纳米结构脂质载体的制备及其聚集动力学研究

doi:10.11949/j.issn.0438-1157.20180472

摘要/Abstract

摘要：

采用高压均质法制备包覆二苯酮-3（BP-3）和对甲氧基肉桂酸辛酯（OMC）两种紫外线吸收剂的纳米结构脂质载体（NLC），并通过单因素实验探究了总油相含量、液体脂质用量、防晒剂含量、乳化剂种类及其用量对NLC粒径、ζ电位和包封率的影响，并优化了工艺配方。此外，还考察了电解质的种类、浓度以及乳化剂用量对NLC聚集行为的影响并建立了聚集动力学模型。结果表明，电解质的存在可以压缩胶体体系的双电层，导致ζ电位降低，加剧纳米粒之间的聚集结合。NLC样品在电解质NaCl和CaCl₂存在下的临界聚沉浓度分别为538.2和95.8 mmol·L^-1，且在CaCl₂溶液中的聚集速度比NaCl溶液中更快，适量的乳化剂对维持NLC体系的稳定性具有重要作用。

关键词: 纳米结构脂质载体, 聚集作用, 动力学, 制备, 防晒剂, 模型

Abstract:

Nanostructured lipid carrier (NLC) coated with two sunscreens, benzophenone-3 (BP-3) and octyl methoxycinnamate (OMC), was prepared by high pressure homogenization. The effects of the total oil content, liquid lipid content, sunscreen content, as well as the emulsifier type and dosage on the particle size, zeta potential and entrapment efficiency of NLC were investigated by single-factor experiments, and the technical formula was optimized. Moreover, the effects of electrolyte type and concentration as well as the amount of emulsifier on the aggregation behaviors of NLC were further investigated and the dynamic model was established. The results show that the electrolyte can compress the electric double layer of the colloid system and decrease the zeta potential, which also aggravate the aggregation and binding between the nanoparticles. The critical coagulation concentrations of NLC samples in the inorganic electrolyte solutions of NaCl and CaCl₂ were 538.2 and 95.8 mmol·L^-1, respectively. And the aggregation rate of NLC in the solution of CaCl₂ is faster than that in NaCl solutions. Besides, the proper amount of the emulsifier is also helpful to maintain the stability of the NLC system.

Key words: nanostructured lipid carrier, aggregation, kinetics, preparation, sunscreen, model

中图分类号:

TQ46

魏渊, 凌慧, 郑成, 毛桃嫣, 曾昭文, 彭思玉, 肖润辉. 纳米结构脂质载体的制备及其聚集动力学研究[J]. 化工学报, 2018, 69(10): 4427-4437.

WEI Yuan, LING Hui, ZHENG Cheng, MAO Taoyan, ZENG Zhaowen, PENG Siyu, XIAO Runhui. Preparation and aggregation kinetics of nanostructured lipid carrier[J]. CIESC Journal, 2018, 69(10): 4427-4437.

参考文献 38

[1]	NIKOLIC S, KECK C M, ANSELMI C, et al. Skin photoprotection improvement:synergistic interaction between lipid nanoparticles and organic UV filters[J]. International Journal of Pharmaceutics, 2011, 414(1):276-284.
[2]	NICULAE G, BADEA N, MEGHEA A, et al. Coencapsulation of butyl-methoxydibenzoylmethane and octocrylene into lipid nanocarriers:UV performance, photostability and in vitro release[J]. Photochemistry and Photobiology, 2013, 89(5):1085-1094.
[3]	WISSING S, MULLER R. The development of an improved carrier system for sunscreen formulations based on crystalline lipid nanoparticles[J]. International Journal of Pharmaceutics, 2002, 242(1/2):373-375.
[4]	CHEN C C, TSAI T H, HUANG Z R, et al. Effects of lipophilic emulsifiers on the oral administration of lovastatin from nanostructured lipid carriers:physicochemical characterization and pharmacokinetics[J]. European Journal of Pharmaceutics and Biopharmaceutics, 2010, 74(3):474-482.
[5]	PARDEIKE J, HOMMOSS A, MULLER R H. Lipid nanoparticles (SLN, NLC) in cosmetic and pharmaceutical dermal products[J]. International Journal of Pharmaceutics, 2009, 366(1):170-184.
[6]	KELIDARI H R, MOAZENI M, BABAEI R, et al. Improved yeast delivery of fluconazole with a nanostructured lipid carrier system[J]. Biomedicine & Pharmacotherapy, 2017, 89:83-88.
[7]	TETYCZKA C, GRIESBACHER M, ABSENGER-NOVAK M, et al. Development of nanostructured lipid carriers for intraoral delivery of domperidone[J]. International Journal of Pharmaceutics, 2017, 526(1):188-198.
[8]	YU Y, FENG R, YU S, et al. Nanostructured lipid carrier-based pH and temperature dual-responsive hydrogel composed of carboxymethyl chitosan and poloxamer for drug delivery[J]. International Journal of Biological Macromolecules, 2018, 114(15):462-469.
[9]	PARK S J, GARCIA C V, SHIN G H, et al. Development of nanostructured lipid carriers for the encapsulation and controlled release of vitamin D3[J]. Food Chemistry, 2017, 225:213-219.
[10]	COURANT T, BAYON E, REYNAUDDOUGIER H L, et al. Tailoring nanostructured lipid carriers for the delivery of protein antigens:physicochemical properties versus immunogenicity studies[J]. Biomaterials, 2017, 136:29-42.
[11]	侯冬枝, 谢长生, 平其能. 固体脂质纳米粒作为防晒剂载体的性能研究[J]. 中国药科大学学报, 2007, 38(2):177-180. HOU D Z, XIE C S, PING Q N. Characteristics of solid lipid nanoparticles as carrier system for sunscreen agent[J]. Journal of China Pharmaceutical University, 2007, 38(2):177-180.
[12]	SEVERINO P, SANTANA M H, SOUTO E B. Optimizing SLN and NLC by 2(2) full factorial design:effect of homogenization technique[J]. Materials Science & Engineering C-Materials for Biological Applications, 2012, 32(6):1375-1379.
[13]	SOUTO E B, MULLER R H. Investigation of the factors influencing the incorporation of clotrimazole in SLN and NLC prepared by hot high-pressure homogenization[J]. Journal of Microencapsulation, 2006, 23(4):377-388.
[14]	SITI S, EFFIONORA A, MAHDI D, et al. Preparation and characteristics of nanostructured lipid carrier (NLC) loaded red ginger extract using high pressure homogenizer method[J]. Journal of Pharmaceutical Sciences, 2017, 9(10):1889-1893.
[15]	LIU D, LIU Z, WANG L, et al. Nanostructured lipid carriers as novel carrier for parenteral delivery of docetaxel[J]. Colloids and Surfaces B:Biointerfaces, 2011, 85(2):262-269.
[16]	JOSHI M, PATRAVALE V. Formulation and evaluation of nanostructured lipid carrier (NLC)-based gel of valdecoxib[J]. Drug Development and Industrial Pharmacy, 2006, 32(8):911-918.
[17]	JOSHI M, PATRAVALE V. Nanostructured lipid carrier (NLC) based gel of celecoxib[J]. International Journal of Pharmaceutics, 2008, 346(1):124-132.
[18]	LIU D, JIANG S, SHEN H, et al. Diclofenac sodium-loaded solid lipid nanoparticles prepared by emulsion/solvent evaporation method[J]. Journal of Nanoparticle Research, 2011, 13(6):2375-2386.
[19]	张晓佳, 夏强, 马全红, 等. 高压均质法制备载有维甲酸的纳米结构脂质载体[J]. 过程工程学报, 2005, 5(1):54-57. ZHANG X J, XIA Q, MA Q H, et al. Preparation of nanostructured lipid carriers loaded with retinoic acid by the high pressure homogenization method[J]. The Chinese Journal of Process Engineering, 2005, 5(1):54-57.
[20]	陈锋, 金日显, 陈燕军. 纳米结构脂质载体的研究进展[J]. 中国新药杂志, 2008, 17(6):456-460. CHEN F, JIN R X, CHEN Y J. Research and development of nanostructure lipid carriers[J]. Chinese Journal of New Drugs, 2008, 17(6):456-460.
[21]	MULLER R H, PETERSEN R D, HOMMOSS A, et al. Nanostructured lipid carriers (NLC) in cosmetic dermal products[J]. Advanced Drug Delivery Reviews, 2007, 59(6):522-530.
[22]	SOLEIMANIAN Y, SAH G, VARSHOSAZ J, et al. Formulation and characterization of novel nanostructured lipid carriers made from beeswax, propolis wax and pomegranate seed oil[J]. Food Chemistry, 2018, 244:83-92.
[23]	UNER M. Preparation, characterization and physico-chemical properties of solid lipid nanoparticles (SLN) and nanostructured lipid carriers (NLC):their benefits as colloidal drug carrier systems[J]. Pharmazie, 2006, 61(5):375-386.
[24]	HIDALGO-ÁLVAREZ R, MARTIN A, FERNANDEZ A, et al. Electrokinetic properties, colloidal stability and aggregation kinetics of polymer colloids[J]. Advances in Colloid and Interface Science, 1996, 67(96):111-118.
[25]	LI K, ZHANG W, HUANG Y, et al. Aggregation kinetics of CeO2 nanoparticles in KCl and CaCl2 solutions:measurements and modeling[J]. Journal of Nanoparticle Research, 2011, 13(12):6483-6491.
[26]	CHEN K L, ELIMELECH M. Aggregation and deposition kinetics of fullerene (C60) nanoparticles[J]. Langmuir, 2006, 22(26):10994-11001.
[27]	凌慧, 郑成, 毛桃嫣, 等. 响应面法优化微波辅助合成中碳链甘油三酯工艺[J]. 化工学报, 2016, 67(S2):231-244. LING H, ZHENG C, MAO T Y, et al. Optimization of microwave-assisted synthesis of medium-chain triacylglycerols using response surface methodology[J]. CIESC Journal, 2016, 67(S2):231-244.
[28]	CHEN K L, MYLON S E, ELIMELECH M. Aggregation kinetics of alginate-coated hematite nanoparticles in monovalent and divalent electrolytes[J]. Environmental Science & Technology, 2006, 40(5):1516-1523.
[29]	YANG X, ZHAO L, ALMASY L, et al. Preparation and characterization of 4-dedimethylamino sancycline (CMT-3) loaded nanostructured lipid carrier (CMT-3/NLC) formulations[J]. International Journal of Pharmaceutics, 2013, 450(1):225-234.
[30]	CHEN Y, YANG X, ZHAO L, et al. Preparation and characterization of a nanostructured lipid carrier for a poorly soluble drug[J]. Colloids and Surfaces A:Physicochemical and Engineering, 2014, 455(1):36-43.
[31]	刘晓慧, 李琼, 陈良红, 等. 纳米固体脂质体及其在化妆品中的应用研究进展[J]. 日用化学工业, 2013, 43(6):469-473. LIU X H, LI Q, CHEN L H, et al. Progress in research work with respect to preparation of nanostructured solid liposome and its application in cosmetics[J]. China Surfactant Detergent & Cosmetics, 2013, 43(6):469-473.
[32]	LIU X H, LIANG X Z, FANG X, et al. Preparation and evaluation of novel octylmethoxycinnamate loaded solid lipid nanoparticles[J]. International Journal of Cosmetic Science, 2015, 37(4):446-453.
[33]	ALI H, ELSAYED K, SYLVESTER P W, et al. Molecular interaction and localization of tocotrienol-rich fraction (TRF) within the matrices of lipid nanoparticles:evidence studies by differential scanning calorimetry (DSC) and proton nuclear magnetic resonance spectroscopy (1H NMR)[J]. Colloids and Surfaces B:Biointerfaces, 2010, 77(2):286-297.
[34]	HONARY S, ZAHIR F. Effect of zeta potential on the properties of nano-drug delivery systems-a review (part 1)[J]. Tropical Journal of Pharmaceutical Research, 2013, 12(2):265-273.
[35]	KIM T, LEE C H, JOO S W, et al. Kinetics of gold nanoparticle aggregation:experiments and modeling[J]. Journal of Colloid and Interface Science, 2008, 318(2):238-243.
[36]	MYLON S E, CHEN K L, ELIMELECH M. Influence of natural organic matter and ionic composition on the kinetics and structure of hematite colloid aggregation:implications to iron depletion in estuaries[J]. Langmuir, 2004, 20(21):9000-9006.
[37]	WEI C C, GE Z Q. Influence of electrolyte and poloxamer 188 on the aggregation kinetics of solid lipid nanoparticles (SLNs)[J]. Drug Development and Industrial Pharmacy, 2012, 38(9):1084-1089.
[38]	李葵英. 界面与胶体的物理化学[M]. 哈尔滨:哈尔滨工业大学出版社, 1998:197-202. LI K Y. Physical Chemistry of Interface and Colloids[M]. Harbin:Harbin Institute of Technology Press, 1998:197-202.