受限微细通道内的流动沸腾流型转化准则

doi:10.3969/j.issn.0438-1157.2013.05.010

化工学报 ›› 2013, Vol. 64 ›› Issue (5): 1573-1579.DOI: 10.3969/j.issn.0438-1157.2013.05.010

受限微细通道内的流动沸腾流型转化准则

刘昕, 张树生, 程林, 常威

山东大学热科学与工程研究中心, 山东济南 250061

收稿日期:2012-08-12 修回日期:2012-10-07 出版日期:2013-05-05 发布日期:2013-05-05
通讯作者: 程林
作者简介:刘昕(1985-),女,博士研究生。
基金资助:
国家重点基础研究发展计划项目(2007CB206900)。

Flow pattern transition criteria of flow boiling in confined mini/micro-channel

LIU Xin, ZHANG Shusheng, CHENG Lin, CHANG Wei

Institute of Thermal Science and Technology, Shandong University, Jinan 250061, Shandong, China

Received:2012-08-12 Revised:2012-10-07 Online:2013-05-05 Published:2013-05-05
Supported by:
supported by the National Basic Research Program of China(2007CB206900).

摘要/Abstract

摘要： 理论分析了微细尺度条件下通道尺寸对气泡运动特性的影响,指出当通道尺寸小于气泡脱离直径时一种特殊流型"受限泡状流"的产生及其特性。对受限通道内流动沸腾过程中的流型转变准则进行了推导,绘制了相应的流型图,并进行了实验验证。研究表明,微细通道内沸腾流动气液两相流流型转变比绝热工况下有明显的推迟;而在流动沸腾工况、相同热通量和质量流速条件下,随着微细通道尺寸的减小,流型转化会在一定程度上提前产生。

关键词: 微细通道, 流动沸腾, 流型, 受限泡状流

Abstract: The effect of channel size on bubble motion characteristics under mini/micro-scale condition is analyzed theoretically.The comparison between channel width and bubble departure diameter indicate that when the former is smaller than the latter, the flow pattern of confined bubbly flow will occur, the flow features of which is further analyzed.On this basis, traditional flow patterns in confined mini/micro-channel are subdivided and flow pattern transition criteria are derived.The prediction of the theoretical model agrees well with corresponding experimental data.The analysis on characteristics of the transition criteria shows an apparent postponement of transition for flow boiling in mini/micro-channel than that under adiabatic conditions.Moreover, for flow boiling under the same heat flux and mass flux conditions, the flow pattern transition may occur earlier with the decrease of channel size.

Key words: mini/micro-channel, flow boiling, flow patterns, confined bubbly flow

中图分类号:

TK124

刘昕, 张树生, 程林, 常威. 受限微细通道内的流动沸腾流型转化准则[J]. 化工学报, 2013, 64(5): 1573-1579.

LIU Xin, ZHANG Shusheng, CHENG Lin, CHANG Wei. Flow pattern transition criteria of flow boiling in confined mini/micro-channel[J]. CIESC Journal, 2013, 64(5): 1573-1579.

参考文献 16

[1]	Taitel T, Dukler A E.A model for predicting flow regime transitions in horizontal and hear horizontal gas-liquid flow[J].AIChE Journal, 1976, 22(1):47-55
[2]	Mishima K, Ishii M.Flow regime transition criteria for upward two-phase flow in vertical tubes[J].International Journal of Heat and Mass Transfer, 1984, 27(5):723-737
[3]	He Kui(何奎), Wang Shuangfeng(汪双凤), Huang Jianzhen(黄间珍).Phase split characteristic of two-phase flow through a micro-T-junction[J].CIESC Journal(化工学报), 2011, 62(S1):92-96
[4]	Zhou Yunlong(周云龙), Wang Hongbo(王红波).Flow characteristics of gas-liquid two-phase flow in small vertical rectangular channel[J].CIESC Journal(化工学报), 2011, 62(5):1226-1232
[5]	Bonjour J, Lallemand M.Flow patterns during boiling in a narrow space between two vertical surfaces[J].International Journal of Multiphase Flow, 1998, 24(6):947-960
[6]	Kandlikar S G.Fundamental issues related to flow boiling in minichannels and microchannels[J].Experimental Thermal and Fluid Science, 2002, 26(2/3/4):389-407
[7]	Kew P, Cornwell K.Correlations for prediction of boiling heat transfer in small diameter channels[J].Applied Thermal Engineering, 1997, 17(8/9/10):705-715
[8]	Thome J R.Boiling in microchannels:a review of experiment and theory[J].International Journal of Heat and Mass Transfer, 2004, 25(2):128-139
[9]	Qu W, Mudawar I.Prediction and measurement of incipient boiling heat flux in micro-channel heat sinks[J].International Journal of Heat and Mass Transfer, 2002, 45(19):3933-3945
[10]	Hibiki T, Ishii M.Active nucleation site density in boiling systems[J].International Journal of Heat and Mass Transfer, 2003, 46(14):2587-2601
[11]	Chen L, Tian T G, Karayiannis T G.The effect of tube diameter on vertical two-phase flow regimes in small tubes[J].International Journal of Heat and Mass Transfer, 2006, 49(21/22):4220-4230
[12]	Xu Jijun(徐济鋆).Boiling Heat Transfer and Gas-Liquid Two-Phase Flow(沸腾传热和气液两相流)[M].2nd ed.Beijing:Atomic Energy Press, 2001
[13]	Xu J L, Cheng P, Zhao T S.Gas-liquid two-phase flow regimes in rectangular channels with mini/micro gaps[J].International Journal of Multiphase Flow, 1999, 25(3):411-432
[14]	Wilmarth T, Ishii M.Interfacial area concentration and void fraction of two-phase flow in narrow rectangular vertical channels[J].Journal of Fluids Engineering, 1997, 119(4):916-922
[15]	Taitel Y, Bornea D, Dukler A E.Modelling flow pattern transitions for steady upward gas-liquid flow in vertical tubes[J].AIChE Journal, 1980, 26(3):345-354
[16]	Hibiki T, Mishima Kaichiro.Flow regime transition criteria for upward two-phase flow in vertical narrow rectangular channels[J].Nuclear Engineering and Design, 2001, 203(2/3):117-131

受限微细通道内的流动沸腾流型转化准则

Flow pattern transition criteria of flow boiling in confined mini/micro-channel

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 16

相关文章 15

编辑推荐

Metrics

本文评价

[1]	周绍华, 詹飞龙, 丁国良, 张浩, 邵艳坡, 刘艳涛, 郜哲明. 短管节流阀内流动噪声的实验研究及降噪措施[J]. 化工学报, 2023, 74(S1): 113-121.
[2]	宋瑞涛, 王派, 王云鹏, 李敏霞, 党超镔, 陈振国, 童欢, 周佳琦. 二氧化碳直接蒸发冰场排管内流动沸腾换热数值模拟分析[J]. 化工学报, 2023, 74(S1): 96-103.
[3]	王玉兵, 李杰, 詹宏波, 朱光亚, 张大林. R134a在菱形离散肋微小通道内的流动沸腾换热实验研究[J]. 化工学报, 2023, 74(9): 3797-3806.
[4]	郭雨莹, 敬加强, 黄婉妮, 张平, 孙杰, 朱宇, 冯君炫, 陆洪江. 稠油管道水润滑减阻及压降预测模型修正[J]. 化工学报, 2023, 74(7): 2898-2907.
[5]	张建伟, 高伟峰, 董鑫, 冯颖. 浸没式撞击流反应器流场涡特性的数值研究[J]. 化工学报, 2022, 73(8): 3553-3564.
[6]	周宇航, 陈建义, 王亚安, 张丁于, 马红莹, 叶松. 基于液膜流型的双入口管柱式气液分离器性能研究[J]. 化工学报, 2022, 73(3): 1221-1231.
[7]	张井志, 赵玉婷, 王英迪, 齐建荟, 雷丽. 正弦型微通道内液-液两相流型及流动特性实验研究[J]. 化工学报, 2022, 73(3): 1111-1118.
[8]	杨蕊, 朱宝锦, 吕超, 张磊, 肖迎松. 脉动条件下旋流场内气液两相流流型及其转变机理[J]. 化工学报, 2022, 73(10): 4389-4398.
[9]	湛伟, 刘西洋, 朱春英, 马友光, 付涛涛. 台阶式并行微通道内液液两相流流型及其转变机理[J]. 化工学报, 2022, 73(1): 184-193.
[10]	周培, 张秀平, 唐景春, 杨磊, 叶斌, 黄荣华. 过冷流动沸腾中气泡浮升直径的实验及理论研究[J]. 化工学报, 2022, 73(1): 194-203.
[11]	匡以武, 孙礼杰, 王文, 耑锐, 张亮. 基于双流体模型的液氢流动沸腾数值模拟[J]. 化工学报, 2021, 72(S1): 184-193.
[12]	朱业铭, 刘金平, 许雄文, 朱丹丹. 竖直多孔平板上液膜流动特性的研究[J]. 化工学报, 2021, 72(8): 4081-4092.
[13]	田永生, 季万祥, 陈增桥, 王乃华. 大长径比垂直换热管外瞬态池沸腾的研究[J]. 化工学报, 2021, 72(4): 2018-2026.
[14]	郝仁杰, 谯敏, 黄卫星. 气-液并流通过堆叠筛板填料的脉冲流特性[J]. 化工学报, 2021, 72(3): 1314-1321.
[15]	丁国栋, 陈家庆, 李振林, 蔡小垒. 注气孔位置对文丘里管式微气泡发生器成泡特性的影响分析[J]. 化工学报, 2021, 72(11): 5552-5562.