汞在MnOx-CeO2/γ-Al2O3催化剂表面的赋存形态分析

doi:10.11949/j.issn.0438-1157.20141887

化工学报 ›› 2015, Vol. 66 ›› Issue (6): 2082-2088.DOI: 10.11949/j.issn.0438-1157.20141887

• 催化、动力学与反应器 • 上一篇下一篇

汞在MnO_x-CeO₂/γ-Al₂O₃催化剂表面的赋存形态分析

罗小雨, 苏胜, 向军, 汪一, 王鹏鹰, 尤默, 陆骑

华中科技大学国家煤燃烧重点实验室, 湖北武汉 430074

收稿日期:2014-12-19 修回日期:2015-03-02 出版日期:2015-06-05 发布日期:2015-06-05
通讯作者: 苏胜
基金资助:
高等学校博士学科点专项科研基金项目(20130142110086)。

Speciation of mercury formed on MnO_x-CeO₂/γ-Al₂O₃catalyst surface

LUO Xiaoyu, SU Sheng, XIANG Jun, WANG Yi, WANG Pengying, YOU Mo, LU Qi

State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology, Wuhan 430074, Hubei, China

Received:2014-12-19 Revised:2015-03-02 Online:2015-06-05 Published:2015-06-05
Supported by:
supported by the Specialized Research Fund for the Doctoral Program of Higher Education (20130142110086).

摘要/Abstract

摘要：

为了高效经济地控制燃煤电站汞的排放, 探索新型SCR催化剂上汞的催化氧化具有重要的学术价值和广阔的应用前景。Hg⁰在MnO_x-CeO₂/γ-Al₂O₃(MnCe15)催化剂上被氧化后会以多种形态存在于催化剂表面, 为确定MnCe15催化剂上汞的化合物的赋存形态, 使用程序升温热分解方法研究了纯汞化合物的分解曲线, 并与在不同烟气条件下处理过的MnCe15催化剂的分解脱附曲线进行了对比。研究确认了反应中HgO、HgCl₂、Hg(NO₃)₂和HgSO₄的生成, 并根据实验结果分析了相应的汞化合物生成的反应路径。结果表明, 在模拟烟气条件下HgCl₂是主要的异相催化反应产物, 同时可以在催化剂表面检测到少量HgO和HgSO₄的生成。这一结论可为研究SCR催化剂上Hg⁰的催化氧化机理提供基础。

关键词: 汞, 污染, 催化剂, 选择催化还原, 汞形态分析

Abstract:

Hg⁰ oxidation over selective catalytic reduction (SCR) catalysts would be of great scientific and practical value to control mercury emission in coal-fired power stations. To elucidate the mercury species existing on the MnO_x-CeO₂/γ-Al₂O₃(MnCe15) catalyst surface, a temperature programmed thermal decomposition (TPTD) method was used in this study to analyze the characteristics of the mercury species formed on the MnCe15 catalysts. A series of pure mercury compounds mixed with fresh MnCe15 were first studied for qualitative calibration. Then, the TPTD method was used to identify the Hg species on used MnCe15 catalysts pretreated under different operation conditions. The formation of HgO, HgCl₂, Hg(NO₃)₂ and HgSO₄ during the oxidation process was confirmed and the reaction pathways were proposed. The mercury species present were mainly HgCl₂ after MnCe15 catalysts were used to oxidize Hg⁰ under simulated flue gas conditions. HgO and HgSO₄were found to exist in very low concentrations. This study provided the basis for the study on catalytic oxidation mechanism of Hg⁰on SCR catalyst.

Key words: mercury, pollution, catalyst, SCR, mercury speciation

中图分类号:

TQ534.9

罗小雨, 苏胜, 向军, 汪一, 王鹏鹰, 尤默, 陆骑. 汞在MnO_x-CeO₂/γ-Al₂O₃催化剂表面的赋存形态分析[J]. 化工学报, 2015, 66(6): 2082-2088.

LUO Xiaoyu, SU Sheng, XIANG Jun, WANG Yi, WANG Pengying, YOU Mo, LU Qi. Speciation of mercury formed on MnO_x-CeO₂/γ-Al₂O₃catalyst surface[J]. CIESC Journal, 2015, 66(6): 2082-2088.

参考文献 23

[1]	Zhang Anchao (张安超), Xiang Jun (向军), Sun Lushi (孙路石), Hu Song (胡松), Fu Peng (付鹏), Cheng Wei (程伟), Qiu Jianrong (邱建荣). Synthesis and characterization of novel modified sorbents and their performance for elemental mercury removal [J]. CIESC Journal (化工学报), 2009, 60 (6): 1546-1553.
[2]	Wang P, Su S, Xiang J, You H, Cao F, Sun L, Hu S, Zhang Y. Catalytic oxidation of Hg0 by MnOx-CeO2/γ-Al2O3 catalyst at low temperatures [J]. Chemosphere, 2014, 101: 49-54.
[3]	He S, Zhou J, Zhu Y, Luo Z, Ni M, Cen K. Mercury oxidation over a vanadia-based selective catalytic reduction catalyst [J]. Energy & Fuels, 2008, 23 (1): 253-259.
[4]	Eom Y, Jeon S, Ngo T, Kim J, Lee T. Heterogeneous mercury reaction on a selective catalytic reduction (SCR) catalyst [J]. Catalysis Letters, 2008, 121 (3/4): 219-225.
[5]	Biester H, Scholz C. Determination of mercury binding forms in contaminated soils: mercury pyrolysis versus sequential extractions [J]. Environmental Science & Technology, 1996, 31 (1): 233-239.
[6]	Feng X, Lu J, Grègoire D, Hao Y, Banic C, Schroeder W. Analysis of inorganic mercury species associated with airborne particulate matter/aerosols: method development. [J]. Analytical & Bioanalytical Chemistry, 2004, 380 (4): 683-689.
[7]	Bradshaw P, Koksoy M, Turkey W, Proceedings of the 23rd International Geology Congress [C]. Academia, Prague, Section 7, 1968: 341-355
[8]	Windmöller C C, Wilken R D, Jardim W D F. Mercury speciation in contaminated soils by thermal release analysis [J]. Water, Air, and Soil Pollution, 1996, 89 (3/4): 399-416.
[9]	Biester H, Gosar M, Covelli S. Mercury speciation in sediments affected by dumped mining residues in the drainage area of the Idrija mercury mine, Slovenia [J]. Environmental Science & Technology, 2000, 34 (16): 3330-3336.
[10]	Raposo C, Windmöller C C, DurãoJúnior W A. Mercury speciation in fluorescent lamps by thermal release analysis [J]. Waste Management, 2003, 23 (10): 879-886.
[11]	Ozaki M, Uddin M A, Sasaoka E, Wu S. Temperature programmed decomposition desorption of the mercury species over spent iron-based sorbents for mercury removal from coal derived fuel gas [J]. Fuel, 2008, 87 (17/18): 3610-3615.
[12]	Uddin M A, Ozaki M, Sasaoka E, Wu S. Temperature-programmed decomposition desorption of mercury species over activated carbon sorbents for mercury removal from coal-derived fuel gas [J]. Energy & Fuels, 2009, 23 (10): 4710-4716.
[13]	Murakami A, Uddin M A, Ochiai R, Sasaoka E, Wu S. Study of the mercury sorption mechanism on activated carbon in coal combustion flue gas by the temperature-programmed decomposition desorption technique [J]. Energy & Fuels,2010, 24 (8): 4241-4249.
[14]	Wu S, Uddin M A, Nagano S, Ozaki M, Sasaoka E. Fundamental study on decomposition characteristics of mercury compounds over solid powder by temperature-programmed decomposition desorption mass spectrometry [J]. Energy & Fuels, 2010, 25 (1): 144-153.
[15]	Rallo M, Lopez-Anton M A, Perry R, Maroto-Valer M M. Mercury speciation in gypsums produced from flue gas desulfurization by temperature programmed decomposition [J]. Fuel, 2010, 89 (8): 2157-2159.
[16]	Lopez-Anton M A, Yuan Y, Perry R, Maroto-Valer M M. Analysis of mercury species present during coal combustion by thermal desorption [J]. Fuel,2010, 89 (3): 629-634.
[17]	Rallo M, Lopez-Anton M A, Meij R, Perry R, Maroto-Valer M M. Study of mercury in by-products from a Dutch co-combustion power station [J]. Journal of Hazardous Materials, 2010, 174 (1/2/3): 28-33.
[18]	Lopez-Anton M A, Perry R, Abad-Valle P, Díaz-Somoano M, Martínez-Tarazona M R, Maroto-Valer M M. Speciation of mercury in fly ashes by temperature programmed decomposition [J]. Fuel Processing Technology, 2011, 92 (3): 707-711.
[19]	Abad-Valle P, Lopez-Anton M A, Diaz-Somoano M, Martinez-Tarazona M R. The role of unburned carbon concentrates from fly ashes in the oxidation and retention of mercury [J]. Chemical Engineering Journal, 2011, 174 (1): 86-92.
[20]	Rallo M, Heidel B, Brechtel K, Maroto-Valer M M. Effect of SCR operation variables on mercury speciation [J]. Chemical Engineering Journal, 2012, 198/199: 87-94.
[21]	Rumayor M, Diaz-Somoano M, Lopez-Anton M A, Martinez-Tarazona M R. Mercury compounds characterization by thermal desorption [J]. Talanta,2013, 114: 318-322.
[22]	Presto A A, Granite E J. Survey of catalysts for oxidation of mercury in flue gas [J]. Environmental Science & Technology, 2006, 40 (18): 5601-5609.
[23]	Niksa S, Fujiwara N. A predictive mechanism for mercury oxidation on selective catalytic reduction catalysts under coal-derived flue gas [J]. Journal of the Air & Waste Management Association:Air & Waste Management Association, 2005, 55 (12): 1866-1875.

汞在MnO_x-CeO₂/γ-Al₂O₃催化剂表面的赋存形态分析

Speciation of mercury formed on MnO_x-CeO₂/γ-Al₂O₃catalyst surface

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 23

相关文章 15

编辑推荐

Metrics

本文评价

[1]	李艺彤, 郭航, 陈浩, 叶芳. 催化剂非均匀分布的质子交换膜燃料电池操作条件研究[J]. 化工学报, 2023, 74(9): 3831-3840.
[2]	陈杰, 林永胜, 肖恺, 杨臣, 邱挺. 胆碱基碱性离子液体催化合成仲丁醇性能研究[J]. 化工学报, 2023, 74(9): 3716-3730.
[3]	杨百玉, 寇悦, 姜峻韬, 詹亚力, 王庆宏, 陈春茂. 炼化碱渣湿式氧化预处理过程DOM的化学转化特征[J]. 化工学报, 2023, 74(9): 3912-3920.
[4]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[5]	杨欣, 彭啸, 薛凯茹, 苏梦威, 吴燕. 分子印迹-TiO₂光电催化降解增溶PHE废水性能研究[J]. 化工学报, 2023, 74(8): 3564-3571.
[6]	吕龙义, 及文博, 韩沐达, 李伟光, 高文芳, 刘晓阳, 孙丽, 王鹏飞, 任芝军, 张光明. 铁基导电材料强化厌氧去除卤代有机污染物：研究进展及未来展望[J]. 化工学报, 2023, 74(8): 3193-3202.
[7]	杨菲菲, 赵世熙, 周维, 倪中海. Sn掺杂的In₂O₃催化CO₂选择性加氢制甲醇[J]. 化工学报, 2023, 74(8): 3366-3374.
[8]	李凯旋, 谭伟, 张曼玉, 徐志豪, 王旭裕, 纪红兵. 富含零价钴活性位点的钴氮碳/活性炭设计及甲醛催化氧化应用研究[J]. 化工学报, 2023, 74(8): 3342-3352.
[9]	李盼, 马俊洋, 陈志豪, 王丽, 郭耘. Ru/α-MnO₂催化剂形貌对NH₃-SCO反应性能的影响[J]. 化工学报, 2023, 74(7): 2908-2918.
[10]	余娅洁, 李静茹, 周树锋, 李清彪, 詹国武. 基于天然生物模板构建纳米材料及集成催化剂研究进展[J]. 化工学报, 2023, 74(7): 2735-2752.
[11]	涂玉明, 邵高燕, 陈健杰, 刘凤, 田世超, 周智勇, 任钟旗. 钙基催化剂的设计合成及应用研究进展[J]. 化工学报, 2023, 74(7): 2717-2734.
[12]	张琦钰, 高利军, 苏宇航, 马晓博, 王翊丞, 张亚婷, 胡超. 碳基催化材料在电化学还原二氧化碳中的研究进展[J]. 化工学报, 2023, 74(7): 2753-2772.
[13]	朱理想, 罗默也, 张晓东, 龙涛, 余冉. 醌指纹法指示三氯乙烯污染土功能微生物活性应用研究[J]. 化工学报, 2023, 74(6): 2647-2654.
[14]	张希庆, 王琰婷, 徐彦红, 常淑玲, 孙婷婷, 薛定, 张立红. Mg量影响的纳米片负载Pt-In催化异丁烷脱氢性能[J]. 化工学报, 2023, 74(6): 2427-2435.
[15]	张谭, 刘光, 李晋平, 孙予罕. Ru基氮还原电催化剂性能调控策略[J]. 化工学报, 2023, 74(6): 2264-2280.