.
[11]	LI J F, WU J, SUN H F, et al. Advanced treatment of biologically treated coking wastewater by membrane distillation coupled with pre-coagulation[J]. Desalination, 2016, 380(15):43-51.
[12]	LI X Y, XU J, CHENG J P, et al. TiO2-SiO2/GAC particles for enhanced electrocatalytic removal of acid orange 7(AO7) dyeing wastewater in a three-dimensional electrochemical reactor[J]. Separation and Purification Technology, 2017, 187(31):303-310.
[13]	ZHENG T L, WANG Q H, SHI Z N, et al. Advanced treatment of wet-spun acrylic fiber manufacturing wastewater using three-dimensional electrochemical oxidation[J]. Environmental Sciences, 2016, 50:21-31.
[14]	李云钊, 宋兴福, 孙玉柱, 等. 基于响应曲面法的反应-萃取-结晶工艺优化[J]. 化工学报, 2016, 67(2):588-597. LI Y Z, SONG X F, SUN Y Z, et al. Optimization of reactive extraction-crystallization process based on response surface methodology[J]. CIESC Journal, 2016, 67(2):588-597.
[15]	蒋新生, 吕科宗, 魏树旺, 等. 基于响应曲面法的三相泡沫灭火剂基础配方优化设计[J]. 化工学报, 2017, 68(7):2886-2895. JIANG X S, LÜ K Z, WEI S W, et al. Optimal design of three phase fire-fighting foam formulation based on response surface methodology[J]. CIESC Journal, 2017, 68(7):2886-2895.
[16]	BASHIR M J K, AZIZ H A, YUSOFF M S, et al. Application of response surface methodology(RSM) for optimization of ammoniacal nitrogen removal from semi-aerobic landfill leachate using ion exchange resin[J]. Desalination, 2010, 254(1/2/3):154-161.
[17]	赵翠梅. 高性能电极材料及新型非对称超级电容器的研究[D]. 长春:吉林大学, 2014. ZHAO C M. Study of high-performance electrode materials and the novel asymmetric supercapacitors[D]. Changchun:Jilin University, 2014.
[18]	丁杰, 宋迪慧, 刘先树, 等. 序批式复极性三维电催化反应器降解苯并噻唑的影响因素[J]. 环境工程学报, 2017, 6(11):140-147. DING J, SONG D H, LIU X S, et al. Effects of sequencing batch bipolar three-dimensional electrocatalytic reactor on benzothiazole degradation[J]. Chinese Journal of Environmental Engineering, 2017, 6(11):140-147.
[19]	MARTINEZ J, ORTIZ A, ORTIZ I. State-of-the-art and perspectives of the catalytic and electrocatalytic reduction of aqueous nitrates[J]. Applied Catalysis B:Environmental, 2017, 207(15):42-59.
[20]	黄力华. 石墨烯修饰电极强化微生物燃料电池性能研究[D]. 无锡:江南大学, 2017. HUANG L H. Study on the performance of microbial fuel cell strengthened by graphene modified electrode[D]. Wuxi:Jiangnan University, 2017.
[21]	PANG F, SONG F E, ZHANG Q D, et al. Study on the influence of oxygen-containing groups on the performance of Ni/AC catalysts in methanol vapor-phase carbonylation[J]. Chemical Engineering, 2016, 293(1):129-138.
[22]	SUN P, ZHANG B, ZENG X B, et al. Deep study on effects of activated carbon's oxygen functional groups for elemental mercury adsorption using temperature programmed desorption method[J]. Fuel, 2017, 200(15):100-106.
[23]	LI J, LIU Q, JI Q Q, et al. Degradation of p-nitrophenol(PNP) in aqueous solution by Fe0-PM-PS system through response surface methodology(RSM)[J]. Applied Catalysis B:Environmental, 2017, 200:633-646.
[24]	WANG Y M, WEI H Z, ZHAO Y, et al. Low temperature modified sludge-derived carbon catalysts for efficient catalytic wet peroxide oxidation of m-cresol[J]. Green Chemistry, 2017, 19:1362-1370.
[25]	SINGH J, YANG J K, CHANG Y Y. Rapid degradation of phenol by ultrasound-dispersed nano-metallic particles(NMPs) in the presence of hydrogen peroxide:a possible mechanism for phenol degradation in water[J]. Environmental Management, 2018, 175(15):60-65.
[26]	SVOBODA L, PRAUS P, LIMA M J, et al. Graphitic carbon nitride nanosheets as highly efficient photocatalysts for phenol degradation under high-power visible LED irradiation[J]. Materials Research Bulletin, 2018, 100:322-332.
[27]	CIEZAK-JENKINS J A. High-pressure polymorphism of the electrochemically active organic molecule tetrahydroxy-p-benzoquinone[J]. Molecular Structure, 2016, 1119(5):71-77.
[28]	CHEN S Y, YAN R, ZHANG X L, et al. Photogenerated electron modulation to dominantly induce efficient 2, 4-dichlorophenol degradation on BiOBr nanoplates with different phosphate modification[J]. Applied Catalysis B:Environmental, 2017, 209(15):320-328.
[29]	CHU L B, YU S Q, WANG J L. Degradation of pyridine and quinoline in aqueous solution by gamma radiation[J]. Radiation Physics and Chemistry, 2017, 144:322-328.
[30]	魏琳. 工业难降解有机污染物的电化学氧化处理方法研究[D]. 武汉:武汉大学, 2011. WEI L. Study on electrochemical oxidation treatment of industrial organic pollutants[D]. Wuhan:Wuhan University, 2011.
[31]	郭莹, 陈鸿汉, 张焕祯, 等. 基于Box-Behnken响应曲面法优化Fenton预处理高浓度燃料中间体生产废水[J]. 环境科学研究, 2017, 30(5):775-783. GUO Y, CHEN H H, ZHANG H Z, et al. Optimization of Fenton pre-treatment of high concentration dye intermediate wastewater based on Box-Behnken response surface methodology[J]. Research of Environmental Sciences, 2017, 30(5):775-783.
[32]	NOSUHI M, NEZAMZADEH-EJHIEH A. High catalytic activity of Fe(Ⅱ)-clinoptilolite nanoparticales for indirect voltammetric determination of dichromate:experimental design by response surface methodology(RSM)[J]. Electrochimica Acta, 2017, 223(1):47-62.