煤粉料仓通气下料流动行为

doi:10.3969/j.issn.0438-1157.2014.04.005

化工学报 ›› 2014, Vol. 65 ›› Issue (4): 1186-1193.DOI: 10.3969/j.issn.0438-1157.2014.04.005

煤粉料仓通气下料流动行为

陶顺龙, 陆海峰, 郭晓镭, 孙晓林, 龚欣

华东理工大学煤气化及能源化工教育部重点实验室, 上海 200237

收稿日期:2013-07-29 修回日期:2013-09-30 出版日期:2014-04-05 发布日期:2013-11-28
通讯作者: 郭晓镭
作者简介:陶顺龙（1988—），男，硕士研究生。
基金资助:
国家自然科学基金项目（21006027,21206041）；中国博士后科学基金项目（2012M520847）；中央高校基本科研业务费专项资金。

Flow behavior of aerated discharging of pulverized coal from hopper

TAO Shunlong, LU Haifeng, GUO Xiaolei, SUN Xiaolin, GONG Xin

Key Laboratory of Coal Gasification and Energy Chemical Engineering of Ministry of Education, East China University of Science and Technology, Shanghai 200237, China

Received:2013-07-29 Revised:2013-09-30 Online:2014-04-05 Published:2013-11-28
Supported by:
supported by the National Natural Science Foundation of China (21006027, 21206041), the China Postdoctoral Science Foundation Funded Project(2012M520847) and the Fundamental Research Funds for the Central Universities.

摘要/Abstract

摘要： 在可视化有机玻璃料仓系统上对煤粉下料过程及其特性进行了实验研究。研究表明，煤粉介质粒径小、比表面积大，属于黏附性非自由流动粉体，下料流动困难；料仓通气技术可以显著改善煤粉流动性从而促进料仓下料，但过量通气反而会抑制煤粉下料。通过分析下料过程中料仓壁面的压力信号，揭示了料仓压力分布特性，分析了超侧压现象并定义了压力转换面。实验发现，通气可以在一定程度内减小超侧压幅度，扩大煤粉流化疏松区域，提升转换面高度。此外，研究还发现通气下料过程中存在气体穿透现象，穿透临界高度随通气量的增加而提高，并且穿透后煤粉下料流率降低。

关键词: 煤粉下料, 两相流, 压力分布, 压力转换面, 气体穿透

Abstract: The process and characteristics of pulverized coal discharge from a visualized plexiglass hopper were investigated. The discharge of coal was difficult due to its small particle size and large specific surface area with strong agglomeration and poor flowability. The addition of gas could improve the flowability of coal as well as increase discharge rate, however excess aeration would decrease discharge rate. The features of pressure distribution were revealed by analyzing the pressure signals from hopper wall during discharge, and overpressure phenomenon was analyzed and pressure transition surface was defined. The quality of discharge such as reduction of overpressure，extension of loose area of coal and increase of height of transition surface could be improved by aeration to some extent. In addition, gas penetration occurred during aerated discharge. Increase of gas flow rate increased the critical height of gas penetration and discharge rate of coal decreased after gas penetration.

Key words: coal discharge, two-phase flow, pressure distribution, pressure transition surface, gas penetration

中图分类号:

TQ536

陶顺龙, 陆海峰, 郭晓镭, 孙晓林, 龚欣. 煤粉料仓通气下料流动行为[J]. 化工学报, 2014, 65(4): 1186-1193.

TAO Shunlong, LU Haifeng, GUO Xiaolei, SUN Xiaolin, GONG Xin. Flow behavior of aerated discharging of pulverized coal from hopper[J]. CIESC Journal, 2014, 65(4): 1186-1193.

参考文献

[1] Dai Zhenghua, Gong Xin, Guo Xiaolei, Liu Haifeng, Wang Fuchen, Yu Zunhong. Pilot-trial and modeling of a new type of pressurized entrained-flow pulverized coal gasification technology[J]. Fuel, 2008, 87: 2304-2313
[2] Gong Xin(龚欣), Guo Xiaolei(郭晓镭), Dai Zhenghua(代正华), Yu Zunhong(于遵宏), Han Fei(韩飞), Zhao Ruitong(赵瑞同), Lü Chuanlei(吕传磊), Lu Wenxue(路文学). New-type gasification technology of pressurized entrained-flow for pulverized coal[J]. Modern Chemical Industry (现代化工), 2005, 25(3): 51-54
[3] Huang Jiejie(黄戒介), Fang Yitian(房倚天), Wang Yang(王洋). Development and progress of modern coal gasification technology[J]. Journal of Fuel Chemistry and Technology (燃料化学学报), 2002, 30(5): 385
[4] Chen Ruchao(陈汝超), Chen Xiaoping(陈晓平), Cai Jiaying(蔡佳莹), Zhang Tienan(张铁男), Liang Cai(梁财). Research on the discharge stability of granular coal from an aeration silo[J]. Proceedings of the CSEE (中国电机工程学报), 2012, 32(5): 33-38
[5] Huang Wanjie, Gong Xin, Guo Xiaolei, Dai Zhenghua, Liu Haifeng, Zheng Lijiao, Zhao Jinchao, Xiong Yanjun. Discharge characteristics of cohesive fine coal from aerated hopper[J]. Powder Technology, 2009, 194: 126-131
[6] Lu Haifeng, Guo Xiaolei, Gong Xin, Cong Xingliang, Liu Kai, Qi Haifeng. Experimental study on aerated discharge of pulverized coal[J]. Chemical Engineering Science, 2012, 71: 438-448
[7] Jorgen Nielsen. Pressures from flowing granular solids in silos[J]. Phil. Trans. R. Soc. Lond. A, 1998, 356: 2667-2684
[8] Du Mingfang(杜明芳), Liu Qixia(刘起霞), Jiang Zhi’e (蒋志娥), Gao Xinnan(高新南). The PFC simulations of the density influence upon pressure in silo[J]. Journal of Zhengzhou Institute of Technology (郑州工程学院学报), 2004, 25(3): 40-43
[9] Donsi G, Ferrari G, Poletto M. Distribution of gas pressure inside a hopper discharging fine powders[J]. Chemical Engineering Science, 1997, 52: 4291-4302
[10] Couto A, Ruiz A, Aguado P J. Experimental study of the pressures exerted by wheat stored in slender cylindrical silos, varying the flow rate of material during discharge. Comparison with Eurocode 1 part 4[J]. Powder Technology, 2013, 237: 450-467
[11] Nedderman R M,Tuzun U,Thorpe R B. The effect of interstitial air pressure gradients on the discharge from bins[J]. Powder Technology, 1983, 35: 69-81
[12] Chen Pan, Yuan Zhulin, Chyang Chien-Song, Zhuan Fu-Xiong. Sawdust discharge rate from aerated hoppers[J]. Particuology, 2011, 9(3): 306-313
[13] Papazoglou C S, Pyle D L. Air-assisted flow from a bed of particles[J]. Powder Technology, 1970, 4(1): 9-18
[14] Altiner H K. Flow of solids from aerated hoppers: effect of aeration methods[J]. AIChE, Symp., Ser., 1983, 222: 55-59
[15] Ouwerkerk C E D, Molenaar H J, Frank M J W. Aerated bunker discharge of fine dilating powders[J]. Powder Technology, 1992, 72: 241-253
[16] Zheng Lijiao(郑利娇), Guo Xiaolei(郭晓镭), Dai Zhenghua(代正华), Guo Yunzhou(郭云舟), Xiao Weiguo(肖为国), Huang Wanjie(黄万杰), Gong Xin(龚欣). Flow characteristics of pulverized coal from aeration silo[J]. Journal of Chemical Industry and Engineering (China) (化工学报), 2007, 58(9): 2375-2381
[17] Xie Xiaoxu(谢晓旭), Shen Xianglin(沈湘林), Tang Xuemei(汤雪美), Chen Xiaoping(陈晓平). Study on some factors impacting flowability of pulverized coal[J]. Journal of China Coal Society(煤炭学报), 2008, 31(1): 85-88
[18] Kim Esther H J, Chen Xiaodong, Pearce D. Effect of surface composition on the flowability of industrial spray-dried dairy powders[J]. Colloids and Surfaces B: Biointerfaces, 2005, 46: 182-187
[19] Donsi G, Ferrari G. Improvement of bulk flow properties of powders[J]. Powder Technology, 1991, 65: 469-476
[20] Altiner H K. Flow of solids form aerated hopper: effect of aeration methods[J]. American Institute of Chemical Engineers Symposium Series, 1983, 222: 55-59
[21] Lu Haifeng(陆海峰), Guo Xiaolei(郭晓镭), Tao Shunlong(陶顺龙), Gong Xin(龚欣). Application of electrical capacitance tomography in hopper discharge of pulverized coal[J]. CIESC Journal (化工学报), in press
[22] Graham J Weir. A mathematical model for dilating, non-cohesive granular granular flows in steep-walled hoppers[J]. Chemical Engineering Science, 2004, 59: 149-161
[23] Brown R L, Richards J C. Profiles of flow of granules through apertures[J]. Transactions of the Institute of Chemical Engineers, 1960, 38: 243-256
[24] Donsi G, Ferrari G, Poletto M, Russo P. Gas pressure measurements inside an aerated hopper[J]. Trans. IChemE, Part A, Chemical Engineering Research Design, 2004, 82(A1): 72-84

煤粉料仓通气下料流动行为

Flow behavior of aerated discharging of pulverized coal from hopper

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	周绍华, 詹飞龙, 丁国良, 张浩, 邵艳坡, 刘艳涛, 郜哲明. 短管节流阀内流动噪声的实验研究及降噪措施[J]. 化工学报, 2023, 74(S1): 113-121.
[2]	江河, 袁俊飞, 王林, 邢谷雨. 均流腔结构对微细通道内相变流动特性影响的实验研究[J]. 化工学报, 2023, 74(S1): 235-244.
[3]	肖明堃, 杨光, 黄永华, 吴静怡. 浸没孔液氧气泡动力学数值研究[J]. 化工学报, 2023, 74(S1): 87-95.
[4]	温凯杰, 郭力, 夏诏杰, 陈建华. 一种耦合CFD与深度学习的气固快速模拟方法[J]. 化工学报, 2023, 74(9): 3775-3785.
[5]	王玉兵, 李杰, 詹宏波, 朱光亚, 张大林. R134a在菱形离散肋微小通道内的流动沸腾换热实验研究[J]. 化工学报, 2023, 74(9): 3797-3806.
[6]	袁佳琦, 刘政, 黄锐, 张乐福, 贺登辉. 泡状入流条件下旋流泵能量转换特性研究[J]. 化工学报, 2023, 74(9): 3807-3820.
[7]	何松, 刘乔迈, 谢广烁, 王斯民, 肖娟. 高浓度水煤浆管道气膜减阻两相流模拟及代理辅助优化[J]. 化工学报, 2023, 74(9): 3766-3774.
[8]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[9]	高燕, 伍鹏, 尚超, 胡泽君, 陈晓东. 基于双流体喷嘴的磁性琼脂糖微球的制备及其蛋白吸附性能探究[J]. 化工学报, 2023, 74(8): 3457-3471.
[10]	郭雨莹, 敬加强, 黄婉妮, 张平, 孙杰, 朱宇, 冯君炫, 陆洪江. 稠油管道水润滑减阻及压降预测模型修正[J]. 化工学报, 2023, 74(7): 2898-2907.
[11]	高金明, 郭玉娇, 鄂承林, 卢春喜. 一种封闭罩内顺流多旋臂气液分离器的分离特性研究[J]. 化工学报, 2023, 74(7): 2957-2966.
[12]	何宣志, 何永清, 闻桂叶, 焦凤. 磁液液滴颈部自相似破裂行为[J]. 化工学报, 2023, 74(7): 2889-2897.
[13]	牛超, 沈胜强, 杨艳, 潘泊年, 李熠桥. 甲烷BOG喷射器流动过程计算与性能分析[J]. 化工学报, 2023, 74(7): 2858-2868.
[14]	刘起超, 周云龙, 陈聪. 起伏振动垂直上升管气液两相流截面含气率分析与计算[J]. 化工学报, 2023, 74(6): 2391-2403.
[15]	江锦波, 彭新, 许文烜, 门日秀, 刘畅, 彭旭东. 泵出型螺旋槽油气密封泄漏特性及参数影响研究[J]. 化工学报, 2023, 74(6): 2538-2554.