[C16H33N(CH3)3]3[PO4(WO3)4]催化脂肪酸甲酯环氧化性能

doi:10.11949/j.issn.0438-1157.20141518

CIESC Journal ›› 2015, Vol. 66 ›› Issue (3): 1007-1011.DOI: 10.11949/j.issn.0438-1157.20141518

• 催化、动力学与反应器 • 上一篇下一篇

[C₁₆H₃₃N(CH₃)₃]₃[PO₄(WO₃)₄]催化脂肪酸甲酯环氧化性能

王艳涛, 李坤兰, 马英冲, 魏立纲, 王俊梅, 王鑫

大连工业大学轻工与化学工程学院, 辽宁大连 116034

收稿日期:2014-10-09 修回日期:2014-12-16 出版日期:2015-03-05 发布日期:2015-03-05
通讯作者: 李坤兰
基金资助:
辽宁省教育厅科学技术研究项目(202073424)。

Catalytic performance of [C₁₆H₃₃N(CH₃)₃]₃[PO₄(WO₃)₄] in fatty acid methyl ester epoxidation

WANG Yantao, LI Kunlan, MA Yingchong, WEI Ligang, WANG Junmei, WANG Xin

School of Light Industry and Chemical Engineering, Dalian Polytechnic University, Dalian 116034, Liaoning, China

Received:2014-10-09 Revised:2014-12-16 Online:2015-03-05 Published:2015-03-05
Supported by:
supported by the Liaoning Education Department of Science and Technology Research Project (202073424).

摘要/Abstract

摘要： 在无酸、无溶剂条件下,以[C₁₆H₃₃N(CH₃)₃]₃[PO₄(WO₃)₄]为反应控制相转移催化剂,研究各因素对脂肪酸甲酯(FAME)环氧化反应的影响。结果表明,水相pH对环氧化反应的影响最大,反应适宜pH为4;适宜反应条件为过氧化氢与脂肪酸甲酯中双键摩尔比为1.05:1,反应温度50～60℃,反应时间5 h。在此反应条件下催化剂循环5次不失活,产品环氧值大于4.0%,碘值小于5 g I·(100 g)^-1。并通过元素分析与红外光谱,研究了催化剂在反应过程中的变化,认为磷钨杂多阴离子的分解是导致催化剂失活的关键原因。

关键词: 催化, 无酸无溶剂法, 脂肪酸甲酯, 环氧化, 合成, 催化剂

Abstract: The influence of reaction conditions on epoxidation of unsaturated fatty acid methyl ester (FAME) under acid and solvent free conditions with [C₁₆H₃₃N(CH₃)₃]₃[PO₄(WO₃)₄] as a reaction controlled phase transfer catalyst was investigated. The results indicated that pH of the aqueous phase was the most important factor and the proper pH value of solution was 4. With molar ratio of hydrogen peroxide to double bond in FAME is 1.05:1, reaction at 50—60℃ for 5 h, the catalyst could be recycled 5 times without deactivation, and epoxy value of the product was more than 4.0%, while iodine value was less than 5 g I·(100 g)^-1. Change of catalyst during the epoxidation process was investigated with IR spectroscopy and elemental analysis, and the result indicated that decomposition of heteropolyphosphatotungstate anion was the key reason for catalyst deactivation.

Key words: catalysis, acid-free non-solvent, fatty acid methyl esters, epoxidation, synthesis, catalyst

中图分类号:

O623.6

王艳涛, 李坤兰, 马英冲, 魏立纲, 王俊梅, 王鑫. [C₁₆H₃₃N(CH₃)₃]₃[PO₄(WO₃)₄]催化脂肪酸甲酯环氧化性能[J]. CIESC Journal, 2015, 66(3): 1007-1011.

WANG Yantao, LI Kunlan, MA Yingchong, WEI Ligang, WANG Junmei, WANG Xin. Catalytic performance of [C₁₆H₃₃N(CH₃)₃]₃[PO₄(WO₃)₄] in fatty acid methyl ester epoxidation[J]. , 2015, 66(3): 1007-1011.

参考文献 20

[1]	Zhang Shengjun, Zhao Gongda, Gao Shuang, Xi Zuwei, Xu Jie. Secondary alcohols oxidation with hydrogen peroxide catalyzed by [n-C16H33N(CH3)3]3PW12O40: transform-and-retransform process between catalytic precursor and catalytic activity species [J]. J. Mol. Catal. A, 2008, 289: 22-27
[2]	Zhou Ning, Xi Zuwei, Cao Guoying, Gao Shuang. Epoxidation of propylene by using [π-C5H5NC16H33]3[PW4O16] as catalyst and with hydrogen peroxide generated by 2-ethylanthrahydroquinone and molecular oxygen [J]. Appl. Catal. A, 2003, 250:239-245
[3]	Zheng Hongwei, Sun Zhong, Chen Xiaoli, Zhao Qian, Wang Xiaohong, Jiang Zijiang. A micro reaction-controlled phase-transfer catalyst for oxidative desulfurization based on polyoxometalate modified silica [J]. Appl. Catal. A, 2013, 467:26-32
[4]	Gao Jinbo, Chen Yangying, Han Bo, Feng Zhaochi, Li Can, Zhou Ning, Gao Shuang, Xi Zuwei. A spectroscopic study on the reaction-controlled phase transfer catalyst in the epoxidation of cyclohexene [J]. J. Mol. Catal. A , 2004 ,210:197-204
[5]	Xi Zuwei, Zhou Ning, Sun Yu, Li Kunlan. Reaction-controlled phase-transfer catalysis for propylene epoxidation to propylene oxide [J]. Science, 2001, 292: 1139-1141
[6]	Wu Qing, Yang Hua, Cheng Hongwei, Liu Zhiguang, You Wansheng, Gao Shuang. A new Mo/V-oxide-based cationic species templated by Keggin polyoxotungstates (4-) and its catalytic activity in benzene hydroxylation [J]. Journal of Molecular Structure, 2012, 1030:83-88
[7]	Ding Yong, Zhao Wei, Hua Hui, Ma Baochun. [π-C5H5N(CH2)15CH3]3[PW4O32]/ H2O2/ethyl acetate/alkenes: a recyclable and environmentally benign alkenes epoxidation catalytic system [J]. Green Chem., 2008, 10: 910-913
[8]	Jin Guojie (金国杰), Yang Hongyun (杨红云), Chen Hao (陈皓), Gao Huanxin (高焕新), Xie Zaiku (谢在库). Factors affecting propylene epoxidation catalyzed by reaction-controlled phase-transfer catalyst [J]. Chin. J. Catal. (催化学报), 2005, 26: 75-80
[9]	Li Kunlan (李坤兰), Gao Shuang (高爽), Xi Zuwei (奚祖威). Soybean oil epoxide via reaction-controlled phase transfer catalysis [J]. Chinese Journal of Applied Chemistry (应用化学), 2007, 24 (10): 1177-1181
[10]	Li Kunlan (李坤兰), Gao Shuang (高爽), Xi ZuWei (奚祖威). Study on non-acid synthesis of soybean oil epoxide [J]. Chemical World (化学世界), 2008, 5: 293-295
[11]	Oyama S T. Mechanisms in Homogeneous and Heterogeneous Epoxidation Catalysis[M]. Amsterdam: Elsevier, 2008:429-447
[12]	Li Jian, Gao Shuang, Li Meng, Zhang Ronghua, Xi Zuwei. Influence of composition of heteropolyphosphatotungstate catalyst on epoxidation of propylene [J]. J. Mol. Catal. A, 2004, 218: 247-252
[13]	Jin Guojie, Lu Guanzhong, Guo Yanglong, Guo Yun, Wang Junsong, Liu Xiaohui. Epoxidation of propylene by molecular oxygen over modified Ag–MoO3 catalyst [J]. Catalysis Letters, 2003, 87 (3/4): 249-252
[14]	Chen Yangying, Zhuang Jianqin, Liu Xiumei, Gao Jinbo, Han Xiuwen, Bao Xinhe, Zhou Ning, Gao Shuang, Xi Zuwei. On the nature of reaction-controlled phase transfer catalysts for epoxidation of olefin: a 31P NMR investigation [J]. Catalysis Letters, 2004, 93: 41-46
[15]	Dean C Duncan, Carlisle R Chambers, Eric Hecht, Craig L Hill. Mechanism and dynamics in the H3[PW12O40]-catalyzed selective epoxidation of terminal olefins by H2O2. Formation, reactivity, and stability of {PO4[WO(O2)2]4}3- [J]. J. Am. Chem. Soc., 1995, 117: 681-691
[16]	Evelyne Poli, Nicolas Bion, Joël Barrault, Stefano Casciato, Vincent Dubois, Yannick Pouilloux, Jean-Marc Clacens. Selective epoxidation of unsaturated fatty esters over peroxophosphotungstic catalysts (POW) under solvent free conditions: study of the POW catalyst's mechanism [J]. Catalysis Today, 2010, 157 (1/2/3/4): 371-377
[17]	Evelyne Poli, Jean-Marc Clacens, Joël Barrault, Yannick Pouilloux. Solvent-free selective epoxidation of fatty esters over a tungsten-based catalyst [J]. Catalysis Today, 2009, 140 (1/2): 19-22
[18]	Evelyne Poli, Jean-Marc Clacens, Yannick Pouilloux. Synthesis of peroxophosphotungstate immobilized onto polymeric support as heterogeneous catalyst for the epoxidation of unsaturated fatty esters [J]. Catalysis Today, 2011, 164 (1): 429-435
[19]	Feng Shubo (冯树波), Yang Hua (杨华), Zheng Erli (郑二丽), Zhang Lin (张琳), Fan Ming (范明). Epoxidation of fatty acid methyl esters catalyzed by heteropolyphosphatotungstate catalyst [J]. J. Mol. Catal . (China) (分子催化), 2010, 24 (3): 222-227
[20]	Weng Zhihuan (翁志焕), Wang Jinyan (王锦艳), Jian Xigao (蹇锡高). Synthesis and characterization of the phosphotungstic reaction-controlled phase-transfer catalyst [J]. Acta Chimica Sinica (化学学报), 2008,66 (3): 371-375

[C₁₆H₃₃N(CH₃)₃]₃[PO₄(WO₃)₄]催化脂肪酸甲酯环氧化性能

Catalytic performance of [C₁₆H₃₃N(CH₃)₃]₃[PO₄(WO₃)₄] in fatty acid methyl ester epoxidation

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王琪, 张斌, 张晓昕, 武虎建, 战海涛, 王涛. 氯铝酸-三乙胺离子液体/P₂O₅催化合成伊索克酸和2-乙基蒽醌[J]. 化工学报, 2023, 74(S1): 245-249.
[2]	范孝雄, 郝丽芳, 范垂钢, 李松庚. LaMnO₃/生物炭催化剂低温NH₃-SCR催化脱硝性能研究[J]. 化工学报, 2023, 74(9): 3821-3830.
[3]	吴雷, 刘姣, 李长聪, 周军, 叶干, 刘田田, 朱瑞玉, 张秋利, 宋永辉. 低阶粉煤催化微波热解制备含碳纳米管的高附加值改性兰炭末[J]. 化工学报, 2023, 74(9): 3956-3967.
[4]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[5]	程业品, 胡达清, 徐奕莎, 刘华彦, 卢晗锋, 崔国凯. 离子液体基低共熔溶剂在转化CO₂中的应用[J]. 化工学报, 2023, 74(9): 3640-3653.
[6]	陈杰, 林永胜, 肖恺, 杨臣, 邱挺. 胆碱基碱性离子液体催化合成仲丁醇性能研究[J]. 化工学报, 2023, 74(9): 3716-3730.
[7]	李艺彤, 郭航, 陈浩, 叶芳. 催化剂非均匀分布的质子交换膜燃料电池操作条件研究[J]. 化工学报, 2023, 74(9): 3831-3840.
[8]	杨菲菲, 赵世熙, 周维, 倪中海. Sn掺杂的In₂O₃催化CO₂选择性加氢制甲醇[J]. 化工学报, 2023, 74(8): 3366-3374.
[9]	李凯旋, 谭伟, 张曼玉, 徐志豪, 王旭裕, 纪红兵. 富含零价钴活性位点的钴氮碳/活性炭设计及甲醛催化氧化应用研究[J]. 化工学报, 2023, 74(8): 3342-3352.
[10]	杨欣, 彭啸, 薛凯茹, 苏梦威, 吴燕. 分子印迹-TiO₂光电催化降解增溶PHE废水性能研究[J]. 化工学报, 2023, 74(8): 3564-3571.
[11]	陈雅鑫, 袁航, 刘冠章, 毛磊, 杨纯, 张瑞芳, 张光亚. 蛋白质纳米笼介导的酶自固定化研究进展[J]. 化工学报, 2023, 74(7): 2773-2782.
[12]	汤晓玲, 王嘉瑞, 朱玄烨, 郑仁朝. 基于Pickering乳液的卤醇脱卤酶催化合成手性环氧氯丙烷[J]. 化工学报, 2023, 74(7): 2926-2934.
[13]	余娅洁, 李静茹, 周树锋, 李清彪, 詹国武. 基于天然生物模板构建纳米材料及集成催化剂研究进展[J]. 化工学报, 2023, 74(7): 2735-2752.
[14]	李彬, 徐正虎, 姜爽, 张天永. 双氧水催化氧化法清洁高效合成促进剂CBS[J]. 化工学报, 2023, 74(7): 2919-2925.
[15]	涂玉明, 邵高燕, 陈健杰, 刘凤, 田世超, 周智勇, 任钟旗. 钙基催化剂的设计合成及应用研究进展[J]. 化工学报, 2023, 74(7): 2717-2734.