超临界二氧化碳垂直管内传热恶化数值模拟研究

doi:10.11949/0438-1157.20211399

摘要/Abstract

摘要：

超临界二氧化碳(supercritical carbon dioxide， S-CO₂)布雷顿循环燃煤发电系统中，炉膛内水冷壁管内S-CO₂传热恶化行为，对该系统的设计建造与安全运行具有重要意义。建立S-CO₂垂直上升管流动传热过程数值模型，开展S-CO₂在垂直上升管流动及传热行为的数值模拟研究，分析了压力、质量流量、热通量和管径以及由物性变化引起的浮升力效应与流动加速效应等因素对传热特性的影响。结果表明：对于垂直上升管内加热条件下的S-CO₂，提高其压力与质量流量有利于降低传热恶化程度。而提高热通量与管径则会加剧传热恶化。此外，在S-CO₂垂直上升管内，存在明显的浮升力效应，导致发生传热恶化现象，而流动加速效应对传热的影响可以忽略。最后，在内径为4~10 mm、压力为11.07~22.14 MPa、质量流量为0~1200 kg/(m²·s)、热通量为0~200 kW/m²的宽范围工况下，建立深度神经网络模型(DNN)，提出了临界热通量预测关联式，其预测精度可提升至94.96%。

关键词: 超临界二氧化碳, 垂直管, 流动, 传热恶化, 预测关联式

Abstract:

In the supercritical carbon dioxide(S-CO₂) Brayton cycle coal-fired power generation system, the deterioration of S-CO₂ heat transfer in the water wall tube in the furnace is of great significance to the design, construction and safe operation of the system. Numerical simulation study of heat transfer for S-CO₂ flowing in vertical tubes is carried out in the present paper. The effect of operating parameters including pressure, mass flow, heat flux and tube diameter, as well as buoyancy and flow acceleration caused by changes in physical properties of S-CO₂ on the wall temperature and convective heat transfer coefficient is analyzed. It is shown that increasing the pressure and mass flow rate can reduce the degree of heat transfer deterioration, while increasing the heat flux density and pipe diameter will aggravate the degree of heat transfer deterioration. In addition, there is an obvious buoyancy effect which will cause heat transfer deterioration, while the influence of flow acceleration on heat transfer can be ignored under the working conditions studied in this paper. A new critical heat flux correlation is proposed using a deep neural network (DNN) method under wide working conditions of the diameter 4—10 mm, pressure 11.07—22.14 MPa, mass flux 0—1200 kg/(m²·s) and heat flux 0—200 kW/m², of which the prediction accuracy can be improved to 94.96%.

Key words: supercritical carbon dioxide, vertical tubes, flow, heat transfer deterioration, correlations

中图分类号:

TK 124

汪森林, 李照志, 邵应娟, 钟文琪. 超临界二氧化碳垂直管内传热恶化数值模拟研究[J]. 化工学报, 2022, 73(3): 1072-1082.

Senlin WANG, Zhaozhi LI, Yingjuan SHAO, Wenqi ZHONG. Numerical simulation on heat transfer deterioration of supercritical carbon dioxide in vertical tube[J]. CIESC Journal, 2022, 73(3): 1072-1082.

图/表 6

参考文献 44

1	Tumanovskii A G, Shvarts A L, Somova E V, et al. Review of the coal-fired, over-supercritical and ultra-supercritical steam power plants[J]. Thermal Engineering, 2017, 64(2): 83-96.
2	徐进良, 刘超, 孙恩慧, 等. 超临界二氧化碳动力循环研究进展及展望[J]. 热力发电, 2020, 49(10): 1-10.
	Xu J L, Liu C, Sun E H, et al. Review and perspective of supercritical carbon dioxide power cycles[J]. Thermal Power Generation, 2020, 49(10): 1-10.
3	李平姣. 超临界二氧化碳循环燃煤流化床锅炉的构型研究[D]. 南京: 东南大学, 2019.
	Li P J. Configuration design study of supercritical carbon dioxide coal-fired circulating fluidized bed boiler[D]. Nanjing: Southeast University, 2019.
4	Liu X J, Zhong W Q, Li P J, et al. Design and performance analysis of coal-fired fluidized bed for supercritical CO₂ power cycle[J]. Energy, 2019, 176: 468-478.
5	Bae Y Y, Kim H, Kang D J. Forced and mixed convection heat transfer to supercritical CO₂ vertically flowing in a uniformly-heated circular tube[J]. Experimental Thermal and Fluid Science, 2010, 34(8): 1295-1308.
6	Kim H Y, Kim H, Song J H, et al. Heat transfer test in a vertical tube using CO₂ at supercritical pressures[J]. Journal of Nuclear Science and Technology, 2007, 44(3): 285-293.
7	吴新明. 超临界二氧化碳在竖直圆管内流动传热特性实验研究[D]. 北京: 华北电力大学(北京), 2019.
	Wu X M. Experimental study on the flow and heat transfer characteristics of supercritical carbon dioxide in vertical tubes[D]. Beijing: North China Electric Power University, 2019.
8	Song J H, Kim H Y, Kim H, et al. Heat transfer characteristics of a supercritical fluid flow in a vertical pipe[J]. The Journal of Supercritical Fluids, 2008, 44(2): 164-171.
9	Liao S M, Zhao T S. An experimental investigation of convection heat transfer to supercritical carbon dioxide in miniature tubes[J]. International Journal of Heat and Mass Transfer, 2002, 45(25): 5025-5034.
10	Lei X L, Zhang J, Guo L T, et al. Experimental study on convection heat transfer of supercritical CO₂ in small upward channels[J]. Energy, 2019, 176: 119-130.
11	Li Z H, Jiang P X, Zhao C R, et al. Experimental investigation of convection heat transfer of CO₂ at supercritical pressures in a vertical circular tube[J]. Experimental Thermal and Fluid Science, 2010, 34(8): 1162-1171.
12	Kim D E, Kim M H. Experimental investigation of heat transfer in vertical upward and downward supercritical CO₂ flow in a circular tube[J]. International Journal of Heat and Fluid Flow, 2011, 32(1): 176-191.
13	Eter A, Groeneveld D, Tavoularis S. Convective heat transfer in supercritical flows of CO₂ in tubes with and without flow obstacles[J]. Nuclear Engineering and Design, 2017, 313: 162-176.
14	Zhang Q, Li H X, Liu J L, et al. Numerical investigation of different heat transfer behaviors of supercritical CO₂ in a large vertical tube[J]. International Journal of Heat and Mass Transfer, 2020, 147: 118944.
15	张良, 朱兵国, 吴新明, 等. 超临界二氧化碳在垂直光管内的传热特性[J]. 中国电机工程学报, 2019, 39(15): 4487-4497.
	Zhang L, Zhu B G, Wu X M, et al. Heat transfer characteristics of supercritical pressure CO₂ in a vertical smooth tube[J]. Proceedings of the CSEE, 2019, 39(15): 4487-4497.
16	庄晓如, 徐心海, 杨智, 等. 高温吸热管内超临界CO₂传热特性的数值模拟[J]. 物理学报, 2021, 70(3): 176-188.
	Zhuang X R, Xu X H, Yang Z, et al. Numerical investigation on heat transfer of supercritical CO₂ in solar receiver tube in high temperature region[J]. Acta Physica Sinica, 2021, 70(3): 176-188.
17	Du X, Lv Z H, Yu X, et al. Heat transfer of supercritical CO₂ in vertical round tube: a considerate turbulent Prandtl number modification[J]. Energy, 2020, 192: 116612.
18	Shiralkar B S, Griffith P. Deterioration in heat transfer to fluids at supercritical pressure and high heat fluxes[R]. Office of Scientific and Technical Information (OSTI), 1968.
19	Kim J K, Jeon H K, Lee J S. Wall temperature measurement and heat transfer correlation of turbulent supercritical carbon dioxide flow in vertical circular/non-circular tubes[J]. Nuclear Engineering and Design, 2007, 237(15/16/17): 1795-1802.
20	Grabezhnaya V A, Kirillov P L. Heat transfer under supercritical pressures and heat transfer deterioration boundaries[J]. Thermal Engineering, 2006, 53: 296-301.
21	Cheng X, Yang Y H, Huang S F. A simplified method for heat transfer prediction of supercritical fluids in circular tubes[J]. Annals of Nuclear Energy, 2009, 36(8): 1120-1128.
22	Kline N, Feuerstein F, Tavoularis S. Onset of heat transfer deterioration in vertical pipe flows of CO₂ at supercritical pressures[J]. International Journal of Heat and Mass Transfer, 2018, 118: 1056-1068.
23	Saltanov E, Pioro I, Mann D, et al. Study on specifics of forced-convective heat transfer in supercritical carbon dioxide[J]. Journal of Nuclear Engineering and Radiation Science, 2015, 1(1): 011008.
24	张宇, 姜培学, 石润富, 等. 竖直圆管中超临界压力CO₂在低Re数下对流换热研究[J]. 工程热物理学报, 2008, 29(1): 118-120.
	Zhang Y, Jiang P X, Shi R F, et al. Convection heat transfer of CO₂ at supercritical pressure in a vertical tube at low Reynolds numbers[J]. Journal of Engineering Thermophysics, 2008, 29(1): 118-120.
25	朱兵国. 超临界二氧化碳垂直管内对流换热研究[D]. 北京: 华北电力大学(北京), 2020.
	Zhu B G. Research on convective heat transfer of super-critical carbon dioxide in vertical tube[D]. Beijing: North China Electric Power University, 2020.
26	Xu J L, Zhang H S, Zhu B G, et al. Critical supercritical-boiling-number to determine the onset of heat transfer deterioration for supercritical fluids[J]. Solar Energy, 2020, 195: 27-36.
27	王振川. 超临界压力流体湍流换热实验与数值模拟研究[D]. 北京: 清华大学, 2018.
	Wang Z C. Experimental and numerical research on turbulent convection heat transfer of supercritical pressure fluid[D]. Beijing: Tsinghua University, 2018.
28	朱兵国, 张海松, 孙恩慧, 等. 超高参数CO₂在垂直管中的传热分析[J]. 化工进展, 2019, 38(11): 4880-4889.
	Zhu B G, Zhang H S, Sun E H, et al. Heat transfer analysis of ultra high parameter CO₂ in vertical pipe[J]. Chemical Industry and Engineering Progress, 2019, 38(11): 4880-4889.
29	Jackson J D, Hall W B. Influences of buoyancy on heat transfer to fluids flowing in vertical tubes under turbulent conditions[J]. Institution of Mechanical Engineers, Conference Publications, 1979, 2: 613-640.
30	McEligot D M, Coon C W, Perkins H C. Relaminarization in tubes[J]. International Journal of Heat and Mass Transfer, 1970, 13(2): 431-433.
31	Pioro I L, Duffey R B. Experimental heat transfer in supercritical water flowing inside channels (survey)[J]. Nuclear Engineering and Design, 2005, 235(22): 2407-2430.
32	Duffey R B, Pioro I L. Experimental heat transfer of supercritical carbon dioxide flowing inside channels (survey)[J]. Nuclear Engineering and Design, 2005, 235(8): 913-924.
33	Jiang P X, Xu Y J, Lv J, et al. Experimental investigation of convection heat transfer of CO₂ at super-critical pressures in vertical mini-tubes and in porous media[J]. Applied Thermal Engineering, 2004, 24(8/9): 1255-1270.
34	石润富, 姜培学, 张宇. 细圆管内超临界二氧化碳对流换热的实验研究[J]. 工程热物理学报, 2007, 28(6): 995-997.
	Shi R F, Jiang P X, Zhang Y. Experimental investigations of convection heat transfer of CO₂ at supercritical pressures in small tubes[J]. Journal of Engineering Thermophysics, 2007, 28(6): 995-997.
35	Jiang P X, Zhang Y, Zhao C R, et al. Convection heat transfer of CO₂ at supercritical pressures in a vertical mini tube at relatively low Reynolds numbers[J]. Experimental Thermal and Fluid Science, 2008, 32(8): 1628-1637.
36	Kim J K, Jeon H K, Lee J S. Wall temperature measurements with turbulent flow in heated vertical circular/non-circular channels of supercritical pressure carbon-dioxide[J]. International Journal of Heat and Mass Transfer, 2007, 50(23/24): 4908-4911.
37	Kim H, Kim H Y, Song J H, et al. Heat transfer to supercritical pressure carbon dioxide flowing upward through tubes and a narrow annulus passage[J]. Progress in Nuclear Energy, 2008, 50(2/3/4/5/6): 518-525.
38	Jiang P X, Zhang Y, Shi R F. Experimental and numerical investigation of convection heat transfer of CO₂ at supercritical pressures in a vertical mini-tube[J]. International Journal of Heat and Mass Transfer, 2008, 51(11/12): 3052-3056.
39	Kim D E, Kim M H. Experimental study of the effects of flow acceleration and buoyancy on heat transfer in a supercritical fluid flow in a circular tube[J]. Nuclear Engineering and Design, 2010, 240(10): 3336-3349.
40	Zahlan H, Groeneveld D, Tavoularis S. Measurements of convective heat transfer to vertical upward flows of CO₂ in circular tubes at near-critical and supercritical pressures[J]. Nuclear Engineering and Design, 2015, 289: 92-107.
41	Xu R N, Luo F, Jiang P X. Buoyancy effects on turbulent heat transfer of supercritical CO₂ in a vertical mini-tube based on continuous wall temperature measurements[J]. International Journal of Heat and Mass Transfer, 2017, 110: 576-586.
42	熊超. 超临界压力二氧化碳在竖直细圆管中的强化换热实验研究[D]. 北京: 清华大学, 2017.
	Xiong C. Experimental investigation of enhanced heat transfer of CO₂ at super-critical pressure in small vertical tubes[D]. Beijing: Tsinghua University, 2017.
43	Zhang S J, Xu X X, Liu C, et al. Experimental investigation on the heat transfer characteristics of supercritical CO₂ at various mass flow rates in heated vertical-flow tube[J]. Applied Thermal Engineering, 2019, 157: 113687.
44	Zhu B G, Xu J L, Wu X M, et al. Supercritical “boiling” number, a new parameter to distinguish two regimes of carbon dioxide heat transfer in tubes[J]. International Journal of Thermal Sciences, 2019, 136: 254-266.

[1]	宋瑞涛, 王派, 王云鹏, 李敏霞, 党超镔, 陈振国, 童欢, 周佳琦. 二氧化碳直接蒸发冰场排管内流动沸腾换热数值模拟分析[J]. 化工学报, 2023, 74(S1): 96-103.
[2]	周绍华, 詹飞龙, 丁国良, 张浩, 邵艳坡, 刘艳涛, 郜哲明. 短管节流阀内流动噪声的实验研究及降噪措施[J]. 化工学报, 2023, 74(S1): 113-121.
[3]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[4]	王玉兵, 李杰, 詹宏波, 朱光亚, 张大林. R134a在菱形离散肋微小通道内的流动沸腾换热实验研究[J]. 化工学报, 2023, 74(9): 3797-3806.
[5]	洪瑞, 袁宝强, 杜文静. 垂直上升管内超临界二氧化碳传热恶化机理分析[J]. 化工学报, 2023, 74(8): 3309-3319.
[6]	赵健, 周兴超, 夏丹, 董航. 机械搅拌对原油储罐射流加热过程传热特性的影响规律研究[J]. 化工学报, 2023, 74(5): 1982-1999.
[7]	周必茂, 许世森, 王肖肖, 刘刚, 李小宇, 任永强, 谭厚章. 烧嘴偏转角度对气化炉渣层分布特性的影响[J]. 化工学报, 2023, 74(5): 1939-1949.
[8]	王倩倩, 刘明言, 马永丽. 水中超声波脱气的效应研究[J]. 化工学报, 2023, 74(4): 1693-1702.
[9]	郑书闽, 郭鹏程, 颜建国, 王帅, 李文博, 周淇. 微小通道内过冷流动沸腾阻力特性实验及预测研究[J]. 化工学报, 2023, 74(4): 1549-1560.
[10]	张浩, 徐惠斌, 高健, 刘帝宏, 周泽华. Geldart-D类湿颗粒倾斜落料行为及其强化[J]. 化工学报, 2023, 74(4): 1519-1527.
[11]	朱兵国, 何吉祥, 徐进良, 彭斌. 冷却条件下渐扩/渐缩管内超临界压力二氧化碳的传热特性[J]. 化工学报, 2023, 74(3): 1062-1072.
[12]	张梦波, 楼琳瑾, 冯艺荣, 郑雨婷, 张浩淼, 王靖岱, 阳永荣. 烷基铝氧烷合成技术研究进展[J]. 化工学报, 2023, 74(2): 525-534.
[13]	盛林, 昌宇, 邓建, 骆广生. 阶梯式T型微通道内有序气泡群的形成和流动特性研究[J]. 化工学报, 2023, 74(1): 416-427.
[14]	姚翰林, 辛忠. 液相沉淀反应在管式微通道反应器中的流动行为研究[J]. 化工学报, 2022, 73(8): 3518-3528.
[15]	解文潇, 贾胜坤, 张会书, 罗祎青, 袁希钢. 受限空间内浮升气泡与液体间传质行为实验研究[J]. 化工学报, 2022, 73(7): 2902-2911.